Issuing Date 13-Apr-2015 Revision Date 15-Mar-2017 Revision Number 1 1. IDENTIFICATION OF THE SUBSTANCE/PREPARATION AND THE COMPANY/UNDERTAKING

Transcription

1 SAFETY DATA SHEET Issuing Date 13-Apr-2015 Revision Number 1 1. IDENTIFICATION OF THE SUBSTANCE/PREPARATION AND THE COMPANY/UNDERTAKING GHS product identifier Product Name JET-LUBE TF-25 Other means of identification Product Code(s) 235 Synonyms TF-15 Recommended use of the chemical and restrictions on use Recommended Use Uses advised against Lubricants, Greases and Release Products, Sealant information available Supplier's details Manufacturer Address Jet-Lube, LLC 930 Whitmore Dr. Rockwall, Texas TEL: Toll Free: Emergency telephone number Emergency Telephone Number CHEMTREC: (INTERNATIONAL) (NORTH AMERICA) Classification 2. HAZARDS IDENTIFICATION This chemical is considered hazardous according to the OSHA Hazard Communication Standard 2012 (29 CFR ) Skin Sensitization Category 1 GHS Label elements, including precautionary statements Emergency Overview Signal Word Hazard Statements May cause an allergic skin reaction Warning Page 1 / 7

2 Appearance Black Physical State Semi-fluid (gel). Odor Petroleum Oil-Pungent Precautionary Statements Prevention Avoid breathing dust/fume/gas/mist/vapors/spray. Contaminated work clothing should not be allowed out of the workplace. Wear protective gloves. General Advice Specific treatment (see supplemental first aid instructions on this label) Skin IF ON SKIN: Wash with plenty of soap and water. If skin irritation or rash occurs: Get medical advice/attention. Wash contaminated clothing before reuse. Storage ne Disposal Dispose of contents/container to an approved waste disposal plant. Hazard t Otherwise Classified (HNOC) t applicable Other information 52.7% of the mixture consists of ingredient(s) of unknown toxicity. 3. COMPOSITION/INFORMATION ON INGREDIENTS Synonyms TF-15 Chemical Name CAS- Weight % Trade secret Graphite * Talc * Mica * 1,3,4-Thiadiazole, 2,5-bis(octyldithio) <1 * *The exact percentage (concentration) of composition has been withheld as a trade secret. 4. FIRST AID MEASURES Description of necessary first-aid measures Eye Contact Rinse thoroughly with plenty of water for at least 15 minutes and consult a physician. Skin Contact Inhalation Ingestion Wash skin with soap and water. Move to fresh air. Clean mouth with water and afterwards drink plenty of water. Do not induce vomiting without medical advice. Most important symptoms/effects, acute and delayed Most Important Symptoms/Effects Indication of immediate medical attention and special treatment needed, if necessary tes to Physician Treat symptomatically. Page 2 / 7

3 5. FIRE-FIGHTING MEASURES Suitable Extinguishing Media Water spray. Carbon dioxide (CO 2). Foam. Dry powder. Use extinguishing measures that are appropriate to local circumstances and the surrounding environment. Unsuitable Extinguishing Media Do not use a solid water stream as it may scatter and spread fire. Specific Hazards Arising from the Chemical Burning produces obnoxious and toxic fumes. Carbon monoxide, carbon dioxide and unburned hydrocarbons (smoke). Explosion Data Sensitivity to Mechanical Impact Sensitivity to Static Discharge ne. ne. Protective Equipment and Precautions for Firefighters As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH (approved or equivalent) and full protective gear. 6. ACCIDENTAL RELEASE MEASURES Personal precautions, protective equipment and emergency procedures Personal Precautions Use personal protective equipment. Environmental Precautions Environmental Precautions Prevent further leakage or spillage if safe to do so. Do not allow material to contaminate ground water system. Prevent product from entering drains. Local authorities should be advised if significant spillages cannot be contained. Methods and materials for containment and cleaning up Methods for Containment Methods for Cleaning Up Prevent further leakage or spillage if safe to do so. Dam up. Soak up with inert absorbent material. Pick up and transfer to properly labeled containers. 7. HANDLING AND STORAGE Precautions for safe handling Handling Wear personal protective equipment. Ensure adequate ventilation. Wash thoroughly after handling. Conditions for safe storage, including any incompatibilities Storage Incompatible Products Keep container tightly closed in a dry and well-ventilated place. Strong oxidizing agents. 8. EXPOSURE CONTROLS / PERSONAL PROTECTION Control parameters Exposure Guidelines Chemical Name ACGIH TLV OSHA PEL NIOSH IDLH Page 3 / 7

