Laser Spectrometers for Online Moisture Measurement in Natural Gas. Ken Soleyn GE M&C
|
|
- Olivia Booth
- 5 years ago
- Views:
Transcription
1 Laser Spectrometers for Online Moisture Measurement in Natural Gas Ken Soleyn GE M&C
2 Introduction TDLAS (Tunable Diode Lase Absorption Spectroscopy) Moisture Analyzers have become the technology of choice for natural gas Natural gas is dehydrated for storage, transportation, contractual and intercompany requirements (7 lbs/mmscf tariff for interstate transfer in the USA) Dehydration is a trade-off between costs/energy consumption and gas quality Based on Fundamental Beer-Lambert Law Non-Contact Fast Response Field calibration not required Higher initial cost; lower cost of ownership and greater precision Discussion: Can these instruments be used in closed loop control for optimization of the dehydration process? 2
3 TDLAS Moisture Analyzers - Field Proven 3
4 Triethylene Glycol Gas Dehydration 4
5 Desiccant Dryers Sorbent material such as activated alumina, molecular sieve etc. Multiple columns Of line column is regenerated by backpurgging with hot lower pressure dry gas Capable of drying gas to dew points of <-100C and sub ppmv level 5
6 Refrigeration Gas is cooled below the dew point (water and Hydrocarbon) Water & heavy hydrocarbon condense and are separated Heavier hydrocarbons may be separated into liquids fractionally by temperature (Inverse of fraction distillation) Feed gas must be dried to prevent ice formation in heat exchangers 6
7 Beer-Lambert Law A = Absorption I = The measurement of beam intensity tuned to an absorbing frequency I o = The reference measurement or beam intensity when tuned away from the moisture absorbing frequency S = The fundamental absorption line strength L = The path length of the beam through the sample. N = The mole fraction of water contained in the beam path passing through the sample ln is the natural log I0 A ln( ) S L N I The Beer-Lambert law states that the mole fraction (concentration) of a gas can be measured by the intensity of light at a given wavelength entering the medium and comparing the intensity of light exiting the medium. 7
8 Wavelength Modulated Spectroscopy If the light is tuned to a specific wavelength the analyte will absorb a portion of the photonic energy. The light energy is not lost but is converted to other types of energy. Water s O-H (Oxygen-Hydrogen bond) embodies very unique stretching and vibro-rotational characteristics resulting in absorption at very specific wavelengths of light. Water has particular absorption bands for light in near infrared spectrum ( nm). The laser is typically held to a constant base temperature by thermal bonding to a thermoelectric heat pump. By ramping the injection current the laser is swept through a narrow frequency band. The current ramp is also modulated at high frequency This technique is known as wavelength modulation spectroscopy (WMS). 8
9 Schematic of TDL Analyzer 9
10 Wavelength Modulation Current ramp Direct absorption signal Current ramp applied to tunable laser Results in sweep of frequency in the near-infrared Laser is modulated at high frequency Signal loss (direct absorption) is attributable to water 10
11 2F Absorption at Various Concentrations F Absoption ppmv 25 ppmv 46 ppmv 99 ppmv 246 ppmv 504 ppmv 995 -ppmv
12 Psychrometric Relationships Dew Point & Water Vapor Pressure P H20(water ) K w t exp t K w x10 6 P P H20(Ice) K i t exp t K i x10 6 P P H20 (water) = Saturation water vapor pressure over water in mbar P H20 (ice) = Saturation water vapor pressure over ice in mbar t = Dew/Frost Point Temperature in C K w = Coefficient to correct for deviation from an ideal gas for liquid water in standard air K i = Coefficient to correct for deviation from an ideal gas for ice in standard air P = Absolute pressure in mbar 12
13 Frost Point (F) Dew Point vs. Lbs/MMSCF lbs/mmscf 13
14 Psychrometric Relationships Absolute Humidity & Concentration Dalton s Law P T P 1 P 2... P P T = Total Absolute Pressure P 1, P 2, P n = Component Gases Concentration ppm P H20 6 v 10 PT P H2O = Partial Pressure of H 2 O P T = Total Pressure n Absolute Humidity g 216PH 20 3 m T P H20 = Partial Pressure of H 2 O T = Temperature in C From To Multiply By mg/m 3 g/m lbs/mmscf mg/m lbs/mmscf ppm v mg/m 3 ppm v
15 Sample Conditioning 15
16 Response Time (Dry to Wet) 1.E+04 1.E+03 1.E+02 Step Change: 11 to 5,375 ppmv Response Time: 40 Seconds 1.E+01 1.E+00 17:28:19 17:29:46 17:31:12 17:32:38 17:34:05 17:35:31 17:36:58 17:38:24 17:39:50 17:41:17 16
17 Response Time (Wet to Dry) 1.E+04 1.E+03 1.E+02 Step Change: 5,375 to 11 ppmv Response Time: 50 Seconds 1.E+01 1.E+00 17:42:43 17:44:10 17:45:36 17:47:02 17:48:29 17:49:55 17:51:22 17:52:48 17
18 16:28:25 16:28:48 16:29:12 16:29:35 16:29:59 16:30:22 16:30:45 16:31:09 16:31:32 16:31:56 16:32:20 16:32:43 16:33:06 16:33:30 16:33:53 16:34:17 16:34:40 16:35:04 16:35:27 16:35:51 Process Upset Simulation 1.00E E E+02 Flow Rate: 1 SCFH Length of sample Tubing: 10 Ft 1.00E E+00 Water was injected into a 8 ppmv natural gas sample stream. The system immediately spiked to 3000 ppmv Recovery: Within 4 ppm after 4 minutes. Full recovery took 7 minutes 18
