Safety data sheet according to 1907/2006/EC, Article 31

Transcription

1 Page 1/5 * 1 Identification of the substance/mixture and of the company/undertaking Product identifier Relevant identified uses of the substance or mixture and uses advised against Application of the substance / the preparation Ink for office use Details of the supplier of the safety data sheet Manufacturer/Supplier: Trodat GmbH Linzer Strasse Wels, Austria phone: +43 (0) 7242/239-0 fax: +43 (0) 7242/ Further information obtainable from: Innovation Center: +43 (0) 7242/ trodat@trodat.net Emergency telephone number: Poison Information Centre: Hazards identification Classification of the substance or mixture Classification according to Regulation (EC) No 1272/2008 The product is not classified according to the CLP regulation. Classification according to Directive 67/548/EEC or Directive 1999/45/EC Not applicable. Information concerning particular hazards for human and environment: The product does not have to be labelled due to the calculation procedure of the "General Classification guideline for preparations of the EU" in the latest valid version. Classification system: The classification is according to the latest editions of the EU-lists, and extended by company and literature data. Label elements Labelling according to Regulation (EC) No 1272/2008 Void Hazard pictograms Void Signal word Void Hazard statements Void Other hazards Results of PBT and vpvb assessment PBT: Not applicable. vpvb: Not applicable. * 3 Composition/information on ingredients Chemical characterization: Mixtures Description: Mixture of substances listed below with nonhazardous additions. Dangerous components: CAS: EINECS: glycerol substance with a Community workplace exposure limit <50.0% Additional information: For the wording of the listed risk phrases refer to section 16. * 4 First aid measures Description of first aid measures General information: No special measures required. After inhalation: Supply fresh air; consult doctor in case of complaints. After skin contact: Generally the product does not irritate the skin. (Contd. on page 2)

2 Page 2/5 (Contd. of page 1) After eye contact: Rinse opened eye for several minutes under running water. After swallowing: If symptoms persist consult doctor. Information for doctor: Most important symptoms and effects, both acute and delayed No further relevant information available. Indication of any immediate medical attention and special treatment needed No further relevant information available. * 5 Firefighting measures Extinguishing media Suitable extinguishing agents: Use fire extinguishing methods suitable to surrounding conditions. Special hazards arising from the substance or mixture No further relevant information available. Advice for firefighters Protective equipment: Wear self-contained respiratory protective device. * 6 Accidental release measures Personal precautions, protective equipment and emergency procedures Not required. Environmental precautions: Dilute with plenty of water. Do not allow to enter sewers/ surface or ground water. Methods and material for containment and cleaning up: Absorb with liquid-binding material (sand, diatomite, acid binders, universal binders, sawdust). Reference to other sections No dangerous substances are released. See Section 7 for information on safe handling. See Section 8 for information on personal protection equipment. See Section 13 for disposal information. * 7 Handling and storage Handling: Precautions for safe handling No special measures required. Information about fire - and explosion protection: No special measures required. Conditions for safe storage, including any incompatibilities Storage: Requirements to be met by storerooms and receptacles: No special requirements. Information about storage in one common storage facility: Not required. Further information about storage conditions: None. Specific end use(s) No further relevant information available. * 8 Exposure controls/personal protection Additional information about design of technical facilities: No further data; see item 7. Control parameters Ingredients with limit values that require monitoring at the workplace: glycerol WEL Long-term value: 10 mg/m³ Additional information: The lists valid during the making were used as basis. (Contd. on page 3)