4 Graphite Talc Mica TWA: 15 mg/m 3 total dust synthetic TWA: 5 mg/m 3 total dust synthetic (vacated) TWA: 2.5 mg/m 3 respirable dust natural (vacated) TWA: 10 mg/m 3 total dust synthetic (vacated) TWA: 5 mg/m 3 respirable fraction synthetic TWA: 15 mppcf natural IDLH: 1250 mg/m 3 TWA: 2.5 mg/m 3 respirable dust TWA: 2 mg/m 3 (vacated) TWA: 2 mg/m 3 IDLH: 1000 mg/m 3 containg no asbestos and <1% quartz TWA: 2 mg/m 3 TWA: 3 mg/m 3 TWA: 20 mppcf (<1% crystalline silica) 3 mg/m 3 (vacated) IDLH: 1500 mg/m 3 containing <1% quartz TWA: 3 mg/m 3 respirable dust Immediately Dangerous to Life or Health. ACGIH TLV: American Conference of Governmental Industrial Hygienists - Threshold Limit Value. OSHA PEL: Occupational Safety and Health Administration - Permissible Exposure Limits. NIOSH IDLH: Other Exposure Guidelines Vacated limits revoked by the Court of Appeals decision in AFL-CIO v. OSHA, 965 F.2d 962 (11th Cir., 1992). Appropriate engineering controls Engineering Measures Ensure adequate ventilation, especially in confined areas. Individual protection measures, such as personal protective equipment Eye/Face Protection Skin and Body Protection Respiratory Protection Hygiene Measures Safety glasses with side-shields. Long sleeved clothing. Protective gloves. protective equipment is needed under normal use conditions. If exposure limits are exceeded or irritation is experienced, NIOSH/MSHA approved respiratory protection should be worn. When using, do not eat, drink or smoke. Remove and wash contaminated clothing before re-use. Information on basic physical and chemical properties 9. PHYSICAL AND CHEMICAL PROPERTIES Physical State Semi-fluid (gel) Appearance Black Odor Petroleum Oil-Pungent Odor Threshold information available Property Values Remarks/ - Method ph Neutral ne known Melting Point/Range 260 C / 500 F ne known Boiling Point/Boiling Range > 316 C / F ne known Flash Point > 221 C ne known Evaporation rate ne known Flammability (solid, gas) ne known Flammability Limits in Air upper flammability limit lower flammability limit Vapor Pressure ne known Vapor Density ne known Specific Gravity 1.23 ne known Water Solubility Negligible ne known Solubility in other solvents Largely. ne known Partition coefficient: n-octanol/water ne known Autoignition Temperature ne known Decomposition Temperature ne known Viscosity ne known Flammable Properties Page 4 / 7 t flammable

5 Explosive Properties Oxidizing Properties Other information VOC Content (%) Negligible 10. STABILITY AND REACTIVITY Reactivity. Chemical stability Stable under recommended storage conditions. Possibility of hazardous reactions ne under normal processing. Hazardous Polymerization Hazardous polymerization does not occur. Conditions to avoid Incompatible products. Incompatible materials Strong oxidizing agents. Hazardous decomposition products ne known based on information supplied. Information on likely routes of exposure 11. TOXICOLOGICAL INFORMATION Product Information Inhalation Eye Contact Skin Contact Ingestion ne known. ne known. May cause allergic skin reaction t an expected route of exposure. May be harmful if swallowed. Ingestion may cause gastrointestinal irritation, nausea, vomiting and diarrhea. Symptoms related to the physical, chemical and toxicological characteristics Symptoms Delayed and immediate effects and also chronic effects from short and long term exposure Sensitization Mutagenic Effects Carcinogenicity May cause sensitization of susceptible persons. May cause sensitization by skin contact. Contains no ingredients above reportable quantities listed as a carcinogen. Page 5 / 7

