Product Code: Product Name: Company Name: Web site address: SAFETY DATA SHEET 1. Product and Company Identification 42A SUNBELT LABORATORIES P.O. BOX 1563 STAFFORD, TX 77497 www.sunbelt-labs.com Phone Number: (281)261-4747 Emergency Contact: CHEM-TEL (8)255-3924 2. Hazards Identification Page: 1 GHS Signal Word: GHS Hazard Phrases: GHS Precaution Phrases: GHS Response Phrases: GHS Storage and Disposal Phrases: Potential Health Effects (Acute and Chronic): Inhalation: Eye Contact: Ingestion: None Causes mild skin irritation. Keep away from heat/sparks/open flames/hot surfaces. - No smoking. Keep container tightly closed. If skin irritation occurs, get medical advice/attention. Store in cool/well-ventilated place. Dispose of contents/container to... Hazards not otherwise classified (HNOC) or not covered by GHS. Mild irritation effect. Mild irritation effect. Mildly irritating to the eyes. 3. Composition/Information on Ingredients CAS # Hazardous Components (Chemical Name) Concentration 67-63- Isopropyl alcohol 1. -5. % 1336-21-6 Ammonium hydroxide.1 -.5 % 12787-87- Poly(oxy-1,2-ethanediyl),.alpha.-(4-nonylphenyl)-.. -.5 % 111-76-2 Ethanol, 2-Butoxy-. -.25 % Emergency and First Aid Procedures: In Case of Inhalation: In Case of Skin Contact: In Case of Eye Contact: In Case of Ingestion: Signs and Symptoms Of Exposure: Note to Physician: 4. First Aid Measures Drink 1 or 2 glasses of water. Consult a physician if necessary. Effects of contact or inhalation may be delayed. Effects of exposure (inhalation, ingestion or skin contact) to substance may be delayed. Rinse skin with water/shower. Rinse thoroughly with plenty of water for at least 15 minutes and consult a physician. Do NOT induce vomiting. Never give anything by mouth to an unconscious person. Rinse mouth with water. Consult a physician. The most important known symptoms and effects are described in the labelling (see section 2.2) and/or in section 11 Treat symptomatically.
5. Fire Fighting Measures Flash Pt: Method Used: Not Applicable Explosive Limits: LEL: UEL: Autoignition Pt: Fire Fighting Instructions: Flammable Properties and Hazards: Suitable Extinguishing Media:Use water spray, dry chemical, carbon dioxide, or alcohol-resistant foam. Wear self contained breathing apparatus for fire fighting if necessary. Further information: Carbon oxides. 6. Accidental Release Measures Page: 2 Protective Precautions, Protective Equipment and Emergency Procedures: Environmental Precautions: Steps To Be Taken In Case Material Is Released Or Spilled: Follow the OSHA respirator regulations found in 29 CFR 191.134 or European Standard EN 149. Keep away from heat/sparks/open flames/hot surfaces. - No smoking. Allow substance to evaporate. 7. Handling and Storage Precautions To Be Taken in Handling: Precautions To Be Taken in Storing: No special handling procedures are required. Keep container tightly closed in a dry and well-ventilated place. Containers which are opened must be carefully resealed and kept upright to prevent leakage. Handle and store under inert gas. Hygroscopic. 8. Exposure Controls/Personal Protection CAS # Partial Chemical Name OSHA TWA ACGIH TWA Other Limits 67-63- Isopropyl alcohol PEL: 4 ppm TLV: 2 ppm STEL: 4 ppm 1336-21-6 Ammonium hydroxide 12787-87- Poly(oxy-1,2-ethanediyl),.alpha.-(4-non ylphenyl)-. 111-76-2 Ethanol, 2-Butoxy- PEL: 5 ppm TLV: 2 ppm Respiratory Equipment (Specify Type): Eye Protection: Protective Gloves: Other Protective Clothing: Engineering Controls (Ventilation etc.): Work/Hygienic/Maintenance Practices: Splash proof safety goggles. Handle in accordance with good industrial hygiene and safety practice. Wash hands before breaks and at the end of workday.
9. Physical and Chemical Properties Physical States: [ ] Gas [ X ] Liquid [ ] Solid Appearance and Odor: ph: 8. Melting Point: - N.D. Boiling Point: > 212. F (1. C) Flash Pt: Method Used: Not Applicable Evaporation Rate: Flammability (solid, gas): Blue. alcohol-like. NR Explosive Limits: LEL: UEL: Vapor Pressure (vs. Air or mm Hg): Vapor Density (vs. Air = 1): Specific Gravity (Water = 1):.995 at 77. F (25. C) Density: Solubility in Water: Complete Percent Volatile: Autoignition Pt: Stability: Conditions To Avoid - Instability: Incompatibility - Materials To Avoid: Hazardous Decomposition or Byproducts: Possibility of Hazardous Reactions: Conditions To Avoid - Hazardous Reactions: > 99. % by volume. 1. Stability and Reactivity Unstable [ ] Stable [ X ] Heat, flames and sparks. Extremes of temperature and direct sunlight. Page: 3 Oxidizing agents, Acid anhydrides, Aluminum, Halogenated compounds, Acids. Other decomposition products: In the event of fire: see section 5. Will occur [ ] Will not occur [ X ] Product will not undergo polymerization.
