MATERIAL SAFETY DATA SHEET 1 CHEMICAL PRODUCT & COMPANY IDENTIFICATION Trade Name ANTI CORROSION SPRAY MSDS Number 110 CAS Number Supplier - -0 ITW TRANS TECH 475 N. GARY AVENUE CAROL STREAM, IL 60188 USA Telephone Numbers - 24 Hour Emergency Assistance Emergency Telephone Numbers - General Assistance Information (352)323-3500 (630)752-4000 2 COMPOSITION / INFORMATION ON INGREDIENTS Ingredient Name CAS Number Concentration Exposure Limits / Health Hazards MINERAL SPIRITS 64742-88-7 24 % ACGIH TLV: 100 ppm OSHA PELs: 100 ppm MINERAL SPIRITS 140 FLASH 64742-88-7 35 % PARAFFINIC MINERAL OIL 8042-47-5 10 % OSHA PEL: 5mg/m3 ACGIH TLV: 5mg/m3 as Mist 2-METHOXYMETHYLETHOXYPROPANO 34590-94-8 3 % ACGIH TLV: 100 ppm (skin) ACGIH TLV: 150 ppm (skin) STEL: OSHA PELs: 100 ppm (skin) OSHA PELs: 150 ppm (skin) STEL: CARBON DIOXIDE 124-38-9 2 % ACGIH TLV: 5000 ppm OSHA PELs: 5000 ppm 3 HAZARDS IDENTIFICATION Potential Health Effects, Skin May cause irritation upon prolonged contact. Redness and itching or burning sensation may indicate eye or excessive skin exposure. Potential Health Effects, Eye Irritating to eyes. Redness and itching or burning sensation may indicate eye or excessive skin exposure. Potential Health Effects, Inhalation Irritation of the upper respiratory system. May cause nervous system depression. Potential Health Effects, Ingestion Signs & Symptoms of Short-Term (Acute) Exposure Headache, dizziness, nausea, and loss of coordination are indications of excessive exposure to vapors or spray mists. Pre-existing lung problems are aggravated by exposure. Extreme overexposure may result in unconsciousness and possibly death. 110 Trade Name ANTI CORROSION SPRAY 1 / 5
Effects of Long-Term (Chronic) Exposure Repeated overexposure may cause harm to the peripheral nervous system. 4 FIRST AID MEASURES Skin Remove contaminated clothing and launder before reuse. Wash affected areas with soap and water. Eye Flush with large quantities of water for at least 15 minutes. Consult a physician. Inhalation Remove to fresh air. If breathing is difficult: artificial respiration. Keep person warm and at rest. Ingestion Do not induce vomiting. Seek medical advice immediately. Medical Conditions Aggravated by Exposure None generally recognized. 5 FIRE FIGHTING MEASURES Extinguishing Media Foam, carbon dioxide, dry chemical powder Basic Fire Fighting Procedures Aerosol cans may explode if heated above 120ºF. Full protective equipment including self contained breathing apparatus should be used. Water-spray may be ineffective. If water is used, fog nozzles are preferable. Water may be used to cool closed containers to prevent pressure build-up and possible autoignation or explosion when exposed to extreme heat. Unusual Fire & Explosion Hazards Closed container may explode when exposed to extreme heat. Application to hot surfaces requires special precautions. During emergency conditions overexposure to decomposition products may cause a health hazard. Symptoms may not be immediately apparent. Obtain medical attention. Flash Point 121 ºF AutoIgnition Temperature 0.9-14 6 ACCIDENTAL RELEASE MEASURES Spill or Leak Procedure Remove sources of ignition. Ventilate area. Remove with liquid binding material. Environmental precautions: prevent spills from entering storm sewers or drains and contact with soil. 7 HANDLING & STORAGE Handling Use only in well ventilated areas. Keep away from heat, sparks and open flames. Consult NFPA Code. Use approved Bonding and Grounding procedures. Contents under pressure, do not puncture, incinerate, or expose to temperature above 120F. Heat from sunlight, radiators, stoves, hot water and other heat sources could cause container to burst. Do not take internally. Keep out of reach of children. Wash after handling. Avoid breathing vapors or mist. Storage Keep away from heat and open flame. Store at room temperature in tightly closed containers. Do not puncture, incinerate, or expose to temperature above 120Fº. Ventilation Local exhaust preferable. General exhaust acceptable if the expsoure to materials in section ii is maintained below applicable exposure limits. Refer to osha standards 1910.94, 1910.107, 1910.108. 110 Trade Name ANTI CORROSION SPRAY 2 / 5
