ZC SWEEPING COMPOUND 50 LB BAG Version 1.2 Revision Date 01/12/2017 Print Date 03/12/2018

Transcription

1 SECTION 1. PRODUCT AND COMPANY IDENTIFICATION Material name : Material number : HDSWEEP50 Manufacturer or supplier's details Company : Zep Inc. Address : 1310 Seaboard Industrial Blvd., NW Atlanta, GA Telephone : Emergency telephone numbers For SDS Information : Compliance Services For a Medical Emergency : Toll Free - All Calls Recorded For a Transportation Emergency : CHEMTREC: All Calls Recorded. In the District of Columbia Recommended use of the chemical and restrictions on use Recommended use : Floor Care Note: This product is labeled as a consumer product in accordance with the United States Consumer Product Safety Commission regulations. The warnings presented below in this Safety Data Sheet (SDS) comply with the 2012 OSHA Hazard Communication Standard (GHS - Globally Harmonized System of Classification and Labeling). The requirements for the labeling and warnings of consumer products may differ from those required for GHS based hazard communication. SECTION 2. HAZARDS IDENTIFICATION Emergency Overview Appearance Colour Odour solid pink odourless GHS Classification Specific target organ toxicity - repeated exposure GHS label elements Hazard pictograms : : Category 2 (Lungs) Signal word Hazard statements Precautionary statements : Warning : H373 May cause damage to organs (Lungs) through prolonged or repeated exposure. : Prevention: 1 / 9

2 P260 Do not breathe dust/ fume/ gas/ mist/ vapours/ spray. Response: P314 Get medical advice/ attention if you feel unwell. Disposal: Dispose of contents/container in accordance with local regulation. SECTION 3. COMPOSITION/INFORMATION ON INGREDIENTS Substance / Mixture : Mixture Hazardous components Chemical name CAS-No. Concentration [%] quartz (SiO2) >= 50 - < 70 Distillates (petroleum), hydrotreated middle >= 1 - < 5 SECTION 4. FIRST AID MEASURES General advice If inhaled In case of skin contact In case of eye contact If swallowed Most important symptoms and effects, both acute and delayed Notes to physician : Move out of dangerous area. Show this safety data sheet to the doctor in attendance. Do not leave the victim unattended. : If unconscious place in recovery position and seek medical advice. If symptoms persist, call a physician. : If skin irritation persists, call a physician. Wash off immediately with plenty of water. Remove contaminated clothing and shoes. Wash contaminated clothing before reuse. : If in eyes, rinse with water for 15 minutes. Remove contact lenses. Protect unharmed eye. Keep eye wide open while rinsing. If eye irritation persists, consult a specialist. : Keep respiratory tract clear. DO NOT induce vomiting unless directed to do so by a physician or poison control center. Never give anything by mouth to an unconscious person. If symptoms persist, call a physician. Take victim immediately to hospital. : Chronic effects are delayed and symptoms may not be observed during an exposure. Effects are dependent on exposure (dose, concentration, contact time). May cause damage to organs through prolonged or repeated exposure. Review section 2 of SDS to see all potential hazards. : Treat symptomatically. Symptoms may be delayed. 2 / 9