19 Pressure & Temperature Compensation At constant water concentration and increase in pressure and temperature reduces the 2F absorption peak. This is due to more interactions between water as well other molecules in the carrier gas (collision broadening) By varying the pressure and temperature calibration data can be stored in the analyzer s memory and used for compensation 19
20 Gas Composition As the background gas composition in natural gas changes the dynamics of the interactions between water and other molecules change the absorption characteristics. The graph above shows the influence of changing methane concentration from 98 to 88.6% Methane at constant water concentration of 200 ppmv 20
21 Calibration Phase 1 N2 Carrier Two pressure system : saturates gas at elevated temperature and low temperature 6 Point Calibration stored in analyzer for linear regression 21
22 Calibration Phase 2, Methane or Custom Gas Mixture Carrier A Permeation generator utilizes membrane to evaporate water into dry gas and controlled rate Rate is related to temperature The outflow of permeation cell is diluted with zero gas to achieve the desired concentration 22
23 Automated Calibration System The data is stored in an enterprise server Redundant standards: Generator + Chilled Mirror Golden Test Unit run on every calibration to study long-term drift characteristics - after 2-1/2 years - no measureable drift 23
24 Conclusion/Discussion: Gas Dehydration Optimization Does the potential exists to realize significant cost savings and reduce energy consumption while at the same time precisely adhere to both contractual and intercompany specifications? Precision and fast response enables continuous around the clock moisture measurement. Initial cost greater than other moisture measurement technologies however the cost of ownership is often better due to the minimal maintenance, and reliability. Reliable standard to avoid shut in due to non-compliant gas caused by high moisture content Real-time blending of low moisture gas with wetter gas supplies or bypassing dehydration systems? 24
Aurora. Moisture Measurement for Industrial Gases. GE Measurement & Control
GE Measurement & Control Aurora Moisture Measurement for Industrial Gases GE s Aurora analyzer uses tunable diode laser absorption spectroscopy (TDLAS) to rapidly and accurately measure moisture in industrial
More informationDEVICES FOR FIELD DETERMINATION OF WATER VAPOR IN NATURAL GAS Betsy Murphy MNM Enterprises 801 N. Riverside Drive Fort Worth, Texas 76111
INTRODUCTION Water vapor in natural gas has more than a substantial effect on the quality of the gas stream. Without quality measurement of water vapor the gas is basically not saleable. Contracts are
More informationHCL MONITORING. ICAC MARAMA WORKSHOP May 18-19th, Presented by: Ty Smith. CEMTEK
HCL MONITORING ICAC MARAMA WORKSHOP May 18-19th, 2011 Presented by: Ty Smith. CEMTEK 1 HCL MONITORING Applications Existing Measurement Technologies New Technologies Calibration and issues 2 APPLICATION
More informationMETHOD 3C - DETERMINATION OF CARBON DIOXIDE, METHANE, NITROGEN, AND OXYGEN FROM STATIONARY SOURCES
METHOD 3C - DETERMINATION OF CARBON DIOXIDE, METHANE, NITROGEN, AND OXYGEN FROM STATIONARY SOURCES 1. Applicability and Principle 1.1 Applicability. This method applies to the analysis of carbon dioxide
More informationReal-time Analysis of Industrial Gases with Online Near- Infrared Spectroscopy
Real-time Analysis of Industrial Gases with Online Near- Infrared Branch 5 Petrochemical, Biofuels Keywords Process, NIR, Gases, Gas Cell, Ethylene, Carbon Dioxide, Propane, Butane, Acetylene Summary Near-infrared
More informationTitle: Standard Operating Procedure for Measurement of Ethylene (C 2 H 4 ) in Ambient Air by Reduced Gas Detection (RGD)
Procedure No: SOP-026 Revision No: 1.0 January 24, 2011 Page No.: 1 of 10 1. INTRODUCTION AND SCOPE To obtain timely data for the purpose of air quality assessment, air quality trend reporting and to meet
More informationGenerating Calibration Gas Standards
Technical Note 1001 Metronics Inc. Generating Calibration Gas Standards with Dynacal Permeation Devices Permeation devices provide an excellent method of producing known gas concentrations in the PPM and
More informationMMS Mercury Monitoring System for Natural Gas
MMS Mercury Monitoring System for Natural Gas Natural gas often contains mercury at concentrations that vary from below 1 to above 10000 µg/m 3. Mercury is both toxic and potentially damaging: it can corrode
More informationThermo Scientific Model 146i Principle of Operation
Thermo Scientific Model 146i Principle of Operation The Model 146i Multi-gas Calibrator dilutes calibration gases to precise concentrations. The diluted gases are used to perform zero, precision and Level
More information973-SF 6 Analyzer. Precise and Stable SF 6 Gas Analyzer REFLECTING YOUR STANDARDS
Precise and Stable SF 6 Gas Analyzer Simultaneous measurement of humidity, SF 6 purity and SO 2 concentration Integrated gas recovery system with automatic pump back Fully automated SF 6 gas testing Fundamental
More informationWhite Paper. Chemical Sensor vs NDIR - Overview: NDIR Technology:
Title: Comparison of Chemical Sensor and NDIR Technologies TSN Number: 25 File:\\MII- SRV1\Metron\Bridge_Analyzers\Customer_Service_Documentation\White_Papers\25_G en EGA NDIR vs Chemical Sensor.docx Created
More informationLaboratory Hardware. Custom Gas Chromatography Solutions WASSON - ECE INSTRUMENTATION. Custom solutions for your analytical needs.
