SAFETY DATA SHEET FREESTYLE SF Beverage Base Part

Transcription

1 1. Identification Product identifier used on the label Other means of identification Recommended use of the chemical and restrictions on use Name, address, and telephone number of the chemical manufacturer, importer, or other responsible party Emergency phone number L-X Mixture for the manufacture of beverages The Coca-Cola Company, One Coca-Cola Plaza, Atlanta, GA 30313, USA. Atlanta Cidra (USA) 2. Hazard(s) identification Classification of the chemical in accordance with paragraph (d) of Serious Eye Damage/Eye Irritation Category 2 Flammable Liquid Category 3 Hazard Symbol(s) Signal Word Hazard Statement(s) Precautionary Statement(s) Prevention Response Warning H226 - Flammable liquid and vapor. H319 - Causes serious eye irritation. P210 - Keep away from heat/sparks/open flames/hot surfaces. No smoking. P233 - Keep container tightly closed. P240 - Ground/bond container and receiving equipment. P241 - Use explosion-proof electrical/ventilating/lighting equipment. P242 - Use only non-sparking tools. P243 - Take precautionary measures against static discharge. P264 - Wash hands thoroughly after handling. P280 - Wear protective gloves, protective clothing, eye protection and face protection. P303+P361+P353 - IF ON SKIN (or hair): Take off immediately all contaminated clothing. Rinse skin with water/shower. P305+P351+P338 - If in eyes: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. Page 1 of 7

2 Storage Disposal Other hazards P337+P313 - If eye irritation persists: Get medical advice/attention. P370+P378 - In case of fire: use extinguishing media listed in Section 5 of the SDS for extinction. P403+P235 - Store in a well-ventilated place. Keep cool. P501 - Dispose of contents and container in accordance with local/regional/national/international regulations. 3. Composition/information on ingredients Chemical Name CAS # Classification ( ) ethanol Eye Irrit. 2; H319 Flam. Liq. 2; H225 Concentration % w/w %w/w The specific chemical identity and/or exact percentage (concentration) of composition has been withheld as a trade secret. 4. First-aid measures Description of necessary measures Inhalation Skin contact Eye contact Ingestion Most important symptoms/effects, acute and delayed. Indication of any immediate medical attention and special treatment needed, if necessary If overcome by exposure, remove victim to fresh air immediately. Seek medical attention. Wash skin thoroughly with water. Seek medical attention if ill effect or irritation develops. Remove any contact lenses at once. Flush eyes well with large quantities of water for at least 15 minutes. Seek medical attention. For small amounts, give a glass or two of water or milk to dilute substance. For large quantities, induce vomiting. CAUTION: NEVER INDUCE VOMITING IF A PERSON IS UNCONSCIOUS. If signs or symptoms of overexposure persist, seek medical attention. Get medical attention if you feel unwell. Get medical attention if you feel unwell. 5. Fire-fighting measures Suitable (and unsuitable) extinguishing media Page 2 of 7

3 Suitable extinguishing media Unsuitable extinguishing media Special hazards arising from the chemical Special protective equipment and precautions for fire-fighters Water, carbon dioxide, dry chemical or foam. High volume water jet. Under fire conditions, this product may release carbon monoxide, carbon dioxide and other decomposition products of undetermined hazards. As with any fire situation, full face, self-contained breathing apparatus and appropriate protective clothing should be worn. 6. Accidental release measures Personal precautions, protective equipment and emergency procedures Methods and materials for containment and cleaning up NO SMOKING. Eliminate other ignition sources. Provide clean-up workers with protective clothing and, when necessary, chemical resistant gloves equivalent to Neoprene/PVC. Safety glasses with side guards should be worn to prevent injury from flying particles and/or other eye contact with this product. Leaking containers should be moved to a dry, well-ventilated area. Isolate spill area. Use handling and disposal procedures appropriate for the spent absorbent material. 7. Handling and storage Precautions for safe handling Conditions for safe storage, including any incompatibilities Avoid eye and skin contact. As with all semi-finished materials, prudent industrial practices should be employed to minimize contact with eyes, skin and mucous membranes. Protect against physical damage to containers. Store in closed containers away from heat, caustics and oxidizing materials or any sources of ignition. Not applicable Do not use compressed air to transfer contents of container. 8. Exposure controls/personal protection Control parameters Substances OSHA PEL ACGIH TLV ethanol 1000 ppm STEL 1000 ppm TWA; 1900 mg/m3 TWA Appropriate Engineering controls Use appropriate engineering controls such as Local Extraction Ventilation when handling this product. It is recommended that a health and safety risk assessment of the immediate area is performed. Individual protection measures, such as personal protective equipment - Respiratory protection No special respiratory protection equipment is recommended under normal conditions of anticipated use with adequate ventilation. - Eye protection Safety glasses with side guards should be worn to prevent injury from flying particles and/or other eye contact with this product. Page 3 of 7

