MATERIAL SAFETY DATA SHEET. Page Number:

Transcription

1 Page Number: 1 SECTION I - PRODUCT AND COMPANY INFORMATION Product Name: GS-125 GUTTER SEALER 7oz. HMIS Hazard Rating: Health: 1 Fire: 3 Reactivity: 0 PPE: B Company Identification: OSI SEALANTS, INC.a Subsidiary of Sovereign Specialty Chems PRODUCTION DRIVE MENTOR OH Information phone/fax: (440) (440) Emergency Phone (24 hour) CHEMTREC (800) Chemtrec (outside-usa) (703) Product Class SEALANT Trade Name PRO-SERIES Product Code xx squeeze tube SECTION II - INGREDIENT AND HAZARD INFORMATION Hazardous Ingredient Name CAS Number Percent TSCA STODDARD SOLVENT Y Light Hydrotreated Naphtha Y Titanium Dioxide ** < 5.0 Y Ingredient Notes: *TITANIUM DIOXIDE IN WHITE ONLY! **The main hazard of Titanium Dioxide is dust inhalation. Because of its incorporation into the caulk, exposure by inhalation is unlikely. Remaining ingredients are not considered OSHA hazardous. SECTION III - PHYSICAL AND CHEMICAL PROPERTIES Form: Medium viscosity, paste Appearance/Color: White or Aluminum Solubility (in water): insoluble

2 Page Number: 2 ph Value, +/-.3: Boiling Range: Vapor Pressure (mmhg): Evaporation Rate: Vapor Density: Not Applicable 135.øF øF (57.22øC øC) 90.@ 68.øF (20.øC) 2. times Faster than n-butyl Acetate Heavier than air % Volatile, Weight 49.% % Volatile, Volume approx. 60.% Specific Gravity: VOC (less H2O or exempt) <500 Gr/L (49%) NOTE: *BOIL RANGE, EVAP RATE, VAPOR DENSITY AND PRESSURE FOR SOLVENT ONLY! SECTION IV - FIRE FIGHTING MEASURES (Flash,UEL,LEL for solvent only) Flammability Class I B Flash Range: 0.øF - 5.øF (-17.78øC øC) Tag Closed Cup Explosive Range (LEL/UEL): 0.9% 6.7% EXTINGUISHING MEDIA: Carbon Dioxide---Dry Chemical---Foam Use water fog to cool material in vicinity of fire. SPECIAL FIRE-FIGHTING PROCEDURES: Use self-contained breathing apparatus with full facepiece operated in pressure demand with full protective equipment. UNUSUAL FIRE AND EXPLOSION HAZARDS: Any closed container may rupture when exposed to extreme heat. Solvent vapors are heavier than air and travel along the ground. Vapors given off are flammable and may be ignited in air explosively SECTION V - HEALTH HAZARD DATA ROUTES OF ENTRY: ENTRY THROUGH... Inhalation and skin most likely CARCINOGENICITY... NTP? N/E IARC Monographs? N/E OHSA? NO EFFECTS OF OVEREXPOSURE Eyes: Can cause irritation, redness, tearing and blurred vision.

