PTRT 2470: Petroleum Data Management 3 - Facilities Test 4 (Spring 2017)
|
|
- Lorin Higgins
- 6 years ago
- Views:
Transcription
1 Use scantron to answer all questions PTRT 2470: Petroleum Data Management 3 - Facilities Test 4 (Spring 2017) 1. The term dehydration of natural gas means A. addition of water vapor B. removal of water vapor C. addition of gas hydrate D. removal of gas hydrate 2. Water content can affect long-distance transmission of natural gas. Which statement is not true? A. Liquid water and natural gas can form hydrates that may plug the pipeline and other equipment B. Natural gas containing CO 2 or H 2 S is corrosive when liquid water is present C. Liquid water in a natural gas pipeline can result in lower flow efficiency of the pipeline D. Water content increases the heating value of natural gas being transported 3. What principle is not applied in dehydration of natural gas? A. cooling B. compression C. reaction D. absorption E. adsorption 4. What is the principle behind dehydration by adsorption? A. distillation B. compression C. reaction D. solid desiccation E. liquid desiccation 5. What is the principle behind dehydration by absorption? A. distillation B. compression C. reaction D. solid desiccation E. liquid desiccation 6. Which is the mostly used glycol for dehydration of natural gas? A. EG B. DEG C. TEG D. T4EG 7. In a typical glycol dehydration plant, where is the inlet gas cleaned of liquid traces before dehydration? A. boiler B. distiller C. scrubber D. contactor E. surge tank The requirements for a trayed type glycol contactor are: Gas flow rate: 11 MMscf/d Gas specific gravity: 0.7 Operating line pressure: 800 psig Gas inlet temperature: 95 o F Outlet gas water content: 5 lb H 2 O/MMscf Design criteria: GWR = 4 gal TEG/lbm H 2 O with 99.5% TEG 8. What is the temperature correction factor C t? A B C D What is the corrected gas capacity (MMscf/d) of the contactor? A B C D E What is the best diameter for the contactor? A. 18 in B. 24 in C. 30 in D. 36 in 11. What is the water content (lb H 2 O/MMscf ) of the inlet gas? A. 40 B C D E. 75 1
2 12. What is the temperature (F) of the outlet gas? A. 20 B. 23 C. 28 D How many trays are required? A. 2 B. 3 C. 4 D. 5 E What type of compressor is used to prevent gas lock of sucker rod pump? 15. What type of compressor is used to restore the pressure drop from transportation in pipelines? 16. What type of compressor is used for underground storage of natural gas? 17. What type of compressor is used in stage separation facilities? 18. What facility in a compressor station removes water, hydrocarbons, and other impurities from natural gas? 19. What facility in a compressor station helps to reduce the noise level? 20. What facility in a compressor station is used to maintain pipeline integrity? In a 4 stage compression, the suction pressures at the first and third stage are 100 psi and 1600 psi. Answer the next 3 questions 21. What is the compression ratio per stage? A. 1 B. 2 C D. 4 E The delivery pressure at the fourth stage is A. 3,200 psi B. 4,032 psi C. 6,400 psi D. 16,128 psi E. 25,600 psi 23. What is the overall compression ratio? A. 32 B. 40 C. 64 D. 160 E For a three stage compressor, compressing from suction p1 to suction p2 to suction p3 is with no pressure losses. If p1 and p3 are known, then the intermediate suction pressure p2 is given by A. p2 = (p1 + p3)/2 B. p2 = (p1 p3) C. p2 = p3 (p3/p1) D. p2 = p1 (p3/p1) E. p2 = p1 (p1/p3) 25. In gas compression, the inlet pressure is always the discharge pressure. A. equal to B. less than C. more than 26. In gas compression, the inlet volume is always the discharge volume. A. equal to B. less than C. more than 2
3 27. Which of these components may not be a part of reciprocation compressor? A. piston B. cylinder C. impeller D. suction valve 28. What type of compressor has a higher mechanical efficiency? A. reciprocating compressor B. centrifugal compressor 29. What type of compressor undergoes adiabatic compression? A. reciprocating compressor B. centrifugal compressor 30. Natural gas is adiabatically compressed in 2 stages with an overall compression ratio of 8 and stage 1 suction temperature of 65 F. Calculate stage 1 discharge temperature assuming z is constant and k=1.3. A. 83 F B. 207 F C. 257 F D. 388 F E. 667 F 31. If no intercooler is used in previous question, what is stage 2 discharge temperature? A. 105 F B. 169 F C. 263 F D. 388 F E. 848 F 32. Intercooling in multi-stage compression is done A. to cool gas at first stage inlet B. to cool gas at final delivery C. to enable compression in two stages D. to minimize the work of compression 33. What type of heat exchanger is shown? A. countercurrent flow B. co-current flow 34. Which of the following gases in natural gas is an acid gas? A. CO 2 B. H 2 O C. He D. N 2 E. all of them 35. Sweetening is the process