SAFETY DATA SHEET CV-22 Disinfectant. 1. Product and Company Identification. 2. Hazards Identification

Transcription

1 Page: 1 Product Code: Product Name: Company Name: 1. Product and Company Identification CV-22 Casco Products Company, Inc. P.O. Box 850 Brookhaven, MS address: cascoproducts@bellsouth.net Emergency Contact: Chemtrec (800) Casco (601) Information: Casco (601) Acute Toxicity: Oral, Category 4 Skin Corrosion/Irritation, Category 1B Serious Eye Damage/Eye Irritation, Category 1 Aquatic Toxicity (Acute), Category 2 2. Hazards Identification GHS Signal Word: GHS Hazard Phrases: GHS Precaution Phrases: GHS Response Phrases: GHS Storage and Disposal Phrases: Danger H302: Harmful if swallowed. H314: Causes severe skin burns and eye damage. H318: Causes serious eye damage. H401: Toxic to aquatic life. P260: Do not breathe {dust/fume/gas/mist/vapors/spray}. P264: Wash {hands} thoroughly after handling. P270: Do not eat, drink or smoke when using this product. P280: Wear {protective gloves/protective clothing/eye protection/face protection}. P : IF SWALLOWED: Call a POISON CENTER or doctor/physician if you feel unwell. P : IF ON SKIN (or hair): Remove/take off immediately all contaminated clothing. Rinse skin with water/shower. P : IF INHALED: Remove victim to fresh air and keep at rest in a position comfortable for breathing. P : IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. P310: Immediately call a POISON CENTER or doctor/physician. P321: Specific treatment {see... on this label}. P330: Rinse mouth. P363: Wash contaminated clothing before reuse. P405: Store locked up. P501: Dispose of contents/container according to Federal, State and Local regulations.

2 Page: 2 Potential Health Effects (Acute and Chronic): Skin: Causes corrosive burns. Brief exposures may cause irritation and defatting of the skin. Eyes: Causes burns and may result in permanent damage to eyes including blindness. Inhalation: Mists and vapors can irritate the throat and respiratory tract. Ingestion: Can cause gastrointestinal irritation, swelling of the larynx, difficulty in breathing, circulatory shock, convulsions and possibly death. Inhalation: Skin Contact: Eye Contact: Ingestion: Can irritate the throat and respiratory tract. Causes corrosive burns. Causes burns and may result in permanent injury to eyes including blindness. Causes gastrointestinal irritation, swelling of the larynx, difficulty in breathing, circulatory shock, convulsions and possibly death. Medical Conditions Generally Asthma Aggravated By Exposure: Pregnant women should avoid chemical exposure. 3. Composition/Information on Ingredients CAS # Hazardous Components (Chemical Name) Concentration Decanaminium, N-Decyl-N,N-dimethyl-, chloride ~13.02 % Quaternary ammonium compounds,benzyl-c12-16-alkyldimethyl, chlorides ~ 8.68 % Water ~78.3 % Emergency and First Aid Procedures: 4. First Aid Measures In Case of Inhalation: In Case of Skin Contact: In Case of Eye Contact: In Case of Ingestion: Signs and Symptoms Of Exposure: Move victim to fresh air. If person is not breathing, call 911 or an ambulance, then give artificial respiration preferably mouth to mouth if possible. Call a poison control center or Doctor for further treatment advice. Take off contaminated clothing. Rinse skin immediately with plenty of water for minutes. Call a poison control center or Doctor for treatment advice. Immediately flush eyes with water for minutes, while holding eyelids open. Remove contact lenses, if present, after the first 5 minutes, then continue rinsing eye. Seek medical attention at once. Call a poison control center or Doctor immediately for treatment advice. Have person sip a glass of water if able to swallow. Do not induce vomiting unless told to do so by a poison control center or Doctor. Do not give anything by mouth to an unconscious person. Eyes: Burning, redness, tearing and difficulty with sight. Skin: Causes corrosive burns and may result in permanent injury to eyes including blindness. Inhalation: Mists and vapors can irritate the throat and respiratory tract. Headaches, dizziness and drowsiness. Ingestion: Irritation, swelling of the larynx, difficulty breathing, circulatory shock, convulsions and possibly death.

