SAFETY DATA SHEET according to 1907/2006/EC, Article 31

Transcription

1 SAFETY DATA SHEET according to 1907/2006/EC, Article 31 NEO 800 Page 1/5 SECTION 1: Identification of the substance/mixture and of the company/undertaking 1.1. Product identifier Product name NEO Relevant identified uses of the substance or mixture and uses advised against Use of the Substance/Mixture: Cleaning agent / Sanitizer Recommended restrictions on use: Reserved for industrial and professional use Details of the supplier of the safety data sheet SECTION 2: Hazards identification 2.1. Classification of the substance or mixture Classification (CHIP): Classification (CLP): -: R31; N: R50 Skin Irrit. 2: H315 Eye Dam. 1: H318 Aquatic Acute 1: H400 EUH206: 2.2. Label elements Label elements under CLP (1272/2008): Hazard statements: Signal words: Hazard pictograms: H315: Causes skin irritation. H318: Causes serious eye damage H400: Very toxic to aquatic life EUH206: Warning! Do not use together with other products. May release dangerous gases (chlorine). Danger GHS05: Corrosion GHS09: Environment Precautionary statements: P102: Keep out of reach of children P280: Wear protective gloves / eye protection / face protection. P101: If medical advice is needed, have product container or label at hand. P : IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. P273: Avoid release to the environment. P233: Keep container tightly closed. P234: Keep only in original container. Label elements under CHIP (1999/45/ЕC): Hazard symbols: N: Dangerous for the environment. Risk phrases: R31: Contact with acids liberates toxic gas. R50: Very toxic to aquatic organisms.

2 Page 2/5 Safety phrases: 2.3. Other hazards PBT: S2 - Keep out of the reach of children. S24/25 - Avoid contact with skin and eyes. S26 - In case of contact with eyes, rinse immediately with plenty of water and seek medical advice. S28 - After contact with skin, wash immediately with plenty of water. S61 - Avoid release to the environment. Refer to special instructions/ Safety data sheets. This product is not identified as a PBT substance. SECTION 3: Composition/information on ingredients 3.2. Mixtures 67/548/EEC / 1999/45/EC Chemical Name CAS No. Conc. (%w/w) Classification Sodium Hypochlorite % C: R34; N: R50; -: R31 Skin Corr. 1B: H314; Aquatic Acute 1: H400; EUH031 SECTION 4: First aid measures 4.1. Description of first aid measures General advice: Consult a physician. Show this safety data sheet to the doctor in attendance. If inhaled: If breathed in, move person into fresh air. If not breathing, give artificial respiration. Consult a physician. In case of skin contact: Wash off with soap and plenty of water. Consult a physician. In case of eye contact: If swallowed: Rinse thoroughly with plenty of water for at least 15 minutes and consult a physician. Never give anything by mouth to an unconscious person. Rinse mouth with water. Consult a physician. 4.2 Most important symptoms and effects, both acute and delayed The most important known symptoms and effects are described in the labelling (see section 2.2) and/or in section Indication of any immediate medical attention and special treatment needed no data available. SECTION 5: Firefighting measures 5.1. Extinguishing media Use water spray, alcohol-resistant foam, dry chemical or carbon dioxide. 5.2 Special hazards arising from the substance or mixture Hydrogen chloride gas, Sodium oxides 5.3 Advice for firefighters Wear self-contained breathing apparatus for fire fighting if necessary. 5.4 Further information no data available SECTION 6: Accidental release measures 6.1. Personal precautions, protective equipment and emergency procedures Use personal protective equipment. Avoid breathing vapours, mist or gas. Ensure adequate ventilation. Evacuate personnel to safe areas. For personal protection see section Environmental precautions Do not allow product to enter drains or any water course. Prevent further spillage if safe. Advise local authorities if large spills cannot be contained. Discharge into the environment must be avoided Methods and material for containment and cleaning up Soak up with inert absorbent material and dispose of as hazardous waste. Keep in suitable, closed containers for disposal. 6.4 Reference to other sections For disposal see section 13.