6 Reproductive Toxicity STOT - single exposure STOT - repeated exposure Aspiration Hazard Numerical measures of toxicity - Product Acute Toxicity 52.7% of the mixture consists of ingredient(s) of unknown toxicity. The following values are calculated based on chapter 3.1 of the GHS document: LD50 Oral 2295 mg/kg; Acute toxicity estimate 12. ECOLOGICAL INFORMATION Ecotoxicity The environmental impact of this product has not been fully investigated. Chemical Name Toxicity to Algae Toxicity to Fish Toxicity to Microorganisms Talc LC50 96 h: > 100 g/l semi-static (Brachydanio rerio) Daphnia Magna (Water Flea) Persistence and Degradability Bioaccumulation Other Adverse Effects 13. DISPOSAL CONSIDERATIONS Waste Disposal Methods This material, as supplied, is not a hazardous waste according to Federal regulations (40 CFR 261). This material could become a hazardous waste if it is mixed with or otherwise comes in contact with a hazardous waste, if chemical additions are made to this material, or if the material is processed or otherwise altered. Consult 40 CFR 261 to determine whether the altered material is a hazardous waste. Consult the appropriate state, regional, or local regulations for additional requirements. Contaminated Packaging Do not re-use empty containers. 14. TRANSPORT INFORMATION DOT ICAO IATA IMDG/IMO RID ADR International Inventories TSCA DSL Complies Complies 15. REGULATORY INFORMATION Legend TSCA - United States Toxic Substances Control Act Section 8(b) Inventory DSL/NDSL - Canadian Domestic Substances List/n-Domestic Substances List U.S. Federal Regulations Page 6 / 7

7 Section 313 of Title III of the Superfund Amendments and Reauthorization Act of 1986 (SARA). This product does not contain any chemicals which are subject to the reporting requirements of the Act and Title 40 of the Code of Federal Regulations, Part 372. SARA 311/312 Hazard Categories Acute Health Hazard Chronic Health Hazard Fire Hazard Sudden Release of Pressure Hazard Reactive Hazard Yes Clean Water Act This product does not contain any substances regulated as pollutants pursuant to the Clean Water Act (40 CFR and 40 CFR ). CERCLA This material, as supplied, does not contain any substances regulated as hazardous substances under the Comprehensive Environmental Response Compensation and Liability Act (CERCLA) (40 CFR 302) or the Superfund Amendments and Reauthorization Act (SARA) (40 CFR 355). There may be specific reporting requirements at the local, regional, or state level pertaining to releases of this material. U.S. State Regulations California Proposition 65 This product does not contain any Proposition 65 chemicals. U.S. State Right-to-Know Regulations "X" designates that the ingredients are listed on the state right to know list. Chemical Name New Jersey Massachusetts Pennsylvania Illinois Rhode Island Ptfe X X Graphite X X X X Talc X X X X Mica X X X X U.S. EPA Label Information EPA Pesticide Registration Number t applicable 16. OTHER INFORMATION NFPA Health Hazard 2 Flammability 1 Instability 0 Physical and Chemical Hazards - HMIS Health Hazard 2 Flammability 1 Physical Hazard 0 Personal Protection X Prepared By Issuing Date Revision Date Revision te Product Stewardship 23 British American Blvd. Latham, NY Apr Mar-2017 Updated company information.. General Disclaimer The information provided on this SDS is correct to the best of our knowledge, information and belief at the date of its publication. The information given is designed only as a guide for safe handling, use, processing, storage, transportation, disposal and release and is not to be considered as a warranty or quality specification. The information relates only to the specific material designated and may not be valid for such material used in combination with any other material or in any process, unless specified in the text. End of Safety Data Sheet Page 7 / 7