1. Material Data Safety sheet - Action Lanospray MATERIAL SAFETY DATA SHEET Section 1: IDENTIFICATION ACTION LANOSPRAY Commercial Grade Lanolin Protection Recommended Use: Lubricant, Rust Inhibitor and water proofing Product Code: ACT400 350G AEROSOL Hazchem Code: 2YE Poisons Schedule non toxic Last Issue Date : September 2015 Action Corrosion Pty Ltd (A.B.N. 406 2945 4461) Postal Address: 3/18 Industry Drive, South Tweed Heads NSW 2486 Telephone Number: 1300 731 311 Facsimile: 07 5524 2990 Emergency Telephone Number: Poisons Information Centre (National) 131126 Section 2: HAZARDS IDENTIFICATION Hazard Classification - This material is hazardous according to health criteria of Safe Work Australia Hazard Category - Xn Harmful Risk Phrases - Extremely Flammable R65- May cause lung damage if swallowed. Safety Phrases - S23: Do no breathe vapour S24/25: Avoid contact with skin and eyes S36/37/39 Wear suitable protective clothing, gloves and eye/face protection S62 If swallowed, do not induce vomiting; seek medical advice immediately and show this container or label. Keep out of reach of children Keep container in a well ventilated place Keep away from sources of ignition. Poisons Schedule (Aust) S5 Classified as Dangerous Goods by the criteria of the Australian Code for the Transport of Dangerous Good by Road and Rail and the New Zealand NZS5433: Transport of Dangerous Goods on Land Class 2.1
1. Material Data Safety sheet - Action Lanospray Section 3: COMPOSITION INFORMATION Ingredient Lanolin Anhydrous Hydro treated Heavy Naphtha Propellant Ingredients determined to be non hazardous CAS No 8006-54-0 64742-48-9 106-97-8 74-98-6 Proportion >25% 40% 35% Section 4: FIRST AID Eye (Contact) - Flush with water for several minutes. Will not cause eye injury. Skin (Contact) - Wash area with soap. Not expected to require first aid measures. Inhalation(Breathing) - Remove from further exposure. If irritation, dizziness, nausea or unconciousness occurs, get medical assistance. If breathing is shallow or has stopped, ensure airways are clear and apply resuscitation, preferable with a demand valve resuscitator, bag-valve mask device, or pocket mask as trained. Ingestion (Swallowing) - Minimal toxicity may cause discomfort to digestive track. Give a glass of water. Contact a doctor or poisons information centre 131126. Advice to Doctor -Treat symptomatically. First Aid Facilities -Eyewash bottle or basin. Flashpoint: - >83deg C Autoignition Point: - >200 C Flammability Limits: Section 5: FIREFIGHTING MEASURE Specific Hazards: Flammable gas. May form flammable vapour mixtures with air. Flameproof equipment necessary in area where this chemical is being used. Electrical requirements for work area should be assessed according to AS3000. Avoid all ignition sources. Do not smoke. Degree of fire /explosion hazard: Slight, when exposed to naked flame Extinguishing Media: Dry chemical powder, foam, carbon dioxide, water fog Hazardous decomposition Products: Carbon dioxide, carbon monoxide, nitrogen oxides and smoke may be released in fire. Special fire-fighting Procedures: Wear self contained breathing apparatus and protective clothing. Use water sprays to cool fire.
1. Material Data Safety sheet - Action Lanospray Section 6: ACCIDENTAL RELEASE MEASURES Emergency Procedures - Eliminate all sources of ignition and ventilate area. Methods and materials for containment and clean up - - Clean up spills immediately - Avoid breathing vapours and contact with skin and eyes. - If safe to do so, damaged cans should be placed into a container in a well ventilated area (outside) until the gas has discharged. - Clean up spills with inert material and dispose of in accordance with current legislation. Section 7: HANDLING AND STORAGE Use in a well ventilated area. Do not store or use in confined spaces. Classified as a flammable gas for storage and handling purposes. Store in a cool, dry, well ventilated area, out of direct sunlight. Avoid sparks, flames and other ignition sources. Store away from incompatible materials such as oxidising materials, flammable liquids and corrosive materials. Section 8: EXPOSURE CONTROL/PERSONAL PROTECTION NO OCCUPATIONAL EXPOSURE STANDARDS HAVE BEEN ASSIGNED BY NOHSC. Biological Limit Values Not applicable Engineering Controls - Keep away from sunlight, heat and sources of ignition. Use only with adequate ventilation. Personal Protective Equipment - Use suitable protective equipment to avoid skin and eye contact. Section 9: PHYSICAL AND CHEMICAL PROPERTIES Appearance Brown Liquid Odour Slight wool fleece odour Flammability Limits: N/A Flash point: >179 degrees Vapour Pressure: N/AV Vapour Density: 0.8461 Solubility: Very low. Section 10: STABILITY AND REACTIVITY Chemical Stability - Stable under normal conditions Conditions to AVOID - extreme heat Incompatible materials - Strong oxidising agents, flammable liquids and corrosive materials. Hazardous reactions - No hazardous polymerisation will occur. Ingestion: May cause stomach upset. Section 11: TOXICOLOGICAL INFORMATION
1. Material Data Safety sheet - Action Lanospray Eye Contact: Non irritant Skin Contact: Non irritant Section 11: TOXICOLOGICAL INFORMATION Inhalation: Inhalation of mists & aerosols may produce respiratory irritation and coughing. Inhalation of high concentrations may lead to respiratory collapse. No specific data is available. Section 12: ECOLOGICAL INFORMATION Section 13: DISPOSAL CONSIDERATIONS Do not incinerate or puncture aerosol cans. Bury residues and emptied cans at an approved site. Section 14: TRANSPORT INFORMATION Not classified as Dangerous Goods by the criteria of the Australian Dangerous Goods Code (ADG Code). DG Class: AEROSOL CLASS 2.1 UN Number: 1950 Hazchem Code:2YE Packing Group: II Proper Shipping Name: Aerosols Segregation: Not to be loaded with explosives (Class 1), flammable liquids (Class 3), if both are in bulk, flammable solids (Class 4.1), spontaneous combustible substances (Class 4.2), dangerous when wet substances )Class 4.3) oxidising agents (Class 5.1), organic peroxides (Class 5.2) or radioactive substances (Class 7), however exemptions may apply. Section 15: REGULATORY INFORMATION Poisons Schedule: Not allocated Dangerous Goods: Not Regulated under the Australian Dangerous Goods Code and understate/ Territory Storage of Dangerous Goods Regulations. Section 16: OTHER INFORMATION Action Corrosion Contact Details/Poisons information centre: 3/18 Industry Drive, South Tweed Heads NSW 2486 1300 731 311 Date of preparation: SEPTEMBER 2015
1. Material Data Safety sheet - Action Lanospray Section 16: OTHER INFORMATION Every endeavor has been made to ensure that the information contained in this publication is reliable and offered in good faith. It is meant to describe the safety requirements of our products and should not be construed as guaranteeing specific properties. Customers are encouraged to conduct their own tests as end user suitability of the product for particular uses is beyond our control. The information is not intended as an inducement to bargain and no warranty expressed or implied is made as to its accuracy, reliability or completeness. Action Corrosion accepts no liability for loss, injury or damage arising from reliance upon the information contained in this data sheet except in conjunction with the proper use of the product to which it refers. Due care should be taken that the use and disposal of this product is in compliance with appropriate Federal, State and Local Government regulations.