3 Page 3/5 SECTION 7: Handling and storage 7.1. Precautions for safe handling Avoid contact with skin and eyes. Avoid inhalation of vapour or mist. For precautions see section Conditions for safe storage, including any incompatibilities Store in cool place. Keep container tightly closed in a dry and well-ventilated place. Containers which are opened must be carefully resealed and kept upright to prevent leakage. 7.3 Specific end use(s) Apart from the uses mentioned in section 1.2 no other specific uses are stipulated SECTION 8: Exposure controls/personal protection 8.1 Control parameters Components with workplace control parameters Contains no substances with occupational exposure limit values Exposure controls Appropriate engineering controls Handle in accordance with good industrial hygiene and safety practice. Wash hands before breaks and at the end of workday. Respiratory protection Hand protection Eye protection Protective equipment Do not breathe dust/fume/gas/mist/vapour/spray. Wear suitable respiratory equipment when necessary. Chemical resistant gloves (PVC). Avoid contact with eyes. In case of splashing, wear eye protection. Avoid contact with eyes and skin. Immediately remove all soiled and contaminated clothing. Wash all contaminated clothing before reuse. Control of environmental exposure Prevent further leakage or spillage if safe to do so. Do not let product enter drains. Discharge into the environment must be avoided. SECTION 9: Physical and chemical properties 9.1. Information on basic physical and chemical properties Appearance: Liquid Colour: Colourless Odour: Characteristic Odour threshold: ph-value at 20 C: 11.5 ± 0.5 Melting point: Boiling point: Flash point: Flammability (solid, gaseous): Auto-ignition temperature: Decomposition temperature: Self-igniting: Danger of explosion: Product does not present an explosion hazard. Explosion limits: Vapour pressure: Density at 20 C: ± 0.02 g/cm³ Relative density Vapour density Evaporation rate Solubility in / Miscibility with water: Fully miscible. Oxidizing properties Partition coefficient (n-octanol/water): Viscosity: Dynamic at 20 C: Kinematic: 9.2 Other information:

4 Page 4/5 SECTION 10: Stability and reactivity 10.1 Reactivity: Chemical stability Stable under normal conditions. Thermal decomposition / conditions to be avoided: No decomposition if used according to specifications Possibility of hazardous reactions: Hazardous reactions will not occur under normal transport or storage conditions Conditions to avoid Heat Incompatible materials: Strong oxidizing agents. Strong acids. Strong alkalis Hazardous decomposition products: In combustion emits toxic fumes. SECTION 11: Toxicological information Information on toxicological effects Acute toxicity: Primary irritant effect: on the skin: on the eye: Sensitization: There may be irritation and redness at the site of contact. There may be irritation and redness. The eyes may water profusely. There may be severe pain. The vision may become blurred. There may be permanent damage. No sensitizing effects known. Additional toxicological information: SECTION 12: Ecological information 12.1 Toxicity 12.2 Persistence and degradability The surfactant(s) contained in this preparation complies (comply) with the biodegradability criteria as laid down in Regulation (EC) N 648/2004 on detergents. Data to support this assertion are held at the disposal of the competent authorities of the Member States and will be made available to them at their direct request or at the request of a detergent manufacturer Bioaccumulative potential 12.4 Mobility in soil Mobility: Soluble in water Results of PBT and vpvb assessment PBT: vpvb: 12.6 Other adverse effects: Very toxic to aquatic life. SECTION 13: Disposal considerations General information Do not allow product to enter drains. Offer surplus and non-recyclable solutions to a licensed disposal company. Uncleaned packaging: Recommendation: Disposal must be made according to official regulations. Dispose of as unused product.

5 Page 5/5 14. TRANSPORT INFORMATION UN number UN number: UN UN proper shipping name Shipping name: ENVIRONMENTALLY HAZARDOUS SUBSTANCE, LIQUID, N.O.S. (hypochlorite solution) Transport hazard class(es) Transport class: Packing group Packing group: III Environmental hazards Environmentally hazardous: Marine pollutant: Yes Yes Special precautions for user Tunnel code: E Transport category: 3 Road transport notes Note : Product in pack size of 5 Litres or less is classed as a "Limited Quantity" for Transport 15. REGULATORY INFORMATION Safety, health and environmental regulations/legislation specific for the substance or mixture Labelling according to Regulation (EC) No 1272/2008 This safety data sheet is in compliance with the Regulation (EC) N 1907/2006 Chemical safety assessment: A Chemical Safety Assessment has not been carried out. 16. OTHER INFORMATION Revision: This document differs from the previous version in the following areas: Full text of classifications [CLP/GHS] H314: Causes severe skin burns and eye damage H315: Causes skin irritation H318: Causes serious eye damage H400: Very toxic to aquatic life EUH031: EUH206: Full text of classifications [DSD/DPD] R31: Contact with acids liberates toxic gas. R34: Causes burns R50: Very toxic to aquatic organisms. Contact with acids liberates toxic gas Warning! Do not use together with other products. May release dangerous gases (chlorine). Further information: The information supplied in this Safety Data Sheet is designed only as guidance for the safe use, storage and handling of the product. This information is correct to the best of our knowledge and belief at the date of publication however no guarantee is made to its accuracy. This information relates only to the specific material designated and may not be valid for such material used in combination with any other materials or in any other process.