Safety Data Sheet SKINTEGRITY HYDROGEL

Transcription

1 Safety Data Sheet SKINTEGRITY HYDROGEL Section 1. Identification Product Identifier Synonyms Manufacturer Stock Numbers Recommended use Uses advised against Manufacturer Contact Address SKINTEGRITY HYDROGEL MSC6102; MSC6104; MSC6022; MSC6044; MSC6144; MSD_SDS0031 MSC6102; MSC6104; MSC6022; MSC6044; MSC6144 For use on pressure and stasis ulcers, first and second degree burns, cuts and skin irritations. Medline Industries, Inc. One Medline Place Mundelein, IL, USA Section 2. Hazards Identification Phone Emergency Phone Fax (800) (800) CHEMTREC (847) Website Classification Signal Word Pictogram Hazard Statements Precautionary Statements Response Prevention Storage Disposal Ingredients of unknown toxicity No OSHA Hazard Classifications Applicable - Category No OSHA Hazard Classifications Applicable 0% Page 1 of 7

2 Hazards not Otherwise Classified None known. Section 3. Ingredients CAS Ingredient Name Weight % Aloe Barbadensis Leaf Juice Proprietary % Water Proprietary % Urea, (2,5-dioxo-4-imidazolidinyl)- Proprietary % Glycine, N,N'-1,2-ethanediylbis[N-(carboxymethyl)-, disodium salt Proprietary % ,2,3-Propanetriol Proprietary % Benzoic acid, 4-hydroxy-, methyl ester Proprietary % D-Glucitol Proprietary % Propenoic acid, homopolymer Proprietary % Urea, N,N''-methylenebis[N'-[3-(hydroxymethyl)-2,5-dioxo-4-imidazolidinyl]- Proprietary % Ethanol, 2,2',2''-nitrilotris- Proprietary % Occupational exposure limits, if available, are listed in Section 8. Section 4. First-Aid Measures General Advice: Eye Contact: Skin Contact: Inhalation Ingestion: Take proper precautions to ensure your own health and safety before attempting rescue and providing first aid. Consult a physician. Show this safety data sheet to the doctor in attendance. Move out of dangerous area. Flush eyes with large amounts of water for at least 15 minutes. Remove contact lenses, if worn. If irritation persists, seek medical attention. If irritation develops wash area with water. Get medical attention if irritation persists. Remove to fresh air. If not breathing, give artificial respiration. If breathing is difficult, give oxygen. If signs/symptoms continue, get medical attention. Never give anything by mouth to an unconscious person. Consult a physician if necessary. Section 5. Fire Fighting Measures Suitable Extinguishing Media Unsuitable Extinguishing Media Unusual Fire and Explosion Hazards: Special Fire Fighting Procedures: In case of fire, use Dry Chemical, Foam, Carbon Dioxide (CO2), Water spray None known Page 2 of 7

3 Section 6. Accidental Release Measures Non-hazardous Small Spill: Non-hazardous Large Spill: Should be cleaned up at the time of the spill. Take all necessary precautions and wear any personal protective equipment that is applicable. Dispose of per local and state regulations. Should be cleaned up at the time of the spill. May require special treatment, equipment and/or emergency assistance. Dispose of per local and state regulations. Section 7. Handling and Storage Handling Non-hazardous: Storage Non-hazardous: This product is considered to be an article which does not release or otherwise result in exposure to a hazardous chemical under nomal use conditions. Store in original package. Discard unused portion. Do not reuse. No special storage conditions required. Page 3 of 7

