: Hardcore Blue Impression Compound

Transcription

1 Revision date:02/12/2013 Supersedes:01/27/2007 Version: SECTION 1: Identification of the substance/mixture and of the company/undertaking 1.1. Product identifier Product form Product name. Product code : Mixture : : HCB Relevant identified uses of the substance or mixture and uses advised against Use of the substance/preparation 1.3. Details of the supplier of the safety data sheet : Casting material SIRCHIE Finger Print Laboratories 100 Hunter Place Youngsville, NC - USA T ; F ; Emergency telephone number Emergency number : SECTION 2: Hazards identification 2.1. Classification of the substance or mixture Classification (GHS-US) Carc. 1A STOT RE 1 H350 H Label elements GHS-US labeling Hazard pictograms (GHS-US) : Signal word (GHS-US) Hazard statements (GHS-US) Precautionary statements (GHS-US) 2.3. Other hazards Other hazards not contributing to the classification 2.4. Unknown acute toxicity (GHS US) No data available : Danger GHS08 : H350 - May cause cancer H372 - Causes damage to organs through prolonged or repeated exposure : P201 - Obtain special instructions before use P202 - Do not handle until all safety precautions have been read and understood P260 - Do not breathe dust. P264 - Wash all exposed skin thoroughly after handling. P270 - Do no eat, drink or smoke when using this product P280 - Wear eye protection, protective gloves. P308+P313 - IF exposed or concerned: Get medical advice/attention P314 - Get medical advice and attention if you feel unwell. P405 - Store locked up P501 - Dispose of contents/container to local/regional/national/international regulations. P271 - Use only outdoors or in a well-ventilated area P301+P312 - If swallowed, call a doctor if you feel unwell. P302+P352 - IF ON SKIN: Wash with plenty of soap and water P305+P351+P338 - If in eyes: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. P332+P313 - If skin irritation occurs: Get medical advice/attention P337+P313 - If eye irritation persists: Get medical advice/attention : None under normal conditions. SECTION 3: Composition/information on ingredients 3.1. Substances 3.2. Mixtures 12/02/2013 EN (English US) 1/6

2 Name Product identifier % Classification (GHS-US) calcium sulfate (CAS No.) Not classified quartz, conc respirable crystalline silica>=10% (CAS No.) Carc. 1A, H350 STOT RE 1, H372 SECTION 4: First aid measures 4.1. Description of first aid measures First-aid measures general First-aid measures after inhalation First-aid measures after skin contact First-aid measures after eye contact First-aid measures after ingestion : Never give anything by mouth to an unconscious person. If you feel unwell, seek medical advice (show the label where possible). : Assure fresh air breathing. Allow the victim to rest. : Remove affected clothing and wash all exposed skin area with mild soap and water, followed by warm water rinse. : Rinse immediately with plenty of water. Obtain medical attention if pain, blinking or redness persist. : Rinse mouth. Do NOT induce vomiting. Obtain emergency medical attention Most important symptoms and effects, both acute and delayed Symptoms/injuries : Not expected to present a significant hazard under anticipated conditions of normal use Indication of any immediate medical attention and special treatment needed SECTION 5: Firefighting measures 5.1. Extinguishing media Suitable extinguishing media : Foam. Dry powder. Carbon dioxide. Water spray. Sand. Unsuitable extinguishing media : Do not use a heavy water stream Special hazards arising from the substance or mixture Reactivity : No reactivity hazard other than the effects described in sub-sections below Advice for firefighters Firefighting instructions Protection during firefighting : Use water spray or fog for cooling exposed containers. Exercise caution when fighting any chemical fire. Avoid (reject) fire-fighting water to enter environment. : Do not enter fire area without proper protective equipment, including respiratory protection. SECTION 6: Accidental release measures 6.1. Personal precautions, protective equipment and emergency procedures For non-emergency personnel Emergency procedures For emergency responders Protective equipment Emergency procedures : Evacuate unnecessary personnel. : Equip cleanup crew with proper protection. : Ventilate area Environmental precautions Prevent entry to sewers and public waters. Notify authorities if liquid enters sewers or public waters Methods and material for containment and cleaning up Methods for cleaning up 6.4. Reference to other sections See Heading 8. Exposure controls and personal protection. SECTION 7: Handling and storage 7.1. Precautions for safe handling Precautions for safe handling 7.2. Conditions for safe storage, including any incompatibilities Storage conditions Incompatible products Incompatible materials 7.3. Specific end use(s) : On land, sweep or shovel into suitable containers. Minimize generation of dust. Store away from other materials. : Wash hands and other exposed areas with mild soap and water before eat, drink or smoke and when leaving work. Provide good ventilation in process area to prevent formation of vapor. : Keep only in the original container in a cool, well ventilated place away from : Keep container closed when not in use. : Strong bases. strong acids. : Sources of ignition. Direct sunlight. 12/02/2013 EN (English US) 2/6