of removing what gas from natural gas? 36. Which of the following may not be responsible for sweetening solvent losses? A. vaporization B. temperature C. degradation D. mechanical E. viscosity 37. Which of the following may not be an operating problem in a sweetening plant? A. foaming in the contactor B. corrosion C. vaporization of solvent D. degradation of solvent E. good contact of solvent with contactor 38. Which of the following is not a desirable characteristic of a sweetening solvent? A. Hydrocarbons pickup must be low B. Acid gas pickup must be high C. Solvent must be thermally stable D. Solvent losses must be minimized E. Solvent should foam in the contactor 39. Which of these processes cannot be used to remove traces of CO 2 from natural gas? A. iron-sponge B. monoethanoalamine C. hot pot D. glycol/amine E. all 40. Why would water be added to monoethanoalamine in a natural gas sweetening plant? A. to pickup H 2 S B. to pickup CO 2 C. to pickup H 2 O D. to wet the gas for effectiveness 3
4 41. Which process has difficulty in meeting the H 2 S specification if the H 2 S/CO 2 ratio is high? A. sulfinol B. alkanolamine C. iron-sponge D. glycol/amine E. hot pot 42. Which process has the ability of removing water vapor, H 2 S and CO 2 in the same process? A. sulfinol B. alkanolamine C. iron-sponge D. glycol/amine E. hot pot 43. What is the value of y to balance the following regeneration reaction in a sweetening plant? x Fe 2 S 3 + y O 2 v Fe 2 O 3 + w S A. 1 B. 2 C. 3 D. 4 E What is the value of x to balance the following regeneration reaction in a sweetening plant? x Fe 2 S 3 + y O 2 v Fe 2 O 3 + w S A. 1 B. 2 C. 3 D. 4 E What does methane number of natural gas measure? A. volume B. heating value C. lightness D. load on burner E. dew point 46. What type of gas is dissolved in oil? A. associated gas B. non-associated gas C. solution gas D. gas hydrate E. gas condensate 47. What is the minimum percentage of methane in dry natural gas? A. 5 B. 15 C. 50 D. 85 E Which of the following parameters is not a typical standard sales gas requirement? A. volume B. methane number C. viscosity D. calorific value E. dew point 49. Which of the following is NOT true about odorization of natural gas? A. it gives the gas unpleasant smell B. it enables to detect gas leaks C. it enables to see gas D. it is deliberately added to gas E. sulfur is a good odorant 50. Which of the following cannot be classified as conventional natural gas? A. associated gas B. non-associated gas C. gas condensate D. coal-bed methane 51. Which of the following gases in natural gas can reduce its heating value? 52. Which of the following gases in natural gas can primarily lead to gas hydrate? 53. In which of the following natural gas forms can heptane be mostly found? 54. Which of the following natural gas forms contains mainly methane? 55. Which of the following natural gas forms is referred to as natural gasoline? 4
5 56. What equipment is needed to remove condensate from natural gas? 57. What equipment is needed to process NGL into purity products? 58. What equipment is needed to produce LNG? 59. In an LNG plant, what is least considered necessary to be removed before the gas is liquefied? A. condensate B. carbon dioxide C. nitrogen D. water vapor E. hydrogen sulfide 60. If 1 scf of natural gas generates 1000 Btu of heat, what is the heating value of 90 MMscf (million standard cubic feet) of the gas in dekatherms? 1 dekatherm = 1,000,000 Btu A. 90 B. 9,000 C. 90,000 D. 900,000 E. 9,000,000 5
Optimizing Effective Absorption during Wet Natural Gas Dehydration by Tri Ethylene Glycol
IOSR Journal of Applied Chemistry (IOSRJAC) ISSN : 2278-5736 Volume 2, Issue 2 (Sep-Oct. 212), PP 1-6 Optimizing Effective Absorption during Wet Natural Gas Dehydration by Tri Ethylene Glycol Khan, Mohd
More informationOIL AND GAS PROCESSES AND EMISSIONS
OIL AND GAS PROCESSES AND EMISSIONS This document provides a brief description of oil and gas activities, equipment and expected pollutants from those equipment types. The emissions processes are discussed
More informationINTEROFFICE MEMORANDUM MODIFICATIONS TO DEW POINT CONTROL PROCESS
INTEROFFICE MEMORANDUM TO: FROM: SUBJECT: NEW ENGINEER I.M. ANOLDGUY MODIFICATIONS TO DEW POINT CONTROL PROCESS DATE: JANUARY 10, 2017 We are looking to make modifications to our initial design for a DPC
More informationDEHYDRATION OF ACID GAS PRIOR TO INJECTION Eugene W. Grynia, John J. Carroll, Peter J. Griffin, Gas Liquids Engineering, Calgary, Canada
DEHYDRATION OF ACID GAS PRIOR TO INJECTION Eugene W. Grynia, John J. Carroll, Peter J. Griffin, Gas Liquids Engineering, Calgary, Canada Acid gas is a mixture of hydrogen sulfide and carbon dioxide, with
More informationTraining Fees 4,000 US$ per participant for Public Training includes Materials/Handouts, tea/coffee breaks, refreshments & Buffet Lunch.
