1. Substance/preparation and manufacturer/supplier identification. MasterFinish RL 211 also RHEOFINISH 211

Transcription

1 Safety data sheet Page: 1/8 1. Substance/preparation and manufacturer/supplier identification MasterFinish RL 211 also RHEOFINISH 211 Use: Product for construction chemicals Manufacturer/supplier: BASF Australia Limited (ABN ) Level 12, 28 Freshwater Place Southbank Victoria 3006, AUSTRALIA Telephone: Telefax number: Emergency information: BASF Emergency Advice Number: (24h) [within Australia] BASF Emergency Advice Number: [outside Australia] 2. Hazard identification Classification of the substance and mixture: No need for classification according to GHS criteria for this product. Label elements and precautionary statement: The product does not require a hazard warning label in accordance with GHS criteria. Other hazards which do not result in classification: If applicable information is provided in this section on other hazards which do not result in classification but which may contribute to the overall hazards of the substance or mixture. May produce an allergic reaction. Contains: 1,2-BENZISOTHIAZOL-3(2H)-ONE

2 Page: 2/8 3. Composition/information on ingredients Chemical nature Emulsion based on: vegetable oils, in water No particular hazards known. 4. First-Aid Measures General advice: First aid personnel should pay attention to their own safety. Immediately remove contaminated clothing. If inhaled: If difficulties occur after vapour/aerosol has been inhaled, remove to fresh air and seek medical attention. On skin contact: After contact with skin, wash immediately with plenty of water and soap. Under no circumstances should organic solvent be used. If irritation develops, seek medical attention. On contact with eyes: Wash affected eyes for at least 15 minutes under running water with eyelids held open, consult an eye specialist. On ingestion: Rinse mouth immediately and then drink plenty of water, seek medical attention. Do not induce vomiting unless told to by a poison control center or doctor. Note to physician: Symptoms: The most important known symptoms and effects are described in the labelling (see section 2) and/or in section 11. Treatment: Treat according to symptoms (decontamination, vital functions), no known specific antidote. 5. Fire-Fighting Measures Suitable extinguishing media: foam, water spray, dry powder, carbon dioxide Unsuitable extinguishing media for safety reasons: water jet Specific hazards: carbon dioxide, carbon monoxide, harmful vapours, nitrogen oxides, fumes/smoke, carbon black Special protective equipment: Wear a self-contained breathing apparatus.

3 Page: 3/8 Further information: The degree of risk is governed by the burning substance and the fire conditions. If exposed to fire, keep containers cool by spraying with water. Collect contaminated extinguishing water separately, do not allow to reach sewage or effluent systems. Contaminated extinguishing water must be disposed of in accordance with official regulations. 6. Accidental Release Measures Personal precautions: Do not breathe vapour/aerosol/spray mists. Wear eye/face protection. If exposed to high vapour concentration, leave area immediately. Use personal protective clothing. Handle in accordance with good building materials hygiene and safety practice. Environmental precautions: Contain contaminated water/firefighting water. Do not discharge into drains/surface waters/groundwater. Methods for cleaning up or taking up: For small amounts: Pick up with inert absorbent material (e.g. sand, earth etc.). Dispose of contaminated material as prescribed. For large amounts: Pump off product. 7. Handling and Storage Handling Wear respiratory protection when spraying. Avoid inhalation of mists/vapours. Avoid skin contact. Wear suitable protective clothing and eye/face protection. No special measures necessary provided product is used correctly. Storage Suitable materials for containers: High density polyethylene (HDPE), Carbon steel (Iron) Further information on storage conditions: Keep only in the original container in a cool, dry, wellventilated place away from ignition sources, heat or flame. Protect from direct sunlight. Protect from temperatures below: 5 C The packed product must be protected from temperatures below the indicated one. Protect from temperatures above: 30 C 8. Exposure controls and personal protection Components with occupational exposure limits Rape oil, ; TWA value 10 mg/m3 (AU NOEL), Inhalable mist

4 Page: 4/8 Personal protective equipment Respiratory protection: Wear respiratory protection if ventilation is inadequate. Combination filter for gases/vapours of organic, inorganic, acid inorganic and alkaline compounds (e.g. EN Type ABEK). Hand protection: impermeable gloves Synthetic rubber gloves Manufacturer's directions for use should be observed because of great diversity of types. Eye protection: Safety glasses with side-shields (frame goggles) (e.g. EN 166) Body protection: light protective clothing General safety and hygiene measures: Do not inhale gases/vapours/aerosols. Avoid contact with the skin, eyes and clothing. Avoid exposure - obtain special instructions before use. Handle in accordance with good building materials hygiene and safety practice. Wearing of closed work clothing is recommended. When using, do not eat, drink or smoke. Hands and/or face should be washed before breaks and at the end of the shift. At the end of the shift the skin should be cleaned and skin-care agents applied. Gloves must be inspected regularly and prior to each use. Replace if necessary (e.g. pinhole leaks). 9. Physical and Chemical Properties Form: Colour: Odour: Odour threshold: liquid white mild No applicable information available. ph value: Melting point: approx. -4 C boiling temperature: > 100 C Flash point: Evaporation rate: A flash point determination is unnecessary due to the high water content. not determined Flammability (solid/gas): not flammable Thermal decomposition: No decomposition if stored and handled as prescribed/indicated. Vapour pressure: The product has not been tested.