3 Page Number: 3 Skin: Prolonged or repeated contact can cause moderate irritation, drying of the skin, and dermatitis. Inhalation: Excessive inhalation of vapors can cause respiratory irritation, headache, drowsiness and fatigue. High concentrations of vapors are anesthetic and may cause central nervous system effects such as dizziness. Ingestion: Can cause gastrointestinal irritation, nausea, vomiting and diarrhea. FIRST AID MEASURES Eyes: Flush eyes gently with water for at least 15 minutes lifting eyelids occasionally; get prompt medical attention Skin: Wash thoroughly with soap and water; apply a mild skin cream. Remove contaminated clothing. Inhalation: Move affected person to fresh air; if breathing is difficult, administer oxygen; if breathing has stopped, give artificial respiration. Get medical attention. Ingestion: DO NOT INDUCE VOMITING! Get immediate medical attention. CHRONIC HAZARDS NOTICE: Reports have associated repeated and prolonged occupational overexposure to solvents with permanent brain, nervous system, liver or kidney damage or may cause cardiac arrhythmia. INTENTIONAL misuse of this product by deliberately inhaling its vapors may be harmful or fatal. SECTION VI - STABILITY AND REACTIVITY Stability: This product is stable Hazardous Polymerization: Hazardous polymerization will not occur INCOMPATABILITY: Keep away from strong oxidizing agents. CONDITIONS TO AVOID: Keep away from heat, spark, open flames and any ignition source. HAZARDOUS DECOMPOSITION PRODUCTS: Will produce fumes and smoke containing carbon monoxide and dioxide under fire conditions. SECTION VII - ACCIDENTAL RELEASE AND DISPOSAL MEASURES: STEPS TO BE TAKEN IN CASE OF SPILL: Eliminate all ignition sources. Ventilate confined areas. (Open windows and doors). Wear appropriate protective clothing. Cover with absorbent. Scoop into sealable safety container.

4 Page Number: 4 WASTE DISPOSAL METHOD: Dispose of following local, state, and federal regulations. SECTION VIII - EXPOSURE CONTROLS/PERSONAL PROTECTION Occupational Exposure Limits ACGIH TLV ACGIH TLV-C ACGIH STEL OSHA STEL OSHA PEL STODDARD SOLVENT PPM N/est N/est N/est PPM Light Hydrotreated Naphtha PPM N/est N/est N/est PPM Titanium Dioxide ** mg/f3 N/est N/est N/est mg/f3 RESPIRATORY PROTECTION: If TLV of the product is exceeded, a NIOSH/MSHA jointly approved air supply respirator is advised in the absence of proper ventilation. OSHA regulations also permit the use of other types of NIOSH/MSHA respirators under specified conditions. (See your safety equipment supplier for more information) VENTILATION: Provide sufficient mechanical (general and/or local exhaust) ventilation to maintain exposure below TLV. Ventilate during application and curing of this product. PROTECTIVE CLOTHING: Rubber gloves should be worn where skin contact is likely. Wear impervious clothing and shoes. EYE PROTECTION: Chemical goggles or safety glasses should be worn. HANDLING AND STORAGE PRECAUTIONS: Keep away from heat, spark and flame. Keep out of reach of children. Keep container closed while not in use. Do not cut or burn recepticals that have contained a solvent based product. Do not reuse this container. Use only in a well ventilated area N/A=NOT APPLICABLE N/AV=NOT AVAILABLE N/E, N/est=NOT ESTABLISHED

5 Page Number: 5 SECTION IX - TRANSPORT INFORMATION: DOT CLASSIFICATIONS FOR ONE GALLON AND UNDER CONTAINERS DESCRIPTION: ORM-D, Consumer commodity CLASS/ UN NO.: none DOT LABEL: ORM-D (Caulking) IMDG class: 3.3 IMDG BOL: Flammable Liquid nos.,3,un1993,pg III,LTD QTY SECTION X - REGULATORY INFORMATION: This material fits the EPA Hazard Category definition of Immediate (Acute)and Delayed (Chronic) Health Hazards and Fire Hazard under SARA Sections 311, 312. Chemical ingredients are listed on the TSCA inventory. SARA Section 313 toxic chemicals: NONE above the de minimis reporting thresholds. California PROP.65 Chemicals: none known DISCLAIMER: The information contained herein is based on data available as of the date of preparation of this MSDS and which we believe to be reliable. However, no warranty is expressed or implied regarding the accuracy of the data. We shall not be responsible for the use of this information, or of any product, method, or apparatus mentioned, and the user must make his own investigation to determine the suitability of the information or products for his particular purpose, for the protection of the environment, and the health and safety of the users of this material. Last Page