4 - Skin protection - Hand protection Wear suitable gloves resistant to chemical penetration appropriate to the conditions of use. - Other Skin protection appropriate to the conditions of use. 9. Physical and chemical properties Information on basic physical and chemical properties Appearance Color Odor Odor threshold ph 7.1 Melting point/freezing point Initial boiling point and boiling range Flash point Evaporation Rate Flammability (solid, gas) Upper/lower flammability or explosive limits Clear liquid Colorless (clear) Alcohol >35 C Vapor pressure at 50 C (kpa) <50 Vapor pressure at 55 C (kpa) <50 Vapor Density Relative Density at 20 C 1.0 Solubility(ies) Partition coefficient: n- octanol/water Auto-ignition temperature Decomposition temperature Viscosity Other information Wick Test (seconds) Setaflash Open Cup Test (seconds) >45 C ASTM D 93 Pensky-Martens Closed Cup Not determined 15 (Supports Combustion) 10. Stability and reactivity Reactivity Chemical stability Stable Page 4 of 7

5 Possibility of hazardous reactions None known Conditions to avoid Incompatible materials Hazardous decomposition products None Strong alkalis, strong oxidizing agents and other incompatible materials. None known 11. Toxicological information Likely routes of exposure (inhalation, ingestion, skin and eye contact) Symptoms related to the physical, chemical and toxicological characteristics; (a) Acute toxicity; (b) Skin corrosion/irritation; (c) Serious eye damage/irritation; ph 7.1 Classification is based on ph and the components listed in Section 3. (d) Respiratory or skin sensitization; (e) Germ cell mutagenicity; (f) Carcinogenicity; (g) Reproductive toxicity; (h) STOT-single exposure; (i) STOT-repeated exposure; (j) Aspiration hazard; Has the chemical been classified as a Carcinogen by NTP, IARC or OSHA? None of the ingredients have been shown to cause cancer. Page 5 of 7

6 12. Ecological information Ecotoxicity (aquatic and terrestrial, where available) Persistence and degradability Bioaccumulative potential Mobility in soil Other adverse effects None known 13. Disposal considerations Waste treatment methods This product has the hazards indicated in Section 2 and it may be subject to restrictions under national or local law. Consult your legal and/or environmental advisor to ensure compliance with applicable requirements when disposing of waste product or its packaging. 14. Transportation information UN Number UN 1993 UN proper shipping name Flammable liquid, n.o.s. (Ethanol) Transport hazard class(es) 3 Packing group, if applicable PG III (> 45.0 C) Environmental hazards No Transport in bulk (according to Annex Not applicable II of MARPOL 73/78 and the IBC Code) Special precautions which a user needs to be aware of, or needs to comply with, in connection with transport or conveyance either within or outside their premises 15. Regulatory information Regulated Components: Handle in accordance with instructions given in Sections 5, 6, 7 and 8. Because of the hazard characteristics noted above and in Sections 2 and 3, transportation of this product may be regulated under the DOT(road), IMDG Code(sea), IATA(air) and national laws that incorporate the requirements of one or more of those international modal codes. Chemical Name CAS number TSCA CERCLA SARA EHS SARA 313 U.S. HAP California Prop 65 ethanol Yes No No No No Yes 16. Other information Page 6 of 7

7 The information contained in this Safety Data Sheet is considered accurate as of the version date and based on the best information currently available to the Company. However, no representations or warranties are expressed or implied regarding the accuracy of the information. The use of the information must be determined by the User/Recipient to be in accordance with applicable local laws and regulations. It is the User/Recipient s obligation to determine the suitability of the product for its intended application and the Company assumes no legal responsibility for the use of the information by the User/Recipient. End of document Page 7 of 7