Murphy and Son Ltd SAFETY DATA SHEET. Section 1: Identification of the substance/mixture and of the company/undertaking

Transcription

1 Page: 1 Compilation date: 30/07/2014 Revision date: 23/01/2015 Revision No: 2 Section 1: Identification of the substance/mixture and of the company/undertaking 1.1. Product identifier Product name: REACH registered name: REACH registered number(s): CAS number: EINECS number: Product code: Synonyms: DIPOTASSIUM DISULPHITE XXXX POTMETA DIPOTASSIUM DISULPHITE POTASSIUM PYROSULFITE 1.2. Relevant identified uses of the substance or mixture and uses advised against Use of substance / mixture: Beverage Processing Aids and Other Usages 1.3. Details of the supplier of the safety data sheet Company name: Alpine Street Nottingham Nottinghamshire NG6 0HQ United Kingdom Tel: Emergency telephone number technical@murphyandson.co.uk Emergency tel: Section 2: Hazards identification (office hours only) 2.1. Classification of the substance or mixture Classification under CLP: Classification under CHIP: Most important adverse effects: Eye Dam. 1: H318; Acute Tox. 4: H302; -: EUH031 -: R31; Xi: R41; Xn: R22 Contact with acids liberates toxic gas. Causes serious eye damage. Harmful if swallowed Label elements Label elements under CLP: Hazard statements: EUH031: Contact with acids liberates toxic gas.

2 Signal words: Hazard pictograms: SAFETY DATA SHEET H318: Causes serious eye damage. H302: Harmful if swallowed. Danger GHS05: Corrosion GHS07: Exclamation mark Page: 2 Precautionary statements: P264: Wash skin thoroughly after handling. P280: Wear protective gloves/protective clothing/eye protection/face protection. P : IF SWALLOWED: Immediately call a POISON CENTER or doctor. P : IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing Other hazards PBT: This product is not identified as a PBT/vPvB substance. Section 3: Composition/information on ingredients 3.1. Substances Chemical identity: CAS number: EINECS number: REACH registered number(s): Section 4: First aid measures 4.1. Description of first aid measures Skin contact: Eye contact: XXXX Wash immediately with plenty of soap and water. Bathe the eye with running water for 15 minutes. Transfer to hospital for specialist examination. Ingestion: Wash out mouth with water. Do not induce vomiting. If conscious, give half a litre of water to drink immediately. Inhalation: Remove casualty from exposure ensuring one's own safety whilst doing so Most important symptoms and effects, both acute and delayed Skin contact: Eye contact: Ingestion: Inhalation: Delayed / immediate effects: There may be mild irritation at the site of contact. There may be irritation and redness. There may be severe pain. The eyes may water profusely. The vision may become blurred. Corneal burns may occur. There may be soreness and redness of the mouth and throat. There may be difficulty swallowing. There may be vomiting. Absorption through the lungs can occur causing symptoms similar to those of ingestion. Immediate effects can be expected after short-term exposure.

3 Page: Indication of any immediate medical attention and special treatment needed Section 5: Fire-fighting measures 5.1. Extinguishing media Extinguishing media: Suitable extinguishing media for the surrounding fire should be used Special hazards arising from the substance or mixture Exposure hazards: In combustion emits toxic fumes Advice for fire-fighters Advice for fire-fighters: Wear self-contained breathing apparatus. Wear protective clothing to prevent contact with skin and eyes. Section 6: Accidental release measures 6.1. Personal precautions, protective equipment and emergency procedures Personal precautions: Refer to section 8 of SDS for personal protection details. Do not create dust. Mark out the contaminated area with signs and prevent access to unauthorised personnel. If outside do not approach from downwind Environmental precautions Environmental precautions: Do not discharge into drains or rivers Methods and material for containment and cleaning up Clean-up procedures: Transfer to a closable, labelled salvage container for disposal by an appropriate method Reference to other sections Section 7: Handling and storage 7.1. Precautions for safe handling Handling requirements: Ensure there is sufficient ventilation of the area. Avoid the formation or spread of dust in the air. Avoid direct contact with the substance Conditions for safe storage, including any incompatibilities Storage conditions: Suitable packaging: Store in cool, well ventilated area. Must only be kept in original packaging Specific end use(s) Specific end use(s): Beverage Processing Aids and Other Usages Section 8: Exposure controls/personal protection 8.1. Control parameters Workplace exposure limits:

