TECHNICAL CHARACTERSTICS

Size: px
Start display at page:

Download "TECHNICAL CHARACTERSTICS"

Transcription

1 and solenoid valves spool version GM - GL series Type of valves with dorsal consumption: GM-...series with integrated connections GL-...series without connections TECHNICAL CHARACTERSTICS Ambient temperature: C. Fluid temperature: 50 C max. Fluid: filtered air 50 µm not dehumified or neutral gases with or without lubrication. Switching system: spool Body: die-cast zamak. Valve function: 5/2-5/3-3/2+3/2. Pressure: 1,5 9 bar. Flow rate: 740 NI/min 5/2 670 NI/min 5/3, 640 NI/min 3/2+3/2. Control: indirect electropneumatic or pneumatic. Return: mechanical spring, pneumomechanical spring (GM series), pneumatic spring (GL series). Seals: nitrile rubber. Coils: GM series: 24 Vdc-2 W standard; 12 Vdc-2,5 W upon request. GL series: see codification key on page 45. Protection: IP65. Manifold sub-base and end plates in self-extinguishing plastic IXEF. Fittings according to UNIVER design, straight, low or high at 90 for tube Ø mm with fixing plate. Solenoid valves 5/2-5/3-3/2 + 3/2 spool system for sub-plate mounting Female Sub D flying connector with cable (see page 50) Modular tierods places Manifold sub-base Standard supplied with 24Vdc coil and connector Silencers Threaded and/or closing end plate* Fixing plate for fittings BUS card connection Diaphragm prearranged for integrated connection Fittings according to UNIVER design, straight, low or high 90 for tube ø mm Lifting bracket Threaded endplate* with male connector 25 pin up to: (coils) 18+6 (coils) * It is advisable to use fittings wit cylindrical thread with tightening torque 3 Nm for G 1/8 and 10 Nm for G 1/4. 44-III

2 GM - GL series GM series Codification key GM D Option Coil voltage Control 12 Control 14 Type Size Series SERIES GM =Electrovalves for sub-base mounting with bottom consumptions, with integrated connection standard / coils and connectors included. GL = and electrovalves for sub-base mounting, bottom consumption, without coils and connectors. SIZE 6 =Side 20 mm GL series TYPE 2 =5/2 3 =5/3 closed centres 4 =5/3 open centres 5 =5/3 pressurized centres 6 =3/2+3/2 NC-NC 7 =3/2+3/2 NC-NO 8 =3/2+3/2 NO-NO Coils and connectors Sect. Accessories page10 Flow rates according to the type of fittings: 5/2 5/3 3/2+3/2 Straight type for tube Ø 8 mm for tube Ø 8 mm Straight type for tube Ø 6 mm for tube Ø 6 mm Straight type for tube Ø 4 mm for tube Ø 4 mm CONTROL 14 3 =pneumatic (GL series) 4 =electric only d.c. electropilot 15x15 (GM-... series) 5 =electric d.c. and a.c. electropilot 15x15 (GL-... series) 6 =electric only d.c. electropilot 10x10 (GL-... series) CONTROL 12 0 =pneumatic spring 1 =mechanical spring 2 =pneumatic not 3 =pneumatic 4 = only d.c. electropilot 15x15 (GM-... series) 5 = d.c. and a.c. electropilot 15x15 (GL-... series) 6 = only d.c. electropilot 10x10 (GL-... series) 7 = not only d.c. electropilot 15x15 (GM-... series) 8 = not d.c. and a.c. electropilot 15x15 (GL-... series) 9 = not only d.c. electropilot 10x10 (GL-... series) COIL VOLTAGE (excluded GL series) 24 Vdc (standard) 12 Vdc (upon request) OPTION D =External pilot supply to solenoid. 45-III

3 Symbol Control /2 Single - double pneumatic impulse Ø mm Flow Nl/min. Pressure bar (supply pipe Ø 6) Manual override Mass kg Part number pneumatic pneumo mechanical , ,092 GL on body spring pneumatic on body mechanical spring , ,092 GL pneumatic pneumatic , ,103 GL on body on body 5/2 Single - double impulse Time ms energ de-energ Coils pneumomechanical spring mechanical spring , ,112 GL-6240 DD-... 1, ,092 GL-6260 DE , ,137 GM , ,112 GL-6241 DD-... 1, ,092 GL-6261 DE , ,137 GM , ,143 GL-6244 DD-... 0, ,123 GL-6266 DE-... 5/3 Closed centres, open centres, pressurized centres , ,193 GM CLOSED CENTRES OPEN CENTRES 1, ,148 GL-6344 DD-... 1, ,128 GL-6366 DE-... 1, ,198 GM ,4 9 2, ,148 GL-6444 DD-... supply pipe Ø ,4 8 2, ,128 GL-6466 DE-... supply pipe Ø ,4 9 2,0 9 supply pipe Ø ,198 GM PRESSURIZED CENTRES Electrical Electrical 1, ,148 GL-6544 DD-... 1, ,128 GL-6566 DE-... 3/2 + 3/2 Amplified control 3/2NC+3/2NC 3/2NC+3/2NO 3/2NO+3/2NO 1, ,198 GM , ,140 GL-6644 DD-... 1, ,122 GL-6666 DE , ,190 GM , ,140 GL-6744 DD-... 1, ,122 GL-6766 DE , ,190 GM , ,140 GL-6844 DD-... 1, ,122 GL-6866 DE , ,190 GM = Impulse not protruding 46-III

4 Overall dimensions GM-... Series 21 valve thckness Number of valve station x 21 mm GL-... Series 1 Supply G 1/4 3-5 Exhaust G 1/ Exhaust from solenoid pilot G 1/8 21 valve thckness Number of valve station x 21 mm 1 Supply G 1/4 5-3/3-5 Exhaust G 1/ /84-82 Exhaust from solenoid pilot G 1/8 47-III

