STATE OF FLORIDA DEPARTMENT OF MILITARY AFFAIRS Office of the Adjutant General St. Francis Barracks, P.O. Box 1008 St. Augustine, Florida

Size: px
Start display at page:

Download "STATE OF FLORIDA DEPARTMENT OF MILITARY AFFAIRS Office of the Adjutant General St. Francis Barracks, P.O. Box 1008 St. Augustine, Florida"

Transcription

1 STATE OF FLORIDA DEPARTMENT OF MILITARY AFFAIRS Office of the Adjutant General St. Francis Barracks, P.O. Box 1008 St. Augustine, Florida ADMF 19 September 1985 DEPARTMENT OF MILITARY AFFAIRS Florida Army National Guard Pamphlet October 1985 SAFETY Respiratory Protection Program Supersession: None Applicability: This regulation applies to all military and civilian personnel in the Florida Army National Guard whose work requires the use of respiratory protective equipment to include air purifying devices, atmospheric supplying devices and self-contained underwater breathing apparatus used in diving operations. This supplement does not include the wearing of military gas masks when used during tactical NBC situations or self-contained breathing apparatus used in Army aircraft. Suggested Improvements: The Proponent agency of this Pamphlet is the Florida Army National Guard, Director of Administration, Department of Military Affairs. Users are invited to send comments and suggested improvements on DA Form 2028 (Recommend Changes to Publications) directly to TAG-FL, (ATTN: ADMF), St. Francis Barracks, P.O. Box 1008, St. Augustine, FL TABLE OF CONTENTS TABLE OF CONTENTS PARAGRAPH PAGE CHAPTER 1 INTRODUCTION Purpose References Scope Definitions Policy CHAPTER 2 RESPONSIBILITIES Adjutant General Safety Manager Occupational Health Nurse Support Personnel Management Office Commanders/Supervisors Users of Respiratory Equipment Glossary G-1 G-2

2 CHAPTER 1 INTRODUCTION 1-1. Purpose: To establish a respiratory protection program in the Florida Army National Guard and to comply with the requirements of the Occupational Safety and Health Act (OSHA) , Respiratory Protection and TB Med 502, Respiratory Protection Program References: a. AR 40-5 Health & Environment dated June 1985 AR Army National Guard Safety Program dated November 1983 b. TB Med 502 Respiratory Protection Program dated February 1982 c. Title 29, CFR, 1981 rev. Part 1910, Occupational Safety & Health Standards, Section Lead. 1-3 Scope: This regulation provides for: a. The identification and evaluation of operations at which respiratory protection is required and the correct respirator for use at those operations. b. The determination of employee physical and physiological fitness for respiratory protection use and periodic medical surveillance. c. Fitting employees with respiratory protection devices. d. Cleaning and maintaining respiratory equipment. e. Training in the correct use of respiratory protective equipment. f. Record keeping necessary for an effective respiratory protection program. 1-4 Definition of Terms: Definition of terms used in the publication are found in the glossary of Terms 1-5 Policy: a. All respiratory protective equipment used in the Florida Army National Guard will be approved by NIOSH and MSHA unless otherwise directed by DA. b. Respiratory protection, as an effective method of protecting the health of military and civilian personnel, will only be used under the following circumstances. (1) When there are no feasible engineering control that can be used to adequately control the hazard. (2) During intermittent or non-routine operations.

3 (3) During interim periods when engineering controls are being designed and/or installed. (4) During emergencies. c. Respirators requiring a good face piece-to-face seal to be effective will not be considered adequate when user conditions prevent such. Typical conditions may be growth of beard, sideburns, a skull cap that projects under the face piece, temple pieces on corrective spectacles or goggles or the absence of one or both dentures. (1) Where possible, measures will be taken to correct conditions that prevent a good face piece-to-face seal. (2) Where a good face piece-to-face seal is not possible but required, the employee will not be allowed to work in an area requiring respirator protection. d. Contact lenses shall not be worn in hazardous environment without appropriate covering safety eyewear. Contact lenses shall not be allowed for use with respirators equipped with full face piece, helmet, hood or suit. e. Where respiratory protective equipment is used in atmosphere immediately dangerous to life or health, a standby person or personnel with visual, voice and signal line contact will be present with suitable equipment for emergency rescue. f. Compressed air cylinders for self contained respiratory protection will be maintained as prescribed in Shipping Container Specifications of the Department of Transportation (49 CFR part 178) and will be filled with compressed air that meets the requirements as described in the American National Standards Institute (ANSI) Standard ZX86.1/Compressed Gas Association (CGA) Specification G g. Any air compressors supplying air shall be equipped with the necessary safety and standby devices as described in paragraph (d) of the OSHA Standards. CHAPTER 2 RESPONSIBILITES 2-1 The Adjutant General will establish policies and responsibilities to: a. Provide each employee with a healthy work environment free of respiratory hazards that are likely to cause illness or injury. b. Comply with pertinent directives and policies through functional managers and first line supervisors. c. Ensure that each first line supervisor is provided a list of personnel under their control requiring medical surveillance The Safety Manager will:

4 a. Conduct regular inspections of work areas to assure continued effectiveness of the respiratory protection program. b. Check gas containers to ensure proper labeling. c. Check self-contained respirators to ensure that breathing gas cylinders are marked as specified in ANSI Standard Z (R1971). d. Notify the Occupational Health Nurse of all operations reported and/or noted during surveys and inspections where a need for respiratory protection is suspected. e. Establish an abatement program to alleviate the need for respiratory protection through engineering controls when advised by the industrial hygienist that such controls are feasible The Occupational Health Nurse will: a. Provide guidance and information to promote and implement the respiratory protection program. b. Provide training and guidance upon request concerning the safe use of respirators in dangerous atmospheres. c. Review the respiratory protection program periodically and conduct on-site evaluations to ensure it is functioning well, that maximum protection is provided to the user and to determine the feasibility of engineering controls, and advise the State Safety Manger of the findings. d. Maintain and provide the Safety Office and user directorate with updates of all operations by location, at which respiratory protective equipment is required. e. Conduct sampling for air quality on all sources of supplies air. f. Evaluate personnel assigned or being considered for tasks requiring the use of respiratory protective equipment to ensure they are physically and physiologically capable of wearing respiratory equipment. g. Periodically monitor personnel required to use respiratory protection, maintain a record of the monitoring and recommend action when the monitoring indicates an abnormal finding. h. Perform required fit testing upon issue of respirators and maintain records of all individuals fitted. i. Inspect respiratory equipment for damage and cleanliness. 2-4 Support Personnel Management Office will: a. Provide support to supervisors and other individuals responsible for ensuring or enforcing the requirements of the Respiratory Protection Program.