Training Title GAS CONDITIONING & PROCESSING Training Duration 5 days Training Venue and Dates Gas Conditioning & Processing 5 07 11 April, 2019 $4,000 Dubai, UAE Trainings will be conducted in any of
More informationOffshore Equipment. Yutaek Seo
Offshore Equipment Yutaek Seo Flash Gas Compressor (East spar) Dehydration NGL recovery Slug catcher Separator Stabilization Booster compressor Gas export compression (Donghae-1 Platform) May 7 th Gas
More informationSHOP WELDED TANKS STANDARD CONNECTIONS
STEEL WELDED TANKS Tanks are constructed using 3/16 and ¼ inch A36 material. Welding and testing are performed according to API 12F specifications. Shop welded tanks are also available in special sizes
More informationVapor Recovery from Condensate Storage Tanks Using Gas Ejector Technology Palash K. Saha 1 and Mahbubur Rahman 2
37 Journal of Chemical Engineering, IEB Vapor Recovery from Condensate Storage Tanks Using Gas Ejector Technology Palash K. Saha 1 and Mahbubur Rahman 2 Abstract 1 Bibyana Gas Field 2 Department of Petroleum
More informationGas Conditioning & Processing
An Intensive 5 Day Training Course Gas Conditioning & Processing 09-13 Sep 2018, Dubai 20-NOV-17 This course is Designed, Developed, and will be Delivered under iso Quality standards Gas Conditioning &
More informationSimplicity in VRU by using a Beam Gas Compressor
Simplicity in VRU by using a Beam Gas Compressor By Charlie D. McCoy and Mark Lancaster Abstract: Vapor Recovery Units are often expensive, complicated to operate and unable to deal with High H2S and liquids.
More informationFrom the Choke KO drum, the gas passes through another gas/gas exchanger - the 'LTS Pre-cooler'.
Refer to Figures: 16 & 17 as you read on. Wet, natural gas direct from the wellstreams, at about 1600 Psi, is first pre-cooled and separated from liquids in an 'Intermediate Separator' and cooled in a
More informationAdvanced Management of Compressed Air Systems Pre-Workshop Assignment
Advanced Management of Compressed Air Systems Page 1 In order to ensure that the Compressed Air Challenge Level II Training is most useful to you, it will be important for you to bring information about
More informationGLOSSARY OF TERMS. Adiabatic Compression Compression process when all heat of compression is retained in the gas being compressed.
GLOSSARY OF TERMS Absolute pressure Total pressure measured from absolute zero i.e. a perfect vacuum. As a practical matter, gauge pressure plus atmospheric pressure. Absolute temperature Temperature measured
More informationPRESENTED AT: NACE CORROSION 2006 SAN DIEGO, CA
PRESENTED AT: NACE CORROSION 2006 SAN DIEGO, CA POSSIBLE GLYCOL CORROSION IN NOMINALLY DRY GAS PIPELINES John S. Smart, III John Smart Consulting Engineers Houston, TX 77079 Tel 281 493 5946 email jacksmartiii@hotmail.com
More informationGAS DEHYDRATION SYSTEM
GAS DEHYDRATION SYSTEM High pressure and compressed gases flow to the Glycol Contactor (MAF-3110). In the Contactor, gas flows through trays, contacting the lean glycol that is flowing across the trays
More informationFundamentals of Compressed Air Systems. Pre-Workshop Assignment
Page 1 In order to ensure that the Compressed Air Challenge Fundamentals of Compressed Air Systems Training is most useful to you, it will be important for you to bring information about your plant s compressed
More informationEarlier Lecture. In the earlier lecture, we have seen Kapitza & Heylandt systems which are the modifications of the Claude System.
17 1 Earlier Lecture In the earlier lecture, we have seen Kapitza & Heylandt systems which are the modifications of the Claude System. Collins system is an extension of the Claude system to reach lower
More informationwww.ompressedairsystems.com ultra-high purity nitrogen generators nitrogen purity: 95% to 99.999% www.ompressedairsystems.com ultra-high purity nitrogen generators nitrogen purity: 95% to 99.999% Leading
More informationA centrifugal pump consists of an impeller attached to and rotating with the shaft and a casing that encloses the impeller.
