SAFETY DATA SHEET. Section 1: Identification of the substance/mixture and of the company/undertaking. Section 2: Hazards identification

Transcription

1 Sent to: Arco Ltd (NDC) SAFETY DATA SHEET Page: 1 Compilation date: 22/11/2011 Revision No: 7 Section 1: Identification of the substance/mixture and of the company/undertaking 1.1. Product identifier Product name: Product code: Relevant identified uses of the substance or mixture and uses advised against Use of substance / mixture: Solvent mixture containing detergent, Used to degrease. Spray on, allow to penetrate the greasy dirt, and hose off Details of the supplier of the safety data sheet Company name: ARCO LTD P.O. Box 21 Waverley Street HULL East Yorkshire HU1 2SJ Tel: Fax: bridget.roantree@arco.co.uk 1.4. Emergency telephone number Section 2: Hazards identification 2.1. Classification of the substance or mixture Classification under CHIP: Most important adverse effects: -: R52/53; Xn: R65; -: R66 Harmful to aquatic organisms, may cause long-term adverse effects in the aquatic environment. Harmful: may cause lung damage if swallowed. Repeated exposure may cause skin dryness or cracking Label elements Label elements under CHIP: Hazard symbols: Harmful. Risk phrases: R52/53: Harmful to aquatic organisms, may cause long-term adverse effects in the aquatic environment. R65: Harmful: may cause lung damage if swallowed. R66: Repeated exposure may cause skin dryness or cracking.

2 Safety phrases: SAFETY DATA SHEET Page: 2 S36/37: Wear suitable protective clothing and gloves. S61: Avoid release to the environment. Refer to special instructions / safety data sheets. S62: If swallowed, do not induce vomiting: seek medical advice immediately and show this container or label Other hazards Other hazards: PBT: Combustible. This substance does meet the criteria for classification as dangerous in accordance with Directive 1999/45/EC This substance is not identified as a PBT substance. Section 3: Composition/information on ingredients 3.2. Mixtures Contains: Hydrocarbon solvents with detergent Section 4: First aid measures 4.1. Description of first aid measures Skin contact: Eye contact: Ingestion: Inhalation: Remove all contaminated clothes and footwear immediately unless stuck to skin. Drench the affected skin with running water for 10 minutes or longer if substance is still on skin. Transfer to hospital if there are burns or symptoms of poisoning. Bathe the eye with running water for 15 minutes. If irritation persists seek medical advice Do not induce vomiting. If conscious, rinse out mouth with water, and give water to drink Transfer to hospital as soon as possible. Remove casualty from exposure ensuring one's own safety whilst doing so. Move the exposed person to fresh air at once. Get medical attention if any discomfort continues 4.2. Most important symptoms and effects, both acute and delayed Skin contact: Eye contact: Ingestion: Inhalation: There may be irritation and redness at the site of contact. There may be irritation and pain. Nausea and stomach pain may occur. There may be vomiting. There may be loss of consciousness. Convulsions may occur. Exposure may cause coughing or wheezing. There may be congestion of the lungs causing severe shortness of breath. There may be loss of consciousness. Convulsions may occur Indication of any immediate medical attention and special treatment needed Section 5: Fire-fighting measures 5.1. Extinguishing media Extinguishing media: All extinguishing media except water are suitable. Use water spray to cool containers Special hazards arising from the substance or mixture Exposure hazards: In combustion emits toxic fumes.

