Safety Data Sheet Zinc Oxide Solution No.1 Revision date : 2015/05/06 Page: 1/11

Transcription

1 Revision date : 2015/05/06 Page: 1/11 1. Identification Product identifier used on the label Recommended use of the chemical and restriction on use Recommended use*: for industrial use only Suitable for use in industrial sector: chemical industry * The Recommended use identified for this product is provided solely to comply with a Federal requirement and is not part of the seller's published specification. The terms of this Safety Data Sheet (SDS) do not create or infer any warranty, express or implied, including by incorporation into or reference in the seller's sales agreement. Details of the supplier of the safety data sheet Company: BASF CORPORATION 100 Park Avenue Florham Park, NJ 07932, USA Telephone: Emergency telephone number CHEMTREC: BASF HOTLINE: HELP (4357) Other means of identification 2. Hazards Identification According to Regulation 2012 OSHA Hazard Communication Standard; 29 CFR Part Classification of the product Skin Corr./Irrit. 2 Skin corrosion/irritation Eye Dam./Irrit. 2A Serious eye damage/eye irritation STOT SE 3 (irritating to Specific target organ toxicity single exposure respiratory system) Aquatic Acute 2 Hazardous to the aquatic environment - acute Aquatic Chronic 2 Hazardous to the aquatic environment - chronic Label elements

2 Revision date : 2015/05/06 Page: 2/11 Pictogram: Signal Word: Warning Hazard Statement: H319 H315 H335 H401 H411 Causes serious eye irritation. Causes skin irritation. May cause respiratory irritation. Toxic to aquatic life. Toxic to aquatic life with long lasting effects. Precautionary Statements (Prevention): P280 Wear protective gloves and eye/face protection. P273 Avoid release to the environment. P271 Use only outdoors or in a well-ventilated area. P260 Do not breathe dust/gas/mist/vapours. P264 Wash with plenty of water and soap thoroughly after handling. Precautionary Statements (Response): P312 Call a POISON CENTER or doctor/physician if you feel unwell. P305 + P351 + P338 IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. P304 + P340 IF INHALED: Remove person to fresh air and keep comfortable for breathing. P303 + P352 IF ON SKIN (or hair): Wash with plenty of soap and water. P332 + P313 If skin irritation occurs: Get medical advice/attention. P391 Collect spillage. P337 + P311 If eye irritation persists: Call a POISON CENTER or doctor/physician. P362 + P364 Take off contaminated clothing and wash before reuse. Precautionary Statements (Storage): P403 + P233 Store in a well-ventilated place. Keep container tightly closed. P405 Store locked up. Precautionary Statements (Disposal): P501 Dispose of contents/container to hazardous or special waste collection point. Hazards not otherwise classified No specific dangers known, if the regulations/notes for storage and handling are considered. According to Regulation 1994 OSHA Hazard Communication Standard; 29 CFR Part Emergency overview DANGER: CAUSES EYE BURNS. Avoid contact with the skin, eyes and clothing. Avoid prolonged and/or repeated contact with the skin. Ensure adequate ventilation.

3 Revision date : 2015/05/06 Page: 3/11 3. Composition / Information on Ingredients According to Regulation 2012 OSHA Hazard Communication Standard; 29 CFR Part CAS Number Content (W/W) Chemical name >= < 20.0 % Zinc oxide >= < 10.0 % Ammonium hydroxide >= < 20.0 % Carbonic acid, ammonium salt According to Regulation 1994 OSHA Hazard Communication Standard; 29 CFR Part CAS Number Content (W/W) Chemical name > < 85.0 % Water > < 15.0 % Carbonic acid, ammonium salt > < 15.0 % Zinc oxide < 8.0 % Ammonium hydroxide 4. First-Aid Measures Description of first aid measures General advice: Immediately remove contaminated clothing. If inhaled: Remove the affected individual into fresh air and keep the person calm. Seek medical attention. If on skin: Wash affected areas thoroughly with soap and water. Seek medical attention. If in eyes: Immediately wash affected eyes for at least 15 minutes under running water with eyelids held open, consult an eye specialist. If swallowed: Immediately rinse mouth and then drink plenty of water, do not induce vomiting, seek medical attention. Never induce vomiting or give anything by mouth if the victim is unconscious or having convulsions. Most important symptoms and effects, both acute and delayed Symptoms: The most important known symptoms and effects are described in the labelling (see section 2) and/or in section 11., Further important symptoms and effects are so far not known. Indication of any immediate medical attention and special treatment needed Note to physician Treatment: Treat according to symptoms (decontamination, vital functions), no known specific antidote.