Laboratory Hardware Custom Gas Chromatography Solutions Custom solutions for your analytical needs. Laboratory Hardware Wasson-ECE Instrumentation offers hardware-only solutions for advanced chromatography
More informationChapter 10 Gases. Characteristics of Gases. Pressure. The Gas Laws. The Ideal-Gas Equation. Applications of the Ideal-Gas Equation
Characteristics of Gases Chapter 10 Gases Pressure The Gas Laws The Ideal-Gas Equation Applications of the Ideal-Gas Equation Gas mixtures and partial pressures Kinetic-Molecular Theory Real Gases: Deviations
More informationProtective Atmospheres, Measurement Technologies and Troubleshooting Tools
Protective Atmospheres, Measurement Technologies and Troubleshooting Tools Furnace atmospheres are critical to meet metallurgical specifications defined by control processes. The makeup of a furnace s
More informationDISTILLATION POINTS TO REMEMBER
DISTILLATION POINTS TO REMEMBER 1. Distillation columns carry out physical separation of liquid chemical components from a mixture by a. A combination of transfer of heat energy (to vaporize lighter components)
More informationOptimizing Effective Absorption during Wet Natural Gas Dehydration by Tri Ethylene Glycol
IOSR Journal of Applied Chemistry (IOSRJAC) ISSN : 2278-5736 Volume 2, Issue 2 (Sep-Oct. 212), PP 1-6 Optimizing Effective Absorption during Wet Natural Gas Dehydration by Tri Ethylene Glycol Khan, Mohd
More informationHiBarSens: Measurement of barrier properties by tunable diode laser absorption spectroscopy (TDLAS)
HiBarSens: Measurement of barrier properties by tunable diode laser absorption spectroscopy (TDLAS) H. Beese, W. Grählert, S. Kaskel, J. Grübler *, J. Koch *, K. Pietsch * Fraunhofer IWS, Winterbergstrasse
More informationOnline DGA-monitoring of power transformers
Online DGA-monitoring of power transformers Senior Industry Expert, Vaisala Finland Member of CIGRE A2/D1.47 and D1.52 WGs April 2018 Vaisala Webinar content 1. Dissolved gases why and which gases 2. Fault
More informationLaboratory Hardware. Custom Gas Chromatography Solutions WASSON - ECE INSTRUMENTATION. Engineered Solutions, Guaranteed Results.
Laboratory Hardware Custom Gas Chromatography Solutions Engineered Solutions, Guaranteed Results. WASSON - ECE INSTRUMENTATION Laboratory Hardware Wasson-ECE Instrumentation offers hardware-only solutions
More informationChapter 13 Gases, Vapors, Liquids, and Solids
Chapter 13 Gases, Vapors, Liquids, and Solids Property is meaning any measurable characteristic of a substance, such as pressure, volume, or temperature, or a characteristic that can be calculated or deduced,
More informationCharacterizing a Cu/Mn Alloy for Extracting Oxygen from Inert Gas. Streams
Characterizing a Cu/Mn Alloy for Extracting Oxygen from Inert Gas Streams Grace Lenhard Prattsburgh Central School LLE advisors: Walter Shmayda and Matthew Sharpe Laboratory for Laser Energetics University
More informationPhase Changes * OpenStax
OpenStax-CNX module: m42218 1 Phase Changes * OpenStax This work is produced by OpenStax-CNX and licensed under the Creative Commons Attribution License 3.0 Abstract Interpret a phase diagram. State Dalton's
More informationGCMSD-Headspace Analysis SOP
Before you start GCMSD-Headspace Analysis SOP Method and Sequences names are restricted to 50 characters (MSD program will crash otherwise) The GC oven and Injection Ports need to be cooled to 50 oc to
More informationFigure Vapor-liquid equilibrium for a binary mixture. The dashed lines show the equilibrium compositions.