Centrifugal pump How centrifugal pumps work A centrifugal pump consists of an impeller attached to and rotating with the shaft and a casing that encloses the impeller. In centrifugal pump, liquid is forced
More informationOIL AND GAS SEPARATION DESIGN MANUAL
OIL AND GAS SEPARATION DESIGN MANUAL BY C. RICHARD SIVALLS, P.E. SIVALLS, INC. BOX 2792 ODESSA, TEXAS 79760 All rights reserved. This publication is fully protected by copyright and nothing that appears
More informationGAS DEHYDRATION SYSTEM
GAS DEHYDRATION SYSTEM High pressure and compressed gases flow through the Gas Scrubber (MBF-4540) to the Glycol Contactor (MAF-0900). In the Contactor, gas flows through trays, contacting the lean glycol
More informationGAS DEHYDRATION SYSTEM
GAS DEHYDRATION SYSTEM High pressure gases from the Gas Compressors (CBA-4070/4020) flow to the Glycol Contactor (MAF-1150). In the Contactor, gas flows through trays, contacting the lean glycol that is
More informationRemoving nitrogen. Nitrogen rejection applications can be divided into two categories
Removing nitrogen Doug MacKenzie, Ilie Cheta and Darryl Burns, Gas Liquids Engineering, Canada, present a comparative study of four nitrogen removal processes. Nitrogen rejection applications can be divided
More informationFlashCO2, CO2 at 23 $/ton
FlashCO2, CO2 at 23 $/ton A cost effective solution of capturing CO2 from Steam Methane Reforming (SMR) Hydrogen production plants by the FlashCO2 process Introduction to a cost effective solution Driven
More informationJournal of Chemical and Pharmaceutical Research, 2016, 8(5): Research Article
Available online www.jocpr.com Journal of Chemical and Pharmaceutical Research, 2016, 8(5):567-578 Research Article ISSN : 0975-7384 CODEN(USA) : JCPRC5 Investigation and Optimization of Gas Dehydration
More informationFundamentals Of Petroleum Engineering PRODUCTION
Fundamentals Of Petroleum Engineering PRODUCTION Mohd Fauzi Hamid Wan Rosli Wan Sulaiman Department of Petroleum Engineering Faculty of Petroleum & Renewable Engineering Universiti Technologi Malaysia
More informationNatural Gas Desulfurization Process By MEA Amine: The preferable Engineering Design Procedure
Natural Gas Desulfurization Process By MEA Amine: The preferable Engineering Design Procedure Ribwar Abdulrahman 1, Ibtisam Kamal 2, Jagar Ali 3 1 Faculty of Engineering, KoyaUniversity, Kurdistan region,
More informationANNEX AMENDMENTS TO THE INTERNATIONAL CODE FOR FIRE SAFETY SYSTEMS (FSS CODE) CHAPTER 15 INERT GAS SYSTEMS
Annex 3, page 2 ANNEX AMENDMENTS TO THE INTERNATIONAL CODE FOR FIRE SAFETY SYSTEMS (FSS CODE) CHAPTER 15 INERT GAS SYSTEMS The text of existing chapter 15 is replaced by the following: "1 Application This
More informationApplication Worksheet
Application Worksheet All dimensions are nominal. Dimensions in [ ] are in millimeters. Service Conditions Medium Through Valve: Required C v : Temperature Maximum: Minimum: Normal: Flow Maximum: Minimum:
More informationVortex flowmeters. Product family introduction Principle of operation Product review Applications Key product features
Vortex flowmeters introduction Product review s Key product features This document should not be duplicated, used, distributed, or disclosed for any purpose unless authorized by Siemens. Page 1 Vortex
More informationWaste to energy conversion Dr. Prasenjit Mondal Department of Chemical Engineering Indian Institute of Technology, Roorkee. Lecture 25 Gas Cleanup 2
Waste to energy conversion Dr. Prasenjit Mondal Department of Chemical Engineering Indian Institute of Technology, Roorkee Lecture 25 Gas Cleanup 2 Hi friends. Now we will start discussion on the second
More informationhydro-pac, inc. Low-Pressure Gas Compressors 1500 to 6000 PSI
hydro-pac, inc. LX-SERIES Low-Pressure Gas Compressors 1500 to 6000 PSI hydro-pac, inc. LX-SERIES Features Hydro-Pac LX-SERIES Gas Compressors feature: Oil-free non lubricated gas pistons and cylinders
More informationPREPARING SOLUBILITY DATA FOR USE UPDATING KEY RESOURCES BY THE GAS PROCESSING INDUSTRY:
PREPARING SOLUBILITY DATA FOR USE Mapping Midstream s Future 2012 GPA Convention BY THE GAS PROCESSING INDUSTRY: UPDATING KEY RESOURCES Darryl Mamrosh and Kevin Fisher Trimeric Corporation Jeff Matthews
More informationPETROLEUM & GAS PROCESSING TECHNOLOGY (PTT 365) SEPARATION OF PRODUCED FLUID
PETROLEUM & GAS PROCESSING TECHNOLOGY (PTT 365) SEPARATION OF PRODUCED FLUID Miss Nur Izzati Bte Iberahim Introduction Well effluents flowing from producing wells come out in two phases: vapor and liquid
More informationGPSA ENGINEERING DATABOOK ERRATA (2004 FPS Edition)
GPSA ENGINEERING DATABOOK ERRATA (2004 FPS Edition) PAGE DESCRIPTION 3 10 Correct typo 7 15 Change V 1 to U and gl to W 13 9 Change Eq. 13-16a 14 13 Change reference to Fig. 14-26 20 21 Change wording
More informationDetector Carrier Gas Comments Detector anode purge or reference gas. Electron Capture Nitrogen Maximum sensitivity Nitrogen Argon/Methane
Gas requirements Gases for packed columns The carrier gas you use depends upon the type of detector and the performance requirements. Table 520-1 lists gas recommendations for packed column use. In general,
More informationThe Use of Radioactive Sources in Troubleshooting Gas Plant Problems. By Waleed J. Georgie PRIMAS (Oil & Gas) Consultancy, Aberdeen, Scotland
The Use of Radioactive Sources in Troubleshooting Gas Plant Problems By Waleed J. Georgie PRIMAS (Oil & Gas) Consultancy, Aberdeen, Scotland Introduction Liquid carry over in gas treatment facilities can