3 Page 3/5 (Contd. of page 2) Exposure controls Personal protective equipment: General protective and hygienic measures: The usual precautionary measures are to be adhered to when handling chemicals. Respiratory protection: Not required. Protection of hands: The glove material has to be impermeable and resistant to the product/ the substance/ the preparation. Due to missing tests no recommendation to the glove material can be given for the product/ the preparation/ the chemical mixture. Selection of the glove material on consideration of the penetration times, rates of diffusion and the degradation Material of gloves The selection of the suitable gloves does not only depend on the material, but also on further marks of quality and varies from manufacturer to manufacturer. As the product is a preparation of several substances, the resistance of the glove material can not be calculated in advance and has therefore to be checked prior to the application. Penetration time of glove material The exact break through time has to be found out by the manufacturer of the protective gloves and has to be observed. Eye protection: Goggles recommended during refilling * 9 Physical and chemical properties Information on basic physical and chemical properties General Information Appearance: Form: Fluid Colour: Different according to colouring Odour: Characteristic Odour threshold: Not determined. ph-value: Not determined. Change in condition Melting point/melting range: Boiling point/boiling range: Undetermined. Undetermined. Flash point: > 100 C Flammability (solid, gaseous): Not applicable. Ignition temperature: 400 C Decomposition temperature: Not determined. Self-igniting: Product is not selfigniting. Danger of explosion: Product does not present an explosion hazard. Explosion limits: Lower: 0.9 Vol % Upper: Not determined. Vapour pressure at 20 C: 0.1 hpa Density at 20 C: 1.14 g/cm³ Relative density Not determined. Vapour density Not determined. Evaporation rate Not determined. (Contd. on page 4)

4 Page 4/5 Solubility in / Miscibility with water: Fully miscible. Segregation coefficient (n-octanol/water): Not determined. Viscosity: Dynamic at 20 C: 24 mpas Kinematic: Not determined. Other information No further relevant information available. (Contd. of page 3) * 10 Stability and reactivity Reactivity Chemical stability Thermal decomposition / conditions to be avoided: No decomposition if used according to specifications. Possibility of hazardous reactions No dangerous reactions known. Conditions to avoid No further relevant information available. Incompatible materials: No further relevant information available. Hazardous decomposition products: No dangerous decomposition products known. 11 Toxicological information Information on toxicological effects Acute toxicity: Primary irritant effect: on the skin: No irritant effect. on the eye: No irritating effect. Sensitization: No sensitizing effects known. Additional toxicological information: The product is not subject to classification according to the calculation method of the General EU Classification Guidelines for Preparations as issued in the latest version. When used and handled according to specifications, the product does not have any harmful effects to our experience and the information provided to us. * 12 Ecological information Toxicity Acquatic toxicity: No further relevant information available. Persistence and degradability No further relevant information available. Behaviour in environmental systems: Bioaccumulative potential No further relevant information available. Mobility in soil No further relevant information available. Additional ecological information: General notes: Water hazard class 1 (German Regulation) (Self-assessment): slightly hazardous for water Do not allow undiluted product or large quantities of it to reach ground water, water course or sewage system. Results of PBT and vpvb assessment PBT: Not applicable. vpvb: Not applicable. Other adverse effects No further relevant information available. (Contd. on page 5)

5 Page 5/5 (Contd. of page 4) * 13 Disposal considerations Waste treatment methods Recommendation Smaller quantities can be disposed of with household waste. Uncleaned packaging: Recommendation: Disposal must be made according to official regulations. Recommended cleansing agents: Water, if necessary together with cleansing agents. * 14 Transport information UN-Number ADR, ADN, IMDG, IATA Void UN proper shipping name ADR, ADN Void Transport hazard class(es) ADR, ADN, IMDG, IATA Class Void Packing group ADR, IMDG, IATA Void Environmental hazards: Marine pollutant: No Special precautions for user Not applicable. Transport in bulk according to Annex II of MARPOL73/78 and the IBC Code UN "Model Regulation": - Not applicable. * 15 Regulatory information Chemical safety assessment: A Chemical Safety Assessment has not been carried out. 16 Other information This information is based on our present knowledge. However, this shall not constitute a guarantee for any specific product features and shall not establish a legally valid contractual relationship. Department issuing MSDS: Trodat Gmbh; Innovation Center Contact: +43 (0) 7242/ Abbreviations and acronyms: ADR: Accord européen sur le transport des marchandises dangereuses par Route (European Agreement concerning the International Carriage of Dangerous Goods by Road) RID: Règlement international concernant le transport des marchandises dangereuses par chemin de fer (Regulations Concerning the International Transport of Dangerous Goods by Rail) IMDG: International Maritime Code for Dangerous Goods IATA: International Air Transport Association ICAO: International Civil Aviation Organization GHS: Globally Harmonized System of Classification and Labelling of Chemicals VOC: Volatile Organic Compounds (USA, EU) * Data compared to the previous version altered.