MATERIAL SAFETY DATA SHEET 2. COMPOSITION/INFORMATION ON INGREDIENTS

Transcription

1 1. CHEMICAL PRODUCT AND COMPANY IDENTIFICATION Chemical Family: Non-Chlorinated Hydrocarbon Synonyms: None Emergency Telephone (24 hr.): CHEMTREC Supplier: Zykal th St., Aldergrove, BC Canada. V4W 3L4 2. COMPOSITION/INFORMATION ON INGREDIENTS Weight % OSHA TWA OSHA STEL OSHA SKIN Weight % OSHA Z PEL OSHA Z TWA OSHA Z Ceiling mg/m ppm 180 mg/m 3 50 ppm Not Listed mg/m ppm 1600 mg/m ppm Not Listed mg/m ppm 980 mg/m ppm Not Listed ACGIH TLV TWA ACGIH TLV STEL ACGIH TLV Ceiling 50 ppm Not Listed Not Listed 400 ppm 500 ppm Not Listed 200 ppm 400 ppm Not Listed 3. HAZARDS IDENTIFICATION Emergency Overview: Danger: Extremely flammable. Keep away from heat, sparks and flame. Harmful if inhaled. May be fatal if swallowed. Causes severe eye irritation. Will damage tissue. Avoid contact with skin and eyes. Danger: Poison. HMIS Classification: Health: *2 Flammability: 3 Physical Hazard: 0 NFPA Rating: Health: 1 Flammability: 3 Reactivity: 0 4. FIRST AID MEASURES Eye Contact: Ingestion: Inhalation: In case of contact, or suspected contact, immediately flush eyes with plenty of water for at least 15 minutes and get medical attention immediately after flushing. If swallowed, induce vomiting immediately by giving two glasses of water and sticking fingers down throat; never give anything to an unconscious person. Get medical attention. After vomiting has been induced, give two teaspoonful of baking soda in a glass of water. CALL A PHYSICIAN. If inhaled, remove to fresh air. If not breathing give artificial respiration, preferably mouth-to-mouth. If breathing is difficult give oxygen. Get medical attention. Page 1 of 5

2 Skin Contact: 4. FIRST AID MEASURES In case of contact, immediately flush skin with plenty of soap and water for at least 15 minutes. Get medical attention. Remove contaminated clothing and shoes, and launder before reuse. 5. FIRE FIGHTING MEASURES Flammable Properties Flash Point F( C): -10 (-23C) Flash Point Method: TAG Closed Cup Flammable Limits in Air - Lower (%): 1.8 Flammable Limits in Air - Upper (%): Autoignition Temperature F( C): 610 F (321 C) (Lowest ) Extinguishing Media: Carbon dioxide. Foam. Use water spray to keep containers cool that are exposed to heat or flames. Protection Of Fire-Fighters: Special Fire-Fighting Procedures: Wear approved positive-pressure self-contained breathing apparatus and protective clothing. Hazardous Combustion Products: Carbon Dioxide. Carbon Monoxide. Aerosol Comments: Not Applicable 6. ACCIDENTAL RELEASE MEASURES Personal Precautions: Wear appropriate protective clothing and equipment to prevent skin and eye contact. Spill Procedures: Wear protective equipment specified. Avoid the generation of dust. Sweep, vacuum, or shovel and place into closable container for disposal. Action to be taken if material is released or Neutralize with suitable neutralizing agent after diluting with water. spilled: Environmental Precautions: Keep away from drains. 7. HANDLING AND STORAGE Handling and Storage: Keep away from heat and open flame. Use only in a well ventilated area. Avoid breathing vapors, if exposed to high vapor concentration, leave area at once. Avoid contact with skin and eyes. Keep containers tightly closed when not in use. 8. EXPOSURE CONTROLS/PERSONAL PROTECTION Engineering Controls: Eyes: Skin Protection: Respiratory Protection: Showers. Eyewash stations. Local exhaust ventilation as necessary to maintain exposures to within applicable limits. Wear safety glasses or goggles to protect against exposure. Appropriate respiratory protection shall be worn when applied engineering controls are not adequate to protect against inhalation exposure. 9. PHYSICAL AND CHEMICAL PROPERTIES Appearance: Colorless to light yellow liquid Odor: ALCOHOL ph Value: Vapor Pressure: mm of 20 C Vapor Density (Air=1): 2.5 Boiling Point ( F): Melting/Freezing Point: Solubility in Water: APPRECIABLE Bulk Density at 20 C: Molecular Weight: Mixture Specific Gravity 60 F. Viscosity: Evaporation Rate: VOC Content(%): 100% Page 2 of 5