5 Sub-plates and accessoeries for GM - GL Series Threaded end plate Mass kg. 0,046 Blanking end plate Mass kg. 0,050 GP-6100 GP-6110 Threaded end plate with male connector 25 poles (excluded GL series) Mass kg. 0,100 Mass kg. 0,102 GP coils for control GP coils control 14 6 coils control 12 (only for control 14 more than 12 coils max. 18) Sub-base with diaphragms all open Sub-base with diaphragms all open servoassisted GP-6210 without connection prearranged for integrated connection: GP-6211 monostable GP-6212 bistable GP-6210S without connection prearranged for integrated connection: GP-6211S monostable GP-6212S bistable Sub-base with diaphragms all closed Mass kg. 0,068 Sub-base with diaphragms all closed servoassisted Mass kg. 0,068 GP-6220 without connection prearranged for integrated connection: GP-6221 monostable GP-6222 bistable GP-6220S without connection prearranged for integrated connection: GP-6221S monostable GP-6222S bistable Sub-base with supply closed and exhausts open Sub-base with supply closed and exhausts open, servoassisted GP-6230 without connection prearranged for integrated connection: GP-6231 monostable GP-6232 bistable GP-6230S without connection prearranged for integrated connection: GP-6231S monostable GP-6232S bistable 48-III

6 Sub-base with supply open and exhausts closed Sub-base with supply open and exhausts closed, servoassisted GP-6240 without connection prearranged for integrated connection: GP-6241 monostable GP-6242 bistable GP-6240S without connection prearranged for integrated connection: GP-6241S monostable GP-6242S bistable BUS connection card (excluded GL series) Mass kg. 0,003 for each place control side 12 with 12 pin GP MF (1 place) GP MF (2 places) GP MF (3 places) GP MF (5 places) GP MF (6 places) Upon request customized solutions up to 12 places control side 14 with 12 pin GP MF (1 place) GP MF (2 places) GP MF (3 places) GP MF (5 places) GP MF (6 places) control side 14 with 18 pin GP (only 12 places) For manifold assemblies with control 14 with more than 12 coils up to 18 coils use card GP and then GP Modular tie-rods (package 100 pcs.) GP valve place Mass kg. 0,004 GP valve places Mass kg. 0,010 AZ4-VN0416 screws M04x16 for tie-rods package 100 pcs. AZ4-SN004A hexagonal nut M4 package 100 pcs. GP valve places Mass kg. 0,022 Intermediate supply plate Mass kg. 0,036 Blanking plate for unused station Mass kg. 0,018 To be used only with sub-base GP GP-6380 GP-6385 Blanking plug Mass kg. 0,010 Lifting bracket Mass kg. 0,086 Fittings GZR-100 GP-6411 Ø tube mm Straight fitting GZR-V10004 GZR-V10006 GZR-V10008 Mass kg. 0,010 Low elbow fitting GZR-V20004 GZR-V20006 GZR-V20008 Mass kg. 0,012 High elbow fitting GZR-V20L004 Mass kg. 0,016 GZR-V20L006 Mass kg. 0,018 GZR-V20L008 Mass kg. 0, III

7 Flying prewired connectors Connectors without cable Flying female connector sub D single cable according to CEI II O.R. standard Flying female connector sub D double cable according to CEI II O.R. standard (upon request) TSCF 000 Cable 5 m length TSCF 506 (up to 6 coils) TSCF 510 (up to 10 coils) TSCF 520 (up to 20 coils) Cable 10 m length TSCF 106 (up to 6 coils) TSCF 110 (up to 10 coils) TSCF 120 (up to 20 coils) Cable 5 m length TSCF 533 (3+3 coils) TSCF 555 (5+5 coils) TSCF 511 (10+10 coils) Cable 10 m length TSCF 133 (3+3 coils) TSCF 155 (5+5 coils) TSCF 111 (10+10 coils) Flying female connector sub D according to CEI II O.R. standard Flying male/female connector sub D according to CEI II O.R. standard TSCF 16 S0300 (3 m length) TSCF 16 S0500 (5 m length) Upon request TSCF 16 S1000 (10 m length) TSCF 24 S0300 Prewired for 18 coils with TSCF 24 S0500 cable Ø 8 mm. TSCF 24 S1000 Suitable for mobile laying Prewired for 24 coils TSCF 16 D0300 (3 m length) TSCF 16 D0500 (5 m length) TSCF 16 D1000 (10 m length) Prewired for 16 coils with cable Ø 8 mm. Suitable for mobile laying Table relating to electric connections Manifold side PIN-coil matching Cable side PIN-cable colour matching Male connector Coil PIN operation num coil side side common n.c. n.c. n.c n.c. = not connected. 50-III Female connector Cable colours CN1 Function Function TSCF16S Function TSCF520 TSCF510 TSCF506 TSCF24S up to 20 up to 10 up to 6 Pin TSCF24S TSCF16_ TSCF16D TSCF5 coils coils coils 1 signal 1 white signal 1 white signal 1 white white white 2 signal 2 brown signal 2 brown signal 2 brown brown brown 3 signal 3 green signal 3 green signal 3 green green green 4 signal 4 grey signal 4 grey signal 4 yellow yellow yellow 5 signal 5 pink signal 5 pink signal 5 grey grey grey 6 signal 6 blue signal 6 blue signal 6 pink pink pink 7 signal 7 violet signal 7 violet signal 7 blue blue - 8 signal 8 grey-pink signal 8 grey-pink signal 8 red red - 9 signal 9 red-blue signal 9 red-blue signal 9 black black - 10 signal 10 white-green signal 10 white-green signal 10 violet violet - 11 signal 11 brown-green signal 11 brown-green signal 11 grey-pink signal 12 white-yellow signal 12 white-yellow signal 12 red-blue signal 13 yellow-brown signal 13 yellow-brown signal 13 white-green signal 14 white-grey signal 14 white-grey signal 14 brown-green signal 15 grey-brown signal 15 grey-brown signal 15 white-yellow signal 16 white-pink signal 16 white-pink signal 16 yellow-brown signal 17 pink-brown signal 17 pink-brown signal 17 white-grey signal 18 white-blue signal 18 white-blue signal 18 grey-brown signal 19 black-white signal 19 white-pink - com. GND black nero 20 signal 20 yellow signal 20 pink-brown - 21 signal 21 red - - n.c. - rosso red 22 signal 22 brown-blue - - n.c signal 23 brown-red white-red grey-pink blue com. GND yellow giallo com. GND 24 com. GND black-shield. brown-red red-blue red 25 signal 24 white-red shield shield shield shield shield shield

Pneumatic valve islands

Pneumatic valve islands Pneumatic valve islands The MEGA solenoid air operated spool valve JOUCOMATIC offers a concept of solenoid air operated spool valves which can be fitted together to form islands. Due to its new patented