5 b. Refer personnel being considered for employment in areas or at operations requiring the use of respiratory protective equipment to the Occupational Health nurses for evaluation Commander/supervisors will: a. Ensure that personnel being interviewed for positions requiring the use of respiratory protection are aware of this requirement, the reason for the requirement and the importance of complying with the requirement. b. Ensure users receive initial and periodic medical monitoring as recommended by the Occupational Health Nurse. c. Ensure users are supplies appropriate respiratory protection equipment and use and care for the equipment correctly. d. Report all operations at which a need for respiratory protection equipment is suspected to the State Safety Office. e. Ensure that users are award the respirators are personal property and should not be use by other because of hygiene reasons and improper fitting. f. Provide a location for proper storage of respiratory protective equipment Users of respiratory protection equipment will: a. Wear and care for respiratory protection equipment in accordance with TB Med 502 paragraph 2-7. b. Ensure that the device is clean of all visible contaminate acquired during the performance of work on a daily basis. c. Ensure that such devices are properly stored so that face pieces and other parts rest in their normal positions without deformation. d. Inspect the respirator for fit and to ensure it is in good operating condition. e. Ensure the wearing of respiratory protection devices in hazardous environments. f. Report to supervisor and/or the Safety Office suspected hazards or conditions. BY ORDER OR THE GOVERNOR: ROBERT F. ENSSLIN, JR Major General, FLARNG The Adjutant General

6 OFFICIAL: FRANKLIN M. PERSONS Colonel, INF, FLARNG Director, Administration DISTRIBUTION: A

7 GLOSSARY OF TERMS Approved: Tested and listed as satisfactory by the National Institute for Occupational Safety and Health (NIOSH) or the Mine Safety and Health Administration (MSHA). Contaminant: A harmful, irritating or nuisance material in concentrations exceeding those normally found in the ambient air. Disinfection: The destruction of pathogenic organisms, especially by means of chemical substances. Immediately Dangerous to Life or Health: A condition posing an immediate threat to life or health, or an immediate threat of severe exposure to contaminants likely to have adverse delayed effects on health. This condition includes atmospheres where oxygen content by volume is less than 16 percent. Intermittent Use of Respiratory Protective Equipment: Operations performed less than 1 hour per day for 1 day a week. Oxygen-Deficient Atmosphere: volume. An atmosphere containing 19.5 percent or less oxygen by Permanent Use of Respiratory Protective Equipment: Operations performed greater than 1 hour a day for 1 day a week. Respirator: An approved device designed to provide the wearer with respiratory protection against inhalation of airborne contaminants and for some devices, oxygen-deficient atmospheres. Respiratory Equipment Categories: Respiratory equipment used to protect workers from airborne contaminants (and oxygen-deficient atmosphere) fall under one (or more) of the following categories: a. Air Purifying respirators: (1) participate removing (2) gas and vapor removing (3) combination participate and gas and vapor removing b. Atmospheric supplying respirators: (1) Supplies - air (a) Airline respirator demand regulator pressure-demand regulator continuous flow regulator

8 (b) Hose Mask with blower without blower (2) Self-Contained breathing apparatus (SCBA) (a) (b) pressure-demand regulator demand regulator c. Combination air purifying and atmosphere supplying d. Combination supplied air and self-contained breathing apparatus. Supervisor: Individual directly responsible for the supervision and administration of work duties and performance evaluation of workers performing operations where actual or potential exposure to atmospheric contaminants. User: Any individual who uses respiratory protective equipment. (Does not include the use of an apparatus intended to protect the ambient air from contamination, i.e., use of a surgical mask in a surgical suite.)

A. Evaluation of the written program

A. Evaluation of the written program A. Evaluation of the written program Begin your audit with an evaluation of the written respiratory protection program. In addition to the operating procedures describing respirator selection and use in

More information

RESPIRATORY PROTECTION PROGRAM

RESPIRATORY PROTECTION PROGRAM RESPIRATORY PROTECTION PROGRAM Compliant to 29 CFR 1910.134 NEW MEXICO STATE UNIVERSITY Las Cruces, New Mexico Environmental, Health & Safety (EH&S) 505-646-3327 http://safety.nmsu.edu NMSU Respiratory

More information

ALBUQUERQUE PUBLIC SCHOOLS RESPIRATORY PROTECTION PROGRAM

ALBUQUERQUE PUBLIC SCHOOLS RESPIRATORY PROTECTION PROGRAM ALBUQUERQUE PUBLIC SCHOOLS RESPIRATORY PROTECTION PROGRAM Risk Management Department August, 2008 ALBUQUERQUE PUBLIC SCHOOLS RISK MANAGEMENT DEPARTMENT RESPIRATORY PROTECTION PROGRAM TABLE OF CONTENTS

More information

Respiratory Protection

Respiratory Protection Respiratory Protection Purpose The purpose is to establish a set of guidelines for the selection of respiratory protection equipment, situations for its use, and training in the use of the respirator required.

More information

c. Supervisors/commanders will provide proper personal protective clothing and equipment for employees.

c. Supervisors/commanders will provide proper personal protective clothing and equipment for employees. Chapter 9 Personal Protective Equipment Program 9-1. General a. OSHA standards require that employers assess the workplace to determine if hazards are present which necessitate the use of PPE and clothing.