3 SAFETY DATA SHEET Page: Advice for fire-fighters Advice for fire-fighters: Wear self-contained breathing apparatus. Wear protective clothing to prevent contact with skin and eyes. Section 6: Accidental release measures 6.1. Personal precautions, protective equipment and emergency procedures Personal precautions: Mark out the contaminated area with signs and prevent access to unauthorised personnel. Turn leaking containers leak-side up to prevent the escape of liquid Environmental precautions Environmental precautions: Do not discharge into drains or rivers. Contain the spillage using bunding Methods and material for containment and cleaning up Clean-up procedures: Absorb into dry earth or sand. Use industrial vacuum cleaner to remove material. Wash the spillage site with large amounts of water. Rinse residues away to foul water drain 6.4. Reference to other sections Section 7: Handling and storage 7.1. Precautions for safe handling Handling requirements: Avoid the formation or spread of mists in the air. Avoid direct contact with the substance. Smoking is forbidden Conditions for safe storage, including any incompatibilities Storage conditions: Store away from food and drink. Keep container tightly closed Specific end use(s) Section 8: Exposure controls/personal protection 8.1. Control parameters Workplace exposure limits: 8.2. Exposure controls Engineering measures: Respiratory protection: Hand protection: Eye protection: Skin protection: Ensure there is sufficient ventilation of the area. Breathing Protection may be necessary. Use an air supply or a suitable "gas-mask" If ventilation is poor, Gas/vapour filter, type A: organic vapours (EN141). Plastic or rubber gloves. Safety goggles. Protective clothing with elasticated cuffs and closed neck. Section 9: Physical and chemical properties

4 SAFETY DATA SHEET Page: Information on basic physical and chemical properties State: Liquid Colour: Pale yellow Odour: Characteristic odour Evaporation rate: Slow Solubility in water: Emulsifies with water. Also soluble in: Most organic solvents. Viscosity: Non-viscous Boiling point/range C: Flammability limits %: lower: 0.6 upper: 3 Flash point C: 64 Autoflammability C: about 250 Relative density: about Other information Other information: Section 10: Stability and reactivity Reactivity Chemical stability Chemical stability: Stable under normal conditions Possibility of hazardous reactions Conditions to avoid Conditions to avoid: Sources of ignition Incompatible materials Materials to avoid: Strong oxidising agents Hazardous decomposition products Section 11: Toxicological information Information on toxicological effects Toxicity values: Symptoms / routes of exposure Skin contact: Eye contact: Ingestion: Inhalation: There may be irritation and redness at the site of contact. There may be irritation and pain. Nausea and stomach pain may occur. There may be vomiting. There may be loss of consciousness. Convulsions may occur. Exposure may cause coughing or wheezing. There may be congestion of the lungs causing severe shortness of breath. There may be loss of consciousness. Convulsions may occur.

5 SAFETY DATA SHEET Page: 5 Section 12: Ecological information Toxicity Ecotoxicity values: Persistence and degradability Persistence and degradability: Slowly Biodegradable Bioaccumulative potential Bioaccumulative potential: No bioaccumulation potential Mobility in soil Results of PBT and vpvb assessment PBT identification: This substance is not identified as a PBT substance Other adverse effects Other adverse effects: Harmful to aquatic organisms. Harmful to aquatic systems by forming a surface film preventing access of oxygen Section 13: Disposal considerations Waste treatment methods Disposal operations: Disposal of packaging: NB: Used material should be discharged to a foul water drain Clean with water. Dispose of as normal industrial waste. The user's attention is drawn to the possible existence of regional or national regulations regarding disposal. Section 14: Transport information Transport class: This product does not require a classification for transport. Section 15: Regulatory information Safety, health and environmental regulations/legislation specific for the substance or mixture Chemical Safety Assessment Chemical safety assessment: A chemical safety assessment has not been carried out for the substance or the mixture by the supplier. Section 16: Other information Other information Other information: Phrases used in s.2 and 3: This safety data sheet is prepared in accordance with Commission Regulation (EU) No 453/2010. R52/53: Harmful to aquatic organisms, may cause long-term adverse effects in the aquatic environment.

6 Legal disclaimer: SAFETY DATA SHEET R65: Harmful: may cause lung damage if swallowed. R66: Repeated exposure may cause skin dryness or cracking. The above information is believed to be correct but does not purport to be all inclusive and shall be used only as a guide. This company shall not be held liable for any damage resulting from handling or from contact with the above product. Page: 6 [final page]