Product Name: CARBURETOR AND PARTS CLEANER (UPC: )

Transcription

1 Page 1 of 5 I. Basic Information: Manufacturer: RADIATOR SPECIALTY COMPANY Contact: Robert Geer Address: 600 RADIATOR ROAD Information Telephone Number: City, ST Zip: INDIAN TRAIL, NC 8079 Emergency Contact: Rocky Mountain Poision Control Center Country: Emergency Telephone Number: Issue Date: 08/8/008 Supersedes Date: 10/7/006 II. Hazards Identification: EMERGENCY OVERVIEW Danger: Combustible. Harmful or fatal if swallowed. Eye and Skin Irritant. Emergency Restrictions: OSHA Regulatory Status This material is considered hazardous by the OSHA Hazard Communication Standard (9 CFR ). Potential Health Effects Route(s) of Entry: Absorption, Inhalation, and Ingestion. Health Hazards (Acute and Chronic): See Signs and Symptoms Signs and Symptoms: Eye Contact: Irritant. Prolonged contact may cause conjunctivitis. Skin Contact: Irritant. Defatting of tissue, dermatitis may occur. Inhalation: Irritating to the respiratory tract.. Repeated exposure may cause narcosis.. Ingestion: HARMFUL OR FATAL IF SWALLOWED. Medical Conditions Generally Aggravated by Exposure: None known Other Health Warnings: Vomiting and subsequent aspiration into the lungs may lead to chemical pneumonia and pulmonary edema which is a potentially fatal condition. Potential Environmental Effects III. Composition/Information on Ingredients: Chemical Name CAS No. % Range Trade Secret Petroleum naphtha ,,4-Trimethylbenzene Butoxyethanol Naphthalene Petroleum Distillate, Hydrotreated Middle Sodium Glucohrptonate Tall Oil Fatty Acid Triethanolamine

2 Page of 5 IV. First Aid Measures: Emergency and First Aid Procedures: Eye Contact: Flush eyes with clean water for 15 minutes while lifting eyelids. Get prompt medical attention. Skin Contact: Wash with soap and water thoroughly. If irritation persist, get prompt medical attention. Launder contaminated clothing before reuse. Inhalation: Remove to fresh air. If breathing becomes difficult get prompt medical attention. Ingestion: DO NOT INDUCE VOMITING! Call Poison Control Center, physician, or hospital emergency room immediately. Note to Physicians: V. Fire Fighting Measures: Suitable Extinguishing Media: Water Fog, Foam, Carbon Dioxide, Dry Chemical Unsuitable Extinguishing Media: Do not use forced water stream as this could cause the fire to spread. Products of Combustion: Products of combustion: carbon oxides, oxides of nitrogen, smoke. Protection of Firefighters: Wear self-contained positive pressure breathing apparatus and protective clothes. At elevated temperatures containers may vent, rupture or burst, even violently VI. Accidental Release Measures: Personal Precautions: Persons not wearing protective equipment should be excluded from area of spill until clean-up has been completed. Environmental Precautions: Prevent run-off to sewers, streams, or other bodies of water. If run-off occurs, notify proper authorities as required that a spill has occurred. Run off to sewer may create fire or explosion hazard. Methods for Containment: Dike or contain spill and absorb with inert materials (sand, sawdust, absorbent sweeping compounds, rags, etc). Methods for Cleanup: Using a non-metalic scoop, place contaminated material into an approved chemical waste container. Where possible, vacuum spilled liquid using an explosion proof vacuum to recover material. Other Information: Prevent run-off to sewers, streams, or other bodies of water. If run-off occurs, notify proper authorities as required that a spill has occured. VII. Handling and Storage: Handling Precautions: Use with adequate ventilation and proper protective equipment. Do not use or store near fire, sparks, or open flame. Storage Precautions: Keep container closed tightly when not in use. CAUTION: Combustible. Store in a cool place away from ignition sources and oxidizing agents. VIII. Exposure Controls/Personal Protection:

3 Page 3 of 5 Chemical Name OSHA PEL ACGIH TLV Other Limits Petroleum naphtha 100 ppm -Butoxyethanol Triethanolamine Naphthalene 10 ppm 10 ppm 1,,4-Trimethylbenzene Sodium Glucohrptonate Tall Oil Fatty Acid 10 mg/m3 Petroleum Distillate, Hydrotreated Middle Engineering Controls: See above Section for applicable exposure limits. Maintain adequate ventilation. Avoid breathing vapors. In restricted areas, use respirator with approved chemical filters designed to remove vapor. In confined areas, use approved air line type respirator or hood. A self-contained breathing apparatus is required for vapor concentrations above TLV limit Personal Protective Equipment: For prolonged exposure wear protective goggles, gloves, and apron. IX. Physical and Chemical Properties: Boiling Point: > 1 F Boiling Range: Solubility In Water: Emulsifies Flash Point: 146 F Melting Point: Freezing Point: Evaporation Rate (Butyl Acetate = 1): Flash Point Method: TCC Odor Threshold: Appearance and Odor: Clean amber color liquid, aromatic solvent odor. Vapor Density (AIR = 1): Vapor Pressure (mm Hg.): < 1.0 mm 0 C ph Range: Decomposition Temp: Lower Explosive Limit: Specific Gravity (H0 = 1): 0.9 Other Information: VOC Contents: <45% (Wt) Partition Coefficient: Auto-Ignition Temp: Upper Explosive Limit: X. Stability and Reactivity: Stability: Stable Conditions to Avoid: See Incompatible Materials below. Incompatible Materials: Strong oxidizing agents Hazardous Decomposition Products: Products of combustion: carbon oxides, oxides of nitrogen, smoke Possibility of Hazardous Reactions: Will not occur

4 Page 4 of 5 XI. Toxicological Information: XII. Ecological Information: XIII. Disposal Considerations: DISPOSAL: This container may be recycled in a recycling centers when empty. Before offering for recycling, empty the can or bottle by using the product according to the label. If recycling is not available, wrap the container and discard in the trash. Dispose of unused product in accordance with all local, state government and federal laws and regulations XIV. Transport Information: Shipping Name: DOT Hazard Class: UN/NA#: Transportation Information: DOT Shipping Name: Not DOT regulated. DOT Hazard Class: None DOT Subsidiary Hazard Class: Packing Group: The DOT description is provided to assist in the proper shipping classification of this product and may not be suitable for international and air shipping purposes. XV. Regulatory Information: SARA 313 Reportable Chemicals. Petroleum Naphtha ( ) Butoxyethanol ( ) Naphthalene (91-0-3) 1,,4 Trimethyl benzene ( ) USA TSCA: All components of this material are listed on the US TSCA Inventory. Warning: This product contains a chemical known to the State of California to cause cancer. State RTK Chemicals; Butoxyethanol ( ) Naphthalene (91-0-3) XVI. Other Information: Chemical State: X Chemical Type: Liquid Pure X Gas Mixture Solid Hazard Category: X Acute X Chronic X Fire Pressure Reactive 0

5 Page 5 of 5 Additional Manufacturer Warnings: Do not used in confined area without proper ventilation. Contact lenses may cause further damage in case of splash into eye. KEEP AWAY FROM CHILDREN AND ANIMALS! : Not Established : Not Determined N/A: Not Applicable N/AV: Additional Product Information: 0 C While Radiator Specialty Company believes this data is accurate as of the revision date, we make no warranty with respect to the data and we expressly disclaim all liability for reliance thereon. The data is offered solely for information, investigation, and verification. Various government agencies may have specific regulations regarding the transportation, handling, storage, use, or disposal of this product which may not be covered by this MSDS. The user is responsible for full compliance.