More information

University of Dayton Respiratory Protection Program 29 CFR

University of Dayton Respiratory Protection Program 29 CFR University of Dayton Respiratory Protection Program 29 CFR 1910.134 What to expect from this training: Employees who are required to use respirators must be trained such that they can demonstrate knowledge

More information

Cabinet. 1.0 POLICY It is the policy of Calvin College to comply with the MIOSHA Respiratory Protection Standard Part 451.

Cabinet. 1.0 POLICY It is the policy of Calvin College to comply with the MIOSHA Respiratory Protection Standard Part 451. Calvin College Respiratory Protection Program Prepared by: Date: Heather Chapman 10/7/10 Approved by: Cabinet Revision 2 Date: 1.0 POLICY It is the policy of Calvin College to comply with the MIOSHA Respiratory

More information

City of Kalispell RESPIRATOR PROTECTION POLICY October 12, 2015

City of Kalispell RESPIRATOR PROTECTION POLICY October 12, 2015 A. Executive Summary and Introduction City of Kalispell RESPIRATOR PROTECTION POLICY October 12, 2015 1. Annual fit test is required for all employees who will be required to wear a respirator as a part

More information

RESPIRATORY PROTECTION PROGRAM

RESPIRATORY PROTECTION PROGRAM A P P E N D I X 14 RESPIRATORY PROTECTION PROGRAM AP14.1. Purpose. AP14.2. Policy. To establish a written Respiratory Protection Program for CBP. The purpose of an effective respirator program is to provide

More information

RESPIRATORY PROTECTION PROCEDURE

RESPIRATORY PROTECTION PROCEDURE RESPIRATORY PROTECTION PROCEDURE 1. PURPOSE The purpose of this procedure is to protect the health and safety of University faculty and staff who work in areas that may have irritating or hazardous atmospheres.

More information

6A.004 SCBA MAINTENANCE. Policy Number. Page 1 of 5 SCOPE

6A.004 SCBA MAINTENANCE. Policy Number. Page 1 of 5 SCOPE SCBA MAINTENANCE SCOPE Stoney Point Fire Department Self-contained breathing apparatus provides respiratory protection under conditions of oxygen deficiency or in concentrations of toxic gases immediately

More information

RESPIRATORY PROTECTION PROGRAM OSHA Respiratory Protection

RESPIRATORY PROTECTION PROGRAM OSHA Respiratory Protection RESPIRATORY PROTECTION PROGRAM 1910.134 OSHA Respiratory Protection Table of Contents Introduction... 3 Scope... 3 Definitions... 3 Responsibilities... 5 Voluntary Use... 6 Use Requirements... 6 Program

More information

3 Choosing the Right Respirator

3 Choosing the Right Respirator 3 By: Jeanne Bidwell 3M Occupational Health and Environmental Safety Division Originally published February, 1997 for Plant Engineering Magazine Selecting respirators to help protect workers from airborne

More information

COLUMBUS STATE COMMUNITY COLLEGE EMPLOYEE SAFETY MANUAL

COLUMBUS STATE COMMUNITY COLLEGE EMPLOYEE SAFETY MANUAL COLUMBUS STATE COMMUNITY COLLEGE EMPLOYEE SAFETY MANUAL (Hand, Eye, Face, Head, Foot, and Respiratory) Effective October 15, 1995 Page 1 of 15 Updated September 2010 A. At the request of the College Safety

More information

Westbrook Fire & Rescue Department Standard Operating Procedure

Westbrook Fire & Rescue Department Standard Operating Procedure 2017-103 Respiratory Protection Program Westbrook Fire & Rescue Department Standard Operating Procedure Section: Administrative TOPIC: Respiratory Protection Program NUMBER: 2017-103 ISSUE DATE: December

More information

Respirator Fit Testing DEPARTMENT OF LABOR Information on the Requirements Types of Respirators & Filters

Respirator Fit Testing DEPARTMENT OF LABOR Information on the Requirements Types of Respirators & Filters UNITED STATES Respirator Fit Testing DEPARTMENT OF LABOR Information on the Requirements Types of Respirators & Filters This information is about the respirator fit testing requirements for any worker

More information

FACILITIES MANAGEMENT OFFICE OF ENVIRONMENTAL HEALTH AND SAFETY Respiratory Protection Policy 03/20/15 Last Revision

FACILITIES MANAGEMENT OFFICE OF ENVIRONMENTAL HEALTH AND SAFETY Respiratory Protection Policy 03/20/15 Last Revision FACILITIES MANAGEMENT OFFICE OF ENVIRONMENTAL HEALTH AND SAFETY Respiratory Protection Policy 03/20/15 Last Revision 1.0 Intent: 2.0 Scope: It is the intention of the University at Albany to provide a

More information

Standbys. (Owner: Risk Management Section Supervisor)

Standbys. (Owner: Risk Management Section Supervisor) BTCP/BTRF Standbys (Owner: Risk Management Section Supervisor) Site Safety Standard 5500 Introduction Scope The purpose of this standard is to specify detailed roles and responsibilities of Standby personnel

More information

Respiratory Protection. Program

Respiratory Protection. Program Respiratory Protection Program Respiratory Protection Program Table of Contents A. General B. Selection of Respirators C. Medical Screening D. Fit Testing E. Respirator Use Instructions F. Respirator Inspection

More information

Respiratory Protection

Respiratory Protection Respiratory Protection University of Tennessee Safety Program IH-003 Document Contact: EHS-General Safety Date effective: January 1, 2006 Revision Date: March 1, 2014 Purpose It shall be the policy of

More information

HEARING AND RESPIRATOR PROGRAMS - SECTION 2 Nella Davis-Ray Michigan Department of Labor Lansing, MI

HEARING AND RESPIRATOR PROGRAMS - SECTION 2 Nella Davis-Ray Michigan Department of Labor Lansing, MI DAVIS-RAY 183 HEARING AND RESPIRATOR PROGRAMS - SECTION 2 Nella Davis-Ray Michigan Department of Labor Lansing, MI HEALTH HAZARD CONTROL Personal Protective Rule 3501 - General Equipment Requirements 1.