More informationGAS LIFT IN NEW FIELDS
GAS LIFT IN NEW FIELDS GAS LIFT in NEW FIELDS NEW DESIGN FOR WELLS AND COMPRESSORS RESERVOIR AND PRODUCTION SIMULATION MATCHING REQUIRED PRODUCTION NODAL ANALYSIS SIMULATION USED TO SELECT INJECTION DEPTH
More informationMODELLING OF REGENERATION IN TEG NATURAL GAS DEHYDRATION UNITS
MODELLING OF REGENERATION IN TEG NATURAL GAS DEHYDRATION UNITS Aalborg University Esbjerg Oil and Gas Technology Master Thesis, Spring Semester 2017 MODELLING OF REGENERATION IN TEG NATURAL GAS DEHYDRATION
More informationENGINEERING FLUID MECHANICS
DEPARTMENT of MECHANICAL ENGINEERING FLUID MECHANICS Subject code: 10ME46B Faculty name: Naveen H E QUESTION BANK UNIT-1: FLUID PROPERTIES 1. Define the following: i) density, ii) weight density, iii)
More informationChapter 8: Reservoir Mechanics
PTRT 1472: Petroleum Data Management II Chapter 8: Reservoir Mechanics - Reservoir drives Types of Natural Gas Reservoir Fluids Natural gas is petroleum in a gaseous state, so it is always accompanied
More informationDigester Processes. 1. Raw Sludge Pumping System
Digester Processes 1. Raw Sludge Pumping System Removes accumulated sludge from the primary clarifiers, pumped through 1 of 2 pipes either 150 or 200mm in diameter (Fig. 1.1). Fig 1.1 Pipes feeding Digesters
More informationAir Eliminators and Combination Air Eliminators Strainers
Description Air Eliminators and Combination Air Eliminator Strainers are designed to provide separation, elimination and prevention of air in piping systems for a variety of installations and conditions.
More informationColumn Design Using Mass Transfer Rate Simulation
Column Design Using Mass Transfer Rate Simulation by Ralph H. Weiland and John C. Dingman Optimized Gas Treating, Inc, 15638 Whitewater Lane Houston, TX 77079, U.S.A. info@ogtrt.com Presented at the 80
More informationCERTIFICATES OF COMPETENCY IN THE MERCHANT NAVY MARINE ENGINEER OFFICER
CERTIFICATES OF COMPETENCY IN THE MERCHANT NAVY MARINE ENGINEER OFFICER EXAMINATIONS ADMINISTERED BY THE SCOTTISH QUALIFICATIONS AUTHORITY ON BEHALF OF THE MARITIME AND COASTGUARD AGENCY STCW 95 CHIEF
More informationSuperior Result from Analytical Instruments The constant purity of the nitrogen improves system stability and ensures reproducible results
Nitrogen Generator Whisper-N2 Series Features Membrane Technology Superior Result from Analytical Instruments The constant purity of the nitrogen improves system stability and ensures reproducible results
More informationCO 2 radial piston compressor (transcritical)
CO 2 radial piston compressor (transcritical) At a glance Operating limits and performance data Technical data Dimensions and connections Scope of supply 124 126 129 130 131 Radial piston compressor (transcritical)
More informationOxygen Generating Systems Ozone Medical Welding Glassblowing Aquaculture Pulp & Paper Wastewater
Oxygen Generating Systems General Information Extract oxygen directly from the atmosphere and deliver it to any medical or industrial application with an OGSI oxygen generator. Our standard line of Pressure
More informationCompressors. Basic Classification and design overview
Compressors Basic Classification and design overview What are compressors? Compressors are mechanical devices that compresses gases. It is widely used in industries and has various applications How they
More informationPE096: Overview of Gas Processing Technology
PE096: Overview of Gas Processing Technology PE096 Rev.001 CMCT COURSE OUTLINE Page 1 of 6 Training Description: This course is designed for a broad audience and is participative and interactive, utilizing
More informationV-Major, V-Compact. Reciprocating Compressors. Intelligent Air Technology
V-Major, V-Compact Reciprocating Compressors Intelligent Air Technology & Significant Energy Savings with Lower Running Costs Efficient. LOW POWER CONSUMPTION 75% of the running cost of an air compressor
More information800.Keen.Gas
C 2 H 2 ACETYLENE Acetylene is a colorless and tasteless gas with a garlic-like odor. It is flammable and can be an asphyxiant. In order to prevent explosive decomposition, acetylene is supplied in cylinders
More informationApplied Fluid Mechanics
Applied Fluid Mechanics 1. The Nature of Fluid and the Study of Fluid Mechanics 2. Viscosity of Fluid 3. Pressure Measurement 4. Forces Due to Static Fluid 5. Buoyancy and Stability 6. Flow of Fluid and
More informationDesign. Pompetravaini-NSB API SB Liquid Ring Compressor for Gas Processing. Working Principle
SB Pompetravaini-NSB API SB Liquid Ring Compressor for Gas Processing A family of API liquid ring compressors has been developed and has been in the market for nearly a decade, they are specifically made
More informationKolmetz Handbook Of Process Equipment Design AMINE GAS DEHYDRATION SYSTEM SIZING AND SELECTION (ENGINEERING DESIGN GUIDELINE)
Page : 1 of 99 Processing Plant KLM Technology #03-12 Block Aronia, Jalan Sri Perkasa 2 Taman Tampoi Utama 81200 Johor Bahru Malaysia www.klmtechgroup.com, Standards, Software AMINE GAS DEHYDRATION SYSTEM
More informationAIR DRIVEN. Gas Boosters & SYSTEMS. Accepting VISA, MasterCard and American Express
AIR DRIVEN Gas Boosters & SYSTEMS Accepting VISA, MasterCard and American Express Gas Boosters AIR DRIVEN FROM 30 PSI TO 21,750 PSI MAXIMATOR Maximator gas boosters are an excellent alternative to high
More information0B Glycol Dehydration as a Mass Transfer Rate Process. Nathan A. Hatcher, Jaime L. Nava & Ralph H. Weiland Optimized Gas Treating, Inc.
