: Tackle Safe Acid Cleaner RTU

Transcription

1 SECTION 1: Identification 1.1. Identification Product form Product name Tackle Safe Acid Cleaner RTU Revision date: 04/15/2015 : Mixture Product code : A : Tackle Safe Acid Cleaner RTU 1.2. Relevant identified uses of the substance or mixture and uses advised against Use of the substance/mixture 1.3. Details of the supplier of the safety data sheet CSI Group Int'l Inc.-DBA Concrete Services Int'l 575 Route 73 North, Unit C-4 West Berlin, NJ T (856) Emergency telephone number Emergency number : (800) SECTION 2: Hazard(s) identification 2.1. Classification of the substance or mixture Classification (GHS-US) Skin Irrit. 2 Eye Irrit. 2A H315 - Causes skin irritation H319 - Causes serious eye irritation Full text of H-phrases: see section Label elements GHS-US labeling Hazard pictograms (GHS-US) : : Hard Surface Cleaners of all types (bathroom and kitchen cleansers, furniture polish, etc.) Signal word (GHS-US) Hazard statements (GHS-US) Precautionary statements (GHS-US) GHS07 : Warning : H315 - Causes skin irritation H319 - Causes serious eye irritation : P264 - Wash hands and forearms thoroughly after handling P280 - Wear protective gloves/eye protection/face protection P302+P352 - If on skin: Wash with plenty of soap and water P305+P351+P338 - If in eyes: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing P321 - Specific treatment (see First aid measures on this label) P332+P313 - If skin irritation occurs: Get medical advice/attention P337+P313 - If eye irritation persists: Get medical advice/attention P362+P364 - Take off contaminated clothing and wash it before reuse 2.3. Other hazards 2.4. Unknown acute toxicity (GHS US) Not applicable SECTION 3: Composition/information on ingredients 3.1. Substance Not applicable 3.2. Mixture 01/15/2016 EN (English US) Page 1

2 Name Product identifier % Classification (GHS-US) Organic Acid (CAS No) Proprietary Eye Irrit. 2A, H319 Alcohol Ethoxylate (CAS No) Acute Tox. 4 (Oral), H302 Full text of H-phrases: see section 16 SECTION 4: First aid measures 4.1. Description of first aid measures First-aid measures general First-aid measures after inhalation First-aid measures after skin contact First-aid measures after eye contact First-aid measures after ingestion : Never give anything by mouth to an unconscious person. If you feel unwell, seek medical advice (show the label where possible). : Remove victim to fresh air and keep at rest in a position comfortable for breathing. Immediately call a poison center or doctor/physician. : Remove/Take off immediately all contaminated clothing. Rinse skin with water/shower. Immediately call a poison center or doctor/physician. : Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. Immediately call a poison center or doctor/physician. If eye irritation persists: Get medical advice/attention. : Rinse mouth. Do NOT induce vomiting. Immediately call a poison center or doctor/physician Most important symptoms and effects, both acute and delayed Symptoms/injuries : Causes severe skin burns and eye damage. Symptoms/injuries after eye contact : Causes serious eye irritation Indication of any immediate medical attention and special treatment needed SECTION 5: Firefighting measures 5.1. Extinguishing media Suitable extinguishing media : Foam. Dry powder. Carbon dioxide. Water spray. Sand. Unsuitable extinguishing media : Do not use a heavy water stream Special hazards arising from the substance or mixture Reactivity : Thermal decomposition generates : corrosive vapors Advice for firefighters Firefighting instructions Protection during firefighting : Use water spray or fog for cooling exposed containers. Exercise caution when fighting any chemical fire. Prevent fire-fighting water from entering environment. : Do not enter fire area without proper protective equipment, including respiratory protection. SECTION 6: Accidental release measures 6.1. Personal precautions, protective equipment and emergency procedures For non-emergency personnel Emergency procedures For emergency responders Protective equipment Emergency procedures : Evacuate unnecessary personnel. : Equip cleanup crew with proper protection. : Ventilate area Environmental precautions Prevent entry to sewers and public waters. Notify authorities if liquid enters sewers or public waters Methods and material for containment and cleaning up Methods for cleaning up 6.4. Reference to other sections See Heading 8. Exposure controls and personal protection. SECTION 7: Handling and storage 7.1. Precautions for safe handling Precautions for safe handling Hygiene measures : Soak up spills with inert solids, such as clay or diatomaceous earth as soon as possible. Collect spillage. Store away from other materials. : Wash hands and other exposed areas with mild soap and water before eating, drinking or smoking and when leaving work. Provide good ventilation in process area to prevent formation of vapor. Do not breathe dust/mist/spray. Avoid contact during pregnancy/while nursing. : Wash hands and forearms thoroughly after handling. 01/15/2016 EN (English US) 2/6