More information

CHAPTER 15 RESPIRATORY PROTECTION

CHAPTER 15 RESPIRATORY PROTECTION CHAPTER 15 RESPIRATORY PROTECTION 1501. Discussion a. This chapter establishes requirements and responsibilities for an ashore respiratory protection program. Reference 15-1 covers respiratory protection

More information

Respirator Selection Guide

Respirator Selection Guide Unsure about the type of respirator you need? Please use this guide to determine what your best selection may be Click to Begin Warning: This guide is for information purpose only. Users of air purifying

More information

Personnel Protective Equipment

Personnel Protective Equipment Personal Protective Equipment For Law Enforcement Personnel Protective Equipment Course Objectives 1. The participant will be able to choose which respiratory protection should be used for a given hazard.

More information

Standards of Practice Respiratory Protection: Appendix C

Standards of Practice Respiratory Protection: Appendix C Document Authority: EHS Coordinator Standards of Practice Respiratory Protection: Appendix C Document Custodian: EH&S Coordinator Effective Date: 09.01.15 Issuing Dept: College of Agriculture EH&S Next

More information

TEMPLE UNIVERSITY ENVIRONMENTAL HEALTH AND RADIATION SAFETY

TEMPLE UNIVERSITY ENVIRONMENTAL HEALTH AND RADIATION SAFETY Page 1 of 9 ISSUED: 5/00 REVISED: 08/06 Introduction Purpose: In accordance with applicable regulations and Temple University, this policy was developed to minimize exposure to Ethylene Oxide. Applicability

More information

Respiratory Protection Program

Respiratory Protection Program Policy 707 Respiratory Protection Program 707.1 PURPOSE AND SCOPE The is committed to preventing injury and illness in the workplace and makes every effort to protect our employees from harmful airborne

More information

Half Facepiece Respirator Assembly 5000 Series, Dual Cartridge, Disposable

Half Facepiece Respirator Assembly 5000 Series, Dual Cartridge, Disposable Half Facepiece Respirator Assembly 5000 Series, Dual Cartridge, Disposable User Instructions for 3M Organic Vapor Respirator Assembly 5101/5201/5301; 3M Organic Vapor/Acid Gas Respirator Assembly 5103/5203/5303;

More information

Egg Harbor Fire Department and First Responders Standard Operating Policy

Egg Harbor Fire Department and First Responders Standard Operating Policy Egg Harbor Fire Department and First Responders Standard Operating Policy SUBJECT: RESPIRATORY PROTECTION PROGRAM SOP 1206 PURPOSE: SCOPE: To have in place a policy that meets SPS 330.12 (1) (c). This

More information

TEMPLE UNIVERSITY ENVIRONMENTAL HEALTH AND RADIATION SAFETY

TEMPLE UNIVERSITY ENVIRONMENTAL HEALTH AND RADIATION SAFETY Purpose In accordance with applicable regulations and Temple University, this policy was developed to minimize exposure to glutaraldehyde. Applicability This policy is applicable to all Temple University

More information

Texas Department of Insurance. Respiratory Protection. Provided by. Workers Health & Safety HS01-027B (1-06)

Texas Department of Insurance. Respiratory Protection. Provided by. Workers Health & Safety HS01-027B (1-06) Texas Department of Insurance Respiratory Protection Provided by Workers Health & Safety HS01-027B (1-06) Contents Introduction... 3 Definitions... 3 Approved Respirators... 3-4 New Respirator Selection

More information

Protective device that covers the nose and mouth or the entire face or head to guard the wearer against hazardous atmospheres

Protective device that covers the nose and mouth or the entire face or head to guard the wearer against hazardous atmospheres Protective device that covers the nose and mouth or the entire face or head to guard the wearer against hazardous atmospheres Working in an area with insufficient oxygen Situations where harmful dusts,

More information

RESPIRATORY PROTECTION

RESPIRATORY PROTECTION RESPIRATORY PROTECTION OSHA 29 CFR 1910.134 PPT-042-01 1 Respiratory Protection Respirators shall be provided when necessary to protect the health of employees from breathable hazards (should be used as

More information

BREATHE SAFELY: The Proper Use of Respiratory Protection

BREATHE SAFELY: The Proper Use of Respiratory Protection BREATHE SAFELY: The Proper Use of Respiratory Protection This easy-to-use Leader s Guide is provided to assist in conducting a successful presentation. Featured are: INTRODUCTION: A brief description of

More information

Half Facepiece Respirator Assembly 5000 Series, Dual Cartridge, Organic Vapor/P95, Disposable

Half Facepiece Respirator Assembly 5000 Series, Dual Cartridge, Organic Vapor/P95, Disposable Half Facepiece Respirator Assembly 5000 Series, Dual Cartridge, Organic Vapor/P95, Disposable User Instructions for 3M Organic Vapor Respirator, P95 Assembly 51P71/52P71/53P71 Important: Keep these User

More information

Respiratory Protection Program 29CFR

Respiratory Protection Program 29CFR Respiratory Protection Program 29CFR1910.134 Program Objectives OSHA requires employers to establish and implement procedures for the proper use of respirators by doing the following: Verify the need for

More information

SALEM TOWNSHIP FIRE DEPARTMENT RESPIRATORTY PROTECTION PROGRAM

SALEM TOWNSHIP FIRE DEPARTMENT RESPIRATORTY PROTECTION PROGRAM SALEM TOWNSHIP FIRE DEPARTMENT RESPIRATORTY PROTECTION PROGRAM PURPOSE In accordance with Michigan s Occupational Health Standards, Part 451, Respiratory Protection requires that a written Respiratory

