MATERIAL SAFETY DATA SHEET

Transcription

1 MATERIAL SAFETY DATA SHEET SECTION 1. Identification of the Material and Supplier Product Name: Floor Kleen Recommended Use: Commercial grade floor cleaner Supplier Name: A Plus Chemicals and Fragrances Telephone Fax: Emergency Tel No: SECTION 2. Hazard Identification: NOT classified as hazardous according to criteria of ASCC Australia NOT classified as a schedule poison NOT classified as a dangerous good by criteria of the ADG Code Risk Phrases: None under normal operating conditions Safety Phrases: S23 S24/S25 Do not breathe vapors or mists. Avoid contact with skin and eyes S39 Wear eye/face protection S26 In case of contact with eyes, rinse with plenty of water and contact a doctor or the Poison Information Centre Product: Floor Kleen Issue Date:21 October 2015 Page 1 of 5

2 SECTION 3. Composition/ Information on Ingredients: Ingredient CAS Number Proportion Alkaline Salts - L Anionic Surfactants L Glycol Ether L Ammonia L Water H H > 60% M 10-60% L< 10% SECTION 4. First Aid Measures: Swallowed: Give water to drink, DO NOT induce vomiting. If vomiting occurs, lean patient forward to maintain open airways and to prevent asphyxiation. Eyes: Immediately irrigate with copious amounts of water for at least 15 minutes, holding eyelids open. If irritation persists seek immediate medical attention. Skin: Flush affected area with running water Inhalation: Remove victim from exposure to fresh air, consult a doctor if irritation persists Notes to Doctor: Treat Symptomatically SECTION 5. Fire Fighting Measures: Extinguishing Media: Non flammable, no restrictions on the type of extinguisher used. Fire Fighting Alert fire brigade and tell them location and nature of the hazard Wear breathing apparatus plus full protective clothing Evacuate the area move up wind of fire Prevent any entry of product from entering drains or waterways Fire and Explosion Hazard Non Combustible. Decomposition on heating may produce toxic gases Hazchem: None P.P.E: Gloves, eye protection and chemical resistant boots Product: Floor Kleen Issue Date:21 October 2015 Page 2 of 5

3 SECTION 6. Accidental Release Measures: Spills Slippery when split Clean up spills immediately Contain and absorb spills with sand, earth or inert materials Prevent spills from entering drains and waterways Place in a suitable, labelled container for waste disposal Personal protective equipment advice is listed in Section 8 SECTION 7. Handling and Storage: Handling No special handling requirements are necessary. As a precaution wear rubber or PVC gloves and chemical goggles Always wash hands with water after handling Storage Incompatibility Do not store near acids or oxidising agents Storage Requirements Store in original containers out of direct sunlight Keep containers securely sealed Store in a cool, dry well ventilated area Store away from acids, oxidising agents and foodstuffs SECTION 8. Exposure Controls & Personal Protection: Exposure Standards: Ammonia TWA 25ppm STEL 35ppm Biological Limits No biological limits allocated Personal Protective Equipment: Eye Use chemical goggle or safety glasses with side shield Hands Wear chemical resistant gloves e.g PVC Respirator Not normally required Engineering Controls Natural ventilation should be adequate under normal conditions Product: Floor Kleen Issue Date:21 October 2015 Page 3 of 5

4 SECTION 9. Physical and Chemical Properties: Physical State Pale yellow liquid. Odour: Lemon fragrance Boiling Point ( C): Approx. 100 C Flammability: Non flammable Volatile Component: Not available Water Solubility - Complete Specific Gravity ph SECTION 10. Stability and Reactivity: Chemical stability: Stable under normal storage conditions. Incompatible materials: Incompatible with acids and oxidising agents Decomposition: May evoke toxic gas if heated to decomposition Hazardous reactions: Hazardous polymerisation will not occur SECTION 11. Toxicological Information: ACUTE HEALTH EFFECTS: Low to moderate toxicity irritant. Use of safe work practices to avoid eye or skin contact and vapour inhalation. Ammonia is present in very low concentrations and therefore adverse health effects associated with this chemical are not anticipated. Eye: Irritant, contact may result in irritation, pain and redness Inhalation: Irritant, over exposure may result in mucous membranes and respiratory irritation, nausea, dizziness and headaches. Skin: Irritant, Prolonged or repeated contact may result in redness, itching, pain and rash Ingestion: Low to moderate toxicity. Ingestion may result in nausea, vomiting, abdominal pain and diarrhoea. Toxicity Data: Ammonia ( ) LC50 (Inhalation) 800mg/m cubed per 2 hours (guinea Pig) LD (50) (Ingestion) 4000mg/kg (rat) CHRONIC HEALTH EFFECTS Generally not applicable Product: Floor Kleen Issue Date:21 October 2015 Page 4 of 5

5 SECTION 12. Ecological Information: Environment: Atmosphere: Ammonia is rapidly returned to the soil by washout by rain. Soil: Ammonia is strongly absorbed to the soil. Ammonia is highly toxic to fish - levels of 1 pmm in water may be fatal to some species. SECTION 13. Disposal Considerations: Waste Disposal: For small amounts, flush to sewer with excess water or absorb with sand and dispose of to an approved landfill site. SECTION 14. Transport Information: Road and rail transport: Not classified as a Dangerous Good by the criteria of the ADG Code for transport by road or rail U.N Number: None Allocated Class & Subsidiary risk: None Allocated Packaging Group: None Allocated Hazchem Code: None Allocated SECTION 15. Regulatory Information: Based upon available information, this material is not classified as hazardous according to NOHSC Poisonous schedule None allocated SECTION 16. Other Information: Abbreviations: ASCC Australian Safety and Compensation Council Cas No Chemical Abstracts Service Number NOHSC National Occupational Health and Safety Commission ph Relates to hydrogen ion concentration using a scale of 0 (highly acidic) to 14 (highly alkaline) PPE Personal Protective Equipment PPM Parts per million Note: The information contained in this bulletin is offered on data that we believe to be reliable and has been prepared in good faith, but without guarantee, as conditions and methods of use of our products are beyond our control. Product: Floor Kleen Issue Date:21 October 2015 Page 5 of 5