SAFETY DATA SHEET. PC35: Washing and cleaning products (including solvent based products).

Transcription

1 Page: 1 Compilation date: 01/08/2008 Revision date: 25/03/2015 Revision No: 7 Section 1: Identification of the substance/mixture and of the company/undertaking 1.1. Product identifier Product name: Product code: Relevant identified uses of the substance or mixture and uses advised against Use of substance / mixture: PC35: Washing and cleaning products (including solvent based products) Details of the supplier of the safety data sheet Company name: Clover Chemicals Ltd Clover House Macclesfield Road Whaley Bridge, High Peak Derbyshire SK23 7DQ UK Tel: +44 (0) Fax: +44 (0) technical@cloverchemicals.com 1.4. Emergency telephone number Emergency tel: NHS 111 NHS Direct Wales ROI (office hours only) Section 2: Hazards identification 2.1. Classification of the substance or mixture Classification under CLP: Most important adverse effects: Skin Corr. 1A: H314; STOT SE 3: H335 Causes severe skin burns and eye damage. May cause respiratory irritation Label elements Label elements: Hazard statements: Signal words: H314: Causes severe skin burns and eye damage. H335: May cause respiratory irritation. Danger

2 Hazard pictograms: SAFETY DATA SHEET GHS05: Corrosion GHS07: Exclamation mark Page: 2 Precautionary statements: 2.3. Other hazards PBT: P102: Keep out of reach of children. P282: Wear eye protection. P280: Wear protective gloves. P260: Do not breathe fumes. P : IF SWALLOWED: rinse mouth. Do NOT induce vomiting. P314: Get medical attention if you feel unwell. P : IF ON SKIN (or hair): Take off immediately all contaminated clothing. Rinse skin with water/shower. P : IF INHALED: Remove person to fresh air and keep comfortable for breathing. P : IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. P : If eye irritation persists: Get medical attention. P362: Take off contaminated clothing. This product is not identified as a PBT/vPvB substance. Section 3: Composition/information on ingredients 3.2. Mixtures HYDROCHLORIC ACID EINECS CAS PBT / WEL CLP Classification Percent Skin Corr. 1B: H314; STOT SE 3: H % DODECYLDIMETHYLAMINE OXIDE Acute Tox. 4: H302; Skin Irrit. 2: H315; Eye Dam. 1: H318; Aquatic Acute 1: H % ALCOHOLS, C12-C14, ETHOXYLATED POLYMER Aquatic Acute 1: H400; Eye Dam. 1: H % Section 4: First aid measures 4.1. Description of first aid measures Skin contact: Remove all contaminated clothes and footwear immediately unless stuck to skin. Wash immediately with plenty of soap and water.

3 Eye contact: Ingestion: Inhalation: SAFETY DATA SHEET Page: 3 Bathe the eye with running water for 15 minutes. Consult a doctor. Wash out mouth with water. If conscious, give half a litre of water to drink immediately. Consult a doctor. Remove casualty from exposure ensuring one's own safety whilst doing so. Consult a doctor Most important symptoms and effects, both acute and delayed Skin contact: Eye contact: Ingestion: Inhalation: Delayed / immediate effects: There may be irritation and redness at the site of contact. There may be irritation and redness. The eyes may water profusely. There may be soreness and redness of the mouth and throat. There may be irritation of the throat with a feeling of tightness in the chest. Exposure may cause coughing or wheezing. Immediate effects can be expected after short-term exposure Indication of any immediate medical attention and special treatment needed Immediate / special treatment: Eye bathing equipment should be available on the premises. Section 5: Fire-fighting measures 5.1. Extinguishing media Extinguishing media: Water Special hazards arising from the substance or mixture Exposure hazards: In combustion emits toxic fumes of hydrogen chloride / phosgene Advice for fire-fighters Advice for fire-fighters: Wear self-contained breathing apparatus. Wear protective clothing to prevent contact with skin and eyes. Section 6: Accidental release measures 6.1. Personal precautions, protective equipment and emergency procedures Personal precautions: Refer to section 8 of SDS for personal protection details. If outside do not approach from downwind. If outside keep bystanders upwind and away from danger point. Mark out the contaminated area with signs and prevent access to unauthorised personnel. Turn leaking containers leak-side up to prevent the escape of liquid Environmental precautions Environmental precautions: Do not discharge into drains or rivers. Contain the spillage using bunding Methods and material for containment and cleaning up Clean-up procedures: Transfer to a closable, labelled salvage container for disposal by an appropriate method Reference to other sections Reference to other sections: Refer to section 8 of SDS.

