Product Safety Data Sheet

Transcription

1 Product Safety Data Sheet Document Code: SD AU Version: 7.0 Description: Exit Mould Status: Published Revision Reason: PSDS update. Issue Date: 03 Feb 2012 PSDS PSDS PAGE 1 OF TOTAL 6 1. PRODUCT and COMPANY IDENTIFICATION Product Name Other Names Recommended Use Exit Mould None Bathroom surface cleaner Supplier AUSTRALIA COMPANY: Reckitt Benckiser (Australia) Pty Limited ABN: ADDRESS: 44 Wharf Road West Ryde NSW 2114 TELEPHONE: (02) AFTER HOURS EMERGENCY TELEPHONE (5pm to 8am EST Australia): (02) NEW ZEALAND COMPANY: Reckitt Benckiser (New Zealand) Limited ADDRESS: Lincoln Manor 289 Lincoln Road Henderson Auckland 1231 TELEPHONE: (09) Poisons Centre Information AUSTRALIA NEW ZEALAND or 0800 POISON KOREA COMPANY: Reckitt Benckiser Korea ADDRESS: #650 Sukamdong Iksan Junbuk Korea, TELEPHONE: /02/ :06:33 GMT Page 1 Product Safety Data Sheet SD AU

2 2. HAZARD(S) IDENTIFICATION HAZARDOUS ACCORDING TO CRITERIA OF NOHSC NONDANGEROUS GOODS ACCORDING TO ADG CODE (See Section 14) RISK PHRASE(S) R41 Risk of serious eye damage. (See Section 15) R37/38 Irritating to respiratory system and skin. ENVIRONMENTAL RISK PHRASE None SAFETY PHRASE(S) S2 Keep out of the reach of children. S24/25 Avoid contact with eyes and skin. S26 In case of contact with eyes, rinse immediately with plenty of water and seek medical advice. S28 After contact with skin, wash immediately with plenty of water. S37/39 Wear rubber gloves and eye/face protection. S46 If swallowed seek medical advice immediately and show this container or label. S50 Do not mix with acids, bleach products or other household cleaners S51 Use only in wellventilated areas. 3. COMPOSITION / INFORMATION ON INGREDIENTS Chemical Name CAS No Proportion (% w/w) Sodium hypochlorite g/L (as available chlorine) Sodium hydroxide <1 2.4g/L Alkaline salts <1 1.2g/L Nonionic surfactant <1 Other ingredients classified as not hazardous according to NOHSC to FIRST AID MEASURES Eye Contact Skin Contact Inhalation Ingestion Advice to Doctor If in eyes, hold eyelids apart and flush the eye continuously with running water. Continue flushing until advised to stop by the Poison Information Centre or a doctor, or for at least 15 minutes. If skin contact, remove contaminated clothing and flush skin with running water. Remove person to fresh air. If breathing difficulties are experienced, seek medical attention. If swallowed, do NOT induce vomiting. Give 2 glasses of water to drink. Contact a doctor or a Poisons Information Centre. Treat symptomatically. 5. FIREFIGHTING MEASURES Specific Dangers Flammability Extinguisher Type May release hydrochloric acid and chlorine fumes with decomposition. Not flammable. Water, foam, carbon dioxide or dry chemical. 21/02/ :06:33 GMT Page 2 Product Safety Data Sheet SD AU

3 Hazchem code None allocated. 6. ACCIDENTAL RELEASE MEASURES Emergency and Evacuation Procedures Ensure adequate ventilation. Minor Spills Major Spills Soak up product with a wet cloth and wash area with water. Contain spill. Collect with a suitable absorbent such as sand. Shovel into clean, dry, labelled containers and close lids tightly. Do not allow material to enter waterways. 7. HANDLING AND STORAGE Handling Storage Avoid contact with skin and eyes. Store in a cool dry area out of direct sunlight. 8. EXPOSURE CONTROLS / PERSONAL PROTECTION Exposure Standards Australia ingredients: Exposure Standards (1) have been set for the following Ingredient CAS No. (a) TWA STEL Carcinogen ppm (b) mg/m 3(c) ppm (b) mg/m 3(c) Category Notices Sodium hydroxide peak limitation Chlorine peak limitation Exposure Standards New Zealand ingredients: Exposure Standards (3) have been set for the following Ingredient CAS No. (a) TWA STEL ppm (b) mg/m 3(c) ppm (b) mg/m 3(c) Sodium hydroxide Ceiling 2mg/m 3 Chlorine TWA = Time Weighted Average STEL= Short Term Exposure Limit (1) Worksafe Australia Exposure Standards for Atmospheric Contaminants in the Occupational Environment [NOHSC: )] (3) Workplace Exposure Standards endorsed by the Occupational Safety and Health Service (OSH) of the Department of Labour; Revised: July 2011 (a) CAS #, Chemical Abstracts Service Registry. A unique numbering identifier is assigned to each individual chemical. (b) Parts of vapour or gas per million of contaminated air by volume at 25 C and 760 torr. (c) Milligrams of substance per cubic metre of air. (2) Chlorine is a decomposition product from hypochlorite only after strong acidification. Under normal conditions minimal hazardous decomposition products are released. Ceiling = (WES Ceiling) = A concentration that should not be exceeded during any part of the working day. 21/02/ :06:33 GMT Page 3 Product Safety Data Sheet SD AU