Another way to view this problem is to say that the final volume contains V m 3 of alcohol at 5.93 kpa and 20 C V m 3 of air at 94.07 kpa and 20 C V m 3 of air plus alcohol at 100 kpa and 20 C Thus, the
More informationGases&Technology. Measurement of Impurities in Helium Using the Dielectric Barrier Discharge Helium Ionization Detector. FEATURE.
Gases&Technology FEATURE Measurement of Impurities in Helium Using the Dielectric Barrier Discharge Helium Ionization Detector. B Y M A T T H E W M O N A G L E Abstract Bulk gases are often delivered to
More informationDetermination of Dissolved Gases in Ground Waters. By Ray Martrano Laboratory Director Seewald Laboratories Inc.
Determination of Dissolved Gases in Ground Waters By Ray Martrano Laboratory Director Seewald Laboratories Inc. Overview of Presentation What is a dissolved gas? Why do we want to study dissolved gases?
More informationInstruments for Measurement of Dissolved CO 2 and O 2 in Beverages
Instruments for Measurement of Dissolved CO 2 and O 2 in Beverages CboxQC CboxQC At-line CarboQC CarboQC At-line OxyQC OxyQC Wide Range PFD filling device (Plus) 1 Product portfolio CarboQC CarboQC At-line
More informationThe Principles of Vacuum Technology
The Principles of Vacuum Technology Vacuum Terminology Vacuum units Vacuum regimes How to measure vacuum. Gauge designs. How to create vacuum Pump classifications and designs UHV compatibility considerations
More informationChapter 10: Gases. Characteristics of Gases
Chapter 10: Gases Learning Outcomes: Calculate pressure and convert between pressure units with an emphasis on torr and atmospheres. Calculate P, V, n, or T using the ideal-gas equation. Explain how the
More informationA Depletion Compensated Wet Bath Simulator For Calibrating Evidential Breath Alcohol Analyzers
A Depletion Compensated Wet Bath Simulator For Calibrating Evidential Breath Alcohol Analyzers Slemeyer, A. University of Applied Sciences of Giessen, Dept. of Electrical Engineering 1 Wiesenstr. 14, D-35390
More informationChapter 3 Atmospheric Thermodynamics
Chapter 3 Atmospheric Thermodynamics Spring 2017 Partial Pressure and Dalton Dalton's law of partial pressure: total pressure exerted by a mixture of gases which do not interact chemically is equal to
More informationNew Generation System M, leading the World in the Non-Invasive Measurement of Critical Real-Time Parameters.
New Generation System M, leading the World in the Non-Invasive Measurement of Critical Real-Time Parameters. System M Spectrum Medicals total commitment to continuous product improvement is demonstrated
More informationHOW TO MANAGE VAPORIZATION IN AN ANALYTICAL SYSTEM By Dean Slejko and Tony Waters
HOW TO MANAGE VAPORIZATION IN AN ANALYTICAL SYSTEM By Dean Slejko and Tony Waters If the analyzer in your analytical system requires gas but your sample is liquid, the only option is to convert the liquid
More informationPurpose and Scope: Responsibilities: Warnings and precautions: Background Beers law
Purpose and Scope: This document describes the procedures and policies for using the MSE Bruker FTIR Spectrometer. The scope of this document is to establish user procedures. Instrument maintenance and
More informationContinuous Gas Analysis In situ laser gas analyzers TÜV and MCERTS add-on for LDS 6 operating instructions Compact Operating Instructions
Continuous Gas Analysis In situ laser gas analyzers Compact Operating Instructions 1 LDS 6 TÜV/MCERTS certified analyzers for NH3/H2O, NH3 and H2O 1.1 Operation requirements Please observe the following:
More informationPE096: Overview of Gas Processing Technology
PE096: Overview of Gas Processing Technology PE096 Rev.001 CMCT COURSE OUTLINE Page 1 of 6 Training Description: This course is designed for a broad audience and is participative and interactive, utilizing
More informationLINEAR TRANSFORMATION APPLIED TO THE CALIBRATION OF ANALYTES IN VARIOUS MATRICES USING A TOTAL HYDROCARBON (THC) ANALYZER
LINEAR TRANSFORMATION APPLIED TO THE CALIBRATION OF ANALYTES IN VARIOUS MATRICES USING A TOTAL HYDROCARBON (THC) ANALYZER Michael T Tang, Ph.D. Grace Feng Greg Merideth Rui Huang Matheson Gas Applied Lab
More informationTitle: Standard Operating Procedure for Dasibi Model 5008 Gas Dilution Calibrator
Procedure No: SOP-034 Revision No: 1.0 Revised Dec. 29, 2010 Page No.: 1 of 10 1. INTRODUCTION AND SCOPE This procedure is intended to describe the operations of the Dasibi model 5008 calibrator. The Dasibi