More information

West Clinton Fire District

West Clinton Fire District 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 West Clinton Fire District Best Practice Respiratory Protection Program Best

More information

E3628 THE RESPIRATORY PROTECTION PROGRAM: EMPLOYEE TRAINING. Leader s Guide ERI Safety Videos EMPLOYEE TRAINING

E3628 THE RESPIRATORY PROTECTION PROGRAM: EMPLOYEE TRAINING. Leader s Guide ERI Safety Videos EMPLOYEE TRAINING E3628 THE RESPIRATORY PROTECTION PROGRAM: EMPLOYEE TRAINING Leader s Guide 2007 ERI Safety Videos THE RESPIRATORY PROTECTION PROGRAM: EMPLOYEE TRAINING This easy-to-use Leader s Guide is provided to assist

More information

RMM 311 Respiratory Protection Program Page 2 March 2013

RMM 311 Respiratory Protection Program Page 2 March 2013 RMM 311 Respiratory Protection Program Page 2 Z180.1-00 Compressed Breathing Air and Systems. 3.3 NIOSH Standard 42 CFR 84 (1995) for Non Powered Particulate Filtering Respirators 3.4 McMaster University

More information

National Personal Protective Technology Laboratory

National Personal Protective Technology Laboratory National Personal Protective Technology Laboratory Robert Stein CV&SDB/NPPTL/NIOSH Respiratory Protection Let s Clear the Air Quality Partnerships Enhance Worker Safety and Health DISCLAIMER: The findings

More information

Part 18 Personal Protective Equipment

Part 18 Personal Protective Equipment Part 18 Personal Protective Equipment Duty to use personal protective equipment 228(1) If the hazard assessment indicates the need for personal protective equipment, an employer must ensure that (a) workers

More information

The Army Respiratory Protection Program

The Army Respiratory Protection Program Army Regulation 11 34 Army Programs The Army Respiratory Protection Program Headquarters Department of the Army Washington, DC 15 February 1990 Unclassified Report Documentation Page Report Date 15 Feb

More information

Key Technology, Inc. Confined Space Entry Program. July, 2017

Key Technology, Inc. Confined Space Entry Program. July, 2017 Key Technology, Inc. Confined Space Entry Program July, 2017 Page 1 of 11 Key Technology, Inc. CONFINED SPACE ENTRY PROGRAM OVERVIEW Purpose: The purpose of this program is to ensure the protection of

More information

RESPIRATORY PROTECTION SAFETY PROGRAM

RESPIRATORY PROTECTION SAFETY PROGRAM RESPIRATORY PROTECTION SAFETY PROGRAM REGULATORY STANDARD: OSHA - 29 CFR 1910.134-29 CFR 1926.103 ANSI - Z88.2 BASIS: About 32 million workers are potentially exposed to one or more chemical hazards on

More information

COMPLIANCE WITH THIS PUBLICATION IS MANDATORY

COMPLIANCE WITH THIS PUBLICATION IS MANDATORY BY ORDER OF THE COMMANDER TINKER AIR FORCE BASE TINKER AIR FORCE BASE INSTRUCTION 48-103 2 SEPTEMBER 2015 Aerospace Medicine RESPIRATORY PROTECTION PROGRAM COMPLIANCE WITH THIS PUBLICATION IS MANDATORY

More information

This program shall contain, as a minimum, the following components:

This program shall contain, as a minimum, the following components: Section 1: Introduction 1.1 Policy It is the policy of the Pemberton Township Fire Department to maintain comprehensive safety and occupational health programs predicted upon sound engineering, education,

More information

DEPARTMENT OF THE ARMY III CORPS & FH REG HEADQUARTERS, III CORPS AND FORT HOOD Fort Hood, Texas May 1994

DEPARTMENT OF THE ARMY III CORPS & FH REG HEADQUARTERS, III CORPS AND FORT HOOD Fort Hood, Texas May 1994 DEPARTMENT OF THE ARMY III CORPS & FH REG 385-5 HEADQUARTERS, III CORPS AND FORT HOOD Fort Hood, Texas 76544-5056 1 May 1994 Safety RESPIRATORY PROTECTION PROGRAM HISTORY. This regulation supersedes III

More information

BGC HOLDINGS LTD RESPIRATORY PROTECTIVE EQUIPMENT (RPE) POLICY

BGC HOLDINGS LTD RESPIRATORY PROTECTIVE EQUIPMENT (RPE) POLICY BGC HOLDINGS LTD RESPIRATORY PROTECTIVE EQUIPMENT (RPE) POLICY Introduction This document sets out the Health & Safety arrangements we have established for BGC Holdings Ltd, and all subsidiary and associated

More information

Respiratory Protection Self Inspection Checklist

Respiratory Protection Self Inspection Checklist Optional Information Name of School: Date of Inspection: Vocational Program/Course/Room: Signature of Inspector: Respiratory Protection Self Inspection Checklist Guidelines: This checklist covers some

More information

East Brunswick Fire District #1

East Brunswick Fire District #1 Old Bridge Volunteer Fire Company East Brunswick Fire District #1 Standard Operating Guidelines Title: Respiratory Protection Act Function: Procedure Number: Implementation Date: 12/01/2016 Page Number:

More information

The Following information is based on material prepared by the American Lung Association

The Following information is based on material prepared by the American Lung Association The Following information is based on material prepared by the American Lung Association RESPIRATORY PROTECTION FROM INHALATION HAZARDS The inhalation of harmful dusts, toxic gases and vapors at fire and

More information

HEALTH AND SAFETY MANUAL

HEALTH AND SAFETY MANUAL HEALTH AND SAFETY MANUAL Title: Hydrogen Sulfide (H 2 S) Safety Approved by: Greg Savoy Rev. 4/1/08 1 Purpose/Scope: The purpose of this program is to establish minimum requirements for site specific H