5 Page: 5/8 Density: 0.96 g/cm3 Relative vapour density (air): not determined Miscibility with water: Viscosity, dynamic: Viscosity, kinematic: miscible approx. 10 mpa.s > 7 mm2/s Other Information: If necessary, information on other physical and chemical parameters is indicated in this section. 10. Stability and Reactivity Conditions to avoid: See MSDS section 7 - Handling and storage. Thermal decomposition: No decomposition if stored and handled as prescribed/indicated. Substances to avoid: strong acids, strong bases, strong oxidizing agents, strong reducing agents Corrosion to metals: No corrosive effect on metal. Hazardous reactions: The product is stable if stored and handled as prescribed/indicated. No hazardous decomposition products if stored and handled as prescribed/indicated. 11. Toxicological Information Acute toxicity Assessment of acute toxicity: Virtually nontoxic after a single ingestion. Based on available Data, the classification criteria are not met. Irritation Assessment of irritating effects: No irritation is expected under intended use and appropriate handling. Based on available Data, the classification criteria are not met.

6 Page: 6/8 Respiratory/Skin sensitization Assessment of sensitization: Based on available Data, the classification criteria are not met. Germ cell mutagenicity Assessment of mutagenicity: The chemical structure does not suggest a specific alert for such an effect. Based on available Data, the classification criteria are not met. Carcinogenicity Assessment of carcinogenicity: The chemical structure does not suggest a specific alert for such an effect. Based on available Data, the classification criteria are not met. Reproductive toxicity Assessment of reproduction toxicity: The chemical structure does not suggest a specific alert for such an effect. Based on available Data, the classification criteria are not met. Developmental toxicity Assessment of teratogenicity: The chemical structure does not suggest a specific alert for such an effect. Based on available Data, the classification criteria are not met. Repeated dose toxicity and Specific target organ toxicity (repeated exposure) Assessment of repeated dose toxicity: No reliable data was available concerning repeated dose toxicity. Based on available Data, the classification criteria are not met. Aspiration hazard No aspiration hazard expected. Other relevant toxicity information Based on our experience and the information available, no adverse health effects are expected if handled as recommended with suitable precautions for designated uses. The product has not been tested. The statements on toxicology have been derived from the properties of the individual components. 12. Ecological Information Ecotoxicity Assessment of aquatic toxicity:

7 Page: 7/8 Based on available Data, the classification criteria are not met. There is a high probability that the product is not acutely harmful to aquatic organisms. Mobility Assessment transport between environmental compartments: No data available. Persistence and degradability Assessment biodegradation and elimination (H2O): The polymer component of the product is poorly biodegradable. Elimination information: > 70 % (28 d) Readily biodegradable (according to OECD criteria). Bioaccumulation potential Assessment bioaccumulation potential: Discharge into the environment must be avoided. Additional information Other ecotoxicological advice: Do not discharge product into the environment without control. The product has not been tested. The statements on ecotoxicology have been derived from the properties of the individual components. 13. Disposal Considerations Observe national and local legal requirements. Residues should be disposed of in the same manner as the substance/product. Contaminated packaging: Contaminated packaging should be emptied as far as possible; then it can be passed on for recycling after being thoroughly cleaned. 14. Transport Information Domestic transport: Not classified as a dangerous good under transport regulations Sea transport IMDG Not classified as a dangerous good under transport regulations Air transport IATA/ICAO Not classified as a dangerous good under transport regulations

8 Page: 8/8 15. Regulatory Information Other regulations If other regulatory information applies that is not already provided elsewhere in this safety data sheet, then it is described in this subsection. Standard for the Uniform Scheduling of Medicines and Poisons (SUSMP): Not Scheduled Registration status: AICS, AU released / listed 16. Other Information Vertical lines in the left hand margin indicate an amendment from the previous version. The data contained in this safety data sheet are based on our current knowledge and experience and describe the product only with regard to safety requirements. The data do not describe the product's properties (product specification). Neither should any agreed property nor the suitability of the product for any specific purpose be deduced from the data contained in the safety data sheet. It is the responsibility of the recipient of the product to ensure any proprietary rights and existing laws and legislation are observed.