Brizon Inc Safety Data Sheet

Transcription

1 1 Special Note: This product is totally biodegradable 1. GENERAL INFORMATION Manufacturer Manufacturer address 530 Corporate Drive Suite C Information Emergency Chemtel: (USA, Canada and Virgin Island) Generic Name Briteclean-3D 2. COMPONENTS/INGREDIENTS COMPONENT NAME CAS No. Chemical Formula %(wt) Water H 2 O Balanced Surfactant mixture Proprietary Proprietary <20% Metal Chelate agent Proprietary Proprietary <20% Corrosive Inhibitor Surfactant* Proprietary Proprietary <20% *Non-Hazmat, TSCA 3. PHYSICAL AND CHEMICAL CHARACTERISTICS Specific Gravity: (H 2 O = 1.0 at 4C) Color Very light Yellow, Transparent Odor Flash Point: Not applicable Boiling Point: Not appliable Water Solubility: Completely soluble Viscosity at 25 o C Cps ph: HAZARDS IDENTIFICATION Route of Entry Acute Health Hazards (Short - Term) Chronic Health Effects (Long - Term) Medical Condition, Eyes. No specific information available. No specific information available. Eye Contact May cause eye irritation Skin Contact May cause skin irritation This material contains no listed carcinogens according to IARC, ACGIH, NTP and/or OSHA in concentrations of 0.1 percent or greater. Adverse skin effects, and eye effects. *Classification of the substance or mixture: Skin irritation, Category 2, H315 Eye irritation, Category 2B, H320 Skin sensitization, Sub-category 1B, H317 For the full text of H-statement mentioned in this section, please refer section 16 Supplemental Hazard Staement: High temerature processing of this chemical materials may release vapor and/or fumes which cause eye, skin and respiratory tract irritation

2 2 GHS Labelling: Hazard Pictograms: Signal Word: Exclamation Hazard Statement: H315 +H320: Cause skin and eye irritation H317: May cause an allergic reaction Precautionary statements: Prevention: P261 : Avoid breathing gas/mist/vapors/spray. P264 : Wash skin thoroughly after handling. P272 : Contaminated work clothing should not be allowed out of the workplace. P280 : Wear protective gloves. Response: P302 + P352 : IF ON SKIN: Wash with plenty of soap and water. P305 + P351 + P338 : IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. P333 + P313 : If skin irritation or rash occurs: Get medical advice/ attention. P337 + P313 : If eye irritation persists: Get medical advice/ attention. P362 : Take off contaminated clothing and wash before reuse. Disposal: P501 : Dispose of contents/ container to an approved waste disposal plant. Supplemental information: Potential Health Effects: Effects due to processing releases: Irritating to eyes, respiratory system and skin if heated over 100 o c. Prolonged or repeated exposure may cause: headache, drowsiness, nausea, weakness, (severity of effects depends on extent of exposure). 5. FIRST AID MEASURES Move to fresh air Prevent aspiration of vomit and turn victim s head to the side. Seek medical attention. Eye Contact Rinse immediately with plenty of water also under the eyelids for at least 20 minutes, remove the contact lenses. Skin Contact Wash off immediately with plenty of water for at least 20 minutes. If needed, seek medical attention.

3 3 6. FIRE FIGHTING MEASURES Autoignition Temperature Flammability Limits in Air Lower, % by volume Upper, % by volume Explosion Data Sensitivity to static discharge Not expected Fire & Explosion Hazards Hazardous Combustion Products T.D.G. Flammability Class Extinguishing Media Special Fire Fighting Procedures 7. ACCIDENTAL RELEASE MEASURES Sensitivity to impact Not applicable Flash back possible over considerable distance. Fire or intense heat may violent rupture of packages. Oxides of carbon (CO, CO 2, N 2 ) Not applicable. Dry chemical, carbon dioxide, foam, dry sand and limestone powder. Remove all ignition sources. Firefighter should wear the proper protection when entering confined areas where potential for exposure to products of combustion exists. Personal Precautions For Small Spills (i.e. <1 pound) For Large Spills (i.e. >1 pound) Before cleaning any spill(s) or leak(s), individuals involved in spill cleanup must wear appropriate Personal Protective Equipment. Wear suitable protaction clothing gloves and eye/face protaction. Remove spilled material with absorbent material and place into appropriate closed container(s) for disposal. Dispose of properly in accordance with local, state and federal regulations. Wash all affected area(s) and outside container(s) with plenty of soap and water. Remove any contaminated clothing and wash thoroughly before reuse. Recover the large spill with inert materials(e.g. sand or earth). Transfer the liquid to container(s) for recovery or disposal, and solid inert material(s) to separate container(s) for proper disposal. Do not walk on contaminated surface unnecessarily. 8. HANDLING & STORAGE INFORMATION Equipment Storage Need Avoid eye and skin contact. Maintain good personal hygiene. Use adequate ventilation. Wash exposed skin thoroughly with plenty of soap and water after using this product. Do not eat or drink while handling this product. Keep away from heat, acid and base materials. Store in a cool and well ventilated area. Keep away from incompatible materials. Do not store in damaged or unmarked containers or storage devices. Keep container securely closed when not in use. Open slowly on a level stable surface. Empty containers may contain residual amount of this material, therefore, empty container should be handle with care. Keep away from children at all times.

