Revision Number: Issue date: 10/04/ PRODUCT AND COMPANY IDENTIFICATION 2. HAZARDS IDENTIFICATION

Transcription

1 Safety Data Sheet Revision Number: Issue date: 10/04/ PRODUCT AND COMPANY IDENTIFICATION Product type: Lubricant Item number: 40700_160072N Restriction of Use: identified Region: Canada Company address: Henkel Canada Corporation 2515 Meadowpine Boulevard Mississauga, Ontario L5N 6C3 Contact information: Telephone: (905) MEDICAL EMERGENCY Phone: Poison Control Center (toll free) or TRANSPORT EMERGENCY Phone: CHEMTREC (toll free) or Internet: 2. HAZARDS IDENTIFICATION DANGER: EMERGENCY OVERVIEW CAUSES SEVERE SKIN BURNS AND EYE DAMAGE. HAZARD CLASS HAZARD CATEGORY SKIN CORROSION 1C SERIOUS EYE DAMAGE 1 PICTOGRAM(S) Precautionary Statements Prevention: Response: Storage: Disposal: Do not breathe dust or fumes. Wash affected area thoroughly after handling. Wear protective gloves, clothing, eye and face protection. IF SWALLOWED: Rinse mouth. Do NOT induce vomiting. If on skin (or hair): Take off immediately all contaminated clothing. IF INHALED: Remove victim to fresh air and keep at rest in a position comfortable for breathing. Immediately call a POISON CENTER or physician. IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. Wash contaminated clothing before reuse. Store locked up. Dispose of contents and/or container according to Federal, State/Provincial and local governmental regulations. Classification complies with Canadian Hazardous Products Regulations (WHMIS 2015) and is consistent with the provision of the United Nations Globally Harmonized System of Classification and Labeling of Chemicals (GHS). See Section 11 for additional toxicological information. 3. COMPOSITION / INFORMATION ON INGREDIENTS Hazardous Component(s) CAS Number Weight %* heavy Page 1 of 5

2 Petroleum distillates, hydrotreated, light Graphite Calcium oxide Aluminum not powder, dust or fume Distillates (petroleum), straight-run middle * Exact percentages may vary or are trade secret. Concentration range is provided to assist users in providing appropriate protections. 4. FIRST AID MEASURES Inhalation: Skin contact: Move to fresh air. If not breathing, give artificial respiration. If breathing is difficult, give oxygen. Get medical attention. Remove contaminated clothing and footwear. Immediately flush skin with plenty of water (using soap, if available). Get medical attention. Wash clothing before reuse. Eye contact: Rinse immediately with plenty of water, also under the eyelids, for at least 15 minutes. Get medical attention. Ingestion: Do not induce vomiting. Never give anything by mouth to an unconscious person. Get medical attention. Symptoms: See Section FIRE FIGHTING MEASURES Extinguishing media: Special firefighting procedures: Unusual fire or explosion hazards: Hazardous combustion products: Foam, dry chemical or carbon dioxide. Wear self-contained breathing apparatus and full protective clothing, such as turn-out gear. In case of fire, keep containers cool with water spray. Oxides of carbon. Toxic and irritating vapors. 6. ACCIDENTAL RELEASE MEASURES Use personal protection recommended in Section 8, isolate the hazard area and deny entry to unnecessary and unprotected personnel. Environmental precautions: Clean-up methods: Do not allow product to enter sewer or waterways. Scrape up as much material as possible. Clean residue with soap and water. Store in a closed container until ready for disposal. 7. HANDLING AND STORAGE Handling: Storage: Use only with adequate ventilation. Prevent contact with eyes, skin and clothing. Do not breathe vapor and mist. Wash thoroughly after handling. Keep container closed. Keep in a cool, well ventilated area. Shelf Life Statement: 8. EXPOSURE CONTROLS / PERSONAL PROTECTION Employers should complete an assessment of all workplaces to determine the need for, and selection of, proper exposure controls and protective equipment for each task performed. Page 2 of 5

