Issue Date: 01-Jun-2010 Revision Date: 10-Sep-2015 Version 1 1. IDENTIFICATION MSH-32, MSH-1, MSH HAZARDS IDENTIFICATION

Transcription

1 Safety Data Sheet Issue Date: 01-Jun-2010 Version 1 1. IDENTIFICATION Product Identifier Product Name Other means of identification SDS # Product Code MSH - MICRO SHIELD ACE-009 MSH-32, MSH-1, MSH-55 Recommended use of the chemical and restrictions on use Recommended Use Polyelastomer coating used to keep evaporator coils clean and odor free. Details of the supplier of the safety data sheet Manufacturer Address Atlantic Chemical & Equipment Company 3471 Atlanta Industrial Parkway Suite 200 Atlanta, GA USA Emergency Telephone Number Company Phone Number Emergency Telephone (24 hr) CHEMTREC HAZARDS IDENTIFICATION Appearance Opaque liquid Physical State Liquid Odor Ammonia Classification This chemical does not meet the hazardous criteria set forth by the 2012 OSHA Hazard Communication Standard (29 CFR ). However, this Safety Data Sheet (SDS) contains valuable information critical to the safe handling and proper use of this product. This SDS should be retained and available for employees and other users of this product. Unknown Acute Toxicity 7.2% of the mixture consists of ingredient(s) of unknown toxicity Page 1 / 7

2 3. COMPOSITION/INFORMATION ON INGREDIENTS The product contains no substances which, at their given concentration, are considered to be hazardous to health. However, additional component information is available in subsequent sections of this SDS. First Aid Measures 4. FIRST-AID MEASURES Eye Contact Skin Contact Inhalation Ingestion Rinse immediately with plenty of water, also under the eyelids, for at least 15 minutes. Get medical attention if necessary. Wash skin with soap and water. Wash contaminated clothing before reuse. Get medical attention if necessary. Remove to fresh air. Immediately call a poison center or doctor/physician. Drink plenty of water. Do not induce vomiting. Immediately call a poison center or doctor/physician. Most important symptoms and effects Symptoms Direct contact may cause skin or eye irritation. May cause irritation of the respiratory tract. Indication of any immediate medical attention and special treatment needed tes to Physician Treat symptomatically. 5. FIRE-FIGHTING MEASURES Suitable Extinguishing Media Use extinguishing measures that are appropriate to local circumstances and the surrounding environment. Unsuitable Extinguishing Media. Specific Hazards Arising from the Chemical Product is not flammable. Hazardous Combustion Products Carbon monoxide. Protective equipment and precautions for firefighters As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH (approved or equivalent) and full protective gear. 6. ACCIDENTAL RELEASE MEASURES Personal precautions, protective equipment and emergency procedures Personal Precautions Use personal protection recommended in Section 8. Page 2 / 7

3 Environmental Precautions Prevent from entering into soil, ditches, sewers, waterways and/or groundwater. See Section 12, Ecological Information. See Section 13: DISPOSAL CONSIDERATIONS. Methods and material for containment and cleaning up Methods for Containment Methods for Clean-Up Prevent further leakage or spillage if safe to do so. Contain and collect with an inert absorbent and place into an appropriate container for disposal. 7. HANDLING AND STORAGE Precautions for safe handling Advice on Safe Handling Handle in accordance with good industrial hygiene and safety practice. Use personal protection recommended in Section 8. Avoid contact with skin, eyes or clothing. Keep containers closed when not in use. Follow all product label instructions. Use only as directed. Wash face, hands, and any exposed skin thoroughly after handling. Do not eat, drink or smoke when handling this product. Do not contaminate water, food, or feed by storage or disposal. Conditions for safe storage, including any incompatibilities Storage Conditions Incompatible Materials Keep container tightly closed and store in a cool, dry and well-ventilated place. Keep out of the reach of children. Store at ambient conditions. Protect from freezing. ne known based on information supplied. 8. EXPOSURE CONTROLS/PERSONAL PROTECTION Exposure Guidelines This product, as supplied, does not contain any hazardous materials with occupational exposure limits established by the region specific regulatory bodies Appropriate engineering controls Engineering Controls Ensure adequate ventilation, especially in confined areas. Eyewash stations. Showers. Individual protection measures, such as personal protective equipment Eye/Face Protection Skin and Body Protection Respiratory Protection Chemical goggles or full face shield. Refer to 29 CFR for eye and face protection regulations. Impervious rubber gloves. Refer to 29 CFR for appropriate skin and body protection. Ensure adequate ventilation, especially in confined areas. In case of inadequate ventilation wear respiratory protection. Refer to 29 CFR for respiratory protection requirements. General Hygiene Considerations Handle in accordance with good industrial hygiene and safety practice. Do not eat, drink or smoke when using this product. Wash face, hands and any exposed skin thoroughly after handling. Information on basic physical and chemical properties Physical State 9. PHYSICAL AND CHEMICAL PROPERTIES Liquid Page 3 / 7