More information

Pneumatic spool valve islands

Pneumatic spool valve islands Pneumatic spool valve islands P7.GB.R MEGA SPOOL VALVE ISLANDS MEGA pneumatic spool valve islands offer maximum performance along with flexibility, easy installation and simple operation. Due to their

More information

Valves ISO 5599/1 ISO 1, 5/2-5/3, electrically operated, with CNOMO pilot

Valves ISO 5599/1 ISO 1, 5/2-5/3, electrically operated, with CNOMO pilot ISO 1, - 5/3, electrically operated, with CNOMO pilot Executions 0300 ISO1E50 NOTE: FOR VALVES WITH PILOT IN LINE SEE PAGE.111.1 Technical data 03030 ISO1E51 03037 ISO1E5 03031 ISO1E70 0303 ISO1E71 03043

More information

SOLENOID VALVES AND PNEUMATIC VALVES

SOLENOID VALVES AND PNEUMATIC VALVES 9 S E R I E S Electropneumatically and pneumatically operated valves Series 9 Assembly with sub-base (ISO 5599/1 Standards) Sizes 1, 2 and 3 The Series 9 electropneumatically or pneumatically operated

More information

Spool compact valves pilot and solenoid actuated G 1/8 - G 1/4

Spool compact valves pilot and solenoid actuated G 1/8 - G 1/4 Spool compact valves pilot and solenoid actuated G 1/8 - G 1/4 DESCRIPTION Valves series "MEK", in the 5/ and pneumatic functions, have been realized with compact overall dimensions yet assuring high flow.

More information

SPOOL VALVES. ISO 15407/1 - Sizes Series PA568-GB-R3. All leafl ets available at:

SPOOL VALVES. ISO 15407/1 - Sizes Series PA568-GB-R3. All leafl ets available at: SPOOL VLVS ISO 07/ - Sizes 0-0 Series 8-9 P68-GB-R ll leafl ets available at: www.ascojoucomatic.com FTURS These spool valves which comply with the VDM 6 standard offer the advantage of being smaller than

More information

4/2 way Pneumatic Solenoid Valve

4/2 way Pneumatic Solenoid Valve 4/2 way Pneumatic Solenoid Valve Compact design Push-over solenoid coil Exhaust air can be regulated Tube, threaded and sub-base connections Type combined with Seat valve version Type 2508 Type 2510/11

More information

Valves to ISO 5599/1 standards pilot and solenoid actuated size

Valves to ISO 5599/1 standards pilot and solenoid actuated size Series UDS ISO pilot and solenoid actuated size 1 - - 3 DESCRIPTION Valves series "UDS ISO" are produced in the and pneumatic functions according to the interface to ISO 5599/1 standards and they are mounted

More information

VALVES ISO 5599/1, SERIES IPV-ISV

VALVES ISO 5599/1, SERIES IPV-ISV VALVES ISO 99/1, SERIES IPV-ISV The assembly surface dimensions of ISO1 and ISO2 valves are to ISO99-1. They are available in the -way versions with 2 and 3 positions and with pneumatic or solenoid actuation.

More information

seriesuds ISO Valves to ISO 5599/1 standard

seriesuds ISO Valves to ISO 5599/1 standard seriesuds ISO Valves to ISO 5599/1 standard pilot and solenoid actuated sizes 1 - - 3 DESCRIPTION Valves series UDS ISO are produced in the and pneumatic functions according to the interface to ISO 5599/1

More information

SPOOL VALVES. pilot operated single/dual solenoid (mono/bistable function) ISO mm - pad mounting body M12 connection

SPOOL VALVES. pilot operated single/dual solenoid (mono/bistable function) ISO mm - pad mounting body M12 connection SPOOL VALVES pilot operated single/dual solenoid (mono/bistable function) ISO 07-8 mm - pad mounting body M connection x/ - / - / Series 0 ISO 07- (8 mm) FEATURES M connection on top of valve: reduces

More information

Nugget 120 V14 Series

Nugget 120 V14 Series Nugget 0 V Series /2 & /3 Valves Solenoid and Pilot Operated G 1 4 High flow compact valves Sub-base and low profile manifolds Light weight, long life corrosion resistant materials Multipole and Fieldbus

More information

Nugget 120 V14 Series

Nugget 120 V14 Series Nugget 0 V Series /2 & /3 Valves Solenoid and Pilot Operated G 1 4 High flow compact valves Sub-base and low profile manifolds Light weight, long life corrosion resistant materials Multipole and Fieldbus

More information

series UDS ISO to ISO 5599/1 standard pilot and solenoid actuated sizes DESCRIPTION TECHNICAL DATA MATERIALS SPARE PARTS

series UDS ISO to ISO 5599/1 standard pilot and solenoid actuated sizes DESCRIPTION TECHNICAL DATA MATERIALS SPARE PARTS series UDS ISO Valves to ISO 5599/1 standard pilot and solenoid actuated sizes 1 - - 3 DESCRIPTION Valves series UDS ISO are produced in the and functions according to the interface to ISO 5599/1 standard

More information

MULTIPOL - VDMA. PNEUMATIC SPOOL VALVE ISLANDS VDMA ISO 02 - ISO 01 (G1/8 - G1/4) designed for connection to a PLC by multiwire cable

MULTIPOL - VDMA. PNEUMATIC SPOOL VALVE ISLANDS VDMA ISO 02 - ISO 01 (G1/8 - G1/4) designed for connection to a PLC by multiwire cable P8.G.R PEUATIC SPOOL VALVE ISLADS VDA - ISO - ISO (G/8 - G/) designed for connection to a PLC by multiwire cable ULTIPOL - VDA IPUT IPUT OUTPUT OUTPUT OUTPUT IPUT IPUT ULTIPOL - VDA Pneumatic spool valve

More information

filtered air without lubricant. If lubricated air is used, it is recommended to use ISOVG32 oil and to never interrupt lubrication.

filtered air without lubricant. If lubricated air is used, it is recommended to use ISOVG32 oil and to never interrupt lubrication. > Series EN valves and solenoid valves Valves and Solenoid valves Series EN, CC - CO - CP With outlets on the body - For individual or manifold assembly Size 16-19 mm» Mounting on any flat surface» Reduced

More information

Valves series A1 1/2, 3/2, electrically operated

Valves series A1 1/2, 3/2, electrically operated 1/, 3/, electrically operated Executions 3/ NC 0113 A1E430 3/ NO 3 0 A1E431 1 3 3/ 03 A1E43 3/ NC 3/, 0137 A1K430 08 A1K43 Series of spool valves, with static seals, high flow, for panel mounting. Coils