0B Glycol Dehydration as a Mass Transfer Rate Process Nathan A. Hatcher, Jaime L. Nava & Ralph H. Weiland Optimized Gas Treating, Inc. Sugar Land, TX ABSTRACT Glycol dehydration is a process that presents
More informationINNOVATIVE GAS-LIQUID SEPARATOR INCREASES GAS PRODUCTION IN THE NORTH SEA
INNOVATIVE GAS-LIQUID SEPARATOR INCREASES GAS PRODUCTION IN THE NORTH SEA Roy Viteri Sulzer Chemtech USA, Inc. 4106 New West Drive Pasadena, TX 77507 (281) 604-4119 Roy.viteri@sulzer.com Daniel Egger Sulzer
More informationInstructor: Dr. Istadi (http://tekim.undip.ac.id/staf/istadi )
Instructor: Dr. Istadi (http://tekim.undip.ac.id/staf/istadi ) Email: istadi@undip.ac.id Course Syllabus: (Part 1) 1. Definitions of Natural Gas, Gas Reservoir, Gas Drilling and Gas production (Pengertian
More informationLABORATORY LINE ON SITE GAS GENERATORS
LABORATORY LINE ON SITE GAS GENERATORS We develop technology to help companies improving production efficiency, safety and quality of work. ErreDue designs, builds and sells gas generators, mixers and
More informationTHE GUIDE TO MEMBRANE NITROGEN GENERATORS
THE GUIDE TO MEMBRANE NITROGEN GENERATORS MEMBRANE NITROGEN GENERATORS The membrane nitrogen generator utilizes a hollow porous fiber to separate the N 2 molecules from other molecules, including O 2.
More informationTroubleshooting of ADGAS Benfield - HiPure Plant of Natural Gas Sweetening Using Process Simulation
Troubleshooting of ADGAS Benfield - HiPure Plant of Natural Gas Sweetening Using Process Simulation R. Ochieng*, A. S. Berrouk, C. Peters Department of Chemical Engineering, Petroleum Institute, Abu Dhabi-UAE
More informationAtmospheric Hazards. Hazardous Atmosphere 3/29/2017. Oxygen deficiency and enrichment Flammable gases and vapors Toxic contaminants
2017 Wisconsin Safety Council Safety & Health Conference, Presentation by Tim Gackle, OSHA Training Institute April 11, 2017 Atmospheric Hazards Oxygen deficiency and enrichment Flammable gases and vapors
More informationPerformance Monitoring Examples Monitor, Analyze, Optimize
Performance Monitoring Examples Monitor, Analyze, Optimize BETA's Performance Assessment service is a low cost remote monitoring service for reciprocating compressors, centrifugal compressors, engines,
More informationS.A. Klein and G.F. Nellis Cambridge University Press, 2011
16-1 A flow nozzle is to be used to determine the mass flow rate of air through a 1.5 inch internal diameter pipe. The air in the line upstream of the meters is at 70 F and 95 psig. The barometric pressure
More informationNatural Gas Gathering
Natural Gas Gathering Course No: R04-002 Credit: 4 PDH Jim Piter, P.E. Continuing Education and Development, Inc. 9 Greyridge Farm Court Stony Point, NY 10980 P: (877) 322-5800 F: (877) 322-4774 info@cedengineering.com
More informationPRESSURE EQUIPMENT EXEMPTION ORDER. User Guide for. Pressure Equipment Exemption Order. Alberta Regulation 56/2006
the pressure equipment safety authority PRESSURE EQUIPMENT EXEMPTION ORDER User Guide AB-529 REV. 1, 2017-06-06 User Guide for Pressure Equipment Exemption Order Alberta Regulation 56/2006 With amendments
More information16. Studio ScaleChem Calculations
16. Studio ScaleChem Calculations Calculations Overview Calculations: Adding a new brine sample Studio ScaleChem can be used to calculate scaling at one or more user specified temperatures and pressures.