3 Page: 3 5. Fire Fighting Measures Flash Pt: ~ F Method Used: Cleveland Open Cup Explosive Limits: LEL: UEL: Autoignition Pt: Fire Fighting Instructions: Flammable Properties and Hazards: Suitable Extinguishing Media: Dry chemical, foam, carbon dioxide or water fog. Solid water streams may spread burning liquids. Hazardous Combustion Products: Flammable mixtures can forms with air. Fire fighters should wear full protective clothing including self-contained breathing apparatus. Cool fire exposed containers with spray. Irritating and toxic gases or fumes may be released during a fire. 6. Accidental Release Measures Protective Precautions, Protective Equipment and Emergency Procedures: Environmental Precautions: Steps To Be Taken In Case Material Is Released Or Spilled: Ventilate closed spaces before entering. Floor may be slippery. Do not touch or walk through spilled material. Stop leak if you can do it without risk. Prevent entry into water or sewer systems. Isolate spill or leak area immediately. Keep unauthorized personnel away. Stay upwind. Keep out of low areas where vapors may accumulate. 7. Handling and Storage Precautions To Be Taken in Handling: Precautions To Be Taken in Storing: Avoid contact with skin and eyes. Use good personal hygiene practices. Wash hands before eating, drinking,smoking, or using toilet facilities. Wash thoroughly after work using soap and water. Keep container tightly closed and in a cool, well ventilated place. Keep from freezing. Do not handle or store near an open flame, heat or other sources of ignition. 8. Exposure Controls/Personal Protection CAS # Partial Chemical Name OSHA TWA ACGIH TWA Other Limits Decanaminium, N-Decyl-N,N-dimethyl-, chloride Quaternary ammonium compounds,benzyl-c12-16-alkyldimeth yl, chlorides Water Respiratory Equipment (Specify Type): Eye Protection: Protective Gloves: Other Protective Clothing: Engineering Controls (Ventilation etc.): If exposure limits are exceeded or if irritation is experienced, a NIOSH/MSHA approved respirator or an organic-vapor removing cartridge respirator protection device should be worn. Ventilation and other forms of engineering controls are often the preferred means for controlling chemical exposures. Wear chemical goggles. Use a face shield if splashing is possible. Use impervious gloves, rubber, neoprene or nitrile. Wear suitable protective clothing. Eye wash fountain and emergency showers are recommended.

4 Page: 4 9. Physical and Chemical Properties Physical States: [ ] Gas [ X ] Liquid [ ] Solid Appearance and Odor: ph: ~ Melting Point: NE Boiling Point: NE Flash Pt: ~ F Method Used: Cleveland Open Cup Evaporation Rate: Flammability (solid, gas): Appearance: Clear Colourless Straw-colored Liquid Odor: Benzaldehyde-like odor Explosive Limits: LEL: UEL: Vapor Pressure (vs. Air or mm Hg): Vapor Density (vs. Air = 1): Specific Gravity (Water = 1): ~ lbs./gal Solubility in Water: Octanol/Water Partition Coefficient: VOC / Volume: Autoignition Pt: NA Decomposition Temperature: NE Viscosity: Stability: Conditions To Avoid - Instability: Incompatibility - Materials To Avoid: Hazardous Decomposition or Byproducts: Possibility of Hazardous Reactions: Conditions To Avoid - Hazardous Reactions: ~ mm2/s at 23.0 C 10. Stability and Reactivity Unstable [ ] Stable [ X ] Keep away from heat and strong oxidizing agents. Strong oxidizing agents and reducing agents. Carbon monoxide, carbon dioxide and hydrogen chloride vapors. Will occur [ ] Will not occur [ X ]

5 Page: 5 Toxicological Information: Irritation or Corrosion: Carcinogenicity: General Ecological Information: Waste Disposal Method: LAND TRANSPORT (US DOT): 11. Toxicological Information Acute Oral LD50: 561 mg/kg (rat) Skin and eyes NTP? No IARC Monographs? No OSHA Regulated? No 12. Ecological Information Toxic to aquatic organisms. 13. Disposal Considerations According to Federal, State and Local regulations. 14. Transport Information DOT Proper Shipping Name: Disinfectant Liquid Corrosive (Quaternary Ammonia Compound) DOT Hazard Class: 8 CORROSIVE UN/NA Number: UN1903 Packing Group: III CAS # Hazardous Components (Chemical Name) 15. Regulatory Information EPA SARA (Superfund Amendments and Reauthorization Act of 1986) Lists S. 302 (EHS) S. 304 RQ S. 313 (TRI) Decanaminium, N-Decyl-N,N-dimethyl-, chloride No No No Quaternary ammonium compounds,benzyl-c12-16-alkyldimethyl, chlorides No No No Water No No No This material meets the EPA 'Hazard Categories' defined for SARA Title III Sections 311/312 as indicated: [X] Yes [ ] No Acute (immediate) Health Hazard [ ] Yes [X] No Chronic (delayed) Health Hazard [ ] Yes [X] No Fire Hazard [ ] Yes [X] No Sudden Release of Pressure Hazard [ ] Yes [X] No Reactive Hazard Revision Date: Hazard Rating System: HMIS: 10/23/2015 HEALTH FLAMMABILITY PHYSICAL PPE 16. Other Information D Flammability Health NFPA: COR Instability Special Hazard Additional Information About This Product: Company Policy or Disclaimer: All responsibility for the proper use, storage and handling of this product is the responsibility of the buyer. Casco Products Company, Inc. makes no other claims or warrantees, expressed or implied. While the information is believed to be accurate, Casco Products Company, Inc. makes no representations as to its accuracy or

6 Page: 6 sufficiency, conditions of use are beyond Casco Products Company, Inc. control and therefore users are responsible to verify data under their own operating conditions.