More information

MECAIR CSN RAINTIGHT ENCLOSURE CLEAN AIR SOLUTIONS PRODUCT LEAFLET

MECAIR CSN RAINTIGHT ENCLOSURE CLEAN AIR SOLUTIONS PRODUCT LEAFLET CSN RAINTIGHT ENCLOSURE CLEAN AIR SOLUTIONS GENERAL CHARACTERISTICS CONSTRUCTION FEATURES ENCLOSURE OPERATING TEMPERATURE 20 C/+60 C COVER Diecast aluminium (anodised) WEIGHT CSN 5 3.5 kg CSN 8 5 kg CSN

More information

AIR TREATMENT H Z E 0. Air Treatment Units CHARACTERISTICS CODIFICATION KEY. Filter. Ambient temperature Fluid Working pressure Max pressure Size Body

AIR TREATMENT H Z E 0. Air Treatment Units CHARACTERISTICS CODIFICATION KEY. Filter. Ambient temperature Fluid Working pressure Max pressure Size Body NEW - HZE Air Treatment Units CHARACTERISTICS Ambient temperature Working pressure Max pressure Body Knob Ring nut Bowl Bowl guard Filter element Seals Springs Diaphragm CODIFICATION KEY H Z E B 8 G +6

More information

Valves, manually operated

Valves, manually operated Valves, manually operated Valves, manually operated Key features VHEM-P K/O-3-PK-3 H-3-¼-B KH/O-3-PK3 TH/O-3-PK3 F-3-¼-B Innovative Versatile Reliable Easy to mount Small and compact for a wide range of

More information

seriesek Spool valves pilot and solenoid actuated G 1/8 - G 1/4 - G 1/2 DESCRIPTION Spool valves series EK 2.43 MATERIALS TECHNICAL DATA SPARE PARTS

seriesek Spool valves pilot and solenoid actuated G 1/8 - G 1/4 - G 1/2 DESCRIPTION Spool valves series EK 2.43 MATERIALS TECHNICAL DATA SPARE PARTS Spool valves pilot and solenoid actuated G 1/8 - G 1/4 - G 1/ DESCRIPTION Valves series "EK" are produced in the 3/, 5/ and pneumatic functions. The piloting solenoid valve can be assembled perpendicular

More information

Valves, manually operated

Valves, manually operated Valves, manually operated Valves, manually operated Key features VHEM-P K/O-3-PK-3 H-3-¼-B KH/O-3-PK3 TH/O-3-PK3 VHEM-L F-3-¼-B Innovative Versatile Reliable Easy to mount Small and compact for a wide

More information

Hand lever valves VHER

Hand lever valves VHER Hand lever valves VHER Hand lever valves VHER Key features Powerful Flexible Practical -M- Flow 170 3800 l/min 4/3-way valve mid-position closed mid-position exhausted mid-position pressurised Connections:

More information

TANDEM MODULATOR FOR OUTLET GAS FLOW: STEPPED (836 TANDEM) - CONTINUOUS (837 TANDEM) SERVO-CONTROLLED PRESSURE REGULATOR

TANDEM MODULATOR FOR OUTLET GAS FLOW: STEPPED (836 TANDEM) - CONTINUOUS (837 TANDEM) SERVO-CONTROLLED PRESSURE REGULATOR SIT Group 836-837 TANDEM MULTIFUNCTIONAL GAS CONTROL MODULATOR FOR OUTLET GAS FLOW: STEPPED (836 TANDEM) - CONTINUOUS (837 TANDEM) SERVO-CONTROLLED PRESSURE REGULATOR ALL ADJUSTMENTS ACCESSIBLE FROM ABOVE

More information

SPCH/ Blowing block

SPCH/ Blowing block > > for linear stretch blow moulding machines > > Compact and safe design > > Best suited for PET bottles up to litres, depending on cycle time Technical features Medium: Compressed air (purity class 3..3

More information

MATERIALS SPARE PARTS. iting pressure (b. Spool compact valves series MEK

MATERIALS SPARE PARTS. iting pressure (b. Spool compact valves series MEK Spool compact valves pilot and solenoid actuated G 1/8 - G 1/4 Valves series "MEK", in trie and pneumatic functions, have been realized with compact overall dimensions yet assuring high flow. The kind

More information

Prewired position switches FA series

Prewired position switches FA series 2 Prewired position switches FA series Selection diagram 01 08 10 11 1 15 1 02 external rubber gasket external rubber gasket 1 51 52 54 55 56 5 ACTUATORS adjustable lever safety adjustable lever 41 45

More information

Position switches FP series

Position switches FP series A Position switches FP series Selection diagram 0 08 8 9 0 0 0 Ø 8 mm Ø, mm external rubber stainless steel stainless steel fiber glass rod gasket sphere sphere adjustable lever safety adjustable lever

More information

MV-01. Features. 2/2-way Solenoid Valve for Fluids. Description: Application:

MV-01. Features. 2/2-way Solenoid Valve for Fluids. Description: Application: MV-01 2/2-way Solenoid Valve for Fluids Description: Features / Nominal diameters 1/4-2 / Pressure up to 10 bar / 24 V DC and all common AC variants / Forced-lifting The pilot-controlled full-way valve

More information

Data sheet Pressure switch type CS December 2001 DKACT.PD.P10.A B1119

Data sheet Pressure switch type CS December 2001 DKACT.PD.P10.A B1119 Pressure switch type CS December 2001 DKACT.PD.P10.A2.02 520B1119 Introduction Pressure switch type CS is part of the Danfoss pressure control range. All CS pressure switches have a built-in pressure-operated,

More information

Proportional pressure regulators VPPE

Proportional pressure regulators VPPE Proportional pressure regulators VPPE Proportional pressure regulators VPPE Product range overview Function Version Pneumatic connection Proportional pressure regulator Nominal size for pressurisation/

More information

Electrically Operated Pressure-Relief Cartridge, Size 10

Electrically Operated Pressure-Relief Cartridge, Size 10 Electrically Operated Pressure-Relief Cartridge, Size 1 Q max = 14 l/min (37 gpm), p max = bar (5 psi) seated pilot stage, spool-type design, with remote contral port Z Series WUVPOC-2, WUVPLC-2 1 Description

More information

VACUUM REGULATORS CONTENTS

VACUUM REGULATORS CONTENTS CAD drawing data catalog is available. ACCESSORIES GENERAL CATALOG AIR TREATMENT, AUXILIARY, VACUUM, AND FLUORORESIN PRODUCTS CONTENTS Small Regulators Features 759 Specifications, Order Codes, Flow Rate

More information

PRESSURE SEQUENCE VALVE TYPE UZK

PRESSURE SEQUENCE VALVE TYPE UZK PRESSURE SEQUENCE VALVE TYPE UZK Size 10, 20, 30 31,5 MPa up to 450 dm 3 /min WK 450 414 04. 2000r. Pressure sequence valves type UZK are used for switching a system or part of a system off when a set

More information

BULLETIN E485A. Standard Interface Poppet Valve Construction Customized Solutions Plug-and-Play Design.

