MATERIAL SAFETY DATA SHEET Complies with OSHA Hazard Communication Standard 29 CFR

Transcription

1 Complies with OSHA Hazard Communication Standard 29 CFR Product Type: Product Name: Part Number(s): Flux Remover GC FLUX REMOVER 16 FL. OZ, VOC 75% A Emergency Contact: Chemtrec Phone: (800) Section 1 - Identification of Product COMMON NAME (used on label)(trade Name & Synonyms): GC FLUX REMOVER 16 FL. OZ. CAS. NUMBER: See Section 2 CHEMICAL NAME: Trichloroethylene & Isopropanol CHEMICAL FAMILY: N/A FORMULA: N/A HMIS RATINGS Minimal Hazard 0 Slight Hazard 1 Health: 2 Moderate Hazard 2 Flammability: 1 Serious Hazard 3 Reactivity: 0 Severe Hazard 4 Personal Protection: B Gloves, Safety Glasses B Section 2 - Hazardous Ingredients Principal Hazardous Component(s) VAPOR OSHA ACGIH PRESSURE CHEMICAL 25 DEG. C. FLASH COMMON NAME(S) CAS. # PEL TLV LEL UEL POINT DEG. F % BY WT. Isopropyl Alcohol ppm 400ppm 31 mmhg (TCC) N-Propyl Bromide Not Established 111mmHg None Hydrotreated Light n/a n/a 0.07mmHg (PMCC) 26 Distillate* **NOTE: This product contains an ingredient subject to Section 313 of SARA Title III. Warning: Contains Bromopropane (n-propyl bromide) which is known to the State of California to cause reproductive toxicity N/A is not available or not applicable Page 1 of 6

2 Section 3 - Physical Data BOILING POINT (Deg. F): Concentrate Range: SPECIFIC GRAVITY (Water = 1): Concentrate: 1.1 VAPOR PRESSURE (mmhg): See Section 2 PERCENT VOLATILE BY WEIGHT (%): 100% PERCENT VOLATILE ORGANIC COMPOUNDS: 75% VAPOR DENSITY (Air = 1): >1 EVAPORATION RATE (BA = 1): >1 SOLUBILITY IN WATER: Negligible REACTIVITY IN WATER: None APPEARANCE AND ODOR: CONCENTRATE: Clear liquid, irritating odor at high concentrations; Section 4 - Fire & Explosion Hazard Data FLASH POINT: See Section 2 FLAMMABLE LIMITS IN AIR - % BY VOLUME: See Section 2 EXTINGUISHER MEDIA: Water fog, dry chemical, carbon dioxide AUTO-IGNITION TEMPERATURE: Unknown SPECIAL FIRE FIGHTING PROCEDURES: Water may be used to cool closed containers to prevent pressure build-up and possible bursting when exposed to high temperatures. Firemen should wear selfcontained, positive pressure, respiratory equipment. UNUSUAL FIRE AND EXPLOSION HAZARDS: Although this mixture is classified as nonflammable, this product should not be used or stored near any open flames or ignition sources. Hazardous decomposition products. Page 2 of 6

3 SOLUBILITY IN WATER: Negligible REACTIVITY IN WATER: None APPEARANCE AND ODOR: CONCENTRATE: Clear liquid, irritating odor at high concentrations; Section 4 - Fire & Explosion Hazard Data FLASH POINT: See Section 2 FLAMMABLE LIMITS IN AIR - % BY VOLUME: See Section Morgan Street EXTINGUISHER MEDIA: Water fog, dry chemical, carbon dioxide Discontinued AUTO-IGNITION TEMPERATURE: Unknown Phone: (815) SPECIAL(815) FIRE FIGHTING PROCEDURES: Water may be used to cool closed containers to prevent Fax: pressure build-up and possible bursting when exposed to high temperatures. Firemen should wear self contained, positive pressure, respiratory equipment. UNUSUAL FIRE AND EXPLOSION HAZARDS: Although this mixture is classified as nonflammable, this MATERIAL SAFETY DATA SHEET product should not be used or stored near any open flames or ignition sources. Hazardous decomposition products. Section 5 - Health Hazard Data THRESHOLD LIMIT VALUE: See Section 2 SIGNS AND SYMPTOMS OF EXPOSURE: EYE CONTACT: Contact with liquid or mist may cause irritation. Vapors may irritate eyes; SKIN CONTACT: Prolonged contact may cause irritation, defatting of skin; INHALATION: Overexposure to vapor may cause dizziness, loss of concentration and irritation. With high exposure levels, effects can include central nervous system (CNS), depression (intoxication), cardiacgc arrhythmia, and death. GC/Waldom Electronics Product Name: FLUX REMOVER 1801 Morgan Street Product vapors displace air and can cause suffocation especially in Revision Date: 8/8/11 confined space. INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING AND INHALING THE CONTENTS OF THE CAN Product Information: (815) MAY BE HARMFUL OR FATAL; INGESTION: HARMFUL OR FATAL IF SWALLOWED. Aspiration may cause rapid absorption through the lungs, which may result in systemic effects. IMPORTANT NOTICE: REPEATED AND PROLONGED OVEREXPOSURE TO SOLVENTS MAY LEAD TO Page 2 of 5 PERMANENT BRAIN AND NERVOUS SYSTEM DAMAGE. EYE WATERING, HEADACHES, NAUSEA, DIZZINESS AND LOSS OF COORDINATION ARE SIGNS THAT SOLVENT LEVELS ARE TOO HIGH. INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING AND INHALING THE CONTENTS MAY BE HARMFUL OR FATAL. EMERGENCY AND FIRST AID PROCEDURES INHALATION: EYES: SKIN: INGESTION: Remove to fresh air. If not breathing, give mouth-to-mouth. If breathing is difficult, give oxygen. Do not give epinephrine or similar drugs. Call a physician. Flush with water for at least 15 minutes. Get medical assistance if irritation persists. Wash off in flowing water or shower. Remove contaminated clothing and wash before reuse. Do not induce vomiting. Call a physician immediately. Do not administer sympathomimetic drugs unless absolutely necessary. No specific antidote NOTE TO PHYSICIANS: BECAUSE OF POSSIBLE DISTURBANCES OF CARDIAC RHYTHM, CATECHOLAMINE DRUGS, SUCH AS EPINEPHRINE, SHOULD ONLY BE USED WITH SPECIAL CAUTION IN SITUATIONS OF EMERGENCY LIFE SUPPORT. NOTE TO PHYSICIAN: BECAUSE RAPID ABSORPTION Page 3 of 5 6 MAY OCCUR THROUGH LUNGS IF ASPIRATED AND CAUSE SYSTEMIC EFFECTS, THE DECISION OF WHETHER TO INDUCE VOMITING OR NOT

