Safety Data Sheet CURAD FLEX SEAL BANDAGE

Transcription

1 Safety Data Sheet CURAD FLEX SEAL BANDAGE Section 1. Identification Product Identifier Synonyms Manufacturer Stock Numbers Recommended use Uses advised against Manufacturer Contact Address CURAD FLEX SEAL BANDAGE CUR76124RB ; MSD_SDS0016 CUR76124RB Medline Industries, Inc. One Medline Place Mundelein, IL, USA Phone Emergency Phone Fax (800) (800) (847) CHEMTREC Website Section 2. Hazards Identification Classification FLAMMABLE AEROSOLS - Category 1 Signal Word Danger Pictogram Hazard Statements Precautionary Statements Response Prevention Extremely flammable aerosol Do not spray on an open flame or other ignition source. Keep away from heat. Page 1 of 6

2 Storage Disposal Ingredients of unknown toxicity Pressurized container: Do not pierce or burn, even after use. Protect from sunlight. Do not expose to temperatures exceeding 50 ºC/122 ºF. 0% Hazards not Otherwise Classified May irritate eye. May cause skin irritation especially if exposure is prolonged and/or repeated. If ingested may cause some irritation to the mouth and upper digestive tract. Human: Prolonged inhalation of high concentrations of the aerosol and derived vapours may induce drowsiness, headache, loss of co-ordination and narcosis. In cases of severe over exposure, death may result. Inhalation of the aerosol may also cause slight irritation to the nose and upper respiratory tract. Ecological: Not completely biodegradable. Discharge of large quantities into the aquatic environment may kill fish and other aquatic organisms. Section 3. Ingredients CAS Ingredient Name Weight % Methane, oxybis- 25% - 50% Ethyl alcohol 50% - 75% Occupational exposure limits, if available, are listed in Section 8. Section 4. First-Aid Measures General Advice: Eye Contact Skin Contact: Inhalation: Ingestion Take proper precautions to ensure your own health and safety before attempting rescue and providing first aid. Consult a physician. Show this safety data sheet to the doctor in attendance. Move out of dangerous area. In cases of eye contact, wash out the eye thoroughly with plenty of clean water. Seek medical advice. In cases of skin contact, wash the skin with soap and water. In cases of inhalation, remove from exposure. Keep warm and at rest. If ingested, wash out the mouth with water. Do not induce vomiting. Seek medical advice. Section 5. Fire Fighting Measures Suitable Extinguishing Media In case of fire use powder, foam, sand, water spray. Avoid using large quantities of water. In case of fire, cool the stored aerosol cans with water spray. In case of fire, self contained breathing apparatus should be worn. Avoid using large quantities of water. Unsuitable Extinguishing Media Unusual Fire and Explosive Hazards: NFPA Aerosol Level: Flammability Rating 1, per NFPA 30B. Fumes containing carbon dioxide, carbon monoxide and oxides of nitrogen may be formed in large fires. Page 2 of 6

3 Section 6. Accidental Release Measures Contain and collect spillage. Extinguish any naked flames and remove any sources of ignition. Absorb on to sand/kieselguhr or other inert material. For spillages involving a large number of units, operators should wear suitable protective clothing such as gloves, overalls, and eye protection during the clearing up operation. May make floor very slippery. Do not wash into the drains. Place in plastic barrels for disposal. Do not mix with any other waste material. Dispose of in accordance with State and local authority regulations. Section 7. Handling and Storage Keep away from sources of ignition. Store the aerosol cans at between 5 and 50 C out of direct sunlight. Do not store close to strong oxidizing agents which could aggravate any fire situation. Use in a well ventilated area. Section 8. Exposure Controls/Personal Protection Occupational Exposure Limits Personal Protective Equipment Ingredient Name Methane, oxybis- Ethyl alcohol ACGIH TLV OSHA PEL STEL STEL: 1,000 ppm Note: Upper respiratory track irritation. Confirmed animal carcinogen with unknown relevance to humans. TWA: 1,000 ppm 1,900mg/mm3 29 CFR Table Z-1 Limits Avoid contact with eyes, skin, or clothes, do not inhale spray. Working procedures should be designed to minimize worker exposure to the product. Page 3 of 6

4 Section 9. Physical and Chemical Properties Physical State Color Aerosol Odor Odor Threshold Solubility Partition coefficient Water/n-octanol VOC% Viscosity Specific Gravity 1 Density lbs/gal Pounds per Cubic Foot Flash Point FP Method Ph Melting Point Boiling Point Boiling Range LEL UEL Evaporation Rate Flammability Decomposition Temperature Auto-ignition Temperature Vapor Pressure Vapor Density Section 10. Stability and Reactivity May react with strong oxidants. Decomposition can occur above 100 C after loss of any volatile components. Section 11. Toxicological Information Eye: Skin: Inhalation: Ingestion: May cause eye irritation. May produce skin irritation after prolonged contact. Prolonged inhalation of high concentrations of the aerosol and derived vapours may induce narcosis and death. Inhalation of the aerosol may induce slight irritation of the nose and throat. May cause some irritation of the mouth and upper digestive tract. Page 4 of 6

5 Section 12. Ecological Information Toxicity: Persistence and degradability: Bioaccumulative potential: Mobility in soil: Other adverse effects: Do not release into surface waters. Section 13. Disposal When disposing of waste or surplus material avoid contact with the eye and skin. Do not wash into the drains. Single units may be disposed of with other household refuse. For larger quantities seek advice from the local waste authority or seek advice from Medtrade Products Ltd. Section 14. Transport Information UN Number 1950 UN Proper Shipping Name Aerosols, flammable DOT Classification 2 Packing Group This product is classified as "Dangerous for Transport" but can be shipped under the Limited Quantities provision. It should be labelled - Aerosols UN 1950 IATA - UN Number: 1950 IATA - Hazard Class: 2.1 IATA - Proper Shipping Aerosols, flammable Name: Page 5 of 6

6 Section 15. Regulatory Information SARA 311/312: SARA 302: SARA 313: TSCA: CERCLA Hazardous Substance List: Clean Air Act (CAA) Section 112, 112 (r): New Jersey Right to Know Components: Massachusetts Right to Know Components: dimethyl ether ETHYL ALCOHOL. DIMETHYL ETHER. ETHYL ALCOHOL DIMETHYL ETHER. Pennsylvania Right to Know Components: Rhode Island Right to Know Components: ETHYL ALCOHOL METHANE, OXYBIS-. ETHYL ALCOHOL Dimethyl ether Section 16. Other Information Revision Date 12/8/2016 Legend - Not Applicable N.E. - Not Established - Not Determined HMIS (U.S.A.): Health 1 Hazard HMIS (U.S.A.): Flammability 3 HMIS (U.S.A.): Reactivity 1 National Fire Protection 1 Association (U.S.A): Health Hazard National Fire Protection 3 Association (U.S.A): Flammability National Fire Protection 1 Association (U.S.A): Instability Hazard Additional Information The information contained herein is furnished without warranty or legal responsibility of any kind. Employers should use this information only as a supplement to other information gathered by them and must make independent determination of suitability and completeness of information from all sources to assure proper use of these materials and the safety and health of employees Page 6 of 6