BULLETIN E485A. Standard Interface Poppet Valve Construction Customized Solutions Plug-and-Play Design. BULLETIN E485A Standard Interface Poppet Valve Construction Customized Solutions Plug-and-Play Design www.rosseuropa.com 1 Glossary Response Time The smallest nominal value difference that causes a change

More information

2/2- and 3/2-way Rocker Solenoid Valve - bistable (impulse) version

2/2- and 3/2-way Rocker Solenoid Valve - bistable (impulse) version 2/2- and 3/2-way Rocker Solenoid Valve - bistable (impulse) version Type 6624 Impulse can be combined with... 10mm width orifice DN 0.8 to 1.2 with pressure range vacuum to 5bar medium separation, for

More information

MULTIFUNCTIONAL CONTROL FOR GAS BURNING APPLIANCE

MULTIFUNCTIONAL CONTROL FOR GAS BURNING APPLIANCE SIT Group SIT -3- SIGMA MULTIFUNCTIONAL CONTROL FOR GAS BURNING APPLIANCE 9.955. Subject to change without notice Application Domestic gas appliances: central heating boilers, combi boilers, instantaneous

More information

BW0500AO. ByWire Elements BW0500AO Element 4/3 with side ports IBW0500 Interface

BW0500AO. ByWire Elements BW0500AO Element 4/3 with side ports IBW0500 Interface ywire Elements Element 4/3 with side ports IW5 Interface efore use, carefully read the GENERL INSTRUCTIONS FOR USE OF DIRECTIONL CONTROL VLVES 398SW5EN - 5--8 Technical data Nominal flow 5 l/min 3. US

More information

Proportional Throttle Cartridges, Size 16

Proportional Throttle Cartridges, Size 16 Proportional Throttle Cartridges, Size 16 Q max = 5 l/min, p max = 5 bar, Q N max = 14 l/min at p 1 bar Two-Stage, with Seat-Valve Shut-Off 1 Description Normally closed Seat-valve shut-off from 1 Compact

More information

V83 series Redundant valve manifold systems - Modular with bypass 1oo2 Safety, 2oo2 Availability and 2oo3 Safety and Availability

V83 series Redundant valve manifold systems - Modular with bypass 1oo2 Safety, 2oo2 Availability and 2oo3 Safety and Availability V8 series Redundant valve manifold systems - Modular with bypass oo Safety, oo Availability and oo Safety and Availability > > Modular design - Maxseal valves > > able terminations inside coil housing

More information

Components for air preparation and pressure adjustment. OUT port position ( ) connected Rear side. of IN port. Air tank. directly.

Components for air preparation and pressure adjustment. OUT port position ( ) connected Rear side. of IN port. Air tank. directly. Components preparation and pressure adjustment ABP Overview ABP is a component that enables boosting by s only up to twice primary pressure (.0MPa max.) in combination with using air tank but not using

More information

Compact Ejectors. Compact Ejectors SCPi / SMPi Suction rate from 75 l/min to 185 l/min

Compact Ejectors. Compact Ejectors SCPi / SMPi Suction rate from 75 l/min to 185 l/min Compact Ejectors Suitability for Industry-Specific Applications Applications Handling of air-tight as well as porous workpieces supply and vacuum monitoring in automated systems For use in sheet metal

More information

Precision pressure regulators LRP/LRPS

Precision pressure regulators LRP/LRPS Precision pressure regulators LRP/LRPS q/w Worldwide: Superb: Easy: Festo core product range Covers 80% of your automation tasks Always in stock Festo quality at an attractive price Reduces procurement

More information

Inverse Proportional Pressure-Relief Cart., Size 2 4

Inverse Proportional Pressure-Relief Cart., Size 2 4 Inverse Proportional Pressure-Relief Cart., Size Q max = l/min, p max = 5 bar Direct acting, electrically operated 1 Description inverse proportional pressure-relief valves are direct acting screw-in cartridges

More information

Prop. 3-Way Pressure-Reducing Cart., Size 5 / SAE 08

Prop. 3-Way Pressure-Reducing Cart., Size 5 / SAE 08 Prop. -Way Pressure-Reducing Cart., Size / SAE 8 Q max = 1 l/min (4 gpm), p max = bar (6 psi) Direct acting, electrically operated 1 Description proportional -way pressure-reducing cartridges are size

More information

Inverse Proportional Pressure-Relief Cartridge, Size 10

Inverse Proportional Pressure-Relief Cartridge, Size 10 Inverse Proportional Pressure-Relief Cartridge, Size 1 Q max = 12 l/min, p max = 3 bar Seated pilot, spool-type main stage, damped design 1 Description inverse-proportional pressure-relief valves are size

More information

Proportional Pressure-Relief Cartridge Valve, Size 2...4

Proportional Pressure-Relief Cartridge Valve, Size 2...4 Proportional Pressure-Relief Cartridge Valve, Size... Q max = l/min, p max = 3 bar Direct acting, electrically operated 1 Description proportional pressure-relief valves are direct acting screw-in cartridges

More information

AMG. Model Note) Rated flow (l/min (ANR)) Port size Mass (kg) 1 8, , 3 8. Specifications Fluid. Element life

AMG. Model Note) Rated flow (l/min (ANR)) Port size Mass (kg) 1 8, , 3 8. Specifications Fluid. Element life Water Separator Series AMG Can remove water droplets in compressed air. Use this product in cases where water must be avoided, but not so dry as when an air dryer is used. Through the adoption of an element

More information

BULLETIN E485B. Poppet Valve Construction Customized Solutions Plug-and-Play Design. Subject to technical modifications.