4 Revision date : 2015/05/06 Page: 4/11 5. Fire-Fighting Measures Extinguishing media Suitable extinguishing media: water spray, dry powder, foam Special hazards arising from the substance or mixture Hazards during fire-fighting: harmful vapours Evolution of fumes/fog. The substances/groups of substances mentioned can be released in case of fire. Advice for fire-fighters Protective equipment for fire-fighting: Firefighters should be equipped with self-contained breathing apparatus and turn-out gear. Further information: The degree of risk is governed by the burning substance and the fire conditions. Contaminated extinguishing water must be disposed of in accordance with official regulations. 6. Accidental release measures Personal precautions, protective equipment and emergency procedures Use personal protective clothing. Environmental precautions Do not discharge into drains/surface waters/groundwater. Methods and material for containment and cleaning up For small amounts: Pick up with absorbent material (e.g. sand, sawdust, general-purpose binder). Dispose of absorbed material in accordance with regulations. For large amounts: Pump off product. For residues: Pick up with absorbent material (e.g. sand, sawdust, general-purpose binder). Dispose of absorbed material in accordance with regulations. Spills should be contained, solidified, and placed in suitable containers for disposal. 7. Handling and Storage Precautions for safe handling No special measures necessary provided product is used correctly. Protection against fire and explosion: No special precautions necessary. Conditions for safe storage, including any incompatibilities Further information on storage conditions: Keep container tightly closed in a cool, well-ventilated place. Store protected against freezing. Protect from direct sunlight. Protect from temperatures below: -2 C

5 Revision date : 2015/05/06 Page: 5/11 8. Exposure Controls/Personal Protection Components with occupational exposure limits Zinc oxide OSHA PEL PEL 15 mg/m3 Total dust ; PEL 5 mg/m3 Respirable fraction ; PEL 5 mg/m3 fumes/smoke ; STEL value 10 mg/m3 fumes/smoke ; TWA value 10 mg/m3 Total dust ; TWA value 5 mg/m3 Respirable fraction ; TWA value 5 mg/m3 fumes/smoke ; ACGIH TLV TWA value 2 mg/m3 Respirable fraction ; STEL value 10 mg/m3 Respirable fraction ; Ammonium hydroxide OSHA PEL PEL 50 ppm 35 mg/m3 ; STEL value 35 ppm 27 mg/m3 ; ACGIH TLV TWA value 25 ppm ; STEL value 35 ppm ; Advice on system design: Ensure adequate ventilation. Personal protective equipment Respiratory protection: Wear respiratory protection if ventilation is inadequate. Respiratory protection in case of vapour/aerosol release. Wear a NIOSH-certified (or equivalent) organic vapour/particulate respirator. Observe OSHA regulations for respirator use (29 CFR ). Hand protection: Chemical resistant protective gloves Eye protection: Tightly fitting safety goggles (chemical goggles) and face shield. Body protection: Impermeable protective clothing General safety and hygiene measures: Handle in accordance with good industrial hygiene and safety practice. 9. Physical and Chemical Properties Form: liquid Odour: ammonia-like Odour threshold: Colour: colourless ph value: approx. 11 Freezing point: 0 C The product has not been tested., Information applies to the solvent. Boiling point: 100 C Information applies to the solvent. Flash point: No flash point - Measurement made up to the boiling point. Flammability: not flammable

