Vehicle Components. (High)/15765 (CAN) Cab Controller - Primary. PACCAR CECU3 N/A (High)/15765 (CAN) Vehicle Key Data Points

Transcription

1 VIN Vehicle Make Model Model Year Unit Number 1XPHDP9XXDD Peterbilt Vehicle s Serial Number Software Version Network Brakes Bendix EC-60 Advanced ABS N/A BB41103 BB41104 J1939 (High)/J1587 (Low) Engine PACCAR MX EPA 10 A PC22_1201R07 J1939 (High)/15765 (CAN) Cab Controller - Parameter PACCAR CECU3 N/A N/A J1939 (High)/15765 (CAN) Vehicle Key Data Points Value Parameter Battery Potential volts Coolant Level Normal Engine Oil Level Not Available Odometer 773, km Avg Fuel Econ 2.50 km/l Total Engine Hrs 14, hrs Road Speed Limit km/hr Cruise Spd Limit km/hr DPF Soot Level Low Engine Derate No Derate Malfunction Indicator Lamp Off Red Stop Lamp Off Amber Warning Lamp Off Protect Lamp Off Parking Brake Switch On DPF Lamp Command Off Exhaust System High Temperature LamOff ABS Control Off ABS Control, Trailer Not Available Engine Speed 651 rpm Fuel 35% Diesel Exhaust Fluid Normal Vehicle Issues Value 9 Active Fault(s) Present Page 1 of 6

2 Faults Inactive Brakes J1939 Engine Communications -OR- J1939 Invalid Data (Engine/Retarder) -OR- J1939 Supply Pressure -OR- J1939 ESP Messages Invalid Data -OR- Invalid Data From Transmission -OR- Timeout or invalid data on ETC7/VP15 (for HSA function) -OR- Timeout or invalid data on XBR -OR- J1939 HSA switch error or unavailable -OR- Timeout or Invalid data for ESP AWD operation (Flash Code or or or 11-3 or 11-4 or 11-5 or 11-6 or 11-7 or 11-8) SID Inactive Brakes J1939 Retarder (Flash Code 11-2) SID Active Cab Controller - Open in forward drive axle oil temp circuit N/A 126 Aftertreatment system operator inducement severity message error N/A 1 Diesel Exhaust Fluid Telltale Message Error N/A 1 Regeneration inhibited due to inhibit switch message error N/A 1 Out of Range - Turn Signal Switch N/A 126 Short in high beam toggle switch input or input active for more than 10 seconds Short in marker lamp flash switch input or input active for more than 10 seconds Short in flash to pass switch input or input active for more than 10 seconds Short in washer pump switch input or input active for more than 15 seconds N/A N/A N/A N/A 126 Out of range on low speed wiper switch input N/A 126 Open in ammeter sensor circuit N/A 1 Invalid input from reverse switch N/A 4 Marker lamp output not available N/A 37 Marker lamp output over current N/A 14 Page 2 of 6

3 Marker lamp output under current or open circuit N/A 11 Marker lamp output short to power N/A 56 Marker lamp output general error N/A 61 Right rear turn/stop output general error N/A 40 Left rear turn/stop output general error N/A 40 Right front turn or left front side turn output not available N/A 1 Right front turn or left front side turn output general error N/A 40 Right front turn or left front side turn output over current N/A 1 Right front turn or left front side turn output general error N/A 1 Left front turn or left front side turn output general error N/A 40 Left or right low beam output general error N/A 41 Left or right low beam output under current or open circuit N/A 21 Left or right high beam output general error N/A 41 Diesel Exhaust Fluid Level Message Error N/A 1 Control Unit cannot read messages from Engine on V-CAN N/A 2 Control unit cannot read messages from ABS on V-CAN N/A 67 Control Unit cannot read messages from Cluster on I-CAN N/A 126 Total Engine PTO Fuel Used Message missing N/A 27 High Resolution Vehicle Distance message missing N/A 1 Open in secondary fuel level circuit N/A 126 Page 3 of 6

4 Open in primary fuel level circuit N/A 7 Cruise control rationality check N/A 4 Short in forward drive axle oil temp circuit N/A 126 Total Power Takeoff Hours message missing N/A 126 Instantaneous Fuel Economy message missing N/A 1 Ignition Power is in an indeterminate state N/A 7 Accelerator Pedal Position Message missing 9109 N/A 1 Wheel Based Vehicle Speed Message missing 8409 N/A 1 Short in rear drive axle oil temp circuit 7704 N/A details details details details details details SPN SPN SPN SPN SPN SPN Active Engine Pump module (L074) - Pressure stabilization failed P3932 N/A 1 Active Engine Pump module (L074) - Unable to prime P3843 N/A 1 Inactive Engine CAN communication - From power takeoff (PTO) - Inactive Engine CAN communication - From brake system (HRW) - Inactive Engine CAN communication - From cabin ECU (EEC2) - U1208 N/A 1 U1136 N/A 1 U0143 N/A 1 Page 4 of 6