4 Engineering Controls Personal Protection Ensure adequate ventilation. Use in well ventilated areas. Maintain air concentrations below exposure standards. When handling bulk quantities, wear suitable gloves, safety glasses and protective clothing. If ventilation is insufficient, a suitable respirator should be worn. Work/Hygienic Practices Wash thoroughly with soap and water after handling. 9. PHYSICAL AND CHEMICAL PROPERTIES Physical State Appearance Liquid Clear, pale yellow / green liquid with chlorine odour ph > 12 (neat) at 25 C Vapour Pressure Boiling Point Freezing/Melting Point Solubility in Water 2.3 kpa (water) 100 C (water) Not available Miscible Specific Gravity at 25 C Flashpoint Viscosity Not determined Not available Available Chlorine (as Cl 2 ) % (w/v) Stability Dangerous Reactions Incompatible Materials 10. STABILITY AND REACTIVITY Stable under normal conditions. Will react with acids to release chlorine gas. Do not use together with other products. May release dangerous gases (chlorine). Decomposition Products chloride. Products may include oxides of carbon, chlorine and hydrogen 11. TOXICOLOGICAL INFORMATION Acute Effect(s) Eye Skin Inhaled Swallowed Sensitisation Will cause severe irritation to the eye. Risk of serious eye damage. Will cause irritation to the skin with prolonged/repeated contact. If chlorine vapours are released, will cause irritation to the respiratory system. May cause irritation to the upper gastrointestinal tract. Not expected to be a skin sensitiser. 21/02/ :06:33 GMT Page 4 Product Safety Data Sheet SD AU

5 Chronic Effect(s) Toxicity Information The chronic toxicity of this product has not been determined. Information is based on available component data and toxicity result of similar product. 12. ECOLOGICAL INFORMATION Ecotoxicity Based on component ecotoxicity data the product is not an environmental hazard. However, the alkalinity of the product would result in adverse effects, especially in aquatic environments. 13. DISPOSAL CONSIDERATIONS Disposal Method Product should be treated according to the instructions given under sections 6,7 and 8 above. Dispose of according to Local, State and Federal regulations. Contact relevant authority for details. 14. TRANSPORT INFORMATION Road Transport Regulations (ADG) UN number: None allocated Proper shipping name: None allocated DG class: Not a DG Subsidiary risk: None allocated Packing group: None allocated Hazchem code: None allocated Maritime Transport Regulations (IMDG) UN number: None allocated Proper shipping name: None allocated DG class: Not a DG Subsidiary risk: None allocated Packing group: None allocated Marine Pollutant: Not a Marine Pollutant Air Transport Regulations (IATA) UN number: None allocated Proper shipping name: None allocated DG class: Not a DG Subsidiary risk: None allocated Packing group: None allocated 15. REGULATORY INFORMATION AUSTRALIA Regulatory Status Not applicable. Hazardous Substances Regulation Hazardous Risk Phrase(s) R41 Risk of serious eye damage. R37/38 Irritating to respiratory system and skin. Safety Phrase(s) S2 Keep out of the reach of children. S24/25 Avoid contact with eyes and skin. 21/02/ :06:33 GMT Page 5 Product Safety Data Sheet SD AU

6 S26 In case of contact with eyes, rinse immediately with plenty of water and seek medical advice. S28 After contact with skin, wash immediately with plenty of water. S37/39 Wear rubber gloves and eye/face protection. S46 If swallowed seek medical advice immediately and show this container or label. S50 Do not mix with acids, bleach products or other household cleaners S51 Use only in wellventilated areas. SUSMP NEW ZEALAND Regulatory Status Approved Handler Tracking S5 (Sodium hypochlorite, Sodium hydroxide, Alkaline salt) This product has been approved under HSNO covered by Cleaning Products Group Standard 2006 HSR Not required Not required 16. OTHER INFORMATION CONTACT POINT AUSTRALIA and NEW ZEALAND Regulatory, Safety & Environmental Services From outside Australia Ph: (61) (2) From within Australia Ph: (02) The information contained in this MSDS was compiled using the latest and most reliable information available to Reckitt Benckiser. The information is provided without any warranty, expressed or implied regarding its correctness or accuracy. Similarly no warranty expressed or implied regarding the product described herein shall be created by or inferred from any statement or omission from this MSDS nor will Reckitt Benckiser assume any liability for any loss or damage arising out of the use of this information. It is solely the responsibility of the user to determine safe conditions for use of this product and to assume liability for any loss, damage or expense whatsoever arising out of the product's improper use. KEY/LEGEND ADG = Australian Code for the Transport of Dangerous Goods by Road and Rail DG = Dangerous Goods HSNO = Hazardous Substances and New Organisms Act 1996 (New Zealand) IATA = International Air Transport Association IMDG = International Maritime Dangerous Goods NOHSC = National Occupational Health and Safety Commission (Australia) SUSMP = Standard for the Uniform Scheduling of Medicines and Poisons (Australia) This document is only current on the day of viewing. Printed copies are UNCONTROLLED unless they are a part of a Quality/ Technical Manual or attached to a letter referring to Purchase Order Number. END OF DOCUMENT. 21/02/ :06:33 GMT Page 6 Product Safety Data Sheet SD AU