3 SECTION 8: Exposure controls/personal protection 8.1. Control parameters USA ACGIH ACGIH TWA (mg/m³) mg/m³ 8.2. Exposure controls Personal protective equipment : Avoid all unnecessary exposure. Dust formation: dust mask. Gloves. Safety glasses. Hand protection Eye protection Respiratory protection : Wear protective gloves. : Chemical goggles or safety glasses. : Wear approved mask. : When using, do not eat, drink or smoke. SECTION 9: Physical and chemical properties 9.1. Information on basic physical and chemical properties Physical state : Solid Appearance : Powders. Color : light brown. Odor : odorless. Odor threshold ph Relative evaporation rate (butyl acetate=1) Melting point Freezing point Boiling point Flash point Self ignition temperature Decomposition temperature Flammability (solid, gas) Vapor pressure Relative vapor density at 20 C Relative density Solubility : Miscible with water. Log Pow Log Kow Viscosity, kinematic Viscosity, dynamic Explosive properties Oxidizing properties Explosive limits 9.2. SECTION 10: Stability and reactivity Reactivity No reactivity hazard other than the effects described in sub-sections below Chemical stability Possibility of hazardous reactions Conditions to avoid Refer to Section 10 on Incompatible Materials. None under recommended storage and handling conditions (see section 7). 12/02/2013 EN (English US) 3/6

4 10.5. Incompatible materials strong acids. Strong bases Hazardous decomposition products fume. Carbon monoxide. Carbon dioxide. SECTION 11: Toxicological information Information on toxicological effects Acute toxicity Skin corrosion/irritation Serious eye damage/irritation Respiratory or skin sensitization Germ cell mutagenicity Carcinogenicity Based on available data, the classification criteria are not met : May cause cancer. IARC group 1 Reproductive toxicity Specific target organ toxicity (single exposure) Based on available data, the classification criteria are not met Specific target organ toxicity (repeated exposure) Aspiration hazard Potential Adverse human health effects and symptoms : Causes damage to organs through prolonged or repeated exposure.based on available data, the classification criteria are not met Based on available data, the classification criteria are not met : Based on available data, the classification criteria are not met. SECTION 12: Ecological information Toxicity Persistence and degradability Persistence and degradability Persistence and degradability Biodegradability: not applicable. Biochemical oxygen demand (BOD) Chemical oxygen demand (COD) ThOD BOD (% of ThOD) Bioaccumulative potential Bioaccumulative potential Log Pow Mobility in soil Other adverse effects : Avoid release to the environment. SECTION 13: Disposal considerations Waste treatment methods Waste disposal recommendations : Dispose in a safe manner in accordance with local/national regulations. Ecology - waste materials : Avoid release to the environment. SECTION 14: Transport information In accordance with ADR / RID / ADNR / IMDG / ICAO / IATA UN number 12/02/2013 EN (English US) 4/6

5 14.2. UN proper shipping name Additional information : No supplementary information available. Overland transport Transport by sea Air transport SECTION 15: Regulatory information US Federal regulations Listed on the United States TSCA (Toxic Substances Control Act) inventory International regulations CANADA EU-Regulations Classification according to Regulation (EC) No. 1272/2008 [CLP] Classification according to Directive 67/548/EEC or 1999/45/EC Not classified National regulations Listed on IARC (International Agency for Research on Cancer) US State regulations () U.S. - California - Proposition 65 - Carcinogens List Yes SECTION 16: Indication of changes : Revision - See : *. Data sources Training advice : REGULATION (EC) No 1272/2008 OF THE EUROPEAN PARLIAMENT AND OF THE COUNCIL of 16 December 2008 on classification, labeling and packaging of substances and mixtures, amending and repealing Directives 67/548/EEC and 1999/45/EC, and amending Regulation (EC) No 1907/2006. : Normal use of this product shall imply use in accordance with the instructions on the packaging. Keep in tightly closed container. Keep cool and dry. Avoid all ignition sources - heat, open flame, sparks. Avoid incompatible materials. Avoid dust creation and accumulation. Avoid inhalation and ingestion. Avoid contact with eyes. Wash thoroughly after handling. : None. Full text of H-phrases: see section 16: Carc. 1A Carcinogenicity Category 1A STOT RE 1 Specific target organ toxicity (repeated exposure) Category H350 May cause cancer H372 Causes damage to organs through prolonged or repeated exposure NFPA health hazard NFPA fire hazard : 1 - Exposure could cause irritation but only minor residual injury even if no treatment is given. : 0 - Materials that will not burn. 12/02/2013 EN (English US) 5/6

6 NFPA reactivity : 0 - Normally stable, even under fire exposure conditions, and are not reactive with water. HMIS III Rating Health Flammability Physical Personal Protection : 1 Slight Hazard - Irritation or minor reversible injury possible : 0 Minimal Hazard : 0 Minimal Hazard : E SDS US (GHS HazCom 2012) The information above is believed to be accurate and represents the best information currently available to us. However, we make no warranty of merchantability or any other warranty, expressed or implied, with respect to such information, and we assume no liability resulting from its use. Users should make their own investigation to determine the suitability of the information for their particular purposes. 12/02/2013 EN (English US) 6/6