4 Page: 4 DNEL/PNEC Values DNEL / PNEC 8.2. Exposure controls Engineering measures: Ensure there is sufficient ventilation of the area. Respiratory protection: Respiratory protective device with particle filter. Hand protection: Eye protection: Skin protection: Environmental: Protective gloves. The selected protective gloves have to satisfy the specifications of EU Directive 89/686/EEC and the standard EN374 derived from it. Safety glasses. Ensure eye bath is to hand. Protective clothing. environmental legislation. Section 9: Physical and chemical properties 9.1. Information on basic physical and chemical properties State: Colour: Odour: Evaporation rate: Oxidising: Solubility in water: Viscosity: Refer to specific Member State legislation for requirements under Community Powder Off-white Pungent Negligible Non-oxidising (by EC criteria) Miscible in all proportions Not applicable. Boiling point/range C: Not applicable. Melting point/range C: 190 Decomp. Flammability limits %: lower: Not applicable. upper: Not applicable. Flash point C: Not applicable. Part.coeff. n-octanol/water: Autoflammability C: Not applicable. Vapour pressure: Relative density: 2.34 ph: (5%) 9.2. Other information VOC g/l: Other information: Section 10: Stability and reactivity Reactivity Not applicable. Reactivity: Stable under recommended transport or storage conditions Chemical stability Chemical stability: Stable under normal conditions Possibility of hazardous reactions Hazardous reactions: Hazardous reactions will not occur under normal transport or storage conditions. Decomposition may occur on exposure to conditions or materials listed below.

5 Page: Conditions to avoid Conditions to avoid: Heat Incompatible materials Materials to avoid: Strong oxidising agents. Strong acids Hazardous decomposition products Haz. decomp. products: In combustion emits toxic fumes. Section 11: Toxicological information Information on toxicological effects Toxicity values: Route Species Test Value Units DERMAL RAT LD50 >2 mg/kg ORAL RAT LD mg/kg INV RAT LD mg/kg Relevant hazards for substance: Hazard Route Basis Acute toxicity (ac. tox. 4) ING Based on test data Serious eye damage/irritation OPT Based on test data Symptoms / routes of exposure Skin contact: There may be mild irritation at the site of contact. Eye contact: There may be irritation and redness. There may be severe pain. The eyes may water profusely. The vision may become blurred. Corneal burns may occur. Ingestion: Delayed / immediate effects: Section 12: Ecological information Toxicity There may be soreness and redness of the mouth and throat. There may be difficulty swallowing. There may be vomiting. Inhalation: Absorption through the lungs can occur causing symptoms similar to those of ingestion. Immediate effects can be expected after short-term exposure. Ecotoxicity values: Persistence and degradability Persistence and degradability: Biodegradable Bioaccumulative potential Bioaccumulative potential: No bioaccumulation potential.

6 Page: Mobility in soil Mobility: Non-volatile Results of PBT and vpvb assessment PBT identification: This product is not identified as a PBT/vPvB substance Other adverse effects Section 13: Disposal considerations Waste treatment methods Disposal operations: Transfer to a suitable container and arrange for collection by specialised disposal company. Recovery operations: Not applicable. Disposal of packaging: Dispose of in a regulated landfill site or other method for hazardous or toxic wastes. Spillage and packaging should be disposed of in a manner approved of by the Local Authority. NB: regulations regarding disposal. Section 14: Transport information Transport class: The user's attention is drawn to the possible existence of regional or national This product does not require a classification for transport. Section 15: Regulatory information Safety, health and environmental regulations/legislation specific for the substance or mixture Specific regulations: This product needs to be included in any Safety Report provided under III.C of Annex II of Council Directive 96/82/EC Chemical Safety Assessment Chemical safety assessment: A chemical safety assessment has not been carried out for the substance or the mixture Section 16: Other information Other information by the supplier. Other information: Phrases used in s.2 and s.3: This safety data sheet is prepared in accordance with Commission Regulation (EU) No 453/2010. * indicates text in the SDS which has changed since the last revision. EUH031: Contact with acids liberates toxic gas. H302: Harmful if swallowed. H318: Causes serious eye damage. R22: Harmful if swallowed. R31: Contact with acids liberates toxic gas. R41: Risk of serious damage to eyes.

7 Legend to abbreviations: PNEC = predicted no effect level DNEL = derived no effect level LD50 = median lethal dose LC50 = median lethal concentration EC50 = median effective concentration IC50 = median inhibitory concentration dw = dry weight bw = body weight cc = closed cup oc = open cup MUS = mouse GPG = guinea pig RBT = rabbit HAM = hamster HMN = human MAM = mammal PGN = pigeon IVN = intravenous SCU = subcutaneous SKN = skin DRM = dermal OCC = ocular/corneal PCP = phycico-chemical properties Legal disclaimer: The above information is believed to be correct but does not purport to be all inclusive and shall be used only as a guide. This company shall not be held liable for any damage resulting from handling or from contact with the above product. Page: 7 [final page]