1. PRODUCT AND COMPANY IDENTIFICATION 2. HAZARDS IDENTIFICATION

Transcription

1 Page: 1 Revision: 4/9/215 Product Name: Company Name: Emergency Contact: Part Number: 1. PRODUCT AND COMPANY IDENTIFICATION White OptiShine 714 S. National Springfield, MO 6584 CHEMTREC AS-16-ME33-OZ 2. HAZARDS IDENTIFICATION 1 (8) GHS Signal Word: GHS Hazard Phrases: GHS Precaution Phrases: GHS Response Phrases: GHS Storage and Disposal Phrases: Hazard Rating System: HMIS: Potential Health Effects (Acute and Chronic): Inhalation: Eye Contact: Skin Contact: Ingestion: Warning May cause respiratory irritation. Avoid breathing dust. Use only outdoors or in a well-ventilated area. In case of inadequate ventilation wear respiratory protection. Wear eye protection. Wash {hands} thoroughly after handling. Do not eat, drink or smoke when using this product. IF INHALED: Remove victim to fresh air and keep at rest in a position comfortable for breathing. IF IN EYES: Rinse cautiously with water for several minutes. remove contacts if present and easy to do so. Seek medical advice if eye irritation persists. IF ON SKIN: Wash with soap and water. Seek medical advice if skin irritation develops. Get medical attention/advice if you feel unwell. Store container in a well-ventilated place - out of direct sunlight and away from sources of heat. Dispose of contents/container in compliance with all local, state and Federal regulations. HEALTH 1 FLAMMABILITY PHYSICAL PPE E No data available. Flammability Health NFPA: 1 Instability May cause respiratory tract irritation. Can cause moderate injury (reddening and swelling). Mechanical irritation. Mechanical and chemical irritant. Special Hazard

2 CAS # Revision: 4/9/ COMPOSITION/INFORMATION ON INGREDIENTS Hazardous Components (Chemical Name) Aluminum oxide Emergency and First Aid Procedures: In Case of Inhalation: In Case of Skin Contact: In Case of Eye Contact: In Case of Ingestion: Signs and Symptoms Of Exposure: Concentration <85. % <15. % <15. % RTECS # BD12 Al2O3 WI28 8. EXPOSURE CONTROLS/PERSONAL PROTECTION NA Molecular Formula CH3(CH2)16CO2H Remove to fresh air. Remove victim to fresh air and keep at rest in a position comfortable for breathing. Immediately flush skin with plenty of water for at least 15 minutes. Immediately flush eyes with plenty of water for at least 15 minutes. Induce vomiting and seek immediate medical attention. Coughing and/or sneezing if dust is generated during use. Possible skin or eye irritant. Flash Pt: Explosive Limits: LEL: N/A UEL: N/A Autoignition Pt: Suitable Extinguishing Media:Dry chemical, CO2, water spray or regular foam. Unsuitable Extinguishing N/A Media: Fire Fighting Instructions: Wear proper protective clothing and self-contained breathing apparatus. Toxic vapors may be released. Flammable Properties and Keep away from excessive heat and sources of ignition. Hazards: Protective Precautions, Protective Equipment and Emergency Procedures: Steps To Be Taken In Case Material Is Released Or Spilled: Precautions To Be Taken in Handling: Precautions To Be Taken in Storing: Other Precautions: 4. FIRST AID MEASURES 5. FIRE FIGHTING MEASURES 6. ACCIDENTAL RELEASE MEASURES Avoid dust formation. Use suitable means to minimize dust generation, use vacuum. Dry sweeping in NOT recommended. 7. HANDLING AND STORAGE NA Page: 2 Use suitable means to minimize generating dust (i.e., vacuum). Dry sweeping in not recommended. Store away from sources of ignition. Do not store near heat sources abobe 1 deg.f. Wash thoroughly with soap and water after use. Follow established safety policies. CAS # Partial Chemical Name OSHA TWA ACGIH TWA Other Limits Aluminum oxide PEL: 15 (dust); 5 (resp.) mg/m3 TLV: 1 mg/m3 (E) 5 mg/m3 5 mg/m3