BULLETIN E485B. Poppet Valve Construction Customized Solutions Plug-and-Play Design.   Subject to technical modifications. BULLETIN E485B Poppet Valve Construction Customized Solutions Plug-and-Play Design www.rosseuropa.com 1 Glossary Response Time The smallest nominal value difference that causes a change of the outlet pressure,

More information

SOLENOID VALVES AND PNEUMATIC VALVES

SOLENOID VALVES AND PNEUMATIC VALVES S E R I E S 3 4 2 Electropneumatically operated valves Series 3 and 4 Series 3: G1/8, 3/2 - way and 5/2 - way Series 4: G1/8, G1/4 and G1/2 3/2, 5/2 and 5/3 - way GENERAL DATA Construction Valve group

More information

Prewired position switches FA series

Prewired position switches FA series Prewired position switches Technical data Housing Made of metal, coated with baked epoxy powder 2 m wired cable with 5x0,5 mm 2 wires marked SEV and IMQ Protection degree: IP6 General data Ambient temperature:

More information

Fast Switching Valves

Fast Switching Valves Fast Switching Valves Ultra Fast and Highly Repeatable MH, MH3 and MH4 MH: Flow rate of 100 l/min and ms response MH3: Flow rate of 00 l/min and 3 ms response MH4: Flow rate of 400 l/min and 3.5 ms response

More information

EXH. Specifications. Descriptions. Min. working pressure MPa

EXH. Specifications. Descriptions. Min. working pressure MPa Functional explanation Primary pressure flowed from passes through check valve on side, and flows in chamber A and B. Primary pressure also passes through pressure adjustment section and switching valve,

More information

G1/8 G1/8. Model 0 bar -0,1 bar -0,2 bar -0,3 bar -0,4 bar -0,5 bar -0,6 bar -0,7 bar -0,8 bar

G1/8 G1/8. Model 0 bar -0,1 bar -0,2 bar -0,3 bar -0,4 bar -0,5 bar -0,6 bar -0,7 bar -0,8 bar single stage pumps M/5811 Very high induced air capacity % lower air consumption than comparable single stage units No wearing parts Compatible with a wide range of line contaminants llows direct connection

More information

EPP4 Pressure Regulator Basic G 1/4"

EPP4 Pressure Regulator Basic G 1/4 EPP4 Pressure Regulator Basic G 1/4" Flow Curve 1/4" Dimensions Outlet pressure - bar 9 8 7 6 5 4 3 2 1 0 0 20 40 60 70 80 100 120 Flow rate - Nm 3 /h The male connector adopted on the EPP4 is a standard

More information

Series 4 Cv= Air-Pilot operated valves. 3-way/2-position, 5-way/2-position, 5-way/3-position

Series 4 Cv= Air-Pilot operated valves. 3-way/2-position, 5-way/2-position, 5-way/3-position 3 Cv =.73-2.00 Series 4 Cv=.73-2.00 Air-Pilot operated valves Series 4: 1/8,, 3-way/2-position; 5-way/2-position; 5-way/3-position 1/2 5-way/2-position The pneumatically operated,3-way/2-position, 5-way/2-position

More information

Series 1, 3 and 4 Cv = /8" and 1/4" Ported Manually Operated Valves. 3-way/2-position, 5-way/2-position, 5-way/3position

Series 1, 3 and 4 Cv = /8 and 1/4 Ported Manually Operated Valves. 3-way/2-position, 5-way/2-position, 5-way/3position Cv =.52 -.73 Series, 3 and 4 Cv =.52.3 /8" and /4" Ported Manually Operated Valves 3-way/2-position, 5-way/2-position and 5-way/3-position Ports /8 and /4" NPTF The Series (/8 & /4", 3-way/2-position and

More information

Inverse Proportional Pressure-Relief Cart., Size 2 4

Inverse Proportional Pressure-Relief Cart., Size 2 4 Inverse Proportional Pressure-Relief Cart., Size Q max = l/min, p max = 35 bar Direct acting, electrically operated Description Compact construction for cavity type AL 3/-6 UNF Operated by a proportional

More information

Proportional Pressure-Relief Cartridge Valve, Size 2...4

Proportional Pressure-Relief Cartridge Valve, Size 2...4 Proportional Pressure-Relief Cartridge Valve, Size... Q max = l/min (6 gpm), p max = bar (58 psi) Direct acting, electrically operated Description proportional pressure-relief valves are direct acting

More information

Compact pressure switches for gas and air

Compact pressure switches for gas and air Compact pressure es for gas and air / 5.0 Printed in Germany Edition 0.8 Nr. 9 544 6 Technical description The pressure is an adjustable compact pressure according to EN 854 for combustion plants. The

More information

Complementary valves: shuttle, quick exhaust and check valves

Complementary valves: shuttle, quick exhaust and check valves Complementary valves shuttle, quick exhaust and check valves Complementary valves are very important components of the pneumatic circuits. This group includes the: SHUTTLE VALVES: these valves are used

More information

Specifications. Model VEX Operating style Fluid Proof pressure Max. operating pressure

Specifications. Model VEX Operating style Fluid Proof pressure Max. operating pressure Power Valve Regulator Valve Series 1 Large Capacity Relief Regulator 3 port large capacity poppet exhausting regulator equipped with a relief port the same size as the connection port. Specifications Model

More information

Inverse Prop. Pressure-Relief Cart., Size 2 4

Inverse Prop. Pressure-Relief Cart., Size 2 4 Inverse Prop. Pressure-Relief Cart., Size Q max = l/min (6 gpm), p max = bar (58 psi) Direct acting, electrically operated Description inverse proportional pressure-relief valves are direct acting screw-in

More information

Solenoid Valves VUVG Overview

Solenoid Valves VUVG Overview Solenoid Valves VUVG Overview Universal valve Combination of basic valve and E-boxes Width 10 mm and 14 mm In-line valves VUVG-L and VUVG-S Sub-base valves VUVG-B Internal or external pilot air supply

More information

Solenoid valves VZWF, force pilot operated

Solenoid valves VZWF, force pilot operated Key features and overview Function Normally closed solenoid valve with diaphragm and forced lifting. When the solenoid is energised, the differential pressure from the secondary side of the diaphragm is

