Revision Date 29/07/2013 Revision 4 Supersedes date 29/07/2013 SAFETY DATA SHEET SECTION 1: IDENTIFICATION OF THE SUBSTANCE/MIXTURE AND OF THE COMPANY/UNDERTAKING 1.1. Product identifier Product name Product No. 001802076514 1.2. Relevant identified uses of the substance or mixture and uses advised against 1.3. Details of the supplier of the safety data sheet Supplier Aerosol Solutions Limited Unit C2, Bridgefield Ind Estate, Draycott Road, Breaston, Derby, DE72 3DS. 01332 870030 sales@aerosolsolutions.co.uk 1.4. Emergency telephone number SECTION 2: HAZARDS IDENTIFICATION 2.1. Classification of the substance or mixture Physical and Chemical Hazards Flam. Aerosol 1 - H222 Human health Environment Classification (1999/45/EEC) F+;R12. R66. Not classified. The Full Text for all R-Phrases and Hazard Statements are Displayed in Section 16. 2.2. Label elements Label In Accordance With (EC) No. 1272/2008 Signal Word Hazard Statements Precautionary Statements Supplemental label information 2.3. Other hazards Danger H222 P102 P210 P211 P251 P271 P280 P261 Extremely flammable aerosol. Keep out of reach of children. Keep away from heat/sparks/open flames/hot surfaces. - No smoking. Do not spray on an open flame or other ignition source. Pressurized container: Do not pierce or burn, even after use. Use only outdoors or in a well-ventilated area. Wear protective gloves. Avoid breathing vapour/spray. P410+412 Protect from sunlight. Do not expose to temperatures exceeding 50 C/122 F. Repeated exposure may cause skin dryness or cracking. SECTION 3: COMPOSITION/INFORMATION ON INGREDIENTS 3.2. Mixtures 1 / 6
BUTANE 10-30% CAS-No.: 106-97-8 EC No.: 203-448-7 Flam. Gas 1 - H220 F+;R12 ISOBUTANE 5-10% CAS-No.: 75-28-5 EC No.: 200-857-2 Flam. Gas 1 - H220 F+;R12 ODOURLESS KEROSENE 30-60% CAS-No.: 64742-47-8 EC No.: 265-149-8 Asp. Tox. 1 - H304 Xn;R65. R66. PROPANE 10-30% CAS-No.: 74-98-6 EC No.: 200-827-9 Flam. Gas 1 - H220 F+;R12 The Full Text for all R-Phrases and Hazard Statements are Displayed in Section 16. SECTION 4: FIRST AID MEASURES 4.1. Description of first aid measures General information Move the exposed person to fresh air at once. Get medical attention if any discomfort continues. Inhalation Move the exposed person to fresh air at once. When breathing is difficult, properly trained personnel may assist affected person by administering oxygen. Keep the affected person warm and at rest. Get prompt medical attention. Ingestion DO NOT INDUCE VOMITING! Rinse mouth thoroughly with water and give large amounts of milk or water to people not unconscious. Get medical attention if any discomfort continues. Skin contact Wash the skin immediately with soap and water. Get medical attention if any discomfort continues. Eye contact Make sure to remove any contact lenses from the eyes before rinsing. Promptly wash eyes with plenty of water while lifting the eye lids. Continue to rinse for at least 15 minutes. Get medical attention if any discomfort continues. 4.2. Most important symptoms and effects, both acute and delayed 4.3. Indication of any immediate medical attention and special treatment needed SECTION 5: FIREFIGHTING MEASURES 5.1. Extinguishing media Extinguishing media Use: Powder. Dry chemicals, sand, dolomite etc. Water spray, fog or mist. 2 / 6
5.2. Special hazards arising from the substance or mixture Unusual Fire & Explosion Hazards Aerosol cans may explode in a fire. 5.3. Advice for firefighters Special Fire Fighting Procedures Containers close to fire should be removed or cooled with water. Use water to keep fire exposed containers cool and disperse vapours. SECTION 6: ACCIDENTAL RELEASE MEASURES 6.1. Personal precautions, protective equipment and emergency procedures 6.2. Environmental precautions 6.3. Methods and material for containment and cleaning up Wear necessary protective equipment. Extinguish all ignition sources. Avoid sparks, flames, heat and smoking. Ventilate. Let evaporate. Keep out of confined spaces because of explosion risk. If leakage cannot be stopped, evacuate area. 6.4. Reference to other sections SECTION 7: HANDLING AND STORAGE 7.1. Precautions for safe handling Keep away from heat, sparks and open flame. Avoid spilling, skin and eye contact. Ventilate well, avoid breathing vapours. Use approved respirator if air contamination is above accepted level. 7.2. Conditions for safe storage, including any incompatibilities Aerosol cans: Must not be exposed to direct sunlight or temperatures above 50 C. 7.3. Specific end use(s) SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION 8.1. Control parameters Name STD TWA - 8 Hrs STEL - 15 Min Notes BUTANE WEL 600 ppm 1450 mg/m3 750 ppm 1810 mg/m3 ISOBUTANE WEL 800 ppm 800 ppm ODOURLESS KEROSENE 165 ppm 1200 mg/m3 PROPANE Asphyxiating Asphyxiating. Asphyxiating Asphyxiating. WEL = Workplace Exposure Limit. Ingredient Comments OES = Occupational Exposure Standard. MEL = Maximum Exposure Limit. 8.2. Exposure controls Protective equipment Engineering measures Provide adequate general and local exhaust ventilation. Respiratory equipment No specific recommendation made, but respiratory protection must be used if the general level exceeds the recommended occupational exposure limit. Use chemical cartridge protection with appropriate cartridge. Hand protection Use protective gloves. Eye protection Wear approved chemical safety goggles where eye exposure is reasonably probable. 3 / 6
