SAFETY DATA SHEET. Hagmans Märkspray. Last changed: 05/03/2014 Replaces date: 24/06/2013 Internal No

Transcription

1 SECTION 1: Identification of the substance/mixture and of the company/undertaking 1.1. Product identifier Trade name Synonyms Hagmans Carosol Märkspray fluorescerande,hagmans Carosol Märkspray, Afmærkningsspray, Avmerkingsspray, Merkkaussuihke, Marking Spray, Farba do znakowania Relevant identified uses of the substance or mixture and uses advised against RECOMMENDED USES: Highlight color for road, construction, forestry, etc. Vendor Article No Details of the supplier of the safety data sheet NATIONAL MANUFACTURER/IMPORTER Enterprise Hagmans Kemi AB Address Box 112 Postal code Fritsla Country Sverige/Sweden/Ruotsi/Szwecja Internet Tel +46 (0) Fax +46 (0) SECTION 2: s identification 2.1. Classification of the substance or mixture DPD Classification: F+; R12, R18, R66, R67 CLP Classification: Flam. Aerosol 1;H222, Eye Irrit. 2;H319, Flam. Aerosol 1;H229 Most serious harmful effects:: Extremely flammable aerosol.causes serious eye irritation.pressurized container: may burst if heated 2.2. Label elements Signal word: Danger H-phrases H222 H319 H229 Extremely flammable aerosol. Causes serious eye irritation. Pressurized container: may burst if heated 1 / 9

2 P-phrases P102 Keep out of reach of children. P210 Keep away from heat/sparks/open flames/hot surfaces. - No smoking. P251 Pressurized container: Do not pierce or burn, even after use. P280 Wear protective gloves/eye protection. P305/351/338 IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. P337/313 If eye irritation persists: Get medical advice/attention. P410/412 Protect from sunlight. Do no expose to temperatures exceeding 50 C/122 F. P211 Do not spray on an open flame or other ignition source Other hazards Contains polyamide and fatty acid derivates. May produce an allergic reaction. SECTION 3: Composition/information on ingredients 3.2. Mixtures Ingredient name Reg. no. EC No. CAS No. Conc. (wt) n-butyl acetate acetone Dimetyleter DPD- Classification R10 - R66 - R67 Xi,F,R11 - R36 - R66 - R67 F+,R12 - R18 CLP-classification Flam. Liq. 3 H226 STOT SE 3 H336 EUH066 Flam. Liq. 2 H225 Eye Irrit. 2 H319 STOT SE 3 H336 EUH066 Flam. Gas 1 H220 Press. Gas comp. gas H280 Butan F+,R12 - R18 Flam. Gas 1 H220 Press. Gas comp. gas H280 Propan F+,R12 - R18 Flam. Gas 1 H220 Press. Gas comp. gas H280 Naphtha (petroleum), hydrotreated heavy Polyamide and fatty acid derivates Xn,R10 - R65 - R66 Flam. Liq. 3 H226 - R67 STOT SE 3 H336 Asp. Tox. 1 H304 EUH066 < 1 Xn,Xi,N,R22 - R36/38 - R43 - R48/22 - R50/53 Acute Tox. 4 H302 Skin Irrit. 2 H315 Eye Irrit. 2 H319 Skin Sens. 1 H317 STOT RE 2 H373 Aquatic Acute 1 H400 Aquatic Chronic 1 H410 Full text of R-, H- and EUH-phrases: see section 16. The EUH hazard statements mentioned in CLP-classification are only label elements. SECTION 4: First aid measures 4.1. Description of first aid measures INHALATION Fresh air. Get medical attention if any discomfort continues. 2 / 9

