Pontoon Slide Owner s Manual

Transcription

1 Pontoon Slide Owner s Manual ravesports.com

2 Table of Contents Introduction...2 Safety Rules and Information...3 Boat Compatibility Guide.5 Assembling and Using Your Pontoon Slide...6 Cleaning and Storage...11 Trouble Shooting and Repairs...11 Return Authorization Policy...13 Warranty Information...14 Contents in this package Pontoon Slide Tube 12 VDC Inflator/Deflator Repair Kit Warranty Registration Please make sure you have received the contents listed, and then record the following information for future reference. Date Purchased: Purchased from: Copyright All rights reserved. No part of this publication may be reproduced or transmitted in any form or by any means, electronic or mechanical, including photocopy, recording, or any information storage and retrieval system, without permission in writing from the publisher. Requests should be mailed to RAVE Sports, Inc., 3325 Labore Rd., St. Paul, MN

3 Introduction Water sports can be safe and fun for all levels of enthusiasts. The Owner s Manual is presented to enhance your enjoyment of the sport. It is intended to alert you to some of the potentially dangerous conditions that can arise in all water sports. Please take a few minutes to read this manual before assembling and using the product. Although the product is simple to use, this manual contains important safety information that you and all users must understand to safely enjoy the Pontoon Slide. If you have any questions regarding this product, please call RAVE Sports at Please have the serial number from your product ready when you call.! W A R N I N G UNSAFE USE OF THE PONTOON SLIDE CAN RESULT IN PERSONAL INJURY OR DEATH. To reduce the risk of injury, read and follow all instructions and warnings in this manual. Do not use this product unless you understand and accept the risk of injury involved with this activity. 2

4 Safety Rules and Information Read and understand all of the information contained in this owner s manual before assembling and using your product. Make sure that everyone who uses the product is provided with and understands these safety rules and information. The Pontoon Slide is designed to be used only on pontoon boats in large bodies of water with depths of at least 8 feet of water. Do not use or allow anyone else to use the product on Runabouts, Deck Boats, fishing boats, etc. Also, do not use on land or any other hard surface or in swimming pools. Choose a location for your product that is most protected from wind, of sufficient water depth, and free of obstructions above and below the water for at least 20 feet in all directions. Always mount Pontoon Slide to side gate areas. Never mount slide off the front of the Pontoon. Make sure gate is closed and locked securely. Always wear a U.S. Coast Guard approved Type III (PFD) personal floatation device when using the product. Never use the product after sunset, before dawn, or any other time in poor lighting conditions. Never use the product in rough surface water conditions, during storms, or when there is lightning. If an unexpected storm arises while using the product, seek shelter on shore. Do not stay on the product. Never use the product under the influence of alcohol or drugs. Always stay under control while using the product. Always make sure water near slide entry is clear of swimmers or other obstructions. 3

5 Safety Rules and Information (continued) Never swim or play under the Pontoon Slide. This product is not a towable. Stop motor when ready to use Pontoon Slide. Never have slide inflated and/ or attached while motor is running or boat is in motion. Do not allow more than one person to slide and/or climb on the slide at one time. Exceeding this may result in injury. Never slide down the Pontoon Slide head first or attempt other acrobatic maneuvers on the product. No pushing or shoving persons while on Pontoon Slide. Do not climb up the Pontoon Slide to exit the water. Use boarding ladder on the pontoon. Never jump from top of Pontoon Slide, stay in a seated position at all times. Never use the product while tired or fatigued. Use extreme caution while swimming around the pontoon boat. Always inspect the areas around and under the product before each use to ensure the water is deep enough and free of all rocks, logs, sand bars, and underwater obstructions and that the product is a safe distance from above water hard objects. Ask about local water conditions before using the product in unfamiliar water. When not in use, deflate Pontoon Slide and store in a secure area. Never leave slide inflated and unattended. Inspect your product for any worn, defective, or missing parts and replace or repair before using. Use the Pontoon Slide only under mature, knowledgeable adult supervision. 4

