1. IDENTIFICATION OF THE SUBSTANCE/PREPARATION AND OF THE COMPANY/UNDERTAKING. Reduce Temperature Detergent 1135 Cleansing agents, alkaline

Transcription

1 SAFETY DATA SHEET Reduced Temperature Detergent Preparation Date: 23-Apr-2015 Revision Number: 2 1. IDENTIFICATION OF THE SUBSTANCE/PREPARATION AND OF THE COMPANY/UNDERTAKING Product Name Item#: Recommended use Supplier Reduce Temperature Detergent 1135 Cleansing agents, alkaline DeLaval Manufacturing PO Box Kells Place Hamilton New Zealand Telephone Number (8am - 4:30pm Mon-Fri) Emergency Telephone Number (National Poisons Centre) CHEMCALL Potential Health Effects 2. HAZARD IDENTIFICATION HAZARDOUS SUBSTANCE DANGEROUS GOODS DANGER Harmful if swallowed The product causes burns to eyes, skin, and mucous membranes May be corrosive to metals Toxic to aquatic life with long lasting effects Principle Routes of Exposure Eye contact Skin contact Ingestion Inhalation Major effects of exposure EYES SKIN INGESTION INHALATION Corrosive to the eyes and may cause severe damage including blindness Corrosive to skin. May cause skin burns and irritation. Ingestion causes burns of the upper digestive and respiratory tracts. Possible harmful effects to the linings of the nose, mouth, and throat Read Safety Data Sheet before use Page 1 / 6

2 3. COMPOSITION/INFORMATION ON INGREDIENTS Chemical Name CAS-No Weight % Water Alkane sulfonic acid Sodium hypochlorite Sodium hydroxide Other ingredients, determined not to be hazardous subject to the provisions of the Hazardous Substances (identification) Regulations 2001, make up the product concentration to 100% 4. FIRST AID MEASURES General Advice Eye contact Skin contact Inhalation Ingestion Protection of First-aiders Immediate medical attention is required. Show this safety data sheet to the doctor in attendance. Ensure that eyewash stations and safety showers are close to the workstation location. Immediate medical attention is required Rinse immediately with plenty of water, also under the eyelids, for at least 15 minutes Keep eye wide open while rinsing Wash off immediately with soap and plenty of water removing all contaminated clothes and shoes. Move to fresh air If not breathing, give artificial respiration If breathing is difficult, give oxygen Call a physician or Poison Control Centre immediately Do not induce vomiting. Never give anything by mouth to an unconscious person. Call a physician or Poison Control Centre immediately. Use personal protective equipment. Avoid contact with skin, eyes and clothing. 5. FIRE-FIGHTING MEASURES Hazchem Code Flammable Properties Suitable Extinguishing Media No Hazchem Code allocated Use extinguishing measures that are appropriate to local circumstances and the surrounding environment. Unsuitable Extinguishing Media Specific hazards arising from the chemical Protective Equipment and Precautions for Firefighters Keep product and empty container away from heat and sources of ignition. As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH (approved or equivalent) and full protective gear. Page 2 / 6

3 6. ACCIDENTAL RELEASE MEASURES Personal precautions Environmental Precautions Methods for cleaning up Use personal protective equipment. Avoid contact with skin, eyes and clothing. Prevent further leakage or spillage if safe to do so. Dam up. Pick up and transfer to properly labelled containers. 7. HANDLING AND STORAGE Handling Storage Wear personal protective equipment. Avoid contact with skin, eyes and clothing. Ensure adequate ventilation. Keep container tightly closed in a dry and well-ventilated place. Engineering Controls 8. EXPOSURE CONTROLS / PERSONAL PROTECTION Chemical Name OSH (New Zealand, 1/2002) Sodium hydroxide Ceiling: 2 mg/m 3 Ensure adequate ventilation, especially in confined areas. Personal Protective Equipment Eye/face Protection Skin Protection Hand Protection Respiratory Protection Tightly fitting safety goggles. Long sleeved clothing, Chemical resistant apron, Boots Neoprene nitrile rubber butyl-rubber Neoprene gloves No special protective equipment required. General Hygiene Considerations When using, do not eat, drink or smoke. Remove and wash contaminated clothing before re-use. 9. PHYSICAL AND CHEMICAL PROPERTIES Appearance Clear Colorless to slightly yellow Form Liquid Odor Slight chlorine ph > 12 Specific Gravity Water Solubility completely soluble Vapor Pressure Vapor Density Flash Point Boiling Point/Range Freezing Point/Range No data available No data available Not applicable No data available no data available Page 3 / 6