3 SECTION 5. FIREFIGHTING MEASURES Suitable extinguishing media Unsuitable extinguishing media Specific hazards during firefighting : Use water spray, alcohol-resistant foam, dry chemical or carbon dioxide. : High volume water jet : Do not allow run-off from fire fighting to enter drains or water courses. Hazardous combustion products Specific extinguishing methods Further information Special protective equipment for firefighters : Carbon dioxide (CO2) Carbon monoxide Smoke : Use extinguishing measures that are appropriate to local circumstances and the surrounding environment. : Standard procedure for chemical fires. : Wear self-contained breathing apparatus for firefighting if necessary. SECTION 6. ACCIDENTAL RELEASE MEASURES Personal precautions, protective equipment and emergency procedures Environmental precautions Methods and materials for containment and cleaning up : Use personal protective equipment. Avoid dust formation. Avoid breathing dust. : Prevent product from entering drains. Prevent further leakage or spillage if safe to do so. If the product contaminates rivers and lakes or drains inform respective authorities. : Keep in suitable, closed containers for disposal. SECTION 7. HANDLING AND STORAGE Advice on safe handling Conditions for safe storage : Avoid formation of respirable particles. Do not breathe vapours/dust. Avoid contact with skin and eyes. For personal protection see section 8. Smoking, eating and drinking should be prohibited in the application area. Dispose of rinse water in accordance with local and national regulations. : Keep container tightly closed in a dry and well-ventilated place. Electrical installations / working materials must comply with the technological safety standards. 3 / 9

4 Materials to avoid : No materials to be especially mentioned. SECTION 8. EXPOSURE CONTROLS/PERSONAL PROTECTION Components with workplace control parameters Engineering measures : effective ventilation in all processing areas Personal protective equipment Respiratory protection : Dust safety masks are recommended when the dust concentration is more than 10 mg/m3. Hand protection Remarks Eye protection Skin and body protection Hygiene measures : The suitability for a specific workplace should be discussed with the producers of the protective gloves. : Safety glasses : Choose body protection according to the amount and concentration of the dangerous substance at the work place. : When using do not eat or drink. When using do not smoke. Wash hands before breaks and at the end of workday. SECTION 9. PHYSICAL AND CHEMICAL PROPERTIES Appearance : solid Colour : pink Odour : odourless Odour Threshold : ph Melting point/freezing point Boiling point Flash point : Not applicable Evaporation rate Upper explosion limit Lower explosion limit Vapour pressure Relative vapour density : Density Solubility(ies) 4 / 9

5 Water solubility Solubility in other solvents Partition coefficient: n- octanol/water Auto-ignition temperature Thermal decomposition Viscosity Viscosity, kinematic : negligible : not determined : : not determined : : SECTION 10. STABILITY AND REACTIVITY Reactivity Chemical stability Possibility of hazardous reactions Conditions to avoid Incompatible materials Hazardous decomposition products : Stable : Stable under normal conditions. : No decomposition if stored and applied as directed. Dust may form explosive mixture in air. : Extremes of temperature and direct sunlight. : : Carbon oxides SECTION 11. TOXICOLOGICAL INFORMATION Potential Health Effects Aggravated Medical Condition Symptoms of Overexposure : None known. : Chronic effects are delayed and symptoms may not be observed during an exposure. Effects are dependent on exposure (dose, concentration, contact time). Carcinogenicity: IARC ACGIH OSHA No component of this product present at levels greater than or equal to 0.1% is identified as probable, possible or confirmed human carcinogen by IARC. No component of this product present at levels greater than or equal to 0.1% is identified as a carcinogen or potential carcinogen by ACGIH. No component of this product present at levels greater than or equal to 0.1% is identified as a carcinogen or potential 5 / 9

6 NTP Acute toxicity Acute oral toxicity carcinogen by OSHA. No component of this product present at levels greater than or equal to 0.1% is identified as a known or anticipated carcinogen by NTP. : Acute toxicity estimate : > 5,000 mg/kg Method: Calculation method Skin corrosion/irritation Serious eye damage/eye irritation Respiratory or skin sensitisation Germ cell mutagenicity Carcinogenicity Carcinogenicity - Assessment Reproductive toxicity quartz (SiO2): Distillates (petroleum), hydrotreated middle: STOT - single exposure STOT - repeated exposure Aspiration toxicity Further information Remarks: : Not classifiable as a human carcinogen. SECTION 12. ECOLOGICAL INFORMATION Ecotoxicity 6 / 9