More informationCompressed Air - Food/Bev. Presented By: Adam Zimmerman
Compressed Air - Food/Bev Presented By: Adam Zimmerman Meeting Summary Metro Air Treatment Compressor Types & Selection Measurment Questions Metropolitan Air Compressor Co., Inc. Serving the Michigan Market
More informationEngine enhancement using enriched oxygen inlet
International Letters of Chemistry, Physics and Astronomy Online: 2015-03-25 ISSN: 2299-3843, Vol. 48, pp 37-49 doi:10.18052/www.scipress.com/ilcpa.48.37 2015 SciPress Ltd., Switzerland Engine enhancement
More informationSpecialty Gases & Equipment ISO 9001: 2008 CERTIFIED. A Division of Norco, Inc.
Specialty Gases & Equipment ISO 9001: 2008 CERTIFIED A Division of Norco, Inc. Located in Boise Idaho, Norlab has been producing and distributing calibration gas mixtures and specialty gases in refillable
More informationTitle: Choosing the right nitrogen rejection scheme
Title: Choosing the right nitrogen rejection scheme Authors: Nicolas Chantant, Paul Terrien, Sylvain Gérard (Air Liquide Global E&C Solutions) Abstract: Nitrogen Rejection Units (NRU) are used to extract
More informationUSE A RELIABLE A INNOVATIVE A COST EFFICIENT GAS EQUIPMENTS AND GAS SYSTEMS
USE A RELIABLE A INNOVATIVE A COST EFFICIENT GAS EQUIPMENTS AND GAS SYSTEMS Air & Opp. Pudumjee Paper Mills, Thergaon, Chinchwad, Pune, Maharashtra State, India-411033 Telephone. ++91 20 27273809 Telefax
More informationCase 12 Multistage Centrifugal Refrigeration System Halocarbon Refrigerant
Case 12 Multistage Centrifugal Refrigeration System Halocarbon Refrigerant Copy Right By: Thomas T.S. Wan 温 ) April 15, 2011 All Rights Reserved Case Background: This case is to show how to achieve the
More informationNatural Gas Conditioning Skids & Equipments
Natural Gas Conditioning Skids & Equipments NATURAL GAS CONDITIONING SKIDS NIRMAL has rich experience of supplying complete package of Natural Gas conditioning skids consisting of emergency shut down,
More informationFLUID DYNAMICS Ch.E-204 Umair Aslam Lecturer Department of Chemical Engineering
FLUID DYNAMICS Ch.E-204 Umair Aslam Lecturer Department of Chemical Engineering Fluid Mechanics is the branch of physics that studies fluids (liquids, gases, and plasmas) and the forces on them. Fluid
More informationDESIGN DATA. Dry 105a. September 5, 2008
September 5, 2008 Dry 105a 1. Description Dry and Preaction Systems require a dependable source of clean dry air under the proper pressure. The air supply must be adequate to restore normal air pressure
More informationAirSep PSA Nitrogen Systems
AirSep PSA Nitrogen Systems For Commercial Applications AirSep Corporation An Organization with a Global Presence Quality and long-term value are built into every AirSep product for total customer satisfaction.
More informationYutaek Seo. Subsea Engineering
Yutaek Seo Subsea Engineering Inlet receiving Gas and liquids that enter the gas processing facilities pass emergency shutdown valves, and then go to inlet receiving, where condensed phases drop out. Gas
More informationINSTRUMENT INSTRUMENT YL INSTRUMENT
INSTRUMENT INSTRUMENT INSTRUMENT Nitrogen Generator Whisper-N2 Series Features Membrane Technology Compressed air is forced through a hollow fiber membrane, with selective permeation of the different components
More informationStructured packing use in fluid catalytic cracker (FCC)
Reprinted from: March 1993 issue, p. 77-81. Used with permission. FCC main fractionator revamps Structured packing can influence unit pressure profiles and increase capacity Differential pressure S. W.