More information

SOUTH LYON FIRE DEPARTMENT Manual of Procedures 300

SOUTH LYON FIRE DEPARTMENT Manual of Procedures 300 RESPIRATORY PROTECTION PROGRAM Issued Date: March 23, 2011 Revised: March 25, 2016 Approved: Chief Mike Kennedy I. SCOPE General Industry standard 1910.134 of the Michigan Occupational Health Standards

More information

Personal Protective Equipment

Personal Protective Equipment Northland Community & Technical College June 1, 2017 Personal Protective Equipment Safety Officer Cory Feller Chemical Hygiene Officer Kristel Kizer Telephone: 218-683-8633 1 Personal Protective Equipment

More information

RPE with a UK Standard Assigned Protection Factor 10 (APF10)

RPE with a UK Standard Assigned Protection Factor 10 (APF10) Health and Safety Executive R COSHH essentials: Supplementary advice RPE with a UK Standard Assigned Protection Factor 10 (APF10) Control approach R Respiratory protective equipment (RPE) The Control of

More information

1 Purpose. 2 Responsibilities. 3 Policy Content ENVIRONMENTAL, HEALTH AND SAFETY STANDARDS. TITLE: CONFINED SPACE ENTRY Document Number: *

1 Purpose. 2 Responsibilities. 3 Policy Content ENVIRONMENTAL, HEALTH AND SAFETY STANDARDS. TITLE: CONFINED SPACE ENTRY Document Number: * (Insert Company Logo) CORPORATE SAFETY MANUAL ENVIRONMENTAL, HEALTH AND SAFETY STANDARDS TITLE: CONFINED SPACE ENTRY Document Number: * Issue Date: Revision Date: * 1 Purpose The purpose of this policy

More information

Personal Protective Equipment 29 CFR 1926

Personal Protective Equipment 29 CFR 1926 Personal Protective Equipment 29 CFR 1926 OSHA- PPE http://www.osha.gov/publications/osha31 51.html NIOSH s Protective Clothing Web Page http://www.cdc.gov/niosh/npptl/topics/prot clothing/ 1926.95 PPE

More information

BP U.S. Pipelines & Logistics (USPL) Safety Manual Page 1 of 8

BP U.S. Pipelines & Logistics (USPL) Safety Manual Page 1 of 8 Safety Manual Page 1 of 8 1. Purpose The purpose of this policy is to protect USPL employees and contractors from overexposure to benzene. 2. Scope This policy applies to all USPL employees and contractors

More information

OSHA s Respiratory Protection Standard 29 CFR

OSHA s Respiratory Protection Standard 29 CFR OSHA s Respiratory Protection Standard 29 CFR 1910.134 This program is intended to be a resource for instructors of occupational safety and health and is not a substitute for any of the provisions of the

More information

Respiratory Protection Programs Policy

Respiratory Protection Programs Policy Applicable Legislation: Occupational Health and Safety Act (OHSA), R.S.O. 1990, Sections 25 to 28 O. Reg. 851, R.R.O. 1990, Industrial Establishments, 79, 127, 128(2)(b), 130, 137, 138 O. Reg. 833/90 Control

More information

OSHA s Respiratory Protection Standard 29 CFR

OSHA s Respiratory Protection Standard 29 CFR OSHA s Respiratory Protection Standard 29 CFR 1910.134 This program is intended to be a resource for instructors of occupational safety and health and is not a substitute for any of the provisions of the

More information

3M Select Software United Kingdom and Ireland

3M Select Software United Kingdom and Ireland 3M Select Software United Kingdom and Ireland Introduction to Select and Service Life Software 3M Select Software is designed to help you choose the appropriate 3M respirator for your work environment.

More information

In addition to the responsibility for managing the elements of the respiratory protection program, he/she will be responsible for:

In addition to the responsibility for managing the elements of the respiratory protection program, he/she will be responsible for: EBBE (1 of 7) EBBE RESPIRATORY PROTECTION POLICY The Muskogee School District is acknowledged as the employer, and as outlined under current Federal regulations, is assigned the responsibility to provide

More information

HOW TO USE A RESPIRATOR

HOW TO USE A RESPIRATOR HOW TO USE A RESPIRATOR A FACT SHEET FOR HURRICANE SANDY CLEANUP WORKERS WHAT IS A RESPIRATOR? A respirator is a type of personal protective equipment (PPE). It is worn over the nose and mouth. Some respirators

More information

Respiratory Protective Equipment Program Appendix A - Definitions and Key Terms

Respiratory Protective Equipment Program Appendix A - Definitions and Key Terms Definitions include those from OSHA Sec. 1910.134(b), NIOSH, and ANSI ACGIH Aerosol Air-Purifying Respirator (APR) American National Standards Institute (ANSI) Approved Assigned Protection Factor (APF)

More information

Respiratory Protection Program

Respiratory Protection Program Respiratory Protection Program General It is necessary to protect persons who may be exposed to harmful mists, smoke, vapors, aerosols, pathogens, etc. or to an oxygen deficient atmosphere. Whenever possible,

More information

Respiratory Protection Written Program

Respiratory Protection Written Program Respiratory Protection Written Program Month/Year Started *This document has been modified to conform with the amended respiratory protection regulations that will take affect January 1, 2008. Major changes

More information

Entry to these spaces must be rigorously controlled to prevent serious injury or death.

Entry to these spaces must be rigorously controlled to prevent serious injury or death. Chapter 6 - Confined Spaces Chapter 6 Confined Spaces Definitions A confined space is defined as any structure that must be entered and that has or may contain dangerous concentrations of hazardous gases

More information

Scope: This plan applies to all personnel, including contractors, who enter or work in confined spaces, or supervise such activities.