4 Page: 4 Section 7: Handling and storage 7.1. Precautions for safe handling Handling requirements: Avoid direct contact with the substance. Ensure there is sufficient ventilation of the area. Do not handle in a confined space. Avoid the formation or spread of mists in the air Conditions for safe storage, including any incompatibilities Storage conditions: Suitable packaging: Store in a cool, well ventilated area. Keep container tightly closed. Polyethylene Specific end use(s) Specific end use(s): No data available. Section 8: Exposure controls/personal protection 8.1. Control parameters HYDROCHLORIC ACID...100% Workplace exposure limits: Respirable dust State 8 hour TWA 15 min. STEL 8 hour TWA 15 min. STEL UK 1 ppm ; 2mg/m3 5 ppm ; 8mg/m3 - - DNEL/PNEC Values DNEL / PNEC No data available Exposure controls Engineering measures: Respiratory protection: Hand protection: Eye protection: Skin protection: Ensure there is sufficient ventilation of the area. Gas/vapour filter, type E: sulphur dioxide and other acid gases (EN141). Protective gloves. Gloves (acid resistant). Breakthrough time of the glove material > 1 hour. Safety glasses. Ensure eye bath is to hand. Acid-resistant protective clothing. Section 9: Physical and chemical properties 9.1. Information on basic physical and chemical properties State: Liquid Colour: Beige Odour: Pungent Evaporation rate: Moderate Oxidising: Non-oxidising (by EC criteria) Solubility in water: Soluble Viscosity: Non-viscous Boiling point/range C: 100 Melting point/range C: <0 Flammability limits %: lower: Not applicable.

5 upper: Not applicable. Flash point C: Not applicable. Part.coeff. n-octanol/water: Not applicable. Page: 5 Autoflammability C: Not applicable. Vapour pressure: Not applicable. Relative density: 1.08 ph: 1.2 VOC g/l: Other information Other information: No data available. Section 10: Stability and reactivity Reactivity Reactivity: Stable under recommended transport or storage conditions Chemical stability Chemical stability: Stable under normal conditions Possibility of hazardous reactions Hazardous reactions: Hazardous reactions will not occur under normal transport or storage conditions Conditions to avoid Incompatible materials Hazardous decomposition products Haz. decomp. products: In combustion emits toxic fumes. Section 11: Toxicological information Information on toxicological effects ALCOHOLS, C12-C14, ETHOXYLATED ORL RAT LD50 >5000 mg/kg Relevant hazards for substance: Hazard Route Basis Skin corrosion/irritation DRM Hazardous: calculated Serious eye damage/irritation OPT Hazardous: calculated STOT-single exposure INH Hazardous: calculated Symptoms / routes of exposure Skin contact: Eye contact: Ingestion: Inhalation: There may be irritation and redness at the site of contact. There may be irritation and redness. The eyes may water profusely. There may be soreness and redness of the mouth and throat. There may be irritation of the throat with a feeling of tightness in the chest. Exposure may cause coughing or wheezing.

6 Delayed / immediate effects: SAFETY DATA SHEET Immediate effects can be expected after short-term exposure. Page: 6 Section 12: Ecological information Toxicity ALCOHOLS, C12-C14, ETHOXYLATED - 48H EC50 >1-<=10 mg/l - 48H EC50 >100 mg/l - 96H LC50 >1-<=10 mg/l - 96H LC50 >1-<=10 mg/l Persistence and degradability Persistence and degradability: The surfactants contained in this preperation comply with the biodegradability criteria as laid down in regulation (EC) No.648/2004 on detergents. Biodegradable Bioaccumulative potential Bioaccumulative potential: No bioaccumulation potential Mobility in soil Mobility: Soluble in water Results of PBT and vpvb assessment PBT identification: This product is not identified as a PBT/vPvB substance Other adverse effects Other adverse effects: Negligible ecotoxicity. Section 13: Disposal considerations Waste treatment methods Disposal operations: Disposal of packaging: NB: Transfer to a suitable container and arrange for collection by specialised disposal company. Dispose of as normal industrial waste. The user's attention is drawn to the possible existence of regional or national regulations regarding disposal. Section 14: Transport information UN number UN number: UN UN proper shipping name Shipping name: CORROSIVE LIQUID, ACIDIC, INORGANIC, N.O.S. (HYDROCHLORIC ACID...17%)

7 Page: Transport hazard class(es) Packing group Transport class: 8 Packing group: III Environmental hazards Environmentally hazardous: No Marine pollutant: No Special precautions for user Special precautions: No special precautions. Tunnel code: E Transport category: 3 Section 15: Regulatory information Safety, health and environmental regulations/legislation specific for the substance or mixture Chemical Safety Assessment Chemical safety assessment: A chemical safety assessment has not been carried out for the substance or the mixture by the supplier. Section 16: Other information Other information Other information: Phrases used in s.2 and s.3: Legal disclaimer: This safety data sheet is prepared in accordance with Commission Regulation (EC) No 1272/2008. This safety data sheet is prepared in accordance with Commission Regulation (EU) No 453/ LTR ; LIMITED QUANTITY FOR ADR 5 LTR ; LIMITED QUANTITY FOR ADR H302: Harmful if swallowed. H314: Causes severe skin burns and eye damage. H315: Causes skin irritation. H318: Causes serious eye damage. H335: May cause respiratory irritation. H400: Very toxic to aquatic life. The above information is believed to be correct but does not purport to be all inclusive and shall be used only as a guide. This company shall not be held liable for any damage resulting from handling or from contact with the above product. [final page]