4 Appearance Opaque liquid Odor Ammonia Color Opaque Odor Threshold Property Values Remarks Method ph 4.0 Melting Point/Freezing Point t applicable Boiling Point/Boiling Range 100 C / 212 F Flash Point >100 C / >212 F Per CPSC Flame Extension Test Evaporation Rate Flammability (Solid, Gas) Liquid-t applicable Upper Flammability Limits Lower Flammability Limit Vapor Pressure C Vapor Density Specific Gravity 1.02 (Water = 1) Water Solubility Dispersible Solubility in other solvents Partition Coefficient Auto-ignition Temperature Decomposition Temperature Kinematic Viscosity Dynamic Viscosity Explosive Properties t an explosive Oxidizing Properties Reactivity t reactive under normal conditions. Chemical Stability Stable under recommended storage conditions. Possibility of Hazardous Reactions ne under normal processing. 10. STABILITY AND REACTIVITY Hazardous Polymerization Hazardous polymerization does not occur. Conditions to Avoid Keep out of reach of children. See Sec. 7 Handling & Storage. Incompatible Materials ne known based on information supplied. Hazardous Decomposition Products Carbon monoxide. Information on likely routes of exposure Product Information 11. TOXICOLOGICAL INFORMATION Eye Contact Skin Contact Inhalation Avoid contact with eyes. Avoid contact with skin. Avoid breathing vapors or mists. Page 4 / 7

5 Ingestion Do not ingest. Component Information Chemical Name Oral LD50 Dermal LD50 Inhalation LC50 Salt of Phosphoric Acid = 3450 mg/kg ( Rat ) Information on physical, chemical and toxicological effects Symptoms Please see section 4 of this SDS for symptoms. Delayed and immediate effects as well as chronic effects from short and long-term exposure Carcinogenicity Based on the information provided, this product does not contain any carcinogens or potential carcinogens as listed by OSHA, IARC or NTP. Numerical measures of toxicity Unknown Acute Toxicity 7.2% of the mixture consists of ingredient(s) of unknown toxicity. 12. ECOLOGICAL INFORMATION Ecotoxicity The product is not classified as environmentally hazardous. However, this does not exclude the possibility that large or frequent spills can have a harmful or damaging effect on the environment. Persistence/Degradability. Bioaccumulation. Mobility Other Adverse Effects Waste Treatment Methods 13. DISPOSAL CONSIDERATIONS Disposal of Wastes Contaminated Packaging Disposal should be in accordance with applicable regional, national and local laws and regulations. Disposal should be in accordance with applicable regional, national and local laws and regulations. 14. TRANSPORT INFORMATION Page 5 / 7

6 te DOT IATA IMDG Please see current shipping paper for most up to date shipping information, including exemptions and special circumstances. t regulated t regulated t regulated 15. REGULATORY INFORMATION International Inventories US Federal Regulations SARA 311/312 Hazard Categories Acute Health Hazard Chronic Health Hazard Fire Hazard Sudden Release of Pressure Hazard Reactive Hazard Yes SARA 313 US State Regulations U.S. State Right-to-Know Regulations Page 6 / 7

7 16. OTHER INFORMATION NFPA HMIS Health Hazards Health Hazards 1 Flammability Flammability 0 Instability Physical Hazards 0 Special Hazards Personal Protection Issue Date: Revision Date: Revision te: 01-Jun Sep-2015 New format Disclaimer The information provided in this Safety Data Sheet is correct to the best of our knowledge, information and belief at the date of its publication. The information given is designed only as a guidance for safe handling, use, processing, storage, transportation, disposal and release and is not to be considered a warranty or quality specification. The information relates only to the specific material designated and may not be valid for such material used in combination with any other materials or in any process, unless specified in the text. End of Safety Data Sheet Page 7 / 7