6 Revision date : 2015/05/06 Page: 6/11 Lower explosion limit: Upper explosion limit: Autoignition: Vapour pressure: As a result of our experience with this product and our knowledge of its composition we do not expect any hazard as long as the product is used appropriately and in accordance with the intended use. As a result of our experience with this product and our knowledge of its composition we do not expect any hazard as long as the product is used appropriately and in accordance with the intended use. not applicable Density: g/cm3 ( 20 C) Relative density: 1.1 Vapour density: Self-ignition temperature: Based on the water content the product does not ignite. Thermal decomposition: Viscosity, dynamic: Particle size: Study does not need to be conducted. Solubility in water: dispersible Evaporation rate: Other Information: No data available. 10. Stability and Reactivity Reactivity No hazardous reactions if stored and handled as prescribed/indicated. Oxidizing properties: not fire-propagating Chemical stability The product is stable if stored and handled as prescribed/indicated. Possibility of hazardous reactions No hazardous reactions when stored and handled according to instructions. The product is chemically stable. Conditions to avoid Avoid freezing. Avoid extreme heat. Incompatible materials metal, oxidizing agents acids Hazardous decomposition products Decomposition products: Hazardous decomposition products: ammonia Hazardous decomposition products: No hazardous decomposition products if stored and handled as prescribed/indicated.

7 Revision date : 2015/05/06 Page: 7/11 Thermal decomposition: 11. Toxicological information Primary routes of exposure Routes of entry for solids and liquids are ingestion and inhalation, but may include eye or skin contact. Routes of entry for gases include inhalation and eye contact. Skin contact may be a route of entry for liquefied gases. Acute Toxicity/Effects Oral Type of value: LD50 Species: rat Value: > 5,000 mg/kg similar structure or composition. Inhalation Type of value: LC50 Species: rat Exposure time: 4 h Dermal Type of value: LD50 Species: rat Skin Species: rabbit Result: Irritant. Method: BASF-Test similar structure or composition. Eye Species: rabbit Result: Irritant. Method: BASF-Test similar structure or composition. Sensitization Guinea pig maximization test Species: guinea pig Result: Non-sensitizing. Method: OECD Guideline 406 The product has not been tested. The statement has been derived from the properties of the individual components. Aspiration Hazard No aspiration hazard expected. Chronic Toxicity/Effects

8 Revision date : 2015/05/06 Page: 8/11 Symptoms of Exposure The most important known symptoms and effects are described in the labelling (see section 2) and/or in section 11., Further important symptoms and effects are so far not known. 12. Ecological Information Toxicity Aquatic toxicity Assessment of aquatic toxicity: Acutely toxic for aquatic organisms. May cause long-term adverse effects in the aquatic environment. The product has not been tested. The statement has been derived from the properties of the individual components. Toxicity to fish LC50 (96 h) > 1-10 mg/l, Leuciscus idus similar structure or composition. Aquatic invertebrates No data available. Aquatic plants No data available. Chronic toxicity to fish No data available regarding toxicity to fish. Chronic toxicity to aquatic invertebrates No data available regarding toxicity to daphnids. Toxicity to fish Information on: Zinc oxide LC50 (96 h) mg/l, Oncorhynchus mykiss (static) similar structure or composition Aquatic invertebrates Information on: Zinc oxide EC50 (48 h) mg/l, Ceriodaphnia dubia similar structure or composition. The statement of the toxic effect relates to the analytically determined concentration Aquatic plants Information on: Zinc oxide EC50 (72 h) mg/l, Pseudokirchneriella subcapitata (OECD Guideline 201, static) The statement of the toxic effect relates to the analytically determined concentration.

9 Revision date : 2015/05/06 Page: 9/ Microorganisms/Effect on activated sludge Toxicity to microorganisms Bacteria: > 1-10 mg/l The product has not been tested. The statement has been derived from the properties of the individual components. Persistence and degradability Assessment biodegradation and elimination (H2O) The polymer component of the product is poorly biodegradable. Bioaccumulative potential Assessment bioaccumulation potential The product has not been tested. Bioaccumulation potential At the present state of knowledge, no negative ecological effects are expected. Mobility in soil Assessment transport between environmental compartments No data available. Additional information Add. remarks environm. fate & pathway: Treatment in biological waste water treatment plants has to be performed according to local and administrative regulations. Other ecotoxicological advice: Do not allow to enter soil, waterways or waste water channels. 13. Disposal considerations Waste disposal of substance: Dispose of in accordance with national, state and local regulations. It is the waste generator's responsibility to determine if a particular waste is hazardous under RCRA. Container disposal: Dispose of in a licensed facility. Recommend crushing, puncturing or other means to prevent unauthorized use of used containers. 14. Transport Information Land transport USDOT Not classified as a dangerous good under transport regulations Sea transport IMDG Hazard class: 9