4 10. STABILITY AND REACTIVITY Chemical Stability Conditions to Avoid Incompatible Materials Hazardous decomposition products Stable under normal conditions. Heat, flames and sparks. No materials to be especially mentioned None under normal use. 11. TOXICOLOGICAL INFORMATION Component Information Chemical Name LD50 Oral LD50 Dermal LC50 Inhalation Water 90 ml/kg ( Rat ) Alkane sulfonic acid 200 mg/kg ( Rat ) 200 mg/kg ( Rabbit ) Sodium hypochlorite 8200 mg/kg ( Rat ) mg/kg ( Rabbit ) Sodium hydroxide 2000 mg/kg 1350 mg/kg Potential Health Effects Carcinogenicity There are no known carcinogenic chemicals in this product. Sensitization Neurological Effects Mutagenic effects Reproductive Effects Developmental Effects Target Organ Effects Page 4 / 6

5 12. ECOLOGICAL INFORMATION Ecotoxicity Ecotoxicity effects Very toxic to aquatic organisms Chemical Name Freshwater Algae Freshwater Fish Microtox Water Flea Alkane sulfonic acid EC50 = 12 mg/l 48 h Sodium hydroxide Persistence and degradability No information available LC50 (96 h) 72 mg/l Bioaccumulation/ Accumulation Mobility No information available 13. DISPOSAL CONSIDERATIONS Waste Disposal Method Contaminated Packaging Dispose of in accordance with local regulations. Empty containers should be taken for local recycling, recovery or waste disposal. UN-No 3266 Proper Shipping Name Hazard Class 8 Packing Group II 14. TRANSPORT INFORMATION CORROSIVE LIQUID, BASIC, INORGANIC, N.O.S. ( Sodium hydroxide Sodium hypochlorite 15. REGULATORY INFORMATION ERMA NZ Registration Number HSR ERMA Group Standard Cleaning Products - (Corrosive) Group Standard 2006 HSNO Classifications HSNO Conditions 6.1D Substances that are acutely toxic 8.1A Substances that are corrosive to metals 8.2B Substances that are corrosive to dermal tissue 8.3A Substances that are corrosive to the eye 9.1B Substances that are ecotoxic to aquatic environment Hazardous Substances Location trigger quantiy: N/A Approved Handler trigger quantiy: N/A Secondary containment trigger quantity: 1000L or 1000kg Signage trigger quantity: 1000L or 1000kg Response Plan trigger quantity: 1000L or 1000kg Page 5 / 6

6 16. OTHER INFORMATION Prepared By Preparation Date: DeLaval Manufacturing N. Congress Ave. Kansas City, MO USA Jan-2011 References NZS 5433:2007 Transport of Dangerous Goods on Land Land Transport (Dangerous Goods) Rule 45001:2005 Hazardous Substances Regulations 2001: - Minimum Degrees of Hazard - Classification - Classes 1 to 5 Controls - Classes 6, 8 and 9 Controls - Packaging Regulations - Identification Regulations - Dispoal Regulations - Emergency Management - Identification Regulations - Disposal Regulations Health and Safety in Employment Regulations 1995 User Guide to the HSNO Thresholds and Classifications OSH Workplace Exposure Standards January 2002 NZCIC Approved Code of Practice - Preparation of Safety Data Sheets Signage for premises storing hazardous substances and dangerous goods Disclaimer The information provided on this SDS is correct to the best of our knowledge, information and belief at the date of its publication. The information given is designed only as a guide for safe handling, use, processing, storage, transportation, disposal and release and is not to be considered as a warranty or quality specification. The information relates only to the specific material designated and may not be valid for such material used in combination with any other material or in any process, unless specified in the text End of SDS Page 6 / 6