3 Hazardous Component(s) ACGIH TLV OSHA PEL AIHA WEEL OTHER heavy Petroleum distillates, hydrotreated, light Graphite Inhalable fraction. mist 10 mg/m3 STEL mist Inhalable fraction. 2 mg/m3 TWA mist 500 ppm (2,000 mg/m3) PEL 5 mg/m3 PEL Mist. 5 mg/m3 PEL Mist. 500 ppm (2,000 mg/m3) PEL 5 mg/m3 PEL 15 mg/m3 PEL 15 MPPCF TWA Calcium oxide 2 mg/m3 TWA 5 mg/m3 PEL Aluminum not powder, dust or fume 5 mg/m3 PEL (as Al) Respirable fraction. 15 MPPCF TWA 50 MPPCF TWA 1 mist Distillates (petroleum), straight-run middle 10 mg/m3 STEL mist mist Engineering controls: Respiratory protection: Eye/face protection: Skin protection: Provide adequate local exhaust ventilation to maintain worker exposure below exposure limits. Use NIOSH approved respirator if there is potential to exceed exposure limit(s). Safety goggles or safety glasses with side shields. Safety showers and eye wash stations should be available. Use impermeable gloves and protective clothing as necessary to prevent skin contact. Neoprene, Butyl-rubber, or nitrile-rubber gloves. 9. PHYSICAL AND CHEMICAL PROPERTIES Physical state: Solid Color: Silver Odor: Mild Odor threshold: ph: Not applicable Vapor pressure: Boiling point/range: Melting point/ range: Specific gravity: 1.10 Vapor density: Flash point: Product is a solid. Burn Rate: Approx 12 mm/2 minutes Flammable/Explosive limits - lower: Flammable/Explosive limits - upper: Autoignition temperature: Flammability: Not applicable Evaporation rate: Solubility in water: Insoluble Partition coefficient (n-octanol/water): VOC content: < 3 % Viscosity: Decomposition temperature: Page 3 of 5

4 10. STABILITY AND REACTIVITY Stability: Hazardous reactions: Hazardous decomposition products: Incompatible materials: Reactivity: Conditions to avoid: Stable under normal conditions of storage and use. under normal processing. Oxides of carbon. Irritating organic vapours. Oxidizing agents. Keep away from heat, spark and flame. 11. TOXICOLOGICAL INFORMATION Relevant routes of exposure: Skin, Inhalation, Eyes, Ingestion Potential Health Effects/Symptoms Inhalation: Skin contact: Eye contact: Ingestion: May cause respiratory tract irritation. This product is severely irritating to the skin and may cause burns. Causes serious eye damage. Not expected under normal conditions of use. May cause gastrointestinal tract irritation if swallowed. Hazardous Component(s) LD50s and LC50s Immediate and Delayed Health Effects Irritant heavy Petroleum distillates, hydrotreated, light Irritant Graphite Lung Calcium oxide Irritant, Corrosive, Eyes Aluminum not powder, dust or fume Central nervous system, Irritant, Lung Distillates (petroleum), straight-run middle Irritant Hazardous Component(s) NTP Carcinogen IARC Carcinogen OSHA Carcinogen (Specifically Regulated) heavy No No No Petroleum distillates, hydrotreated, light No No No Graphite No No No Calcium oxide No No No Aluminum not powder, dust or fume No No No Distillates (petroleum), straight-run middle No No No 12. ECOLOGICAL INFORMATION Ecological information: Page 4 of 5

5 13. DISPOSAL CONSIDERATIONS Information provided is for unused product only. Recommended method of disposal: Follow all local, state, federal and provincial regulations for disposal. 14. TRANSPORT INFORMATION The transport information provided in this section only applies to the material/formulation itself, and is not specific to any package/configuration. Canada Transportation of Dangerous Goods - Ground Not regulated Hazard class or division: Identification number: International Air Transportation (ICAO/IATA) Calcium oxide Hazard class or division: 8 Identification number: UN 1910 III Additional information: No dangerous good according to ADR/RID/ADN. Carriage in accordance with ADR/RID/ADN. Water Transportation (IMO/IMDG) Hazard class or division: Identification number: Not regulated 15. REGULATORY INFORMATION Canada Regulatory Information CEPA DSL/NDSL Status: All components are listed on or are exempt from listing on the Canadian Domestic Substances List. United States Regulatory Information TSCA 8 (b) Inventory Status: All components are listed or are exempt from listing on the Toxic Substances Control Act Inventory. 16. OTHER INFORMATION This safety data sheet contains changes from the previous version in sections: 3, 14 Prepared by: Product Safety and Regulatory Affairs Issue date: 10/04/2017 DISCLAIMER: The data contained herein are furnished for information only and are believed to be reliable. However, Henkel Corporation and its affiliates ( Henkel ) does not assume responsibility for any results obtained by persons over whose methods Henkel has no control. It is the user s responsibility to determine the suitability of Henkel s products or any production methods mentioned herein for a particular purpose, and to adopt such precautions as may be advisable for the protection of property and persons against any hazards that may be involved in the handling and use of any Henkel s products. In light of the foregoing, Henkel specifically disclaims all warranties, express or implied, including warranties of merchantability and fitness for a particular purpose, arising from sale or use of Henkel s products. Henkel further disclaims any liability for consequential or incidental damages of any kind, including lost profits. Page 5 of 5