More informationSAMPLE RH = P 1. where. P 1 = the partial pressure of the water vapor at the dew point temperature of the mixture of dry air and water vapor
moisture starts to condense out of the air. The temperature at which this happens is called the dew point temperature, or the saturation temperature. What is commonly called saturation pressure or condensing
More informationTGA100A Trace Gas Analyzer Overview
TA100A Trace as Analyzer Overview The TA100A Trace as Analyzer measures trace gas concentration in an air sample using tunable diode laser absorption spectroscopy (TDLAS). This technique provides high
More informationUT 3000 Mercury Ultratracer
MERCURY INSTRUMENTS ANALYTICAL TECHNOLOGIES UT 3000 Mercury Ultratracer Measuring of Total Gaseous Mercury (TGM) in Air and other Gases at Ultra Trace Levels. Applications: Air quality studies Monitoring
More informationInstructor: Dr. Istadi (http://tekim.undip.ac.id/staf/istadi )
Instructor: Dr. Istadi (http://tekim.undip.ac.id/staf/istadi ) Email: istadi@undip.ac.id Course Syllabus: (Part 1) 1. Definitions of Natural Gas, Gas Reservoir, Gas Drilling and Gas production (Pengertian
More informationS on equipment and pipelines along with the constant threat to personnel safety justify major investment in H 2
Application Summary Analytes: S (hydrogen sulfide) Detector: OMA-300 S Analyzer Process Stream: natural gas Introduction Raw natural gas contains hydrogen suflide, the level of which varies by field. Due
More informationMATRIX-MG Series. Innovation with Integrity. Automated High-Performance Gas Analyzers FT-IR
MATRIX-MG Series Automated High-Performance Gas Analyzers Innovation with Integrity FT-IR The MATRIX-MG Series comprises three high-performance FT-IR gas analyzers in a compact and rugged housing. They
More informationA Coal Mine Multi-Point Fiber Ethylene Gas Concentration Sensor
PHOTONIC SENSORS / Vol. 5, No. 1, 215: 67 71 A Coal Mine Multi-Point Fiber Ethylene Gas Concentration Sensor Yubin WEI 1,2, Jun CHANG 1*, Jie LIAN 1, and Tongyu LIU 2 1 School of Information Science and
More informationDissolved Oxygen and measurement possibilities. Berno Lüpkes, 15 th March 2017
Dissolved Oxygen and measurement possibilities Berno Lüpkes, 15 th March 2017 Content 1. Introduction to Dissolved Oxygen 2. Amperometric measurement principle 3. Optical measurement principle 4. Optical
More informationChemistry 20 Unit 2 Gases FITB Notes. Topic A Characteristics of Gases
Chemistry 20 Unit 2 Gases FITB Notes General Outcome: Topic A Characteristics of Gases We use technologies that were designed with the knowledge of the visible characteristics ( ) of gases ex. SCUBA equipment,
More informationAn Automated High Precision Saturation/Dilution Calibration System for Trace Moisture Sensors
GE Oil & Gas An Automated High Precision Saturation/Dilution Calibration System for Trace Moisture Sensors The paper discusses the physical construction and operating principles of this saturation/dilution
More informationAnother convenient term is gauge pressure, which is a pressure measured above barometric pressure.
VACUUM Theory and Applications Vacuum may be defined as the complete emptiness of a given volume. It is impossible to obtain a perfect vacuum, but it is possible to obtain a level of vacuum, defined as
More informationVortex flowmeters. Product family introduction Principle of operation Product review Applications Key product features
Vortex flowmeters introduction Product review s Key product features This document should not be duplicated, used, distributed, or disclosed for any purpose unless authorized by Siemens. Page 1 Vortex
More informationH o w t o U s e a R e g u l a t o r t o R e d u c e T i m e D e l a y i n a n A n a l y t i c a l S y s t e m
H o w t o U s e a R e g u l a t o r t o R e d u c e T i m e D e l a y i n a n A n a l y t i c a l S y s t e m By Doug Nordstrom and Mike Adkins Swagelok Company Process measurements are instantaneous but
More informationAutomatic Permeability Testing: The Challenges and Solutions Author: Alyce Hartvigsen, PBI-Dansensor A/S, Ringsted, Denmark
Automatic Permeability Testing: The Challenges and Solutions Author: Alyce Hartvigsen, PBI-Dansensor A/S, Ringsted, Denmark In recent years, numerous product developments and major changes in the distribution
More informationGLOSSARY OF TERMS. Adiabatic Compression Compression process when all heat of compression is retained in the gas being compressed.