5 Inactive Engine CAN communication - From cabin ECU (EBC1) - Inactive Engine CAN communication - From cabin ECU (CCVS1) - Inactive Engine NOx before catalyst sensor (F844) - Data erratic or data not valid Inactive Engine NOx before catalyst sensor (F844) - CAN communication error 2 U0129 N/A 1 U0104 N/A 1 P3979 N/A 49 P3960 N/A 1 Inactive Engine NOx before catalyst sensor (F844) - Oxygen signal error P3958 N/A N/A Inactive Engine NOx before catalyst sensor (F844) - Sensor heating warm-up failure P3957 N/A 5 Inactive Engine NOx before catalyst sensor (F844) - Sensor heating error P3956 N/A N/A Inactive Engine NOx before catalyst sensor (F844) - CAN communication error 1 P3955 N/A 1 Inactive Engine NOx before catalyst sensor (F844) - NOx signal error P3954 N/A N/A Inactive Engine NOx before catalyst sensor (F844) - Heater element error Inactive Engine Tank heater valve (L076) - DEF operating temperature not reached Inactive Engine Exhaust temperature after SCR catalyst sensor (F842) - Temperature too high, most severe level Inactive Engine NOx after catalyst sensor (F843) - Signal value higher than expected (during motoring) Inactive Engine Exhaust temperature after SCR catalyst sensor (F842) - ECU pin B31, signal unlikely Inactive Engine DPF pressure sensor (F837) - ECU pin A70, signal unlikely Inactive Engine MX engine brake cylinder 4 (B414) - short circuit to supply on ECU pin A21 Inactive Engine MX engine brake cylinder 4 (B414) - short circuit to ground on ECU pin A21 Inactive Engine MX engine brake cylinder 2 (B412) - short circuit to ground on ECU pin A16 Inactive Engine MX engine brake cylinder 6 (B416) - short circuit to supply on ECU pin A20 Inactive Engine MX engine brake cylinder 6 (B416) - short circuit to ground on ECU pin A20 Inactive Engine MX engine brake cylinder 1 (B411) - short circuit to ground on ECU pin A17 P3953 N/A N/A P3928 N/A 1 P3815 N/A 5 P3805 N/A 3 P3802 N/A N/A P3762 N/A N/A P3448 N/A 1 P3447 N/A 1 P3439 N/A 1 P3432 N/A 2 P3431 N/A 1 P3407 N/A 2 Page 5 of 6

6 Inactive Engine Power supply - Supply voltage low P3003 N/A 1 Inactive Engine Accelerator pedal sensor - ECU pin B49 and ECU pin B45 sensor out of range relative to idle valid switch P2135 N/A 79 Inactive Engine Accelerator pedal sensor - Limp home active P2106 N/A 5 Inactive Engine Engine protection system - Warning state P2104 N/A 2 Inactive Engine Lambda sensor (F834) - Signal invalid during overrun P1709 N/A N/A Inactive Engine Power supply - Voltage too low. P1563 N/A 1 Inactive Engine Aftertreatment - Misuse mode - Level 4 P151D N/A 2 Inactive Engine Aftertreatment - Misuse mode - Level 2 P151B N/A 2 Inactive Engine Aftertreatment - Misuse mode - Level 1 P151A N/A 2 Inactive Engine Vehicle speed increase - Signal unlikely P1506 N/A 2 Inactive Engine Cylinder 1 combustion - Torque contribution is too high P1263 N/A 1 Inactive Engine Lambda sensor (F834) - Control fault P113A N/A 2 Inactive Engine Air temperature after intercooler sensor (F750) - The air temperature is high. P1127 N/A 1 Inactive Engine Engine protection system - Approaching shutdown state P1105 N/A 5 Inactive Engine BPV actuator (L020) - Power supply P1027 N/A 3 Inactive Engine EGR differential pressure sensor (F751) - Pressure out of range at ignition switch on Inactive Engine Crank speed injection diagnostics - Major decrease in combustion in cylinder 6 relative to the other cylinders. (Misfire) P0486 N/A 3 P0306 N/A 1 Inactive Engine Cylinder 5 - Contribution is too low. P0275 N/A 2 Inactive Engine Engine speed - Overspeed P0219 N/A 5 Inactive Engine Engine cooling system - The temperature is too high P0217 N/A 8 Inactive Engine Accelerator pedal sensor - Short circuit to ground on ECU pin B49 P0122 N/A 26 Page 6 of 6