6 IMPORTANT: FOR PONTOON BOAT USE ONLY. DO NOT ATTEMPT TO USE ON DECKBOATS, RUNABOUTS, FISHING BOATS OR OTHER CRAFT. BEFORE ASSEMBLING OR USING YOUR SLIDE, MAKE SURE YOUR PONTOON MEETS THE FOLLOWING CRITERIA: 1. A secure side railing with a height of inches from the deck to the top of railing. 2. Vertical rail supports that are inches on both sides of the intended slide mounting location. 3. Minimum 34 inches width clearance so the slide can rest squarely on the pontoon deck. These criteria must be met in order for the pontoon slide to be securely fastened to the pontoon. If your boat does not meet these criteria, do not attempt to use the product. 5

7 Assembling your Pontoon Slide: Step 1: Make sure the side gate and railing of pontoon boat are free of sharp objects, your water depth is at a minimum of 8 feet and the pontoon is securely anchored. Ensure the railing is secure and stable with a height between 21 to 30 inches. Do not use if your railing does not meet these requirements. Place deflated Pontoon Slide over locked side gate of the pontoon boat. The climbing portion should be on the inside of the boat and the slide portion should be draped over the outside of the boat. It is preferred for the slide to be attached to the side with more of a confined space; such as between a seat and driver s console as shown. The minimum width clearance you will need is 34 inches. Step 2: Connect the pump provided with the Pontoon Slide to the battery of your pontoon. The red clip of the pump should connect to the positive terminal (red); the black clip should connect to the negative terminal (black). Make sure clips are securely fastened to the battery terminals. 6

8 ! CAUTION Electric Shock Hazard Use caution when connecting inflator to battery to avoid sparks or shock. Ensure hands are dry when connecting/ disconnecting clips to battery. Connect one clip at a time. Use the skinny nozzle on the inflator to inflate the slide rails first. Once the rails are inflated, moisten the plug and insert fully so it is flush with the surface. Locate the main valve and remove cap. A special inflation adaptor is included with this product. Simply lock the adaptor onto the end of the inflation hose and insert into the valve body. Turn ¼ turn to lock in place. NOTE: This inflation adaptor will automatically open the valve when inserted and will close the valve when removed. You do not need to manually open/close the valve when using this special adaptor. Inflate the main chamber of the slide until it is firm. Properly inflated, the slide will be firm and will not buckle during use. 7

9 ! C A U T I O N DO NOT OVER-INFLATE. Do not exceed 2 PSI if filling with compressed air. Excessive pressure can cause the tube to rupture with potentially damaging force to eyes, ears, skin and limbs. Use of an air compressor or over-inflation can rupture the tube beyond repair, thus voiding the warranty. To manually open valve, depress stem and rotate clockwise. To close valve, depress stem and rotate counter-clockwise. Note: It is normal for the air pressure within the tube to fluctuate depending on air and water temperatures. It may be necessary to increase or decrease the air pressure in your product accordingly. To avoid damage on extremely hot days it may be necessary to check and release the air pressure from your product throughout the day. 8

10 Step 3: Attach the upper black straps to the top of pontoon side rail. The strap should run straight down from the side of the slide to the rail. Wrap the strap around railing, up through the center of the buckle and then back down through the front of the buckle. Loosely attach both buckles then pull tight on both sides so the slide is secure and cannot rock side to side. Attach the lower straps of the slide through the nearest vertical bar on railing. The bar should be a maximum of 54 inches and a minimum of 16 inches away from the side of the slide. Wrap end of long strap around vertical bar on railing and then back through the buckle. Repeat for each side and pull taught. Ensure the slide is firm and stable before using. If necessary, add air or adjust straps. To Slide: Before sliding, wet slide surface with water. Sliding on a dry surface can cause burns to the skin. Climb up slide using hand and foot holds. Use top handles when transitioning from the climbing position to a seated position. Always slide feet first. Ensure water is clear of obstructions and other people before going down slide. 9