More information

Series K Air service units G 1/8, G 1/4

Series K Air service units G 1/8, G 1/4 Air service units G /8, G /4 Series FK Filter, G /8 G /4.02 Series RK Pressure regulator, G /8 G /4.04 Series FRK Filter/regulator, G /8 G /4.06 Series OK Lubricator, G /8 G /4.08 Series FROK Two piece

More information

Auto Feed Lube, Auto Feed Tank ALF400 to 900, ALT-5/-9

Auto Feed Lube, Auto Feed Tank ALF400 to 900, ALT-5/-9 Auto Feed Lube, Auto Feed Tank 00 to 900, -/-9 Standard Specifications Fluid Proof pressure Operating pressure differential range (Difference between tank pressure and line pressure) Vibration resistance

More information

compact ejector, Series ECM with Adjustable release pulse with silencer With filter vacuum switch: electronic 2 x PNP

compact ejector, Series ECM with Adjustable release pulse with silencer With filter vacuum switch: electronic 2 x PNP 00134428 Type Miniature compact injector Ambient temperature min./max. +0 C / +0 C Medium temperature min./max. +0 C / +0 C Working pressure min./max. 2. bar / 6 bar Medium Compressed air Max. particle

More information

Standard Specifications

Standard Specifications NARM, 2 Ways of Connection Small Size Pressure Gauge ø5mm Reverse flow function available on the standard model Space Saving -B2 NARM-6A-NG Standard Specifications Fluid Proof pressure psig (MPa) Max.

More information

Precision Regulator. Series Model Regulating pressure range Port size Page

Precision Regulator. Series Model Regulating pressure range Port size Page Precision Regulator Series // Basic Type Air Operated Type Series Model Regulating pressure range Page Series Series Series Series Series.5 to MPa. to MPa. to.8 MPa /8 55.5 to MPa. to MPa /4 55. to.8 MPa.

More information

MPRM1690 MPRM2590 MPRM3290

MPRM1690 MPRM2590 MPRM3290 Pinze elettriche radiali a 2 griffe 2-jaw radial electric grippers MPRM 2-jaw radial self-centering electric gripper Plug & play user friendly gripper. No electricity consumption when gripper is engaged.

More information

Electromechanical pressure switches

Electromechanical pressure switches Presentation Electromechanical pressure switches OsiSense XM For power circuits, type XMP Presentation Pressure switches type XMP are switches for power circuits (direct switching), with an adjustable

More information

1 LS unloading (control valve, orifice, none) 2 LS max pressure relief. 3 Spool type

1 LS unloading (control valve, orifice, none) 2 LS max pressure relief. 3 Spool type Flow Control Valve Series LVM.. high flow rates (8 l/min) flow rates are unaffected by temperature change or when the higher load pressure alternates between the outlet ports proportional flow-sharing

More information

CONNECTION > Super-rapid fittings Series 6000 GENERAL DATA. Fitting with connecting tube. Sprint

CONNECTION > Super-rapid fittings Series 6000 GENERAL DATA. Fitting with connecting tube. Sprint Super-rapid fittings for plastic tubes Series 6000 Sprint Tube external diameters: 3,, 5, 6, 8, 10, 12, 1, 16 mm Fittings threads: metric (M3, M5, M6, M7), BSP (G1/8, G1/, G3/8, G1/2, G3/), BSPT (R1/8,

More information

Pneumatic spool valve islands

Pneumatic spool valve islands neumatic spool valve islands A7.GB.R MGA SOOL VALV ISLANDS MGA pneumatic spool valve islands offer maximum performance along with flexibility, easy installation and simple operation. Due to their design,

More information

Air service units series K G1/8, G1/4

Air service units series K G1/8, G1/4 Air service units series K Series FK Filter 12.011 Series RK Pressure regulator 12.012 Series FRK Filter/regulator 12.013 Series OK Lubricator 12.014 Series FROK Two piece air service unit 12.015 Series

More information

stepper motor 2-phase hybrid stepper motor (bipolar) high protection class with plug or stranded wires optional with encoder / brake

stepper motor 2-phase hybrid stepper motor (bipolar) high protection class with plug or stranded wires optional with encoder / brake stepper motor 2-phase hybrid stepper motor (bipolar) high protection class with plug or stranded wires optional with / brake / 9 www.igus.de MOT-AN-S_EN_2070# part number (not configurable, only for illustration)

More information

Pilot Check Valve: Metal Body Type

Pilot Check Valve: Metal Body Type INFORMATION Pilot Check Valve: Metal Body Type The use of a metal body improves strength and environmental resistance. Temporary intermediate stops are possible. *1 *1 Precise intermediate stops are not

More information

Air preparation units

Air preparation units Overview Description Page Characteristics Dimensions Order instructions Type overview unit three-piece 44, 45, 48 52 6 unit two piece 44, 45, 48 52 6 Filter-regulator 44, 45, 48 53 6 Filter-water-separator

More information

Directional valves Pneumatically operated Series CD07. Brochure

Directional valves Pneumatically operated Series CD07. Brochure Series CD07 Brochure 2 Bosch Rexroth AG Pneumatics Series CD07 2/2-way valve, Series CD07 Qn = 1400 l/min pipe connection compressed air connection output: M14x1,5 suitable for ATEX 3 3/2-way valve, Series

More information

Power Valve: Precision Regulator. High precision, large capacity relief regulator

Power Valve: Precision Regulator. High precision, large capacity relief regulator Power Valve: Precision Regulator Series VEX High precision, large capacity relief regulator port large exhaust capacity pressure reducing valve which utilizes a nozzle flapper mechanism available as air

More information

Heavy Metal Stainless Steel Valves

Heavy Metal Stainless Steel Valves 2.10 page 187 2.10 Heavy Metal Stainless Steel Valves Selected models are available for explosion hazardous environment. They are ATEX-Ex certified. For detailed information refer to chapter 2.12. 316

More information

Calibrated or locked versions available. TREATMENT > Series MD regulators GENERAL DATA. New

Calibrated or locked versions available. TREATMENT > Series MD regulators GENERAL DATA. New > Series MD regulators Series MD pressure regulators New Ports with interchangeable cartridges: threaded (1/8, 1/4, /8) or integrated with super-rapid fitting for tube with Ø 6, 8 and 10 mm Versions: single,

More information

F series Foot Switches

F series Foot Switches F series Foot Switches ITC presents a complete line of foot switches from Bernstein, designed to respond to the most stringent requirements for machine control and safety applications. The F series includes

