SAFETY DATA SHEET <TITLE >

Transcription

1 Product Code: Product Name: Manufacturer Information: Company Name: Web site address: 1. Product and Company Identification 4193 <PRODUCT CONQUEST #60 NAME > SOFTENER AND SOUR PDQ Manufacturing, Inc. 201 Victory Circle Ellijay, GA Emergency Contact: Chemtrec, Reference: CCN (800) Information: (706) Supplier Name and Address: Company Name: Serious Eye Damage/Eye Irritation, Category 2 Skin Corrosion/Irritation, Category 1B <COMPANY NAME > <ADDRESS > <ADDRESS > <CSZ >, 2. Hazards Identification Revision: Phone Number: (706) Phone Number: (999) Page: 1 of 5 09/17/2018 Supersedes Revision: 10/16/2015 GHS Signal Word: GHS Hazard Phrases: GHS Precaution Phrases: GHS Response Phrases: GHS Storage and Disposal Phrases: Danger H314 - Causes severe skin burns and eye damage. H319 - Causes serious eye irritation. P264 - Wash hands thoroughly after handling. P280 - Wear protective gloves and eye protection. P IF SWALLOWED: Rinse mouth. Do NOT induce vomiting. P IF ON SKIN (or hair): Remove/take off immediately all contaminated clothing. Rinse skin with water/shower. P IF INHALED: Remove victim to fresh air and keep at rest in a position comfortable for breathing. P IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. Call a poison control center or physician for treatment advice. Have product container or label with you when calling poison control center or physician. P310 - Immediately call a POISON CENTER or doctor/physician. P321 - Specific treatment see appropriate section on this label. P If eye irritation persists, get medical advice/attention. P363 - Wash contaminated clothing before reuse. P405 - Store locked up. P501 - Dispose of contents/container in accordance with all local, regional, national and international regulations.

2 Potential Health Effects (Acute and Chronic): Inhalation: Skin Contact: Eye Contact: Ingestion: No hazard expected in normal industrial use. Causes skin burns. Causes eye burns. Causes gastrointestinal tract burns. 3. Composition/Information on Ingredients Page: 2 of 5 CAS # Hazardous Components (Chemical Name) Concentration Phosphoric acid {Orthophosphoric acid} % % Emergency and First Aid Procedures: In Case of Inhalation: In Case of Skin Contact: In Case of Eye Contact: In Case of Ingestion: Flash Pt: Autoignition Pt: Fire Fighting Instructions: Flammable Properties and Hazards: % 4. First Aid Measures If breathed in, move person into fresh air. No specific treatment is necessary since this material is not likely to be hazardous by inhalation. Flush skin with plenty of water for at least 15 minutes while removing contaminated clothing and shoes. Wash off with soap and plenty of water. Flush eyes with plenty of water for at least 15 minutes, occasionally lifting the upper and lower eyelids. Get medical aid immediately. Never give anything by mouth to an unconscious person. Rinse mouth with water. Consult a physician. 5. Fire Fighting Measures Explosive Limits: LEL: UEL: Suitable Extinguishing Media:Use water spray, dry chemical, carbon dioxide, or alcohol-resistant foam. Protective Precautions, Protective Equipment and Emergency Procedures: Environmental Precautions: Steps To Be Taken In Case Material Is Released Or Spilled: As in any fire, wear a self-contained breathing apparatus in pressure-demand, MSHA/NIOSH (approved or equivalent), and full protective gear. Substance is noncombustible. Further information. 6. Accidental Release Measures Use personal protective equipment. Avoid breathing vapors, mist or gas. Ensure adequate ventilation. Evacuate personnel to safe areas. Vapours can accumulate in low areas. For personal protection see section 8. Prevent further leakage or spillage if safe to do so. Do not let product enter drains. Use proper personal protective equipment as indicated in Section 8. Spills/Leaks: Do not let this chemical enter the environment. Contain spillage, and then collect with an electrically protected vacuum cleaner or by wet-brushing and place in container for disposal according to local regulations (see section 13). Absorb spill with inert material (e.g. vermiculite, sand or earth), then place in suitable container.

