3. Composition/Information on Ingredients. 4. First Aid Measures

Transcription

1

2 Potential Health Effects (Acute and Chronic): Inhalation: Skin Contact: Eye Contact: Ingestion: Hazards not otherwise classified (HNOC) or not covered by GHS. None. Low hazard for normal industrial handling. May be harmful if inhaled. May cause respiratory tract irritation. May cause sneezing. Exposure may cause irritation characterized by redness, dryness, and inflammation. May be harmful if absorbed through the skin. May cause skin sensitization, an allergic reaction, which becomes evident upon re-exposure to this material. Low hazard for usual industrial handling. May cause eye irritation. Dust may cause mechanical irritation. May cause irritation of the digestive tract. Low hazard for usual industrial handling. May be harmful if swallowed. Ingestion of large amounts may cause gastrointestinal irritation. Expected to be a low ingestion hazard. 3. Composition/Information on Ingredients CAS # Hazardous Components (Chemical Name) Distillates (petroleum), Hydrotreated heavy paraffinic Concentration % Diamond <25.0 % Technical white oil* (regulated as mist only) % Silica, amorphous treated <10.0 % Lecithins, soya % Poly[oxy(methyl-1,2-ethanediyl)],.alpha.-butyl-.omega.-hydr Resin acids and rosin acids, hydrogenated, methyl esters % % NA Natural Wax % Emergency and First Aid Procedures: In Case of Inhalation: In Case of Skin Contact: In Case of Eye Contact: In Case of Ingestion: Signs and Symptoms Of Exposure: Note to Physician: 4. First Aid Measures If breathed in, move person into fresh air. Remove from exposure and move to fresh air immediately. If breathing is difficult, give oxygen. Wash off with soap and plenty of water. Flush skin with plenty of water for at least 15 minutes while removing contaminated clothing and shoes. Get medical aid if irritation develops or persists. Wash clothing before reuse. Get medical aid. Flush eyes with plenty of water for at least 15 minutes, occasionally lifting the upper and lower eyelids. Do NOT allow victim to rub eyes or keep eyes closed. If irritation develo ps, get medical aid. Get medical aid. Never give anything by mouth to an unconscious person. If conscious and alert, rinse mouth and drink 2-4 cupfuls of milk or water. Get medical aid if irritation or symptoms occur. If victim is conscious and alert, give 2-4 cupfuls of milk or water. Wash mouth out with water. The most important known symptoms and effects are described in the labelling (see section 2.2) and/or in section 11 To the best of our knowledge, the chemical, physical, and toxicological properties have not been thoroughly investigated. Treat symptomatically and supportively.

3 5. Fire Fighting Measures Flash Pt: Method Used: Estimate Explosive Limits: LEL: UEL: Autoignition Pt: Suitable Extinguishing Media: Use water spray, dry chemical, carbon dioxide, or alcohol-resistant foam. Substance is noncombustible; use agent most appropriate to extinguish surrounding fire. Use agent most appropriate to extinguish fire. Fire Fighting Instructions: Flammable Properties and Hazards: Protective Precautions, Protective Equipment and Emergency Procedures: Environmental Precautions: Steps To Be Taken In Case Material Is Released Or Spilled: Precautions To Be Taken in Handling: Precautions To Be Taken in Storing: Wear self contained breathing apparatus for fire fighting if necessary. Further information: As in any fire, wear a self-contained breathing apparatus in pressure-demand, MSHA/NIOSH (approved or equivalent), and full protective gear. During a fire, irritating and highly toxic gases may be generated by thermal decomposition or combustion. Use extinguishing media appropriate to surrounding fire conditions. Carbon oxides. 6. Accidental Release Measures Avoid breathing vapors, mist or gas. For personal protection see section 8. Do not let product enter drains. Keep in suitable, closed containers for disposal. Use proper personal protective equipment as indicated in Section 8. Spills/Leaks: Vacuum or sweep up material and place into a suitable disposal container. Clean up spills immediately, observing precautions in the Protective Equipment section. Avoid generating dusty conditions. Provide ventilation. Personal precautions. Avoid breathing vapors, mist or gas. Environmental precautions. Do not let product enter drains. Methods for cleaning up. 7. Handling and Storage For precautions see section 2. Wash thoroughly after handling. Wash hands before eating. Use with adequate ventilation. Minimize dust generation and accumulation. Avoid contact with eyes, skin, and clothing. Keep container tightly closed. Avoid ingestion and inhalation. Normal measures for preventive fire protection. Avoid contact with skin and eyes. Avoid breathing dust, mist, or vapor. Keep container tightly closed in a dry and well-ventilated place. Store in a tightly closed container. Store in a cool, dry, well-ventilated area away from incompatible substances. No special precautions indicated. Store in a cool, dry place. 8. Exposure Controls/Personal Protection CAS # Partial Chemical Name OSHA TWA ACGIH TWA Other Limits Distillates (petroleum), Hydrotreated heavy paraffinic Diamond Technical white oil* (regulated as mist only) Silica, amorphous treated