10 Revision date : 2015/05/06 Page: 10/11 Packing group: III ID number: UN 3082 Hazard label: 9, EHSM Marine pollutant: YES Proper shipping name: ENVIRONMENTALLY HAZARDOUS SUBSTANCE, LIQUID, N.O.S. (contains ZINC OXIDE) Air transport IATA/ICAO Hazard class: 9 Packing group: III ID number: UN 3082 Hazard label: 9, EHSM Proper shipping name: ENVIRONMENTALLY HAZARDOUS SUBSTANCE, LIQUID, N.O.S. (contains ZINC OXIDE) 15. Regulatory Information Federal Regulations Registration status: Chemical TSCA, US released / listed EPCRA 311/312 (Hazard categories): Acute; CERCLA RQ CAS Number Chemical name 1000 LBS Ammonium hydroxide State regulations State RTK CAS Number Chemical name PA Carbonic acid, ammonium salt MA, NJ, PA Zinc oxide MA, NJ, PA Ammonium hydroxide NFPA Hazard codes: Health : 2 Fire: 0 Reactivity: 0 Special: HMIS III rating Health: 2 Flammability: 0 Physical hazard: Other Information SDS Prepared by: BASF NA Product Regulations SDS Prepared on: 2015/05/06 We support worldwide Responsible Care initiatives. We value the health and safety of our employees, customers, suppliers and neighbors, and the protection of the environment. Our commitment to Responsible Care is integral to conducting our business and operating our facilities in a safe and environmentally responsible fashion, supporting our customers and suppliers in ensuring the safe and environmentally sound handling of our products, and minimizing the impact of our

11 Revision date : 2015/05/06 Page: 11/11 operations on society and the environment during production, storage, transport, use and disposal of our products. IMPORTANT: WHILE THE DESCRIPTIONS, DESIGNS, DATA AND INFORMATION CONTAINED HEREIN ARE PRESENTED IN GOOD FAITH AND BELIEVED TO BE ACCURATE, IT IS PROVIDED FOR YOUR GUIDANCE ONLY. BECAUSE MANY FACTORS MAY AFFECT PROCESSING OR APPLICATION/USE, WE RECOMMEND THAT YOU MAKE TESTS TO DETERMINE THE SUITABILITY OF A PRODUCT FOR YOUR PARTICULAR PURPOSE PRIOR TO USE. NO WARRANTIES OF ANY KIND, EITHER EXPRESSED OR IMPLIED, INCLUDING WARRANTIES OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE, ARE MADE REGARDING PRODUCTS DESCRIBED OR DESIGNS, DATA OR INFORMATION SET FORTH, OR THAT THE PRODUCTS, DESIGNS, DATA OR INFORMATION MAY BE USED WITHOUT INFRINGING THE INTELLECTUAL PROPERTY RIGHTS OF OTHERS. IN NO CASE SHALL THE DESCRIPTIONS, INFORMATION, DATA OR DESIGNS PROVIDED BE CONSIDERED A PART OF OUR TERMS AND CONDITIONS OF SALE. FURTHER, YOU EXPRESSLY UNDERSTAND AND AGREE THAT THE DESCRIPTIONS, DESIGNS, DATA, AND INFORMATION FURNISHED BY OUR COMPANY HEREUNDER ARE GIVEN GRATIS AND WE ASSUME NO OBLIGATION OR LIABILITY FOR THE DESCRIPTION, DESIGNS, DATA AND INFORMATION GIVEN OR RESULTS OBTAINED, ALL SUCH BEING GIVEN AND ACCEPTED AT YOUR RISK. END OF DATA SHEET