3 Page: 3 of 5 7. Handling and Storage Precautions To Be Taken in Handling: Precautions To Be Taken in Storing: Do not get in eyes, on skin, or on clothing. Do not ingest or inhale. Avoid contact with skin and eyes. Store in a cool, dry place. Store in a tightly closed container. Keep container tightly closed in a dry and well-ventilated place. 8. Exposure Controls/Personal Protection CAS # Partial Chemical Name OSHA TWA ACGIH TWA Other Limits Phosphoric acid {Orthophosphoric acid} PEL: 1 mg/m3 TLV: 1 mg/m3 STEL: 3 mg/m Isopropyl alcohol {sec-propyl alcohol; IPA; Respiratory Equipment (Specify Type): Eye Protection: Protective Gloves: Other Protective Clothing: Engineering Controls (Ventilation etc.): Work/Hygienic/Maintenance Practices: Environmental Exposure Controls: PEL: 400 ppm Respirator protection is not normally required. TLV: 200 ppm STEL: 400 ppm Use equipment for eye protection tested and approved under appropriate government standards such as NIOSH (US) or EN 166(EU). Wear appropriate protective gloves to prevent skin exposure. Wear appropriate protective clothing to prevent skin exposure. Facilities storing or utilizing this material should be equipped with an eyewash facility and a safety shower. There are no special ventilation requirements. Handle in accordance with good industrial hygiene and safety practice. Wash hands before breaks and at the end of workday. Prevent further leakage or spillage if safe to do so. Do not let product enter drains. 9. Physical and Chemical Properties Physical States: [ ] Gas [ X ] Liquid [ ] Solid Appearance and Odor: Opaque pink liquid Fragrant odor. Melting Point: Boiling Point: Autoignition Pt: Flash Pt: Explosive Limits: LEL: UEL: Specific Gravity (Water = 1): ~ 1.0 Vapor Pressure (vs. Air or mm Hg): Vapor Density (vs. Air = 1): Evaporation Rate: Solubility in Water: Complete Viscosity: Moderate ph: 1% Percent Volatile:

4 Stability: Conditions To Avoid - Instability: 10. Stability and Reactivity Unstable [ ] Stable [ X ] Incompatible materials, Metals. Incompatibility - Materials To Reacts with most common metals to produce hydrogen gas. Is corrosive to many Avoid: materials including leather, rubber, and many organics. Oxidizing agents, Acid anhydrides, Aluminum, Halogenated compounds. Hazardous Decomposition or Byproducts: Possibility of Hazardous Reactions: Conditions To Avoid - Hazardous Reactions: Phosphine, oxides of phosphorus, hydrogen gas. Will occur [ ] Will not occur [ X ] 11. Toxicological Information Toxicological Information: Sensitization: CAS # Hazardous Components (Chemical Name) NTP IARC ACGIH OSHA Phosphoric acid {Orthophosphoric acid} n.a. n.a. n.a. n.a. n.a. n.a. n.a. n.a. n.a. 3 A4 n.a. Page: 4 of 5 Waste Disposal Method: 12. Ecological Information 13. Disposal Considerations Chemical waste generators must determine whether a discarded chemical is classified as a hazardous waste. US EPA guidelines for the classification determination are listed in 40 CFR Parts 261. Additionally, waste generators must consult state and local hazardous waste regulations to ensure complete and accurate classification. 14. Transport Information LAND TRANSPORT (US DOT): DOT Proper Shipping Name: DOT Hazard Class: UN/NA Number: Corrosive liquid, acidic, inorganic, n.o.s. (Phosphoric acid) 8 CORROSIVE UN3264 Packing Group: II 15. Regulatory Information EPA SARA (Superfund Amendments and Reauthorization Act of 1986) Lists CAS # Hazardous Components (Chemical Name) S. 302 (EHS) S. 304 RQ S. 313 (TRI) Phosphoric acid {Orthophosphoric acid} No Yes 5000 LB No No No No No No Yes

5 CAS # Hazardous Components (Chemical Name) Other US EPA or State Lists Phosphoric acid {Orthophosphoric acid} CAA HAP,ODC: No; CWA NPDES: No; TSCA: Yes - Inventory; CA PROP.65: No CAA HAP,ODC: No; CWA NPDES: No; TSCA: Yes - Inventory, 8D TERM; CA PROP.65: No CAA HAP,ODC: No; CWA NPDES: No; TSCA: Yes - Inventory; CA PROP.65: No Page: 5 of 5 Revision Date: Preparer Name: 09/17/2018 Regulatory Affairs 16. Other Information Hazard Rating System: HMIS: HEALTH FLAMMABILITY REACTIVITY PPE B Additional Information About This Product: Company Policy or Disclaimer: The information contained in this Safety Data Sheet is provided pursuant to current OSHA regulations to convey information concerning the hazardous nature of the named product. The information supplied was compiled from the most reliable sources available at the time of preparation and in light of the most reasonable foreseeable exposure situations expected from the intended use of this product. The material(s) may present greater or lesser hazard exposure under other circumstances that are beyond the control of the manufacturer. Therefore it is imperative that all directions and warnings on the product label be read and closely followed.