Scope: This plan applies to all personnel, including contractors, who enter or work in confined spaces, or supervise such activities. 11/13/1995 4 5/20/2013 1 of 10 Authority and Scope Regulation: 29 CFR 1910.146 Scope: This plan applies to all personnel, including contractors, who enter or work in confined spaces, or supervise such

More information

HAZARDOUS WASTE OPERATIONS AND EMERGENCY RESPONSE

HAZARDOUS WASTE OPERATIONS AND EMERGENCY RESPONSE Page 1 of 10 HAZARDOUS WASTE OPERATIONS AND EMERGENCY RESPONSE 1.0 SCOPE This Performance Assessment Guide for Hazardous Waste Operations and Emergency Response (HAZWOPER) will be used to carry out the

More information

Health & Safety Policy and Procedures Manual SECTION 34 HYDROGEN SULFIDE (H2S) PROGRAM

Health & Safety Policy and Procedures Manual SECTION 34 HYDROGEN SULFIDE (H2S) PROGRAM SECTION 34 HYDROGEN SULFIDE (H2S) PROGRAM 1. REGULATORY STANDARD: OSHA - 29 CFR 1910.1200 and 1926.55 Purpose: The purpose of this program is to inform interested persons, including employees, that Maul

More information

RESPIRATORY PROTECTION PROGRAM

RESPIRATORY PROTECTION PROGRAM RESPIRATORY PROTECTION PROGRAM A. Introduction: Due to the potential risks involved from exposure to hazardous substances and atmospheres, UNE has developed a Respiratory Protection Program to protect

More information

POLICY AND PROCEDURE DIVISION OF FIRE AND RESCUE SERVICES

POLICY AND PROCEDURE DIVISION OF FIRE AND RESCUE SERVICES Page 1 o Page 1 of 12 RESPIRATORY PROTECTION POLICY Issued by: Fire Chief Policy No. 26-06AM Authority: Code Section 21-2.(d)(4) Effective Date: April 15, 2005 SUMMARY: ADDRESS: STAFF: BACKGROUND: This

More information

"RESPIRATORY PROTECTION AND SAFETY"

RESPIRATORY PROTECTION AND SAFETY PRESENTER'S GUIDE "RESPIRATORY PROTECTION AND SAFETY" Training for the OSHA RESPIRATORY PROTECTION STANDARD Quality Safety and Health Products, for Today...and Tomorrow OUTLINE OF MAJOR PROGRAM POINTS

More information

HAZWOPER 8-Hr Refresher Aug. 20, 2012

HAZWOPER 8-Hr Refresher Aug. 20, 2012 Institute for Tribal Environmental Professionals Tribal Lands and Environment: A National Forum on Solid Waste, Emergency Response, Contaminated Sites and USTs August 20-23, 2012 Coos Bay, Oregon HAZWOPER

More information

CONFINED SPACE ENTRY PROGRAM

CONFINED SPACE ENTRY PROGRAM CONFINED SPACE ENTRY PROGRAM 2003 ENVIRONMENTAL HEALTH AND SAFETY/RISK MANAGEMENT p1 Rev. 01/07/2003 wrk Environmental Health and Safety/Risk Management CSUCI Confined Space Entry Program TABLE OF CONTENTS

More information

Title: Hexavalent Chromium Compliance. Preparer: Owner: Approver: Texas EHS EHS Team Member

Title: Hexavalent Chromium Compliance. Preparer: Owner: Approver: Texas EHS EHS Team Member Procedure No.: PA-020-0059 Page: 1 of 8 Port Arthur, TX. Reviewed: 06/18 Effective: 08/01/18 Supersedes: 03/12/12 (Rev. 2) Preparer: Owner: Approver: Texas EHS Hub Team Members EHS Team Member EHS Manager

More information

Chapter 16 - Protective Equipment

Chapter 16 - Protective Equipment Chapter 16 Protective Equipment Chapter 16 - Protective Equipment Introduction Hayward Electric will provide suitable equipment to protect employees from hazards in the workplace. The Responsible Safety

More information

Australian/New Zealand Standard

Australian/New Zealand Standard AS/NZS 1715:2009 AS/NZS 1715:2009 Australian/New Zealand Standard Selection, use and maintenance of respiratory protective equipment AS/NZS 1715:2009 This Joint Australian/New Zealand Standard was prepared

More information

Certification of Occupational Hazard Assessment:

Certification of Occupational Hazard Assessment: STATE OF NORTH CAROLINA DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES DIVISION OF WASTE MANAGEMENT Solid Waste Section PERSONAL PROTECTION EQUIPMENT PROGRAM AND HAZARD ASSESMENT Certification of Occupational

More information

Brown County EZ Explanation for Respiratory Protection

Brown County EZ Explanation for Respiratory Protection Brown County EZ Explanation for Respiratory Protection 1910.134 Memorandum of Understanding Background Respiratory protection is of primary importance since inhalation is one of the major routes of exposure

More information

SAFETY AND HEALTH INDUSTRIAL HYGIENE Hazard Communication Program Effective Date: 08/07/14 Standard: 10.1 Document Number: KUSHIH0008 Rev: 01

SAFETY AND HEALTH INDUSTRIAL HYGIENE Hazard Communication Program Effective Date: 08/07/14 Standard: 10.1 Document Number: KUSHIH0008 Rev: 01 Introduction: This Hazard Communication (HazCom) Program manual was designed to meet the requirements of OSHA 29 CFR 1910.1200, MSHA 30 CFR Part 47, and all Rio Tinto Kennecott Copper (RTKC) standards.

More information

Doc #: 1000-AD Revision: - PERSONAL PROTECTIVE EQUIPMENT (PPE) SOP. Author(s): T. Lavoie/ M. Saucedo/ J. Dunlop/ Mtn.