8 EXPOSURE CONTROLS / PERSOL PROTECTION Engineering Controls Adequate to prevent accumulation of vapors. Use mechanical means if necessary to maintain levels below the exposure limits. If working in a confined space, follow applicable OSHA regulations Eye Protection: Personal Protection Equipments (PPE) Wear safety spectacles with unpreforated side shields. Skin Protection: Personal Protection Equipments (PPE) Avoid contact with skin, eyes and clothing. For long or repeated contact, wear chemical resistant gloves. Respiratory Protection: Personal Protection Equipments (PPE) Avoid breathing vapors. If personal exposure cannot be controlled below applicable limits by ventilation, wear a properly fitted organic vapor/particulate respirator approved by NIOSH/MSHA for protection against materials in Section 2. General Intentional misuse by deliberately concentrating and inhaling the contents can be harmful or fatal. 9 10 PHYSICAL & CHEMICAL PROPERTIES Odor and Appearance Dark viscous liquid, petroleum odor. Boiling Point 416 ºF Specific Gravity 0.88 Melting Point N.A. Percent Volatile 71 Evaporation Rate Faster than ether Vapor Density Heavier than air Solubility In Water N.A. Volatile Organic 62.2 PH Value STABILITY & REACTIVITY Stability/Incompatibility Stable Conditions to avoid: None known. Incompatability: None known. Hazardous Reactions/Decomposition Products In case of fire, mainly carbon dioxide, carbon monoxide and soot may be formed. Hazardous Polymerization Will not occur. 11 TOXICOLOGICAL INFORMATION Routes of Exposure Inhalation, ingestion, skin and eye contact. 110 Trade Name ANTI CORROSION SPRAY 3 / 5
Carcinogenicity No ingredient in this product is an IARC, NTP or OSHA listed carcinogen. Sensitization to Material Prolonged overexposure to solvent ingredients in Section 2 may cause adverse effects to the liver and urinary systems. Reports have associated repeated and prolonged overexposure to solvents with permanent brain and nervous system damage. 12 ECOLOGICAL INFORMATION EcoToxicological Information 13 Chemical Fate Information DISPOSAL CONSIDERATIONS Waste Disposal Waste from this product may be hazardous as defined under the Resource Conservation and Recovery Act (RCRA) 40 CFR 261. Waste must be tested for ignitability to determine the applicable EPA hazardous waste numbers. Do not incinerate. Depressurize container. Dispose of in accordance with Federal, State/Provincial, and Local regulations regarding pollution. 14 TRANSPORT INFORMATION Department of Transportation (DOT) Requirements: General Transportation Information for Bulk Shipments Proper Shipping Name Paint related material UN/ Code 1263 15 16 REGULATORY INFORMATION Federal Regulations SARA 313 (40 CFR 372.65C) SUPPLIER NOTIFICATION No ingredients in this product are subject to SARA 313 (40 CFR 372.65C) Supplier Notification. All chemicals in this product are listed, or are exempt from listing on the TSCA Inventory. State Regulations WARNING: This material contains a chemical known to the State of California to cause cancer and birth defects or other reproductive harm. NFPA Ratings Health Flammability Reactivity Special Hazards HMIS Ratings Health 2 Flammability 2 Reactivity 0 Personal Prot. Equip. B Following ingredients of this product are listed in SARA313 SARA Listed Ingredient Name CAS Number Maximum % N-HEXANE 110-54-3 Listed on the following Regulatory List(s) SARA 313 OTHER INFORMATION Disclaimer The information and recommendations contained herein are believed to be reliable and accurate based on the data available to us, however we make no warranty, expressed or implied, regarding the accuracy of this data or the results obtained from the use of this product. 110 Trade Name ANTI CORROSION SPRAY 4 / 5
Miscellaneous This product has been classified in accordance with the hazard criteria of the Canadian Controlled Products Regulations (CPR) and the MSDS contains all of the information required by the CPR. Completed On Completed By 2/16/2009 Replaces Sheet Dated 10/1/2007 110 Trade Name ANTI CORROSION SPRAY 5 / 5