Safety Data Sheet NDT Conditioner NP. 1. Identification

Transcription

1 1. Identification 1.1. Product identifier Product Identity Alternate Names 1.2. Relevant identified uses of the substance or mixture and uses advised against Intended use Application Method Liquid Water Conditioner See Technical Data Sheet Details of the supplier of the safety data sheet Company Name Gurtler Industries, Inc South LaSalle St. South Holland, IL US Emergency 24 hour Emergency Telephone No. (708) Customer Service: Gurtler Industries, Inc. INFOTRAC - (800) Hazard(s) identification 2.1. Classification of the substance or mixture Carc. 2;H351 Acute Tox. 4:H302 Eye Irrit. 2:H319 Skin Irrit. 2:H315 Suspected of causing cancer Harmful if swallowed Causes Serious eye irritation. Causes skin irritation 2.2. Label elements Using the Toxicity Data listed in section 11 and 12 the product is labeled as follows. Warning [Prevention]: P201 Obtain special instructions before use. P202 Do not handle until all safety precautions have been read and understood. P281 Use personal protective equipment as required. Page 1 of 8

2 [Response]: P IF exposed or concerned: Get medical advice / attention. [Storage]: P405 Store locked up. [Disposal]: P501 Dispose of contents / container in accordance with local / national regulations. 3. Composition/information on ingredients This product contains the following substances that present a hazard within the meaning of the relevant State and Federal Hazardous Substances regulations. Ingredient/Chemical Designations Weight % GHS Classification Notes Nitrilotriacetic acid trisodium salt CAS Number: Trisodium (hydroxyethyl)ethylenediamaine triacetate CAS Number: Carc. 2;H351 (@ > 5%) Acute tox. 4;H302 Eye Irrit. 2;H Eye Irrit. 2;H319 Carc. 2;H351 Skin Irrit. 2:H315 [1] [1] In accordance with paragraph (i) of , the specific chemical identity and/or exact percentage (concentration) of composition has been withheld as a trade secret. [1] Substance classified with a health or environmental hazard. [2] Substance with a workplace exposure limit. [3] PBT-substance or vpvb-substance. *The full texts of the phrases are shown in Section First aid measures 4.1. Description of first aid measures General Inhalation Eyes Skin Ingestion In all cases of doubt, or when symptoms persist, seek medical attention. Never give anything by mouth to an unconscious person. If symptoms develop move victim to fresh air. If symptoms persist, obtain medical attention. Flush with cool water. Remove contact lenses, if applicable, and continue flushing. Obtain medical attention if irritation persists. Flush with cool water. Wash with soap and water. Obtain medical attention if irritation persists. Do not induce vomiting. If vomiting occurs naturally, have victim lean forward to reduce risk of aspiration. Never give anything by mouth if victim is unconscious, or is convulsing. Obtain medical attention Most important symptoms and effects, both acute and delayed Overview Symptoms may include redness, edema, drying, defatting and cracking of the skin. Symptoms of overexposure may be headache, dizziness, tiredness, nausea and vomiting. If you feel unwell, seek medical advice (show the label where possible). Ensure that medical personnel are aware of the material(s) involved, and take precautions to protect themselves. Show this safety data sheet to the doctor in attendance. Avoid contact with eyes and skin. Keep out of reach of children. Page 2 of 8