4 Section 5- Health Hazard Data (Continued) NOTE TO PHYSICIAN: BECAUSE RAPID ABSORPTION MAY OCCUR THROUGH LUNGS IF ASPIRATED AND CAUSE SYSTEMIC EFFECTS, THE DECISION OF WHETHER TO INDUCE VOMITING OR NOT SHOULD BE MADE BY AN ATTENDING PHYSICIAN. IF LAVAGE IS PERFORMED, SUGGEST ENDOTRACHEAL AND/OR ESOPHAGEAL CONTROL. DANGER FROM LUNG ASPIRATION MUST BE WEIGHED AGAINST TOXICITY WHEN CONSIDERING EMPTYING THE STOMACH. EXPOSURE MAY INCREASE "MYOCARDIAL IRRITABILITY". DO NOT ADMINISTER SYMPATHOMIMETIC DRUGS UNLESS ABSOLUTELY NECESSARY. NO SPECIFIC ANTIDOTE. SUPPORTIVE CASE. TREATMENT BASED ON JUDGMENT OF THE PHYSICIAN IN RESPONSE TO REACTIONS OF THE PATIENT. Section 6 - Reactivity Data STABILITY: Stable CONDITIONS TO AVOID: Avoid any excessive heat, ignition sources, open flames, or other high temperatures which induce thermal decomposition. Gross contamination with water may cause hydrolysis which will produce small amounts of hydrochloric acid. INCOMPATIBILITY (Materials to Avoid): Chemically Active Metals. Oxidizing agents. Sodium, Potassium, Calcium, etc. Alkali or alkaline earth metals. Powdered Aluminum, Zinc, Magnesium, Beryllium, etc. HAZARDOUS DECOMPOSITION PRODUCTS: N/A HAZARDOUS POLYMERIZATION: Will not occur. CONDITIONS TO AVOID: Not Applicable Section 7 - Spill or Leak Procedures STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED: SMALL SPILLS: Remove ignition sources. Mop up, wipe up, or soak up immediately. Use proper protective equipment. LARGE SPILLS: Evacuate area. Remove ignition sources. Contain liquid; transfer to closed containers; keep out of water supplies. WASTE DISPOSAL METHODS: Dispose in accordance with Federal, State, and Local regulations. Do not incinerate closed or empty containers. Page 4 of 6

5 Section 8 - Special Protection Information RESPIRATORY PROTECTION: NIOSH or Bureau of Mines approved organic vapor-type respirator is required in absence of proper environmental control. VENTILATION: LOCAL EXHAUST: To keep below TLV MECHANICAL (General): To keep below TLV SPECIAL: None OTHER: None PROTECTIVE GLOVES: Solvent resistant gloves - impervious gloves EYE PROTECTION: Safety glasses or goggles OTHER PROTECTIVE CLOTHING OR EQUIPMENT: None reasonably foreseeable. Section 9 Special Precautions PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE: OTHER PRECAUTIONS: Do not store above 120 Deg. F. Do not use or store near any open flames or ignition sources. Avoid repeated contact with skin. Vapors are heavier than air and will collect in low areas. Section 10 - Regulatory Information ALL CHEMICAL COMPONENTS ARE LISTED IN THE TSCA INVENTORY. CHEMICAL LISTED AS CARCINOGEN OR POTENTIAL CARCINOGEN: NATIONAL TOXICOLOGY PROGRAM: No. I.A.R.C. MONOGRAPHS: No OSHA: No. OSHA PERMISSIBLE EXPOSURE LIMIT: See Section 2 AGCIH THRESHOLD LIMIT VALUE: See Section 2 OTHER EXPOSURE LIMITED USED: None Page 5 of 6

6 Section 11 - Other Information TRANSPORTATION INFORMATION DOMESTIC GROUND Shipping Name: Consumer Commodity Hazard Class: ORM-D UN Number: N/A Packing Group: N/A Hazard Label: None Carton Marking: Consumer Commodity, ORM-D Disclaimer GC Electronics believes that the information contained herein is accurate and reliable as of the date of this material safety data sheet, but no representation guarantee or warranty, express or implied, is made as to the accuracy, reliability or completeness of the information. Persons receiving information are encouraged to make their own determination as to the information s suitability and completeness for their particular application. NO INFORMATION CONTAINED HEREIN CONSTITUTES A PRODUCT WARRANTY OF ANY KIND, WHETHER EXPRESS OR IMPLIED; AND ALL IMPLIED WARRANTIES OF MERCHANT ABILITY AND OF FITNESS FOR A PARTICULAR PURPOSE ARE HEREBY DISCLAIMED BY GC ELECTRONICS. Page 6 of 6