3 Decomposition Temperature: Not Known 9. PHYSICAL AND CHEMICAL PROPERTIES 10. STABILITY AND REACTIVITY Chemical Stability: STABLE. Conditions to Avoid: Avoid any source of ignition. Strong oxidizing agents. Temperature over 120 F. Materials to Avoid: Contact with oxidizing agents. Hazardous Decomposition Products: Carbon monoxide. Carbon dioxide. Hazardous Polymerization: WILL NOT OCCUR Toxicological Data: 11. TOXICOLOGICAL INFORMATION Route Species Dose Inhalation Rats Not known. Inhalation Rats LC gm/m 3 /4H Inhalation Rats LC50 16,000 ppm Carcinogenicity: IARC NTP OSHA 12. ECOLOGICAL INFORMATION Remarks: Ecological testing has not been conducted on this product. 13. DISPOSAL CONSIDERATION Waste Classification: Waste Management: Disposal Method: Disposal should be made in accordance with federal, state and local regulations. 14. TRANSPORTATION INFORMATION U.S. DOT: Proper Shipping Name: Flammable Liquid, n.o.s. (, Isopropanol) Hazard Class: 3 UN/NA Number: UN 1993 DOT Packing Group: PG II IMDG: Proper Shipping Name: Flammable Liquid n.o.s. (, Isopropanol) Hazard Class: 3 Hazard Subclass: UN No.: UN 1993 Packing Group: PG II Page 3 of 5

4 Marine Pollutant: No 14. TRANSPORTATION INFORMATION 15. REGULATORY INFORMATION US Federal Regulations: SARA 313 SARA 302 TPQ RQ Listed. Listed. SARA 311/312 Hazard Catagories:. State Regulations: California Prop. 65 California - Prop 65 California Prop. 65 California Prop. 65 Cancer list Developmental Toxicity Reproductive Female Reproductive Male New Jersey Right-to-Know List: Substance no Substance no Substance no Substance no Substance no Substance no Substance no Substance no Substance no Substance no Substance no Substance no Substance no Substance no Substance no Substance no Substance no Substance no Substance no Substance no Substance no U.S. TSCA: Canadian Inventory: The components of this product are listed on the TSCA Inventory. The components of this product are listed on the Canadian DSL or NDSL Inventory. Page 4 of 5

5 Consumer Product Safety Improvement Act of 2008 General Conformity Certification The Supplier identified in Section 1 of this MSDS has evaluated this product and certifies it to be labeled and packaged in compliance with the applicable provisions of the Federal Hazardous Substance Act as stated in 16 CFR 1500 and enforced by the Consumer Product Safety Commission, and where applicable the products that require Child Resistant Closures are packaged in accordance with the Poison Prevention Packaging Act as stated in 16 CFR 1700 and enforced by the Consumer Product Safety Commission. All closures have been tested in accordance with the latest protocols. No other testing is required to certify compliance with the above. The date of manufacture is stamped on the product container. 16. OTHER INFORMATION General Notes: Disclaimer: Do not allow undiluted material or large quantities to reach groundwater, bodies of water or sewer system. The information and recommendations contained herein are based upon tests believed to be reliable. However, the manufacturer/distributor of this product does not guarantee their accuracy or completeness NOR SHALL ANY OF THIS INFORMATION CONSTITUTE A WARRANTY, WHETHER EXPRESSED OR IMPLIED, AS TO THE SAFETY OF THE GOODS, THE MERCHANTABILITY OF THE GOODS, OR THE FITNESS OF THE GOODS FOR A PARTICULAR PURPOSE. Adjustment to conform to actual conditions of usage may be required. The manufacturer/distributor assumes no responsibility for results obtained or for incidental or consequential damages, including lost profits, arising from the use of these data. No warranty against infringement of any patent, copyright or trademark is made or implied. Page 5 of 5