3 Chronic effects: Prolonged or repeated exposure can cause drying, defatting and dermatitis. See section 2 for further details. 5. Fire-fighting measures 5.1. Extinguishing media Treat for surrounding material Special hazards arising from the substance or mixture Hazardous decomposition: May include but are not limited to: Oxides of Carbon 5.3. Advice for fire-fighters Firefighters should wear full protective clothing including self-contained breathing apparatus. ERG Guide No Accidental release measures 6.1. Personal precautions, protective equipment and emergency procedures Put on appropriate personal protective equipment (see section 8) Environmental precautions Do not allow spills to enter drains or waterways. Use good personal hygiene practices. Wash hands before eating, drinking, smoking or using toilet. Promptly remove soiled clothing and wash thoroughly before reuse Methods and material for containment and cleaning up Personal precautions: Keep unnecessary personnel away. Do not touch or walk through spilled material. Do not touch damaged containers or spilled material unless wearing appropriate protective space clothing. Keep people away from and upwind of spill/leak. Environmental precautions: Do not discharge into lakes, streams, ponds or public waters. Methods for containment: Stop leak if you can do so without risk. Prevent entry into waterways, sewers, basements or confined areas. Methods for cleaning up: Before attempting clean up, refer to hazard data given above. Small spills may be absorbed with non-reactive absorbent and placed in suitable, covered, labelled containers. Prevent large spills from entering sewers or waterways. Contact emergency services and supplier for advice. Never return spills to original containers for re-use. 7. Handling and storage 7.1. Precautions for safe handling Use good industrial hygiene practices in handling this material. When using do not eat or drink. Avoid contact with skin and clothing. Avoid contact with eyes. Page 3 of 8

4 Avoid breathing vapors or mists of this product. Keep container tightly closed. Use only with adequate ventilation. Wash thoroughly after handling. See section 2 for further details. - [Prevention]: 7.2. Conditions for safe storage, including any incompatibilities Handle containers carefully to prevent damage and spillage. Store in a closed container away from incompatible materials. Incompatible materials: Acids, oxidizers, reducing agents See section 2 for further details. - [Storage]: 7.3. Specific end use(s). 8. Exposure controls and personal protection 8.1. Control parameters Exposure CAS No. Ingredient Source Value Nitrilotriacetic acid trisodium salt OSHA Trisodium (hydroxyethyl)ethylenediamaine triacetate ACGIH NIOSH Supplier OSHA ACGIH NIOSH Supplier 8.2. Exposure controls Respiratory Eyes Skin Engineering Controls If workers are exposed to concentrations above the exposure limit they must use the appropriate, certified respirators. Protective safety glasses recommended Rubber gloves recommended. Provide adequate ventilation. Where reasonably practicable this should be achieved by the use of local exhaust ventilation and good general extraction. If these are not sufficient to maintain concentrations of particulates and any vapor below occupational exposure limits suitable respiratory protection must be worn. Other Work Practices See section 2 for further details. - [Prevention]: Use good personal hygiene practices. Wash hands before eating, drinking, smoking or using toilet. Promptly remove soiled clothing and wash thoroughly before reuse. 9. Physical and chemical properties Page 4 of 8

5 Appearance Odor Odor threshold Clear, Green Liquid Not measured ph 12.0 Melting point / freezing point Initial boiling point and boiling range Flash Point > 200 F/93.33 C (TCC) Evaporation rate (Ether = 1) Flammability (solid, gas) Not Applicable Upper/lower flammability or explosive limits Lower Explosive Limit: Vapor pressure (Pa) Vapor Density Upper Explosive Limit: Specific Gravity Solubility in Water Partition coefficient n-octanol/water (Log Kow) Auto-ignition temperature Decomposition temperature Viscosity (cst) 9.2. Other information No other relevant information. 10. Stability and reactivity Reactivity Corrodes metals in the presence of water or moisture Chemical stability Stable under normal circumstances Possibility of hazardous reactions Polymerization will not occur Conditions to avoid Avoid elevated temperatures Incompatible materials Avoid contact with oxidizers. Flammable hydrogen may be generated from contact with metals such as alumnimum Hazardous decomposition products Decomposition products depend upon temperature, air supply and the presence of other materials. 11. Toxicological information Page 5 of 8