More information

Filter pressure regulator, Series AS3-FRE G 3/8 - G 1/2 filter porosity: 5 µm lockable for padlocks with pressure gauge suitable for ATEX

Filter pressure regulator, Series AS3-FRE G 3/8 - G 1/2 filter porosity: 5 µm lockable for padlocks with pressure gauge suitable for ATEX Filter regulator, Series AS3-FRE G 3/8 - G 1/2 filter porosity: 5 µm lockable for padlocks with gauge suitable for ATEX 1 00119372 Version Parts Mounting orientation Working min./max. Medium Medium temperature

More information

Type 0404 / /2-way solenoid valve 2/2-Wege-Magnetventil Électrovanne 2/2 voies Operating Instructions Bedienungsanleitung Manuel d utilisation

Type 0404 / /2-way solenoid valve 2/2-Wege-Magnetventil Électrovanne 2/2 voies Operating Instructions Bedienungsanleitung Manuel d utilisation Type 0404 / 5404 2/2-way solenoid valve 2/2-Wege-Magnetventil Électrovanne 2/2 voies Operating Instructions Bedienungsanleitung Manuel d utilisation 1 OPERATING INSTRUCTIONS The operating instructions

More information

Function. Valve Size. Pilot Oil. p min. Bold: Designates Tier I products and options.

Function. Valve Size. Pilot Oil. p min. Bold: Designates Tier I products and options. Catalog HY14-255/US echnical Information ilot Operated ressure Reducing Valves Series VMY*6 General Series VMY*6 valves consist of the main stage with valve spools and the pilot stage with the proportional

More information

Safety and Shut-off Block SAF/DSV

Safety and Shut-off Block SAF/DSV 1. DESCRIPTION 1.1. GENERAL The HYDAC safety and shut-off block is used to shut off and discharge hydraulic accumulators or user units. It complies with the relevant safety standards in accordance with

More information

Cylinder Controls. Operating information. For ATEX specific products contact Sales Office. 2/2 Blockers. PDE2600PNUK Parker Pneumatic

Cylinder Controls. Operating information. For ATEX specific products contact Sales Office. 2/2 Blockers. PDE2600PNUK Parker Pneumatic A range of speed controls, flow controls and back pressure sensors designed to be mounted directly onto the cylinder in the optimum position for maximum performance. "Push-in" or threaded connection Multifunction

More information

Piloted Non-Return Valves

Piloted Non-Return Valves ed Non-Return Valves ed non-return valves are designed to protect installations: if the compressed air supply is removed, they lock the air supply to the cylinder, thus maintaining it in position. Product

More information

Mass Flow Controller (MFC) for gases. Inline MFC for nominal flow rates from 25 I N. /min to I N

Mass Flow Controller (MFC) for gases. Inline MFC for nominal flow rates from 25 I N. /min to I N Mass Flow Controller (MFC) for gases Type 8626 can be combined with Inline MFC for nominal flow rates from 25 I N /min to I N /min; 1/4 to 3/4 High accuracy Fast settling time Fieldbus option Special version

More information

Mass Flow Meter (MFM) for gases

Mass Flow Meter (MFM) for gases Mass Flow Meter (MFM) for gases Type can be combined with Inline MFM for nominal flow rates from 25 l N /min to 1,500 l N /min; 1/4 to 3/4 High accuracy Fast settling time Fieldbus option Special version

More information

Direct Operated Precision Regulator Modular Style. Standard Specifications

Direct Operated Precision Regulator Modular Style. Standard Specifications 1 Direct Operated Precision Regulator Modular Style Series P3 Courtesy of Steven Engineering, Inc.-23 Ryan Way, South San Francisco, CA 948-637-Main Office: (65) 588-92-Outside Local Area: (8) 258-92-www.stevenengineering.com

More information

FEPA PNEUMATICALLY AND SOLENOID ACTUATED VALVES, ONE UNIT MOUNTED TYPE VPG

FEPA PNEUMATICALLY AND SOLENOID ACTUATED VALVES, ONE UNIT MOUNTED TYPE VPG PNEUMATICALLY AND SOLENOID ACTUATED VALVES, ONE UNIT MOUNTED TYPE VPG TECHNICAL CHARACTERISTICS Number of ways / positions : 3/2, 3/3, 5/2, 5/3, 5/4 Nominal sizes (ND) : 4, 6, 9, 12 Medium : compressed

More information

Pressure Transmitters 36 F-27839

Pressure Transmitters 36 F-27839 Pressure Transmitters 36 F-27839 SPD310/SPD360 Air Differential schneider-electric.com 37 SPD310/SPD360 SPD310/SPD360 differential pressure transmitters are intended for use in air handling systems for

More information

Pressure switches for air and water CS

Pressure switches for air and water CS Data sheet Pressure switches for air and water CS CS pressure switches have a built-in pressure operated, three-pole switch. The contact position of which depends on the pressure in the connector and the

More information

Flow and check valves Logic valves series 551. Brochure

Flow and check valves Logic valves series 551. Brochure Flow and check valves Logic valves series 551 Brochure 2 Flow and check valves Logic valves series 551 3/2-directional valve, low pressure operated Qn = 2-120 l/min 3 3/2-directional valve, Qn = 120 l/min

More information

CENTRAL GAS SUPPLY SYSTEMS : CYLINDER BATTERIES AND HIGH PRESSURE HOSES

CENTRAL GAS SUPPLY SYSTEMS : CYLINDER BATTERIES AND HIGH PRESSURE HOSES P0170E-1.DOCX/08.16/MG CENTRAL GAS SUPPLY SYSTEMS : CYLINDER BATTERIES AND HIGH PRESSURE HOSES With a Central Gas Supply System, individual work places or gas take-off stations are supplied with gas through

More information

Y P C MULTIPOLAR CONNECTOR - MCS SERIES ADVANTAGES OF THE MULTIPOLAR CONNECTION SYSTEM

Y P C MULTIPOLAR CONNECTOR - MCS SERIES ADVANTAGES OF THE MULTIPOLAR CONNECTION SYSTEM Y P C MULTIPOLAR CONNECTOR - MCS SERIES ADVANTAGES OF THE MULTIPOLAR CONNECTION SYSTEM ) The connection of every valve doesn t need the utilisation of any tool for the electrical mounting. ) Every connection

More information