4 4 9. EXPOSURE CONTROL / PERSONAL PROTECTION Ventilation Equipments Personal Other Hygienic Practices Provide natural or explosion-proof ventilation adequate to ensure concentrations are kept below exposure limits. Ensure appropriate decontamination equipment is available. Use explosion proof equipment. Provide readily accessible eye wash stations and safety showers Respiratory Eye Skin No occupational exposure standards have been developed for this material. Where exposure through inhalation may occur from use, NIOSH/MSHA approved respiratory protection equipment is recommended, if needed. Avoid eye contact. Wear chemical protective eyewear at all time when handling this material. required under normal condition of use. When handling large quantities and skin contact is possible, protective clothing including gloves, sleeves, boots, head and face protection should be worn. This equipment must be cleaned thoroughly before each use. Eye wash facility should be in close proximity. When handling large quantities, safety showers should be available in the immediate vicinity of any potential exposure. 10. STABILITY & REACTIVITY Stability Hazardous Decomposition Products Condition to Avoid Incompatible Chemicals This material is stable under ambient conditions when stored properly. Unstable at high temperatures. Fumes produced upon decomposition may include irritating vapors and toxic gases. Extreme temperatures and incompatable chemicals/substances. 11. TOXICOLOGICAL INFORMATION Skin Eye Irritation/Corrosion Acute dermal Suspected Carcinogen Reproductive Toxicity Biological Exposure Indices Physician Recommendation Data not avaliable Data not avaliable Contact to eyes may cause irritation Not available Not available Treat symptomatically 12. ECOLOGICAL INFORMATION Environmental Stability Effects on Plants and Animals Effects on Aquatic Life available available available. Release of large volumes may be harmful or fatal to aquatic life.

5 13. DISPOSAL CONSIDERATIONS 5 Waste Disposal In accordance with local, state, and federal hazardous waste laws. Follow company policies and procedures. 14. TRANSPORTATION INFORMATION US Dot Proper Shipping Name Canadian TDG Classification Shipment by Sea Air Transport ICAO/IATA 15. REGULATORY INFORMATION EC EINECS USA TSCA USA FDA Canada DSL Australia AICS Japan ENCS New Zealand South Korea China EPA SARA Title III section 312(40CFR370) EPA SARA Title III section 313(40CFR372) US. CA. Safe Drinking water &toxic Enforce ACT (Proposition 65) WHMIS Hazard Classification Acute Health Hazard and Fire Hazard This product does not contain any chemical known to the state of CA to cause cancer, birthdefects or other harm. Harmless liquid 16. OTHER INFORMATION Health Flammability Reactivity Protective Equipment HIMS-Ratings A HMIS Hazard Ratings NFPA Hazard Ratings 4 = severe 4 = extreme 3 = serious 3 = high 2 = moderate 2 = moderate 1 = slight 1 = slight 0 = minimal 0 = insignificant N = no rating for powders N = no rating for powders Disclaimer Some of the information presented and conclusions draw herein are from sources other than direct test data on the product itself. The information in this MSDS document was obtained from sources which we believe are reliable. However, the information is provided without any warranty, express or implied, regarding its correctness. The conditions or methods of handling, storage, use and disposal of the product are beyond our control and may be beyond our knowledge. For this and other reasons, we do not assume responsibility and expressly disclaim liability for loss, damage or expense arising out of or in any way connected with the handling, storage, use or disposal of the products. Data may change from time to time. Be sure to consult the latest revision.