SAFETY DATA SHEET 1. CHEMICAL PRODUCT & COMPANY IDENTIFICATION Chemical product name : AMIZETT 2L-Y Name of manufacturer/supplier : Kawaken Fine Chemicals Co., Ltd. Head office Name of section : Household Chemicals Business Unit Address : 2-3-3, Nihombashi Horidome-cho, Chuo-ku, Tokyo, 103-0012 Japan Telephone number : +81-3-3663-9521 Fax number : +81-3-3661-5630 Osaka branch Address : 1-2-6, Awaji-machi, Chuo-ku, Osaka, 541-0047 Japan Telephone number : +81-6-6201-1631 Fax number : +81-6-6227-0755 2. HAZARD IDENTIFICATION GHS classification Health hazard Skin corrosion / Irritation : Category 3 Eye damage/irritation : Category 2A Skin sensitization : Not classified Aspiration hazard : Not classified Pictogram : Symbol : Exclamation mark Signal word : Warning Hazard statement : Causes mild skin irritation Causes eye irritation Precautionary statement Prevention : Wash hands thoroughly after handling. Wear eye protection, face protection. Response : If in eyes: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. If eye irritation persists: Get medical advice, attention. If skin irritation occurs; Get medical advice, attention. 3. COMPOSITION/INFORMATION ON INGREDIENTS Substance/Mixture : Substance page 1 of 6
Chemical name(generic name) : Polyoxyethylene Laurate Monoethanolamide INCI name : PPG-3 LAURAMIDE Composition/CAS registry number CAS registry number : 26635-75-6 TSCA master inventory : reg. EINECS number : no. Content(%) : 100% Chemical formula : CH3(CH2)10CONHCH2CH2O(CH2CH2O)2H 4. FIRST-AID MEASURES Inhalation : Remove victim to fresh air and keep at rest in a position comfortable for breathing. Call a POISON CENTER or doctor/physician if you feel unwell. Skin contact : Remove/Take off immediately all contaminated clothing. Rinse skin with water/shower. Take off contaminated clothing and wash before reuse. If skin irritation occurs: Get medical advice/attention. Eye contact : Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. If eye irritation persists: Get medical advice/attention. Ingestion : Rinse mouth. Call a POISON CENTER or doctor/physician if you feel unwell. 5. FIRE-FIGHTING MEASURES Extinguishing media : In case of fire: Use Dry chemical powder, Carbon dioxide, Foam, Water spray for extinction. At small fire, use Dry chemical powder, Carbon dioxide. At large fire, use Water spray, Foam. Specific hazards with regard to fire-fighting measures May produce toxic fumes of carbon monoxide if burning. Specific fire fighting method Protection of fire-fighter Move containers from fire area if it can be done without risk, it not possible, apply water from a safe distance to cool and protect surrounding area. Breathing protection, Protective clothing, Heat-insulating gloves, Face shield or Safety goggles. 6. ACCIDENTAL RELEASE MEASURES Personal precautions, protective equipment and emergency procedures Do not contact with leakage or walk in the area of leakage. Immediately enclose the area as the leakage area, with appropriate distance in all directions from the leakage location. Restrict the area to associated personnel. Worker should wear appropriate protective equipment (Refer to 8. Exposure control/personal protection) and avoid contact with eye, skin or inhalation of gas. Wear air tight and impermeable protective clothing when leaked and no fire. Do not contact with broken container or leakage when not wearing appropriate protective equipment. Stay at windward. Leave lower area. Ventilate closed place before entering. Environmental precautions Pay attention not to flow into river etc. and affect environment. Do not release to the environment. Collecting and neutralization Absorb leakage by inactive material (for example dry sand or soil) and recover into container for chemical waste. Methods and equipment for containment and cleaning up Stop leakage if not dangerous. page 2 of 6
Prevention of secondary disaster Remove all ignition source promptly (Prohibit smoking, spark or flame at surrounding area). Prevent from flow into drain, sewage, basement or closed area. 7. HANDLING & STORAGE Handling : Engineering measures Install facilities as described in 8. Exposure control/personal protection, and wear protective equipment. Local exhaust/total ventilation Install local exhaust, total ventilation as described in 8. Exposure control/personal protection. Measures for safe handling Do not handle until all safety precautions have been read and understood. Keep away from ignition sources such as open flame/heat. No smoking. Wash hands thoroughly after handling. Do not breathe mist/vapours/spray. Avoid contacting with skin. Do not contact with eye. Use only outdoors or in a well ventilated area. Do not eat, drink or smoke when using this product. Contact avoidance: Refer to 10. Stability and reactivity. Hygienic measures: Do not eat or drink when using this product. Wash hand thoroughly after handling. Storage Engineering measures: Comply with Fire Service Law. Incompatible materials: Refer to 10. Stability and reactivity. Storage condition Store away from oxidizing agent. Store away flame and high temperature surface. Keep away from direct sunlight and fire. Store container tightly closed in well-ventilated place Sore locked up. Packaging materials: Store in a closed container. 