11 Deflating your Pontoon Slide: Step 1: Loosen all connection straps from railing. Step 2: Tip slide into boat, or leave draped over side gate. Deflate slide by moving the hose to the deflation port on the side of the air pump. Once all air is removed, make sure slide is completely dry for storage. Make sure to disconnect inflator from battery after use. Deflation port Roll up slide and stow under seat or other storage compartment. When stowing the slide, be sure to avoid any sharp edges that could potentially puncture the material. 10

12 Cleaning and Storage: When the inflatable product is not being used, store it in a covered, shaded area. This will help protect it against ultraviolet (UV) rays and extend the life of the product. Clean the inflatable completely with a mild soap and fresh water. NEVER USE PETROLEUM BASED PRODUCTS OR SOLVENTS FOR CLEANING. NEVER USE A POWER WASHER SINCE THE HIGH PRESSURE WATER WILL DAMGE THE TUBE BEYOND REPAIR. For storage, roll the product loosely and place in a container, preferably one that rodents can t chew through. Secure against unauthorized and unsupervised use. Store in a cool, dry location. Do not store product directly on concrete surface. Place mothballs around stored inflatable to keep mice and insects away. Troubleshooting Air chambers won t hold air: Check to make sure all valves are completely closed. Check for holes in the slide following the Procedures in the Repairs section. 11

13 Repairs For Minor Holes or Tears: Inflate the slide and locate the leak by spraying the tube with soapy water. Bubbles will appear where there is a leak. Determine the hole size and cut a circular patch ½ - 1 inch wider than the hole. Remove air from the tube and dry tube completely where the patch is to be applied. Peel off paper back from patch, apply repair patch to area and work out any air bubbles from beneath the patch. Apply weight to the patched area for one hour before reinflating. 12

14 Return Authorization Policy 1. Customer agrees to ship the product covered by the Return Authorization (R/A) number within thirty (30) days of receipt of the R/A number. Customer understands that failure to ship the product within thirty (30) days will result in the forfeiture of the R/A. RAVE Sports, Inc. (RAVE) will not accept any product that fails to ship within the thirty day time period and the customer will be responsible for all expenses related to shipping and return of rejected product. 2. Customer agrees that RAVE, at its own discretion, will determine whether the product being returned under the R/A Policy is covered by RAVE s Limited Warranty. 3. RAVE agrees to notify or provide, within a reasonable time period, the customer with: a. The acceptance or rejection by RAVE of the warranty claim with regard to the product returned. b. For products outside of the Limited Warranty, a price quote for the repairs required to return the product to a usable state including a cleaning charge for excessively dirty products. The customer agrees that rejection of the price quote or failure to approve the price quote in accordance with Section 3(c) below will result in the immediate return of the product, in the condition it was received by RAVE, FOB shipping location to the address provided by the customer. Customer further authorizes RAVE to charge the customer s credit card for the costs of shipping and handling associated with the return of the product, and the customer agrees to accept such charges. c. If RAVE does not receive an approval from the customer within 45 days of first attempt, the product will be returned to the customer at the customer s expense. Customer authorizes RAVE to charge the customer s credit card for the costs of shipping and handling associated with the return of the product, and the customer agrees to accept such charges. 4. Upon customer approval, RAVE will complete all necessary repairs. If while repairing the product additional damage is discovered and the cost of the repair is less then 10% of the original quote or $25.00, RAVE will proceed with the repair. The customer agrees to accept these additional charges. If the additional cost exceeds 10% or $25.00, RAVE will contact the customer for approval. 5. Once all repairs are complete, the customer authorizes RAVE to charge the customer s credit card for the costs of the repairs, and all shipping and handling associated with the return of the product, and the customer agrees to accept such charges. 6. RAVE will ship the product to the address provided FOB shipping location. 13