GLOSSARY OF TERMS Absolute pressure Total pressure measured from absolute zero i.e. a perfect vacuum. As a practical matter, gauge pressure plus atmospheric pressure. Absolute temperature Temperature measured
More informationFOURIER TRANSFORM INFRARED SPECTROSCOPY
Purpose and Scope: This document describes the procedures and policies for using the MSE Bruker FTIR Spectrometer. The scope of this document is to establish user procedures. Instrument maintenance and
More informationHigh Efficiency SO2 Scrubber Design to Reduce Caustic Consumption
High Efficiency SO2 Scrubber Design to Reduce Caustic Consumption Paper # 35 Andrew C. Bartocci Envitech, Inc. 2924 Emerson Street- Suite 320 San Diego, CA 92106 Ph: 619-223-9925, ext. 203 ABSTRACT An
More informationExample: 25 C = ( ) K = 298 K. Pressure Symbol: p Units: force per area 1Pa (Pascal) = 1 N/m 2
Chapter 6: Gases 6.1 Measurements on Gases MH5, Chapter 5.1 Let s look at a certain amount of gas, i.e. trapped inside a balloon. To completely describe the state of this gas one has to specify the following
More informationChapter 13: The Behavior of Gases
Chapter 13: The Behavior of Gases I. First Concepts a. The 3 states of matter most important to us: solids, liquids, and gases. b. Real Gases and Ideal Gases i. Real gases exist, ideal gases do not ii.
More informationCommercial Practice Test Method Internal Vapor Analysis of Hermetic Devices
Commercial Practice Test Method Internal Vapor Analysis of Hermetic Devices Oneida Research Services, Inc. 8282 Halsey Road Whitesboro, NY 13492 Phone: (315) 736-5480 FAX: (315) 736-9321 1.0 Purpose The
More informationASTM 3612/TOGA/Dissolved Gas GC Revised October 2013
The SRI ASTM 3612/TOGA/ Dissolved Gas GC configuration ( TOGA GC ) permits measurement of gasses dissolved in water, oil or other liquids, and is based on the requirements of ASTM method 3612, option C,
More informationLaser Gas Analyzer LG2000. The Laser Technologies
Laser Gas Analyzer LG2000 The Laser Technologies LG 2000 Series Laser Gas Analyzer Utilizing proprietary technologies of Tunable Diode Laser Absorption Spectroscopy (TDLAS), the LG 2000 system to satisfy
More informationCLOSED LOOP SOLVENT EMISSIONS CONTROL. David C.H. Grant
CLOSED LOOP SOLVENT EMISSIONS CONTROL David C.H. Grant Abstract: An approach to closed loop solvent emissions control systems, useful for all conventional solvent processes and solvents is presented. The
More informationAPPLICATION NOTE. GC Integrated Permeation Device
GC Integrated Permeation Device GC-integrated Design PPB to PPM Level Calibration No Cylinders or Regulators Required Option for Dual Ovens Cost Effective, Safe, Clean, Flexible, NIST Traceable Keywords:
More informationOxygen measurement in diving technology
Oxygen measurement in diving technology Oxygen and nitrogen partial pressure are important parameters for divers, when it comes to calculating maximum depth ranges, decompressions and intervals between
More informationEDUCTOR. principle of operation
EDUCTOR principle of operation condensate and mixing eductor s are designed to mix two liquids intimately in various proportions in operations where the pressure liquid is the greater proportion of the
More informationField verification of on-line HC dew point measurements
Field verification of on-line HC dew point measurements Andy Benton, Technical Consultant, Michell Instruments Limited, Ely, UK andy.benton@michell.com www.michell.com Introduction: The Michell Condumax
More informationChapter 13 Temperature, Kinetic Theory, and the Gas Laws 497
Chapter 13 Temperature, Kinetic Theory, and the Gas Laws 497 Figure 13.25 This photograph of Apollo 17 Commander Eugene Cernan driving the lunar rover on the Moon in 1972 looks as though it was taken at
More informationINTEROFFICE MEMORANDUM MODIFICATIONS TO DEW POINT CONTROL PROCESS
INTEROFFICE MEMORANDUM TO: FROM: SUBJECT: NEW ENGINEER I.M. ANOLDGUY MODIFICATIONS TO DEW POINT CONTROL PROCESS DATE: JANUARY 10, 2017 We are looking to make modifications to our initial design for a DPC
More informationFundamentals of Compressed Air Systems. Pre-Workshop Assignment
Page 1 In order to ensure that the Compressed Air Challenge Fundamentals of Compressed Air Systems Training is most useful to you, it will be important for you to bring information about your plant s compressed
More informationHonors Chemistry Unit 7 Gas Laws Notes
Honors Chemistry Unit 7 Gas Laws Notes Kinetic Molecular Theory 1. List the five assumptions: Assumption Description Extra Info 1 Basically means: the particles themselves have compared to the space between