Doc #: 1000-AD Revision: - PERSONAL PROTECTIVE EQUIPMENT (PPE) SOP. Author(s): T. Lavoie/ M. Saucedo/ J. Dunlop/ Mtn. Doc #: 1000-AD-015-0008 Revision: - PERSONAL PROTECTIVE EQUIPMENT (PPE) SOP Author(s): T. Lavoie/ M. Saucedo/ J. Dunlop/ Mtn. Supervisor TABLE OF CONTENTS REVISION HISTORY... 3 1.0 INTRODUCTION... 4 2.0

More information

University of Alabama Office of Environmental Health and Safety. Respirator Protection Training

University of Alabama Office of Environmental Health and Safety. Respirator Protection Training University of Alabama Office of Environmental Health and Safety Respirator Protection Training Medical Reasons That Could Prohibit the Use of a Respirator A history of pulmonary or lung problems such as:

More information

PPE Refresher- Levels of Protection

PPE Refresher- Levels of Protection PPE Refresher- Levels of Protection The combination of respiratory and chemical protective clothing is described as Levels of Protection A, B or C. Level D is work clothes; these provide no respiratory

More information

PERSONAL PROTECTIVE EQUIPMENT

PERSONAL PROTECTIVE EQUIPMENT C H A P T E R 9 PERSONAL PROTECTIVE EQUIPMENT 9.1. General Personal protective equipment (PPE) when properly used and maintained saves lives and reduces injury and illness. PPE includes equipment for eyes,

More information

ANSI / ASSE Z88.2 American National Standard Practices for Respiratory Protection (1992 rev. versus 2015 rev.)

ANSI / ASSE Z88.2 American National Standard Practices for Respiratory Protection (1992 rev. versus 2015 rev.) ANSI / ASSE Z88.2 BACKGROUND: A substantial body of research has been published since the 1992 revision of Z88.2. This information related to the proper use and performance of respiratory protection in

More information

TABLE OF CONTENTS PART 2 - CONFINED SPACES

TABLE OF CONTENTS PART 2 - CONFINED SPACES May 11, 2006 TABLE OF CONTENTS PART 2 - CONFINED SPACES Page DEFINITIONS... 2-1 GENERAL... 2-2 RESPONSIBILITIES... 2-2 HAZARD ASSESSMENT AND WORK PROCEDURES... 2-3 IDENTIFICATION AND ENTRY PERMITS... 2-3

More information

CHAPTER 4 PERSONAL PROTECTIVE EQUIPMENT

CHAPTER 4 PERSONAL PROTECTIVE EQUIPMENT CHAPTER 4 PERSONAL PROTECTIVE EQUIPMENT Section 1. Head Protection. (a) An approved helmet (safety hard hat) shall be required to be worn by all employees while within working areas, with the exception

More information

Respiratory Protection Self-Inspection Checklist

Respiratory Protection Self-Inspection Checklist Respiratory Protection Self-Inspection Checklist Guidelines: This checklist applies to the use of either atmosphere-supplying or air-purifying respirators being worn, voluntarily or otherwise, for comfort

More information

Occupational Safety and Health Administration

Occupational Safety and Health Administration Occupational Safety and Health Administration Standard Number: 1910.134; 1910.1053; 1910.1200; 1926.1153; 1926.1153(c); 1926.1153(c)(1); 1926.1153(d); 1926.1153(d)(1); 1926.1153(d)(2); 1926.1153(d)(2)(iii)(B);

More information

Tremont Volunteer Fire Department Respiratory Protection Plan

Tremont Volunteer Fire Department Respiratory Protection Plan Tremont Volunteer Fire Department Respiratory Protection Plan PURPOSE: This respiratory protection program is designed to provide a standard operating policy for the Tremont Volunteer Fire Department (TVFD).

More information

RESPIRABLE CRYSTALLINE SILICA PROGRAM July 2018

RESPIRABLE CRYSTALLINE SILICA PROGRAM July 2018 RESPIRABLE CRYSTALLINE SILICA PROGRAM July 2018 A. SCOPE The Respirable Crystalline Silica Program is established in accordance with 29 CFR 1910.1053 and 29 CFR 1926.1153, Respirable Crystalline Silica.

More information

EH&S Program Occupational Safety Next Review: 5/9/19. Scope: University Wide Original date created: 2006

EH&S Program Occupational Safety Next Review: 5/9/19. Scope: University Wide Original date created: 2006 Environmental Health & Safety Policy and Procedure Subject: Confined Space Entry Policy & Procedure Published Date: 5/9/18 EH&S Program Occupational Safety Next Review: 5/9/19 Scope: University Wide Original

More information

A. APPLICATIONS 1. WARNING TO USER

A. APPLICATIONS 1. WARNING TO USER IV. MOLDEX INDUSTRIAL 42 CFR 84 DISPOSABLE RESPIRATOR USER INSTRUCTIONS Each specific model may contain additional warnings and instructions. You MUST refer to the packaging for specific instructions.

More information

PERSONAL PROTECTIVE EQUIPMENT

PERSONAL PROTECTIVE EQUIPMENT 0 PERSONAL PROTECTIVE EQUIPMENT Supplement to Standard Training Module TRAINING REQUIREMENTS OVERVIEW This standard Vivid training module provides a general overview of Personal Protective Equipment (PPE).

More information

Respiratory Protection Program

Respiratory Protection Program Respiratory Protection Program Occupational Health, Safety & Injury Prevention Subject Matter Expert Brandi E. Kissel bek66@cornell.edu 607-882-5273 Page 1 of 15 Contents 1.0 INTRODUCTION...2 2.0 OBJECTIVES

More information

Helping protect people At work, at home, for life

Helping protect people At work, at home, for life Helping protect people At work, at home, for life DIOSH Days: Respiratory Protection-General Overview February 29, 2012 3M 2010. All Rights Reserved. Agenda: Introduction General Overview Types of Hazards

More information

APPLICIPABLE STANDARD: OSHA 29 CFR Confined Space Entry

APPLICIPABLE STANDARD: OSHA 29 CFR Confined Space Entry Northeast Biomanufacturing Center and Collaborative Confined Space Entry (CSE) Program NBC-CSE-000 APPLICIPABLE STANDARD: OSHA 29 CFR 1910.146 Confined Space Entry Document Contents SECTION CONTENT A Scope

More information