3 INGESTION Apart from intentional ingestion, swallowing of major quantities is improbable. Do not induce vomiting. Thoroughly rinse the mouth with water. Drink a few glasses of water or milk. Get medical attention if any discomfort continues. SKIN Remove contaminated clothing. Wash skin with soap and water. Get medical attention if any discomfort continues. EYES Rinse immediately with plenty of water. Hold eyelids apart. Get medical attention if any discomfort continues. GENERAL When obtaining medical advice, show the safety data sheet or label Most important symptoms and effects, both acute and delayed See section Indication of any immediate medical attention and special treatment needed See section: Description of first aid measures SECTION 5: Firefighting measures 5.1. Extinguishing media SUITABLE EXTINGUISHING MEDIA: Extinguish with powder, foam, carbon dioxide or water mist. UNSUITABLE EXTINGUISHING MEDIA Do not use a direct water jet that could spread the fire Special hazards arising from the substance or mixture Extremely flammable. Aerosols can explode when heated to temperatures over 50ºC. Smoking, open flames or other sources of ignition in the vicinity of the product are forbidden.forms explosive mixtures with air Advice for firefighters Use personal protective equipment. Use protective equipment and compressed air breathing apparatus. OTHER INFORMATION Containers close to fire should be removed immediately or cooled with water. SECTION 6: Accidental release measures 6.1. Personal precautions, protective equipment and emergency procedures PERSONAL PRECAUTIONS Ventilate well. See section 8 for type of protective equipment. Keep unnecessary people away, isolate hazard area and deny entry Environmental precautions Prevent discharges into the sewage system, watercourses or ground Methods and material for containment and cleaning up METHODS AND MATERIAL Bank with sand, earth or other inert absorption agent and collect. 3 / 9

4 6.4. Reference to other sections See Section 7 for information on safe handling. See Section 8 for information on personal protection equipment. See Section 13 for disposal information. SECTION 7: Handling and storage 7.1. Precautions for safe handling Smoking, open flames or other sources of ignition in the vicinity of the product are forbidden.see section 8 for type of protective equipment. Ventilate well. Pressurized container: protect from sunlight and do not expose to temperatures exceeding 50 C. Do not pierce or burn, even after use. Do not spray on a naked flame or any incandescent material Conditions for safe storage, including any incompatibilities Keep aerosol cans in a safe place and ensure that the valves do not leak.keep away from sources of ignition - No smoking. Keep in a cool, well-ventilated place. Store safely and keep out of reach of children Specific end use(s) See section 1.2 SECTION 8: Exposure controls/personal protection 8.1. Control parameters Occupational exposure limits Ingredient name CAS No. Range ppm mg/m3 Year Remarks acetone min acetone h n-butyl acetate min n-butyl acetate h Butan min Butan h Dimetyleter min Dimetyleter h R=Toxic for reproduction, H=Skin absorption, K=Carcinogenic, A=Sensitising, T=Upper limit, M=Mutagenic OTHER INFORMATION REGARDING LIMIT VALUES AND MONITORING Contains substances for which hygienic threshold values are stipulated Exposure controls APPROPRIATE ENGINEERING CONTROLS Good working hygiene must always be observed when handling product. Ventilate well. Wash your hands thoroughly after handling and before eating or smoking. Do not breathe gas/fumes/vapour/spray. EYE PROTECTION Wear safety goggles if there is a risk of eye splash. SKIN PROTECTION Protective clothing if necessary. HAND PROTECTION Use protective gloves that are resistant to chemicals. Protective gloves (butyl rubber, nitrile rubber). RESPIRATORY PROTECTION If ventilation is insufficient, suitable respiratory protection must be applied. Respirator with combined gas/particle filter (A/P2). 4 / 9

5 SECTION 9: Physical and chemical properties 9.1. Information on basic physical and chemical properties STATE Aerosol. COLOUR Varying colour. ODOUR Characteristic odour. SOLUBILITY Organic solvents. EXPLOSIVE PROPERTIES In use, may form flammable/explosive vapour-air mixture. SOLUBILITY IN WATER Insoluble in water. Parameter Value/unit Method/reference Observation ph (concentrate) ph (solution for use) Melting point Freezing point Initial boiling point and boiling range Flash point < 0 C Aerosol product 1) Evaporation rate Flammability (solid, gas) Flammability limits Explosion limits 1,2-18,6 Vapour pressure 3600 hpa 20 C Vapour density Relative density Partition coefficient Auto-ignition temperature Decomposition temperature Viscosity 9.2. Other information Parameter Value/unit Method/reference Observation Organic solvents: 90,2 with propellant gas Solids content: 9,8 Note no. Comments 1 Without propellant gas. SECTION 10: Stability and reactivity Reactivity Test data are not available Chemical stability Stable under recommended storage and handling conditions Possibility of hazardous reactions Reacts with acids, alkalis and oxidizing agents Conditions to avoid Pressurized container: protect from sunlight and do not expose to temperatures exceeding 50ºC. Do not pierce or burn, even after use. Do not spray on a naked flame or any incandescent material. 5 / 9