More informationSRL Series. Oil-less Scroll Air Compressors. Pharmaceutical. Research & Development. Food & Beverage. Chemical. Electronic
Pharmaceutical SRL Series Oil-less Scroll Air Compressors Research & Development Food & Beverage Chemical Electronic Hitachi Industrial Equipment Product Brochure Hitachi SRL Series scroll compressors
More informationCost Effective Natural Gas Conditioning Twelve Years Experience of Membrane System Operation
William Echt & Jeff Cook Cost Effective Natural Gas Conditioning Twelve Years Experience of Membrane System Operation WILLIAM ECHT / JEFF COOK (USA) William Echt. William.echt@uop.com Technology Manager
More informationGas Turbine Performance Analysis
Gas Turbine Performance Analysis Gas turbines may seem too complicated or overwhelming at first glance, but for regular field monitoring on a relative basis, it is not all that difficult. A regular check
More informationUnit 24: Applications of Pneumatics and Hydraulics
Unit 24: Applications of Pneumatics and Hydraulics Unit code: J/601/1496 QCF level: 4 Credit value: 15 OUTCOME 2 TUTORIAL 11 AIR COMPRESSORS AND DISTRIBUTION SYSTEM The material needed for outcome 2 is
More informationGenerating Calibration Gas Standards
Technical Note 1001 Metronics Inc. Generating Calibration Gas Standards with Dynacal Permeation Devices Permeation devices provide an excellent method of producing known gas concentrations in the PPM and
More informationAt the end of this lesson, you will be able to do the following:
Liquid-Phase Contacting Scrubbers Goal To familiarize you with the operation, collection efficiency, and major maintenance problems of liquid-phase contacting scrubbers. Objectives At the end of this lesson,
More informationPULSATION DAMPENER / SUPPRESSOR SERIES PDS PROVIDES MULTIPLE SYSTEM SAFEGUARDS
PULSATION / SUPPRESSOR SERIES PDS PROVIDES MULTIPLE SYSTEM SAFEGUARDS FUNCTIONS: 1. Pulsation Dampener smooths pump flow 2. Surge Suppressor absorbs shocks and vibrations 3. Water Hammer Arrestor eliminates
More informationCOPYRIGHT. Reservoir Fluid Core. Single Phase, Single Component Systems. By the end of this lesson, you will be able to:
Single Phase, Single Component Systems Learning Objectives Reservoir Fluid Core Single Phase, Single Component Systems By the end of this lesson, you will be able to: Define terms used to describe the
More informationApplied Technology and Best Practices in CEE. Conference
Geoinform Applied Technology and Best Practices in CEE Conference THE DEVELOPMENT OF MUD GAS LOGGING SYSTEMS AND THEIR ROLE IN HYDROCARBON EXPLORATION Sándor Pugner GEOINFORM Ltd. Budapest, 17 November
More information1 PIPESYS Application
PIPESYS Application 1-1 1 PIPESYS Application 1.1 Gas Condensate Gathering System In this PIPESYS Application, the performance of a small gascondensate gathering system is modelled. Figure 1.1 shows the
More informationEast Building, PHH-30 U.S. Department New Jersey Avenue S.E. of Transportation Washington, D.C DOT-SP (TWENTY-THIRD REVISION)
East Building, PHH-30 U.S. Department 1200 New Jersey Avenue S.E. of Transportation Washington, D.C. 20590 Pipeline and Hazardous Materials Safety Administration DOT-SP 11054 (TWENTY-THIRD REVISION) EXPIRATION
More informationO NEof Premium tools for professionals!
O NEof 6.000 Premium tools for professionals! 1 System Overview 190 Testing of Water Lines & Containers Testing Pumps 191-193 Testing of Gas- & Water Lines Analogue Testing Device 194-195 Testing of Waste
More informationENGINEERING STANDARD FOR PROCESS DESIGN OF GAS TREATING UNITS PART 1 - PROCESS DESIGN OF GAS SWEETENING UNITS ORIGINAL EDITION DEC.
ENGINEERING STANDARD FOR PROCESS DESIGN OF GAS TREATING UNITS PART 1 - PROCESS DESIGN OF GAS SWEETENING UNITS ORIGINAL EDITION DEC. 1997 This standard specification is reviewed and updated by the relevant
More informationIntroduction. S. James Zhou, Howard Meyer, Dennis Leppin and Shiguang Li Gas Technology Institute Benjamin Bikson and Yong Ding PoroGen Corporation
Nano-porous PEEK Hollow Fiber-based Gas/Liquid Membrane Contactors for Sour Gas Treating International Gas Union Research Conference 2014, September 17-19, Copenhagen, Denmark S. James Zhou, Howard Meyer,
More informationHYDROGEN UNIT CHAPTER-4 UTILITY SYSTEM DESCRIPTIION
CHAPTER-4 UTILITY SYSTEM DESCRIPTIION The different utility systems provided in Hydrogen Generation Unit for its smooth operation are described in this chapter. They include 1. Service water 2. Cooling
More informationVERIFYING GAS CHROMATOGRAPH OPERATION AT CUSTODY TRANSFER LOCATIONS Murray Fraser Daniel Measurement & Control
VERIFYING GAS CHROMATOGRAPH OPERATION AT CUSTODY TRANSFER LOCATIONS Murray Fraser Daniel Measurement & Control Houston, Texas ABSTRACT The on-line gas chromatograph (GC) has been widely used for natural
More informationTraining Title IDENTIFY OPERATIONAL UPSETS, REVIEW & VALIDATE IN OIL & CHEMICAL PLANTS
Training Title IDENTIFY OPERATIONAL UPSETS, REVIEW & VALIDATE IN OIL & CHEMICAL PLANTS Training Duration 5 days Training Venue and Dates Identify Operational Upsets, Review & Validate in Oil & Chemical
More informationOverview. OPIPOH10 - SQA Unit Code HG Operate an Oil and Gas Process ( Gas Treatment)
OPIPOH10 - SQA Unit Code HG21 04 Overview This process involves the removal of impurities from the gas stream to reach the specified quality. The process boundary is from the inlet such as separator, compressor
More informationTreatment plants for gas production
5.4 Treatment plants for gas production 5.4.1 Introduction This chapter examines the treatments required for the transport and distribution of natural gas. It will discuss the main processes used to purify
More information