More informationAutomated Determination of Dissolved Gases in Water Anne Jurek. Abstract: Discussion:
Automated Determination of Dissolved Gases in Water Anne Jurek Abstract: The RSK-175 standard operating procedure was developed in order to determine the amount of dissolved gas in water. Due to the expansion
More informationwww.ompressedairsystems.com ultra-high purity nitrogen generators nitrogen purity: 95% to 99.999% www.ompressedairsystems.com ultra-high purity nitrogen generators nitrogen purity: 95% to 99.999% Leading
More informationLOW PRESSURE EFFUSION OF GASES adapted by Luke Hanley and Mike Trenary
ADH 1/7/014 LOW PRESSURE EFFUSION OF GASES adapted by Luke Hanley and Mike Trenary This experiment will introduce you to the kinetic properties of low-pressure gases. You will make observations on the
More informationPotter Nitrogen Generators
Potter Nitrogen Generators What is nitrogen? Nitrogen the inert gas Earth s atmosphere the air we breathe is composed of nitrogen, oxygen, and water vapor. While this atmosphere is great for life, it is
More informationVortex Tube Short Course February 2017
Vortex Tube Short Course February 2017 10125 Carver Rd. Cincinnati, OH 45242 1.800.441.7475 sales@vortec.com Vortex Tube Short Course The vortex tube has been around for decades, yet occasionally it is
More informationOnline gas monitoring by using Raman spectroscopy
NEXTLAB Conference, 2-4 April 2014 Online gas monitoring by using Raman spectroscopy Yamina OUABBAS H. Lucas 2, J. P. Viricelle 1, S. Grimaldi 3, B. Allard-Breton 3 1 Ecole Nationale Supérieure des Mines,
More informationLFE OEM TCD - Thermal Conductivity Detector
LFE OEM TCD - Thermal Conductivity Detector Key features Quick response - T90 3 sec Extremely suppressed ranges High corrosion resistance High temperature capability up to 180 C Infallible containment
More informationGaseous oxygen technical grade Specification
CDC 09 (5010) P3 Rev. TZS 217:1984 FINALIZED TANZANIA STANDARD Gaseous oxygen technical grade Specification TANZANIA BUREAU OF STANDARDS. 2 nd edition TBS 2017 0. FOREWORD 0.1. This Tanzania Draft Standard
More informationTECHNICAL SPECIFICATION. SPC-4 Stirling Process Cryogenerator
TECHNICAL SPECIFICATION SPC-4 Stirling Process Cryogenerator Reference 80 8043 00 Issue Date August 1, 2015 1. INTRODUCTION This document contains detailed technical information and specifications for
More informationFinding leaks in Main Cryogenic Heat Exchangers without shutdown
Finding leaks in Main Cryogenic Heat Exchangers without shutdown Liquefaction is the most fundamental step in the LNG production process. To achieve this there are several process solutions available,
More informationThe HumiPyc - Model 1 - Gas Pycnometer; Density, Moisture, Permeation Analyzer; RH sensor Calibrator
The HumiPyc - Model 1 - Gas Pycnometer; Density, Moisture, Permeation Analyzer; RH sensor Calibrator Designed, built, and supported by InstruQuest Inc. Temperature controlled, multi-technique volumetric
More informationHiden QIC Series Gas Analysers Real-time gas analysis systems
Hiden QIC Series Gas Analysers Real-time gas analysis systems vacuum analysis surface science plasma diagnostics gas analysis Application Focussed Options Multistream valves 20, 40 and 80 way versions
More informationGas Pressure. Pressure is the force exerted per unit area by gas molecules as they strike the surfaces around them.
Chapter 5 Gases Gas Gases are composed of particles that are moving around very fast in their container(s). These particles moves in straight lines until they collides with either the container wall or
More informationThis test shall be carried out on all vehicles equipped with open type traction batteries.
5.4. Determination of hydrogen emissions page 1 RESS-6-15 5.4.1. This test shall be carried out on all vehicles equipped with open type traction batteries. 5.4.2. The test shall be conducted following
More informationWhat I have learned about SF 6 gas testing.a Practical explanation
What I have learned about SF 6 gas testing.a Practical explanation Over the past few years, testing of SF6 gas quality has become increasingly important and with the EPA in USA, setting guidelines for
More informationDr. Tetsuzo KITAGAWA, Tokihiko YONEDA, Shigefumi NAKAJIMA. 1. Preface
PORTABLE BREATH ALCOHOL ANALYZER BY NDIR METHOD Dr. Tetsuzo KITAGAWA, Tokihiko YONEDA, Shigefumi NAKAJIMA KOMYO RIKAGAKU KOGYO K. K. 2-14,2-chome, Nakane, Meguro-ku, Tokyo 152, Japan 1. Preface For the
More informationDetecting Hydrogen in Helium Streams. Samuel Goodman. Pittsford Mendon High School. Rochester, New York. Advisor: Dr.