6 10.5. Incompatible materials Avoid contact with alkaline substances. Acids/ Oxidisers ous decomposition products None known if handled normally. SECTION 11: Toxicological information Information on toxicological effects Acute toxicity - oral Apart from intentional ingestion, swallowing of major quantities is improbable. May cause vomiting and stomach ache, and otherwise similar symptoms to those caused by inhalation. Irritating to skin. Acute toxicity - dermal Degreases and dries the skin. Repeated exposure may cause skin dryness or cracking. Acute toxicity - inhalation Vapours may cause drowsiness and dizziness. Inhalation may cause smarting in the nose and throat. Inhalation may give rise to symptoms such as headache, tiredness, dizziness, nausea. At high contents, the reactions and memory may be impaired. May have an irritating effect on the mucous membranes. Serious eye damage/eye irritation Causes serious eye irritation. Respiratory sensitisation or skin sensitisation Persons with a known allergy to polyamide and fatty acid derivates may exhibit an allergic response to the product. SECTION 12: Ecological information Toxicity ECOTOXICITY Ecotoxilogical information for the product is not available Persistence and degradability The principal constituents are expected to be biodegradable Bioaccumulative potential Bioaccumulation improbable Mobility in soil No information available Results of PBT and vpvb assessment The product does not contain any PBT or vpvb substances Other adverse effects 6 / 9

7 None known. SECTION 13: Disposal considerations Waste treatment methods GENERAL REGULATIONS Can be dumped as landfill or incinerated in accordance with local regulations. Aerosol cans which are not empty are classed as hazardous waste and sent for destruction in accordance with local regulations. Prevents major discharge into sewage systems, groundwater and surface water. CATEGORY OF WASTE EWC code is only a suggestion, final consumer selects a suitable EWC code Packing containing residues of or contaminated by dangerous substances. SECTION 14: Transport information Classified as Dangerous Goods: Yes Land transport (ADR/RID) UN UN proper shipping name Transport hazard class(es) label(s) identification Packing Aerosols Environmental hazards 2 5F Tunnel restriction code - D Inland water ways transport (ADN) UN UN proper shipping name Transport hazard class(es) label(s) Environmental hazard in tank vessels Packing Aerosols Environmental hazards 2 5F - 7 / 9

8 Sea transport (IMDG) UN UN proper shipping name Transport hazard class(es) label(s) Sub Risk: IMDG Code segregation Marine pollutant Substance name(s) on marine pollutant EMS: Packing Aerosols Environmental hazards A No F-D S-U - Air transport (ICAO-TI / IATA-DGR) UN UN proper shipping name Transport hazard class(es) label(s) Packing Aerosols TRANSPORT IN BULK ACCORDING TO ANNEX II OF MARPOL73/78 AND THE IBC CODE Not applicable. SECTION 15: Regulatory information Safety, health and environmental regulations/legislation specific for the substance or mixture Chemical safety assessment OTHER INFORMATION A Chemical Safety Assessment has not been carried out. SECTION 16: Other information ISSUED: 05/03/2014 VENDOR NOTES Information given in this safety data sheet is in accordance with our information on the last revision date. Changes have been done in section no: CLASSIFICATION METHOD Calculation based on the hazards of the known components. 8 / 9

9 LIST OF RELEVANT R-PHRASES R10 Flammable. R11 Highly flammable. R12 Extremely flammable. R18 In use, may form flammable/explosive vapour-air mixture. R22 Harmful if swallowed. R36 Irritating to eyes. R36/38 Irritating to eyes and skin. R43 May cause sensitisation by skin contact. R48/22 Harmful: danger of serious damage to health by prolonged exposure if swallowed. R50/53 Very toxic to aquatic organisms, may cause long-term adverse effects in the aquatic environment. R65 Harmful: may cause lung damage if swallowed. R66 Repeated exposure may cause skin dryness or cracking. R67 Vapours may cause drowsiness and dizziness. LIST OF RELEVANT H-STATEMENTS H220 Extremely flammable gas. H222 Extremely flammable aerosol. H225 Highly flammable liquid and vapour. H226 Flammable liquid and vapour. H280 Contains gas under pressure, may explode if heated. H302 Harmful if swallowed. H304 May be fatal if swallowed and enters airways. H315 Causes skin irritation. H317 May cause an allergic skin reaction. H319 Causes serious eye irritation. H336 May cause drowsiness or dizziness. H373 May cause damage to organs through prolonged or repeated exposure. H400 Very toxic to aquatic life. H410 Very toxic to aquatic life with long lasting effects. H229 Pressurized container: may burst if heated EUH066 Repeated exposure may cause skin dryness or cracking. 9 / 9