6 Acute toxicity Ingredient Oral LD50, mg/kg Skin LD50, mg/kg Inhalation Vapor LC50, mg/l/4hr Inhalation Dust/Mist LC50, mg/l/4hr Inhalation Gas LC50, ppm Trisodium (hydroxyethyl)ethylenediamaine triacetate ( ) mg/kg (rat) Nitrilotriacetic acid trisodium salt - ( ) mg/kg (rat) >10,000 mg/kg (rabbit) >5mg/L (rat) Note: When no route specific LD50 data is for an acute toxin, the converted acute toxicity point estimate was used in the calculation of the product's ATE (Acute Toxicity Estimate). Classification Category Hazard Description Acute toxicity (oral) 4 Harmful if swallowed Acute toxicity (dermal) --- Not Applicable Acute toxicity (inhalation) --- Not Applicable Skin corrosion/irritation 2 Causes skin irritation Serious eye damage/irritation 2 Causes serious eye irritation Respiratory sensitization --- Not Applicable Skin sensitization --- Not Applicable Germ cell mutagenicity --- Not Applicable Carcinogenicity 2 Suspected of causing cancer Reproductive toxicity --- Not Applicable STOT-single exposure --- Not Applicable STOT-repeated exposure --- Not Applicable Aspiration hazard --- Not Applicable 12. Ecological information Toxicity No additional information provided for this product. See Section 3 for chemical specific data. Aquatic Ecotoxicity Ingredient Trisodium (hydroxyethyl)ethylenediamaine triacetate ( ) Nitrilotriacetic acid trisodium salt - ( ) 96 hr LC50 fish, mg/l 48 hr EC50 crustacea, mg/l ErC50 algae, mg/l 808 mg/l (bluegill sunfish) Not Available Not Available >100 mg/l (Pimephales promeas) Not Available Not Available Page 6 of 8

7 12.2. Persistence and degradability There is no data on the preparation itself Bioaccumulative potential Mobility in soil Results of PBT and vpvb assessment This product contains no PBT/vPvB chemicals Other adverse effects. 13. Disposal considerations Waste treatment methods Observe all federal, state and local regulations when disposing of this substance. 14. Transport information DOT (Domestic Surface Transportation) IMO / IMDG (Ocean Transportation) ICAO/IATA UN number Not Applicable Not Regulated Not Regulated UN proper shipping Not Regulated Not Regulated Not Regulated name Transport hazard DOT Hazard Class: Not IMDG: Not Applicable Air Class: Not Applicable class(es) Applicable Sub Class: Not Applicable Packing group Not Applicable Not Applicable Not Applicable Environmental hazards IMDG Marine Pollutant: No Special precautions for user No further information 15. Regulatory information Regulatory Overview Toxic Substance Control Act ( TSCA) US EPA Tier II Hazards The regulatory data in Section 15 is not intended to be all-inclusive, only selected regulations are represented. All components of this material are either listed or exempt from listing on the TSCA Inventory. Fire: No Sudden Release of Pressure: No Reactive: No Immediate (Acute): No Page 7 of 8

8 Delayed (Chronic): No EPCRA 311/312 Chemicals and RQs: EPCRA 302 Extremely Hazardous: EPCRA 313 Toxic Chemicals: Proposition 65 - Carcinogens (>0.0%): Nitrilotriacetic acid trisodium salt - ( ) Proposition 65 - Developmental Toxins (>0.0%): Proposition 65 - Female Repro Toxins (>0.0%): Proposition 65 - Male Repro Toxins (>0.0%): New Jersey RTK Substances (>1%) : Nitrilotriacetic acid trisodium salt - ( ) Pennsylvania RTK Substances (>1%) : Nitrilotriacetic acid trisodium salt - ( ) 16. Other information The information and recommendations contained herein are based upon data believed to be correct. However, no guarantee or warranty of any kind, expressed or implied, is made with respect to the information contained herein. We accept no responsibility and disclaim all liability for any harmful effects which may be caused by exposure to our products. Customers/users of this product must comply with all applicable health and safety laws, regulations, and orders. This is the first version in the GHS SDS format. Listings of changes from previous versions in other formats are not applicable. Information contained herein was obtained from sources considered technically accurate and reliable. While every effort has been made to ensure full disclosure of product hazards, in some cases data is not and is so stated. Since conditions of actual product use are beyond control of the supplier, it is assumed that users of this material have been fully trained according to the requirements of all applicable legislation and regulatory instruments. No warranty, expressed or implied, is made and supplier will not be liable for any losses, injuries or consequential damages which may result from the use of or reliance on any information contained in this document. End of Document Page 8 of 8