3 Respiratory Equipment (Specify Type): Eye Protection: Protective Gloves: Other Protective Clothing: Engineering Controls (Ventilation etc.): Revision: 4/9/215 NIOSH/MSHA approved respirator Page: 3 Goggles Rubber or neoprene gloves Full protective clothing or suit Ventilation is normally required when handling or using this product to keep exposure to airborne contaminants below the exposure limit. Physical States: [ ] Gas [ ] Liquid [ X ] Solid Appearance and Odor: Melting Point: WHITE BAR, SLIGHT SOLVENT ODOR Boiling Point: Autoignition Pt: Flash Pt: Explosive Limits: LEL: N/A UEL: N/A Specific Gravity (Water = 1): Vapor Pressure (vs. Air or mm Hg): Vapor Density (vs. Air = 1): Evaporation Rate: Solubility in Water: Solubility Notes: Percent Volatile: 9. PHYSICAL AND CHEMICAL PROPERTIES N.o data. Insoluble. 1. STABILITY AND REACTIVITY Stability: Conditions To Avoid - Unstable [ ] Stable [ X ] Instability: Keep away from excessive heat and sources of ignition. Incompatibility - Materials To No applicable information found. Avoid: Hazardous Decomposition Or No applicable information found. Byproducts: Possibility of Hazardous Reactions: Conditions To Avoid - Will occur [ ] Will not occur [ X ] Hazardous Reactions: No applicable information found. Toxicological Carcinogenicity/Other 11. TOXICOLOGICAL INFORMATION No applicable information found. IARC: No component of this product present at levels greater than or equal to.1% is identified as probable, possible or confirmed human carcinogen by IARC. NTP: No component of this product present at levels greater than or equal to.1% is identified as a known or anticipated carcinogen by NTP. OSHA: No component of this product present at levels greater than or equal to.1% is identified as a carcinogen or potential carcinogen by OSHA.

4 Revision: 4/1/215 Page: 4 Carcinogenicity: NTP? No IARC Monographs? No OSHA Regulated? No CAS # Hazardous Components (Chemical Name) NTP IARC ACGIH OSHA Aluminum oxide n.a. n.a. A4 n.a. n.a. n.a. n.a. n.a. n.a. n.a. n.a. n.a. General Ecological Waste Disposal Method: 12. ECOLOGICAL INFORMATION No applicable information found. 13. DISPOSAL CONSIDERATIONS Dispose according to Federal, state and local regulations. 14. TRANSPORT INFORMATION LAND TRANSPORT (US DOT): DOT Proper Shipping Name: DOT Hazard Class: UN/NA Number: Not dangerous goods. MARINE TRANSPORT (IMDG/IMO): IMDG/IMO Shipping Name: Not dangerous goods. UN Number: Hazard Class: AIR TRANSPORT (ICAO/IATA): ICAO/IATA Shipping Name: Not dangerous goods. Packing Group: Marine Pollutant: No EPA SARA (Superfund Amendments and Reauthorization Act of 1986) Lists CAS # Hazardous Components (Chemical Name) S. 32 (EHS) S. 34 RQ S. 313 (TRI) Aluminum oxide No No Yes No No No No No No This material meets the EPA 'Hazard Categories' defined for SARA Title III Sections 311/312 as indicated: CAS # [X] Yes [ ] No Acute (immediate) Health Hazard [ ] Yes [X] No Chronic (delayed) Health Hazard [ ] Yes [X] No Fire Hazard [ ] Yes [X] No Sudden Release of Pressure Hazard [ ] Yes [X] No Reactive Hazard Other US EPA or State Lists NJ EHS: Yes ; PA HSL: Yes - E NJ EHS: No; PA HSL: No NJ EHS: No; PA HSL: No Hazardous Components (Chemical Name) Aluminum oxide 15. REGULATORY INFORMATION

5 Page: 5 Revision: 4/9/215 CAS # Hazardous Components (Chemical Name) International Regulatory Lists Aluminum oxide Canadian DSL: Yes Canadian DSL: Yes Canadian DSL: Yes Revision Date: 4/9/215 Additional Information About No data available. This Product: Disclaimer/Statement of Liability 16. OTHER INFORMATION The information contained in this Safety Data Sheet is believed to be reliable. No guarantee is implied or expressed regarding the accuracy of this information. No warranty (whether for fitness for use or for merchant ability or otherwise) is given. Nothing contained herein should be construed as a recommendation to use this product in conflict with existing patents covering any material or its use. Regulatory requirements are subject to change and may differ from one location to another. It is the buyer's responsibility to ensure that all activities comply with Federal, State, and Local laws. The conditions of handling, storage, use, and disposal of the product are beyond our control and may be beyond our knowledge. For this reason and other reasons, we do not assume responsibility and expressly disclaim liability for loss, damage or expense arising out of or in any way connected with the handling, storage or disposal of the product.