Other Protection Wear appropriate clothing to prevent any possibility of liquid contact and repeated or prolonged vapour contact. Hygiene measures DO NOT SMOKE IN WORK AREA! Wash hands at the end of each work shift and before eating, smoking and using the toilet. Promptly remove any clothing that becomes contaminated. When using do not eat, drink or smoke. SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES 9.1. Information on basic physical and chemical properties Appearance Aerosol. Colour Typical Odour Characteristic. Flammability Limit - Lower(%) 0.8 Flammability Limit - Upper(%) 9.0 9.2. Other information SECTION 10: STABILITY AND REACTIVITY 10.1. Reactivity 10.2. Chemical stability Stable under normal temperature conditions. 10.3. Possibility of hazardous reactions 10.4. Conditions to avoid Avoid heat, flames and other sources of ignition. Avoid contact with: Strong oxidising agents. Strong alkalis. Strong mineral acids. 10.5. Incompatible materials 10.6. Hazardous decomposition products Fire creates: Vapours/gases/fumes of: Carbon monoxide (CO). Carbon dioxide (CO2). SECTION 11: TOXICOLOGICAL INFORMATION 11.1. Information on toxicological effects Inhalation May cause irritation to the respiratory system. Vapours may cause headache, fatigue, dizziness and nausea. Prolonged inhalation of high concentrations may damage respiratory system. Ingestion May cause discomfort if swallowed. May cause stomach pain or vomiting. Gastrointestinal symptoms, including upset stomach. Skin contact Prolonged or repeated exposure may cause severe irritation. Acts as a defatting agent on skin. May cause cracking of skin, and eczema. Eye contact Irritating to eyes. May cause chemical eye burns. Route of entry Inhalation. Skin and/or eye contact. SECTION 12: ECOLOGICAL INFORMATION Ecotoxicity Dangerous for the environment if discharged into watercourses. 12.1. Toxicity 12.2. Persistence and degradability 12.3. Bioaccumulative potential 4 / 6
12.4. Mobility in soil 12.5. Results of PBT and vpvb assessment 12.6. Other adverse effects SECTION 13: DISPOSAL CONSIDERATIONS 13.1. Waste treatment methods Empty containers must not be burned because of explosion hazard. Dispose of waste and residues in accordance with local authority requirements. SECTION 14: TRANSPORT INFORMATION 14.1. UN number UN No. (ADR/RID/ADN) 1950 UN No. (IMDG) 1950 UN No. (ICAO) 1950 14.2. UN proper shipping name Proper Shipping Name AEROSOLS 14.3. Transport hazard class(es) ADR/RID/ADN Class 2 ADR/RID/ADN Class Class 2: Gases ADR Label No. 2.1 IMDG Class 2.1 ICAO Class/Division 2.1 Transport Labels FLAMMABLE GAS 2 14.4. Packing group ADR/RID/ADN Packing group IMDG Packing group ICAO Packing group Not Applicable Not Applicable Not Applicable 14.5. Environmental hazards Environmentally Hazardous Substance/Marine Pollutant No. 14.6. Special precautions for user EMS F-D, S-U 14.7. Transport in bulk according to Annex II of MARPOL73/78 and the IBC Code SECTION 15: REGULATORY INFORMATION 15.1. Safety, health and environmental regulations/legislation specific for the substance or mixture 5 / 6
Uk Regulatory References The Chemicals (Hazard Information and Packaging for Supply) Regulations 2002. The Control of Substances Hazardous to Health Regulations 2002. Statutory Instruments Control of Substances Hazardous to Health. The Chemicals (Hazard Information and Packaging for Supply) Regulations 2009 (S.I 2009 No. 716). Approved Code Of Practice Classification and Labelling of Substances and Preparations Dangerous for Supply. Guidance Notes Workplace Exposure Limits EH40. Introduction to Local Exhaust Ventilation HS(G)37. CHIP for everyone HSG(108). 15.2. Chemical Safety Assessment SECTION 16: OTHER INFORMATION Revision Date 29/07/2013 Revision 4 Supersedes date 29/07/2013 Risk Phrases In Full R12 Extremely flammable. R65 Harmful: may cause lung damage if swallowed. R66 Repeated exposure may cause skin dryness or cracking. Hazard Statements In Full H222 Extremely flammable aerosol. H220 Extremely flammable gas. H304 May be fatal if swallowed and enters airways. Repeated exposure may cause skin dryness or cracking. 6 / 6