7 Persistence and degradability Bioaccumulative potential Partition coefficient: n- octanol/water Mobility in soil Other adverse effects Regulation Remarks Additional ecological information : Remarks: 40 CFR Protection of Environment; Part 82 Protection of Stratospheric Ozone - CAA Section 602 Class I Substances This product neither contains, nor was manufactured with a Class I or Class II ODS as defined by the U.S. Clean Air Act Section 602 (40 CFR 82, Subpt. A, App.A + B). : SECTION 13. DISPOSAL CONSIDERATIONS Disposal methods Waste from residues Contaminated packaging : Do not dispose of waste into sewer. Do not contaminate ponds, waterways or ditches with chemical or used container. Dispose of in accordance with local regulations. : Empty remaining contents. Dispose of as unused product. Do not re-use empty containers. SECTION 14. TRANSPORT INFORMATION Transportation Regulation: 49 CFR (USA): Transportation Regulation: IMDG (Vessel): 7 / 9

8 Transportation Regulation: IATA (Cargo Air): Transportation Regulation: IATA (Passenger Air): Transportation Regulation: TDG (Canada): The product as delivered to the customer conforms to packaging requirements for shipment by road under US Department of Transportation (DOT) regulations. Additional transportation classifications noted above are for reference only, and not a certification or warranty of the suitability of the packaging for shipment under these alternative transport regulations. SECTION 15. REGULATORY INFORMATION EPCRA - Emergency Planning and Community Right-to-Know Act CERCLA Reportable Quantity This material does not contain any components with a CERCLA RQ. SARA 304 Extremely Hazardous Substances Reportable Quantity This material does not contain any components with a section 304 EHS RQ. SARA 311/312 Hazards : No SARA Hazards SARA 302 SARA 313 : No chemicals in this material are subject to the reporting requirements of SARA Title III, Section 302. : This material does not contain any chemical components with known CAS numbers that exceed the threshold (De Minimis) reporting levels established by SARA Title III, Section 313. California Prop 65 This product does not contain any chemicals known to State of California to cause cancer, birth defects, or any other reproductive harm. The components of this product are reported in the following inventories: TSCA DSL On TSCA Inventory All components of this product are on the Canadian DSL For information on the country notification status for other regions please contact the manufacturer s regulatory group. Inventory Acronym and Validity Area Legend: TSCA (USA), DSL (Canada), NDSL (Canada) 8 / 9

9 Health Instability SAFETY DATA SHEET SECTION 16. OTHER INFORMATION Further information NFPA: Flammability HMIS III: HEALTH FLAMMABILITY 1* 0 PHYSICAL HAZARD 0 Special hazard. 0 = not significant, 1 =Slight, 2 = Moderate, 3 = High 4 = Extreme, * = Chronic OSHA - GHS Label Information: Hazard pictograms : Signal w ord : Warning: Hazard statements : May cause damage to organs (Lungs) through prolonged or repeated exposure. Precautionary statements : Prevention: Do not breathe dust/ fume/ gas/ mist/ vapours/ spray. Response: Get medical advice/ attention if you feel unw ell. Disposal: Dispose of contents/container in accordance with local regulation. Version: 1.2 Revision Date: 01/12/2017 Print Date: 03/12/2018 We believe the statements, technical information and recommendations contained herein are reliable, but they are given without warranty or guarantee of any kind. The information in this document applies to this specific material as supplied. It may not be valid for this material if it is used in combination with any other materials. Users should make their own investigations to determine the suitability and applicability of the information for their particular purposes. This SDS has been prepared by the Compliance Services organization supporting this manufacturer, supplier or distributor. Zep Inc. markets products under well recognized and established brand names such as Zep, Zep Commercial,Zep Professional, Enforcer, National Chemical, Selig, Mis ty, Next Dimension, Petro, i-chem, TimeMist, TimeWick, MicrobeMax, Country Vet, Konk, Original Bike Spirits, Blue Coral, Black Magic, Rain-X, Niagara National, FC Forward Chemicals,Rexodan, Mykal, and a number of private labeled brands. 9 / 9