4 Lecithins, soya Poly[oxy(methyl-1,2-ethanediyl)],.alpha.-butyl-.omega.-hydr Resin acids and rosin acids, hydrogenated, methyl esters NA Natural Wax Respiratory Equipment (Specify Type): Eye Protection: Protective Gloves: Other Protective Clothing: Engineering Controls (Ventilation etc.): Work/Hygienic/Maintenance Practices: Environmental Exposure Controls: is not required. For nuisance exposures use type OV/AG (US) or type ABEK (EU EN 14387) respirator cartridges. Use respirators and components tested and approved under appropriate government standards such as NIOSH (US) or CEN (EU). Use a NIOSH/MSHA or European Standard EN 149 approved respirator if exposure limits are exceeded or if irritation or other symptoms are experienced. Use equipment for eye protection tested and approved under appropriate government standards such as NIOSH (US) or EN 166(EU). Wear appropriate protective eyeglasses or chemical safety goggles as described by OSHA's eye and face protection regulations in 29 CFR or European Standard EN166. Safety glasses. Not available. Handle with gloves. Use proper glove removal technique (without touching glove's outer surface) to avoid skin contact with this product. Dispose of contaminated gloves after use in accordance with applicable laws and good laboratory practices. Wash and dry hands. Full contact: Material: Nitrile rubber Minimum layer thickness: 0.4 mm. If used in solution, or mixed with other substances, and under conditions which differ from EN 374, contact the supplier of the CE approved gloves. This recommendation is advisory only and must be evaluated by an industrial hygienist and safety officer familiar with the specific situation of anticipated use by our customers. It should not be construed as offering an approval for any specific use scenario. Wear appropriate protective gloves to prevent skin exposure. Impervious clothing. Wear appropriate protective clothing to prevent skin exposure. Facilities storing or utilizing this material should be equipped with an eyewash facility and a safety shower. Use adequate ventilation to keep airborne concentrations low. Good general ventilation should be sufficient to control airborne levels. General industrial hygiene practice. Do not let product enter drains. 9. Physical and Chemical Properties Physical States: [ ] Gas [ ] Liquid [ X ] Solid Appearance and Odor: Paste. Petroleum-like. Melting Point: C Boiling Point: Flash Pt: Method Used: Estimate Evaporation Rate: Flammability (solid, gas): Explosive Limits: LEL: UEL: Vapor Pressure (vs. Air or mm Hg): Vapor Density (vs. Air = 1):

5 Specific Gravity (Water = 1): ~ Density: Solubility in Water: Percent Volatile: Autoignition Pt: Stability: ~ G/CM3 10. Stability and Reactivity Unstable [ ] Stable [ X ] Conditions To Avoid - dust generation, Strong oxidants, Not available. Instability: Incompatibility - Materials To None. Strong oxidizing agents, Strong bases, Strong oxidizers. Not available. Avoid: Hazardous Decomposition or Other decomposition products: No data available. In the event of fire: see section 5. Byproducts: Carbon monoxide, formed under fire conditions. Carbon oxides, Not available. Possibility of Hazardous Will occur [ ] Will not occur [ X ] Reactions: Conditions To Avoid - Hazardous Reactions: Toxicological Information: Irritation or Corrosion: Sensitization: Chronic Toxicological Effects: 11. Toxicological Information No data available. Reproductive toxicity. Aspiration hazard: Epidemiology: No information available. Teratogenicity: No information available. Reproductive Effects: Neurotoxicity: Other Studies: No information found. Skin corrosion/irritation. No data available. Serious eye damage/eye irritation: No data available. Specific target organ toxicity - single exposure: No data available. Specific target organ toxicity - repeated exposure: IARC: No component of this product present at levels greater than or equal to 0.1% is identified as probable, possible or confirmed human carcinogen by IARC. ACGIH: No component of this product present at levels greater than or equal to 0.1% is identified as a carcinogen or potential carcinogen by ACGIH. NTP: No component of this product present at levels greater than or equal to 0.1% is identified as a known or anticipated carcinogen by NTP. Carcinogenicity/Other Information: OSHA: No component of this product present at levels greater than or equal to 0.1% is identified as a carcinogen or potential carcinogen by OSHA. This product is or contains a component that is not classifiable as to its carcinogenicity based on its IARC, ACGIH, NTP, or EPA classification. IARC: No component of this product present at levels greater than or equal to 0.1% is identified as probable, possible or confirmed human carcinogen by IARC. ACGIH: No component of this product present at levels greater than or equal to 0.1% is identified as a carcinogen or potential carcinogen by ACGIH. NTP: No component of this product present at levels greater than or equal to 0.1% is identified as a known or anticipated carcinogen by NTP. OSHA: No component of this product present at levels greater than or equal to 0.1% is identified as a carcinogen or potential carcinogen by OSHA. CAS# : Not listed by ACGIH, IARC, NTP, or CA Prop 65. CAS# : Not listed by ACGIH, IARC, NTP, or CA Prop 65. CAS# : Not listed by ACGIH, IARC, NTP, or CA Prop 65.

6

7