3 7.2. Conditions for safe storage, including any incompatibilities Technical measures Storage conditions Incompatible products Incompatible materials : Comply with applicable regulations. : Keep only in the original container in a cool, well ventilated place away from heat, hot surfaces, sparks, open flame and other ignition sources. No smoking. Keep container closed when not in use. : Strong bases. Strong acids. SECTION 8: Exposure controls/personal protection 8.1. Control parameters : Sources of ignition. Direct sunlight Exposure controls Personal protective equipment : Avoid all unnecessary exposure. Hand protection Eye protection Skin and body protection Respiratory protection Other information : Wear protective gloves/eye protection/face protection protective gloves. : Chemical goggles or face shield. : Wear suitable protective clothing. : Wear appropriate mask. : Do not eat, drink or smoke during use. SECTION 9: Physical and chemical properties 9.1. Information on basic physical and chemical properties Physical state : Liquid Color : clear Odor : Cherry Odor threshold ph : 1-2 Melting point Freezing point Boiling point : F Flash point : 200 F Relative evaporation rate (butyl acetate=1) Flammability (solid, gas) Explosion limits Explosive properties Oxidizing properties Vapor pressure Relative density : Relative vapor density at 20 C : Same as water Solubility : Soluble in water. Log Pow Auto-ignition temperature Decomposition temperature Viscosity Viscosity, kinematic Viscosity, dynamic 9.2. Other information SECTION 10: Stability and reactivity Reactivity Thermal decomposition generates : corrosive vapors. 01/15/2016 EN (English US) 3/6

4 10.2. Chemical stability Stable under normal conditions. Not established Possibility of hazardous reactions Not established Conditions to avoid Direct sunlight. Extremely high or low temperatures Incompatible materials Strong acids. Strong bases Hazardous decomposition products Fume. Carbon monoxide. Carbon dioxide. Thermal decomposition generates : corrosive vapors. SECTION 11: Toxicological information Information on toxicological effects Acute toxicity Alcohol Ethoxylate ( ) LD50 oral rat LD50 dermal rat ATE US (oral) Skin corrosion/irritation Serious eye damage/irritation Respiratory or skin sensitization Germ cell mutagenicity Carcinogenicity Reproductive toxicity Specific target organ toxicity (single exposure) Specific target organ toxicity (repeated exposure) Aspiration hazard Potential Adverse human health effects and symptoms Symptoms/injuries after eye contact 1400 mg/kg > 5000 mg/kg mg/kg body weight : Causes skin irritation. ph: 1-2 : Causes serious eye irritation. ph: 1-2 : Based on available data, the classification criteria are not met. : Causes serious eye irritation. SECTION 12: Ecological information Toxicity Alcohol Ethoxylate ( ) LC50 fish 1 EC50 Daphnia 1 Organic Acid (Proprietary) LC50 fish 1 6 mg/l 2.5 mg/l 100 mg/l Persistence and degradability Tackle Safe Acid Cleaner RTU Persistence and degradability Not established Bioaccumulative potential Tackle Safe Acid Cleaner RTU Bioaccumulative potential Not established. 01/15/2016 EN (English US) 4/6

5 12.4. Mobility in soil Other adverse effects Effect on the global warming Other information : No known ecological damage caused by this product. : Avoid release to the environment. SECTION 13: Disposal considerations Waste treatment methods Waste disposal recommendations Ecology - waste materials SECTION 14: Transport information Department of Transportation (DOT) In accordance with DOT Not regulated for transport TDG Transport by sea Air transport SECTION 15: Regulatory information US Federal regulations Organic Acid (Proprietary) : Dispose in a safe manner in accordance with local/national regulations. Dispose of contents/container in accordance with local/regional/national/international regulations. : Avoid release to the environment. Not listed on the United States TSCA (Toxic Substances Control Act) inventory International regulations CANADA EU-Regulations National regulations US State regulations SECTION 16: Other information Revision date : 04/15/2015 Other information : None. Full text of H-phrases: Acute Tox. 4 (Oral) Acute toxicity (oral) Category Eye Irrit. 2A Serious eye damage/eye irritation Category 2A Skin Irrit. 2 Skin corrosion/irritation Category H302 Harmful if swallowed H315 Causes skin irritation H319 Causes serious eye irritation 01/15/2016 EN (English US) 5/6

6 HMIS III Rating Health Flammability Physical Personal Protection : 2 Moderate Hazard - Temporary or minor injury may occur : 0 Minimal Hazard - Materials that will not burn : 1 Slight Hazard - Materials that are normally stable but can become unstable (self-react) at high temperatures and pressures. Materials may react non-violently with water or undergo hazardous polymerization in the absence of inhibitors. : B B - Safety glasses, Gloves SDS US (GHS HazCom 2012) This information is based on our current knowledge and is intended to describe the product for the purposes of health, safety and environmental requirements only. It should not therefore be construed as guaranteeing any specific property of the product 01/15/2016 EN (English US) 6/6