1 Detecting Hydrogen in Helium Streams Samuel Goodman Pittsford Mendon High School Rochester, New York Advisor: Dr. Walter Shmayda Laboratory for Laser Energetics University of Rochester Rochester, New
More informationLOW PRESSURE EFFUSION OF GASES revised by Igor Bolotin 03/05/12
LOW PRESSURE EFFUSION OF GASES revised by Igor Bolotin 03/05/ This experiment will introduce you to the kinetic properties of low-pressure gases. You will make observations on the rates with which selected
More informationCP Chapter 13/14 Notes The Property of Gases Kinetic Molecular Theory
CP Chapter 13/14 Notes The Property of Gases Kinetic Molecular Theory Kinetic Molecular Theory of Gases The word kinetic refers to. Kinetic energy is the an object has because of its motion. Kinetic Molecular
More informationTitle: Standard Operating Procedure for Sabio 2010 and 4010 Dilution Calibrator
Procedure No: SOP-012 Revision No: 1.2, January 27, 2011 Page No.: 1 of 7 1. INTRODUCTION AND SCOPE This procedure is intended to describe the operations of the Sabio model 2010 and 4010 dilution calibrators.
More informationPREPARING SOLUBILITY DATA FOR USE UPDATING KEY RESOURCES BY THE GAS PROCESSING INDUSTRY:
PREPARING SOLUBILITY DATA FOR USE Mapping Midstream s Future 2012 GPA Convention BY THE GAS PROCESSING INDUSTRY: UPDATING KEY RESOURCES Darryl Mamrosh and Kevin Fisher Trimeric Corporation Jeff Matthews
More information--- III. itti A. on_ coo. & EP Department DOCUMENT NO: WOC-HSE-ST Section H005 Hydrates
--- III itti A. on_ coo WOC LP & EP Department WOC HSE Standards Manual DOCUMENT NO: WOC-HSE-ST-0001 Section H005 Hydrates REV ISSUE PREPARED BY REVIEWED BY APPROVED BY ISSUE DATE 044 /- 6 WO Executive
More informationTitle: Choosing the right nitrogen rejection scheme
Title: Choosing the right nitrogen rejection scheme Authors: Nicolas Chantant, Paul Terrien, Sylvain Gérard (Air Liquide Global E&C Solutions) Abstract: Nitrogen Rejection Units (NRU) are used to extract
More informationAlphasense Application Note AAN NDIR: Gas Concentration Calculation Overview
AAN 21-6 NDIR: Gas Concentration Calculation Overview 1. What is an NDIR Sensor? Alphasense IRC-A sensors use the principle of Non-Dispersive Infra-Red (NDIR to determine gas concentration. Each sensor
More informationColumbus Instruments
Micro-Oxymax Layman s Guide to Measurement Principles Introduction: The Micro-Oxymax Respirometer (Figure 1) measures the production and/or consumption of many gases simultaneously. Data is typically reported
More informationStates of Matter Review
States of Matter Review May 13 8:16 PM Physical States of Matter (Phases) Solid Liquid Melting Gas Condensation Freezing Evaporation Deposition Sublimation Sep 13 6:04 PM 1 May 13 8:11 PM Gases Chapter
More informationBasic GE Sensing Hygrometry Principles User s Guide
GE Sensing Basic GE Sensing Hygrometry Principles User s Guide GE Sensing Basic GE Sensing Hygrometry Principles User s Guide 916-064B August 2006 Table of Contents Introduction.................................................................................
More informationacrolein, acetaldehyde and acetone( cm -1 ); methanol (1306 cm -1 ); ethylene (949 cm -1 ); and isoprene (893 cm -1 ).
acrolein, acetaldehyde and acetone(1550 1800 cm -1 ); methanol (1306 cm -1 ); ethylene (949 cm -1 ); and isoprene (893 cm -1 ). 5 Figure 4a 6 Figure 4b Figure 4c 7 Figure 5 Questions in Student Handout
More informationQuantitative Analysis of Hydrocarbons by Gas Chromatography
Quantitative Analysis of Hydrocarbons by Gas Chromatography Introduction Gas-liquid chromatography (GLC) accomplishes a separation by partitioning solutes between a mobile gas phase and a stationary liquid
More informationDISTILLATION COLUMN PROCESS CONTROL STRATEGIES
DISTILLATION COLUMN PROCESS CONTROL STRATEGIES Satyajit Deshmukh 1, Salil Rajwade 2, Atharva Pundalik 3, Anil Ranveer 4 ABSTRACT 1,2,3,4 Chemical Engineering Department, Datta Meghe College of Engineering,
More informationmaintaining storage tank dissolved oxygen levels utilizing gas transfer membranes
Water Technologies & Solutions technical paper maintaining storage tank dissolved oxygen levels utilizing gas transfer membranes Authors: W.E. Haas, SUEZ, J. Helmrich, Florida Power and Light and J.E.
More information