Safety Data Sheet INFANT HEEL WARMERS

Transcription

1 Safety Data Sheet INFANT HEEL WARMERS Section 1. Identification Product Identifier Synonyms Manufacturer Stock Numbers Recommended use Uses advised against Manufacturer Contact Address INFANT HEEL WARMERS MDS138007; MDS138008; MSD_SDS0188 MDS138007; MDS Hot application for hot therapy. Medline Industries, Inc. One Medline Place Mundelein, IL, USA Phone Emergency Phone Fax (800) (800) (847) CHEMTREC Website Section 2. Hazards Identification Classification Signal Word Pictogram Hazard Statements Precautionary Statements Response Prevention Storage Disposal Ingredients of unknown toxicity No OSHA Hazard Classifications Applicable - Category No OSHA Hazard Classifications Applicable 0% Page 1 of 6

2 Hazards not Otherwise Classified No Data Available Section 3. Ingredients CAS Ingredient Name Weight % Water 40% - 60% Acetic acid, sodium salt 40% - 60% Occupational exposure limits, if available, are listed in Section 8. Section 4. First-Aid Measures General Advice: Primary Routes of Entry: Eye Contact: Skin Contact: Inhalation: Ingestion: Most important symptoms and effects, both acute and delayed: Take proper precautions to ensure your own health and safety before attempting rescue and providing first aid. Consult a physician. Show this safety data sheet to the doctor in attendance. Move out of dangerous area. Eye Skin Ingestion Inhalation Flush eyes with large amounts of water for at least 15 minutes. Remove contact lenses, if worn. If irritation persists, seek medical attention. Take off contaminated clothing and shoes. Wash off with plenty of water for at least 15 minutes and consult a physician if feel uncomfortable. Move victim into fresh air. If breathing is difficult, give oxygen. Do not use mouth to mouth resuscitation if victim ingested or inhaled the substance. If not breathing, give artificial respiration and consult a physician immediately. If swallowed do not induce vomiting. Clean mouth with water and afterwards drink plenty of water. Never give anything by mouth to an unconscious person. Consult a physician if necessary. Section 5. Fire Fighting Measures Suitable Extinguishing Media Unsuitable Extinguishing Media Unusual Fire and Explosive Hazards: Hazardous Decomposition Products: Non-flammable liquid. In case of fire, use Dry Chemical, Alcohol-resistant foam and Carbon Dioxide (CO2) Stable, Combustion of vapor and liquid may produce carbon monoxide, carbon dioxide and other hazardous gases. Carbon monoxide. Sodium oxide. Page 2 of 6

3 Section 6. Accidental Release Measures Personal Precautions, Protective Equipment and Emergency Procedures: Spill/Leak Procedures: Environmental Precautions: Remove all sources of ignition. Ensure adequate ventilation. Take precautionary measures against static discharges. Evacuate personnel to safe areas. Keep people away from and upwind of spill/leak. Use personal protective equipment. Avoid breathing vapors and contact with skin or eyes. Wear protective clothing, gloves, safety glasses and dust respirator. Remove all sources of ignition. Use spark-proof tools and explosion-proof equipment. Absorb spilled material in dry sand or inert absorbent. In case or large amount of spillage, contain spill by bunding. Adhered or collected material should be promptly disposed of, in accordance with appropriate laws and regulations. Prevent further leakage or spillage if safe to do so. Do not let product enter drains. Section 7. Handling and Storage Protective Measures: Handling is performed in a well ventilated place. Wear suitable protective equipment. Avoid contact with skin and eyes. Avoid inhalation of vapors or mist. Measures to prevent fire: Keep away from heat/sparks/open flames/hot surfaces. Take precautionary measures against static discharges. Measures to prevent aerosol and dust generation: Other Precautions: Wash hands and face after using of the substances. Replace the contaminated clothing immediately. In addition to use mentioned in the first parts, unforseen other specific and uses. Section 8. Exposure Controls/Personal Protection Occupational Exposure Limits Personal Protective Equipment Engineering Controls: Respiratory Protection: Skin Protection: Eye Protection: Other protective equipment: Ingredient Name ACGIH TLV OSHA PEL STEL Water Acetic acid, sodium salt Ensure adequate ventilation, especially in confined areas. Ensure that eyewash stations and safety showers are close to the workstation location. Use appropriate respirator if exposure limits are exceeded or if irritation or other symptoms are experienced. Recommended Filter Type: Low boiling organic solvent, Type AX, Brown, conforming to EN371. Wear suitable protective clothing. Wear a tightly fitting chemical safety goggles. None required. Page 3 of 6

4 Section 9. Physical and Chemical Properties Physical State Color Colorless liquid Odor Odor Threshold Solubility Soluble in water Partition coefficient Water/n-octanol VOC% Viscosity Specific Gravity 1.53 Density lbs/gal Pounds per Cubic Foot Flash Point FP Method Ph Melting Point 324 Boiling Point Boiling Range LEL UEL Evaporation Rate Flammability Decomposition Temperature Auto-ignition Temperature No information available Vapor Pressure Vapor Density Molecular Formula: Water H2O Sodium acetate C2H3NaO2 Section 10. Stability and Reactivity Stability: Conditions to avoid: Incompatibility (Materials to avoid): Incompatibility (Materials to Avoid): Hazardous Decomposition or Byproducts Hazardous Decomposition or Byproducts: Hazardous Polymerization Stable under proper operation and storage conditions. Melts and decomposes when strongly heated. Strong bases. Strong acids. Magnesium oxide. Sulfur oxides. Sodium oxide. No polymerization. Page 4 of 6

5 Section 11. Toxicological Information Precautionary Statements: If medical attention is required. Show this safety data sheet (SDS) to the doctor in attendance. Eye: Skin: Inhalation: Ingestion: Target Organs: Primary Routes of Exposure: Percutaneous. Inhalation. Potential Effects of Chronic Exposure: Irritation/Sensitization: Based on available data, the classification criteria are not met. Teratogenicity: Based on available data, the classification criteria not met. Mutagenicity: Based on available data, the classification criteria are not met. Reproductive Toxicity: Based on available data, the classification criteria are not met. Section 12. Ecological Information Ecotoxicity: Biodegradability: Bioaccumulation: Mobility in soil: Other adverse effects: Section 13. Disposal Waste Disposal: Section 14. Transport Information Waste must be disposed of in accordance with federal, state and local environmental control regulations. UN Number UN Proper Shipping Name DOT Classification Packing Group Not Regulated Not Regulated Not Regulated Section 15. Regulatory Information SARA 311/312: SARA 302: SARA 313: TSCA: CERCLA Hazardous Substance List: Clean Air Act (CAA) Section 112, 112 (r): State Regulations: Page 5 of 6

6 Section 16. Other Information Revision Date 5/30/2015 Legend - Not Applicable N.E. - Not Established - Not Determined HMIS (U.S.A.): Health O Hazard HMIS (U.S.A.): Flammability O HMIS (U.S.A.): Reactivity O National Fire Protection O Association (U.S.A): Health Hazard National Fire Protection O Association (U.S.A): Flammability National Fire Protection O Association (U.S.A): Reactivity Additional Information The information contained herein is furnished without warranty or legal responsibility of any kind. Employers should use this information only as a supplement to other information gathered by them and must make independent determination of suitability and completeness of information from all sources to assure proper use of these materials and the safety and health of employees Page 6 of 6