8. EXPOSURE CONTROLS/PERSONAL PROTECTION Control concentration: Not established Acceptable concentration limit The Japan Society for Occupational Health: Not established ACGIH : Not established Facility measures Install eye wash and safety shower in the area where this product is stored or handled. Seal the equipment or install local exhaust to prevent exposure. Protective equipment Respiratory protection : Ventilation, local exhaust, or breathing protection. Hand protection : Protective gloves. Eye protection : Safety goggles or Safety spectacles Skin and body protection : Protective clothing. 9. PHYSICAL & CHEMICAL PROPERTIES Physical state : Liquid or Solid. Color : Pale yellow to yellow (liquid) or white to light yellow (solid). Odor : Slight characteristic odor. ph : 8.0-10.0 (1%, 90%-water : 10%-ethanol sol.) Melting point : 36-40 page 3 of 6
Boiling point : No data. Flash point : 258 (Cleveland open-cup) Evaporation rate : No data. Explosion characteristics Explosion limit : No data. Vapor pressure : No data. Vapor density : No data. Specific gravity (Density) : d(50/4)=0.961 d(60/4)=0.956 d(70/4)=0.950 Solubility in water : Sparingly soluble. / organic solvents : Soluble in ethanol benzene toluene. log Pow : No data. Auto ignition temperature : No data. Decomposition temperature : No data. Viscosity : 60mPa s(50 ) 38mPa s(60 ) 27mPa s(70 ) 10. PHYSICAL HAZARD (Stability & Reactivity) Reactivity : Stable under normal usage. Chemical stability : No data. Possibility of hazardous reaction : No data. Incompatible materials : No data. Hazardous decomposition products : No data. 11. TOXICOLOGICAL INFORMATION Acute toxicity : No data. Skin corrosion / Irritation : 4% (Guinea pig),no effects. : 8% (Guinea pig),mild irritation. 1) (Category 3) Serious eye damage / Eye irritation : 5%(pH=7), (rabbit), irritation. 2) (Category 2A) Respiration or skin sensitization : Skin (Guinea pig),negative. 3) (Not classified) Germ cell mutagenicity : No data. : Ames,Negative. 4) Carcinogenicity : No data. Reproductive toxicity : No data. Specific target organ systemic toxicity single exposure : No data. Specific target organ systemic toxicity repeated exposure : No data. Aspiration hazard : At 40 for the viscous liquid or solid. (Not classified) 12. ECOLOGICAL INFORMATION Biodegradability : No data. Fish toxicity : No data. Bioaccumulation : No data. Hazardous to the ozone layer : A toxic substance is not included. Not classified 13. DISPOSAL CONSIDERATIONS Remaining waste page 4 of 6
Comply with relevant regulations and standard of municipality. Commission the container and content waste disposer licensed by regional authority or commission to local government if it treat waste. Notify waste disposer of hazard of the waste when commission disposal. Contaminated container and packing Clean and recycle container or dispose appropriately complying with standard of local government. Remove all the residual when disposing container. 14. TRANSPORT INFORMATION International regulations Marine regulation UN No. : - Proper Shipping Name : - Class : Not applicable. Sub Risk : - Packing Group : - Marine Pollutant : Not applicable Air regulations UN No. : - Proper Shipping Name : - Class : Not applicable. Sub Risk : - Packing Group : - Special safety measures Load dangerous goods or container so as not to fall, tumble or break. Transport not to cause friction or shake. Take precautionary measures to prevent accident and report to local fire department or other relevant organization when there is a possibility of accident such as significant leakage of dangerous goods during transportation. Keep away from direct sunlight and load not to cause breakage or corrosion of container or leakage and make sure to take measurement to prevent collapse when transporting. Do not transport together with foods. Do not place heavy things on the product. 15. REGULATORY INFORMATION European/International Regulations European Labeling in Accordance with EC Directives Hazard Symbols : No data. Risk Phrases : No data. Safety Phrases : No data. 16. OTHER INFORMATION References : 1) Drug Safety Testing Center Co., Ltd. (July 3, 2009) 2) Bozo Research Center Inc. (October 19, 2009) 3) Drug Safety Testing Center Co., Ltd. (August 3, 2009) 4) Bozo Research Center Inc. (August 6, 2009) To the best of our knowledge, the information contained herein is accurate. However, neither Kawaken Fine Chemicals Co., Ltd. nor any subsidiaries assumes any liability what so ever for the accuracy or completeness of the information contained herein. The final determination of suitability of any material is the sole responsibility of the page 5 of 6
user. All materials may present unknown hazards and should be used in caution. Although certain hazards are described herein, we cannot guarantee that these are the only hazards, which exist. page 6 of 6