11. Toxicological Information Page: 4 Toxicological Information: Sensitization: Carcinogenicity/Other Information: Carcinogenicity: Germ cell mutagenicity: Reproductive toxicity. Aspiration hazard: This product is or contains a component that is not classifiable as to its carcinogenicity based on its IARC, ACGIH, NTP, or EPA classification. IARC: 3 -Group 3: Not classifiable as to its carcinogenicity to humans. NTP: No component of this product present at levels greater than or equal to.1% is identified as a known or anticipated carcinogen by NTP. OSHA: No component of this product present at levels greater than or equal to.1% is identified as a carcinogen or potential carcinogen by OSHA. NTP? No IARC Monographs? No OSHA Regulated? No CAS # Hazardous Components (Chemical Name) NTP IARC ACGIH OSHA 67-63- Isopropyl alcohol n.a. 3 A4 n.a. 1336-21-6 Ammonium hydroxide n.a. n.a. n.a. n.a. 12787-87- Poly(oxy-1,2-ethanediyl),.alpha.-(4-nonylphenyl)-.omega.-hy droxy-,branched n.a. n.a. n.a. n.a. 111-76-2 Ethanol, 2-Butoxy- n.a. 3 A3 n.a. 12. Ecological Information Results of PBT and vpvb assessment: Waste Disposal Method: PBT/vPvB assessment not available as chemical safety assessment not required/not conducted. 13. Disposal Considerations 14. Transport Information LAND TRANSPORT (US DOT): DOT Proper Shipping Name: DOT Hazard Class: UN/NA Number: ISOPROPANOL. 15. Regulatory Information EPA SARA (Superfund Amendments and Reauthorization Act of 1986) Lists CAS # Hazardous Components (Chemical Name) S. 32 (EHS) S. 34 RQ S. 313 (TRI) 67-63- Isopropyl alcohol No No Yes 1336-21-6 Ammonium hydroxide No Yes 1 LB No 12787-87- Poly(oxy-1,2-ethanediyl),.alpha.-(4-nonylphenyl)-. No No No 111-76-2 Ethanol, 2-Butoxy- No No Yes-Cat. N23 This material meets the EPA 'Hazard Categories' defined for SARA Title III Sections 311/312 as indicated: [ ] Yes [X] No Acute (immediate) Health Hazard [ ] Yes [X] No Chronic (delayed) Health Hazard [ ] Yes [X] No Fire Hazard [ ] Yes [X] No Sudden Release of Pressure Hazard [ ] Yes [X] No Reactive Hazard
CAS # Hazardous Components (Chemical Name) Other US EPA or State Lists 67-63- Isopropyl alcohol CAA HAP,ODC: No TSCA: Yes - Inventory, 4 Test 1336-21-6 Ammonium hydroxide CAA HAP,ODC: No TSCA: Yes - Inventory 12787-87- Poly(oxy-1,2-ethanediyl),.alpha.-(4-nonylphenyl)-. CAA HAP,ODC: No TSCA: Yes - Inventory, 8A PAIR 111-76-2 Ethanol, 2-Butoxy- CAA HAP,ODC: No TSCA: Yes - Inventory Page: 5 16. Other Information Revision Date: Preparer Name: 5/14/215 Michael Kirk 281-261-4747 Hazard Rating System: HMIS: HEALTH FLAMMABILITY REACTIVITY PPE 1 Flammability Health NFPA: 1 Instability Special Hazard Additional Information About This Product: Company Policy or Disclaimer: DISCLAIMER: To the best of our knowledge, the information contained herin is accurate. There is no assumption of liability for accuracy contained within this information. The information given is designed only as a guidance for safe handling, use, processing, with any other materials or in any process, unless specified in the text. DISCLAIMER: To the best of our knowledge, the information contained herin is accurate. There is no assumption of liability for accuracy contained within this information. The information given is designed only as a guidance for safe handling, use, processing, with any other materials or in any process, unless specified in the text. DISCLAIMER: To the best of our knowledge, the information contained herin is accurate. There is no assumption of liability for accuracy contained within this information. The information given is designed only as a guidance for safe handling, use, processing, with any other materials or in any process, unless specified in the text.