4 Section 8. Exposure Controls/Personal Protection Occupational Exposure Limits Personal Protective Equipment Engineering Controls: Respiratory Protection: Skin Protection: Eye Protection: Other protective equipment: Work/hygienic practices: Ingredient Name ACGIH OSHA PEL STEL TLV Aloe Barbadensis Leaf Juice Water Urea, (2,5-dioxo-4-imidazolidinyl)- Glycine, N,N'-1,2-ethanediylbis[N- (carboxymethyl)-, disodium salt 1,2,3-Propanetriol 10 mg/m3 (mist) Total dust: 15 mg/m3 TWA: 10 mg/m3 Respirable fraction: 5 mg/m3 TWA: 5mg/m3 Benzoic acid, 4-hydroxy-, methyl ester D-Glucitol 2-Propenoic acid, homopolymer Urea, N,N''-methylenebis[N'-[3- (hydroxymethyl)-2,5-dioxo-4-imidazolidinyl]- Ethanol, 2,2',2''-nitrilotris- TWA: 5 mg/m3 Goggles, Gloves, Apron Ventilation. No special respiratory protection is recommended under anticipated conditions of normal use with adequate ventilation. None required for normal use. For prolonged exposure, use appropriate goggles, protective clothing and gloves. None required for normal use. For prolonged exposure, use appropriate goggles, protective clothing and gloves. Not expected to be necessary under normal conditions of use. Where exposure cannot be adequately controlled, use appropriate protective clothing or equipment Handle in accordance with good industrial hygiene and safety practice. Wash thoroughly with soap and water after handling and before eating, drinking, or using tobacco. Safety shower and eye wash should be available close to work areas. Page 4 of 7

5 Section 9. Physical and Chemical Properties Physical State Liquid Color Colorless Odor Odorless Odor Threshold Solubility Partition coefficient Water/n-octanol VOC% Viscosity 50,000 cps Specific Gravity 1.06 Density lbs/gal Pounds per Cubic Foot Flash Point FP Method Ph 6 Melting Point Boiling Point Boiling Range LEL UEL Evaporation Rate Flammability Not Flammable Decomposition Temperature Auto-ignition Temperature Vapor Pressure Vapor Density Section 10. Stability and Reactivity Stability: Reactivity: Incompatibility (Materials to Avoid): Hazardous Decomposition or Byproducts: Hazardous Polymerization Conditions to avoid: Stable. No reactivity expected under normal conditions None known. None known. None known Section 11. Toxicological Information Acute Toxicity: Eye Contact Not expected to be irritating or hazardous. Acute Toxicity: Skin Contact Not expected to be irritating or hazardous. Acute Toxicity: Inhalation Not expected to be irritating or hazardous. Acute Toxicity: Ingestion Carcinogenicity: IARC listed: Diethanolamine (CAS ) IARC 2B OSHA STEL: ACGIH TLV: Page 5 of 7

6 Section 12. Ecological Information Toxicity: Persistence and degradability: Bioaccumulative potential: Mobility in soil: Other adverse effects: Section 13. Disposal Waste Disposal: Waste must be disposed of in accordance with federal, state and local environmental control regulations. Waste Code: No hazardous goods. Section 14. Transport Information UN Number UN Proper Shipping Name DOT Classification Packing Group Not Regulated Not Regulated Not Regulated Section 15. Regulatory Information SARA 311/312: SARA 302: SARA 313: TSCA: CERCLA Hazardous Substance List: Clean Air Act (CAA) Section 112, 112 (r): New Jersey Right to Know Components: Pennsylvania Right to Know Components: Triethanolamine CAS-No Ethanol, 2,2',2"-nitrilotris-. Page 6 of 7

7 Section 16. Other Information Revision Date 5/26/2015 Legend - Not Applicable N.E. - Not Established - Not Determined HMIS (U.S.A.): Health O Hazard HMIS (U.S.A.): Flammability O HMIS (U.S.A.): Reactivity O National Fire Protection O Association (U.S.A): Health Hazard National Fire Protection O Association (U.S.A): Flammability National Fire Protection O Association (U.S.A): Instability Hazard Additional Information The information contained herein is furnished without warranty or legal responsibility of any kind. Employers should use this information only as a supplement to other information gathered by them and must make independent determination of suitability and completeness of information from all sources to assure proper use of these materials and the safety and health of employees Page 7 of 7