15 Terms and Conditions Limited Warranty 1. The limited warranty set forth below is given by RAVE Sports, Inc. (RAVE) with respect to product(s) purchased and used in the United States and internationally. 2. RAVE s product(s), when delivered to you in a new condition in original container, are warranted against defects in material or workmanship for a period of one (1) year from the date of original purchase when used in a non-commercial application. Product(s) used in a commercial application are warranted against defects or workmanship for a period of six (6) months from the date of original purchase. Defective product(s) returned to RAVE or authorized service location and proven to be defective upon inspection, will be repaired or exchanged for new product(s) or part(s) where applicable. The warranty period for any replacement product shall begin upon shipment of the same, but shall in no event exceed the warranty period of the defective product. 3. When returning any product under this limited warranty, you must first contact RAVE to obtain a return authorization number and then return the product in accordance with RAVE s Return Authorization Policy. The product must be packaged in its original carton with a copy of the bill of sale (or invoice of purchase), together with a complete explanation of the problem and the other information required by the Return Authorization Policy. Shipping charges, if any, must be prepaid. Products covered by this limited warranty will be returned to you without charge by RAVE. 4. This limited warranty covers all defects encountered in normal use of the product and does not apply in the following cases: a. Loss or damage to the product is due to abuse; mishandling; alteration; accident; vandalism; theft; failure to follow operating, maintenance or storage instructions; service performed by a party other than RAVE authorized service personnel; or any acts of God, including but not limited to storm damage or animal damage. b. The product has had its serial number(s) or dating altered or removed. 5. NO IMPLIED WARRANTY (OR CONDITION), INCLUDING ANY IMPLIED WARRANTY (OR CONDITION) OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE, APPLIES TO THE PRODUCT AFTER THE APPLICABLE PERIOD OF EXPRESS WARRANTY STATED ABOVE, AND NO OTHER EXPRESS WARRANTY OR GUARANTY, EXCEPT AS MENTIONED ABOVE, GIVEN BY ANY PERSON, FIRM, OR CORPORATION WITH RESPECT TO THE PRODUCT SHALL BIND RAVE SPORTS. (SOME STATES OR PROVINCES DO NOT ALLOW LIMITATIONS ON HOW LONG AN IMPLIED WARRANTY LASTS, SO THE ABOVE LIMITATIONS MAY NOT APPLY TO YOU). 6. RAVE SHALL NOT BE LIABLE FOR LOSS OF REVENUE OR PROFIT, FAILURE TO REALIZE SAVINGS OR OTHER BENEFITS, OR FOR ANY OTHER SPECIAL, INCIDENTAL OR CONSEQUENTIAL DAMAGES CAUSED BY THE USE, MISUSE OR INABILITY TO USE THE PRODUCT REGARDLESS OF THE LEGAL THEORY ON WHICH THE CLAIM IS BASED, AND EVEN IF RAVE HAS BEEN ADVISED OF THE POSSIBILITY OF SUCH DAMAGES. NOR SHALL RECOVERY OF ANY KIND AGAINST RAVE BE GREATER IN AMOUNT THAN THE PURCHASE PRICE OF THE PRODUCT SOLD BY RAVE AND CAUSING THE ALLEGED DAMAGE. 7. Without limiting the foregoing, you assume all risk and liability for loss, damage or injury to you and your property and to others and their property arising out of the use, misuse, or inability to use any product sold by RAVE not caused directly by the negligence of RAVE. (Some states or provinces do not allow the exclusion or limitation of incidental or consequential damages, so the above limitation may not apply to you.) This limited warranty shall not extend to anyone other than the original purchaser of any product, or the person for whom it was purchased as a gift. 8. This limited warranty gives you specific legal rights, and you may have other rights which very from state to state or province to province. 14

16 3325 Labore Rd. St. Paul, MN December