1 IDENTIFICATION Product identifier Other means of identification Recommended use of the chemical and restrictions on use Manufacturer Dominion Sure Seal Ltd. 6175 Danville Road Mississauga, Ontario Canada L5T 2H7 Tel: +1(905)670 5411 Fax: +1(905)670 5174 www.dominionsureseal.com Emergency telephone number BodyworX Stone Guard Solvent Base Chip Resistant Coating 1L,, Coating. Importer GPI Automotive Products Pty. Ltd. 275 Wellington Road Mulgrave VIC 3170 Australia Tel: (03) 8541 7500 Fax: (03) 9562 0789 sales@gpi.com.au Poisons Information Centre (Australia) Tel: 13 11 26 2 HAZARD IDENTIFICATION Classification/s of the Flammable liquid and vapour Category 3 hazardous chemical Signal word CAUTION Hazard statements H226: Flammable liquid and vapour. H312: Harmful in contact with skin. H315: Causes skin irritation. H332: Harmful if inhaled. Precautionary statements P260: Do not breathe dust/fumes/gas/mist/vapour/spray. P262: Do not get in eyes, on skin, or on clothing. P271: Use only outdoors or in a well-ventilated area. Symbol/s 3 COMPOSITION AND INFORMATION ON INGREDIENTS Ingredient name CAS Number Proportion Xylene (C 8 H 10 ) Calcium carbonate (CaCO 3 ) Carbon black 1330-20-7 1317-65-3 1333-86-4 25<50% 25<50% 1<5% Expiry date: 6 May 2019 Page 1 of 6
4 FIRST AID MEASURES Symptoms of poisoning may even occur after several hours; therefore medical observation for at least 48 hours after the accident. Route of exposure Symptoms First Aid Inhalation May cause respiratory irritation. Supply fresh air. If required, provide artificial respiration. Keep patient warm. Consult doctor if symptoms persist. Ingestion May cause headache, nausea, vomiting and weakness. If symptoms persist consult doctor. Skin contact May cause irritation to the skin. Immediately wash with water and soap and rinse thoroughly. Eye contact No irritating effect. Rinse opened eye for several minutes under running water. 5 FIRE FIGHTING MEASURES Suitable extinguishing media Carbon dioxide, sand, dry chemical. Do not use: Water. Specific hazards arising from the chemical Special protective equipment and precautions for fire fighters 6 ACCIDENTAL RELEASE MEASURES Personal precautions, protective equipment and emergency procedures Environmental precautions Methods and materials for containment and cleaning up Wear protective equipment. Keep unprotected persons away. Do not allow to enter sewers/surface or ground water. Absorb with liquid-binding material (sand, diatomite, acid binders, universal binders, sawdust). Dispose contaminated material as waste according to item 13. Ensure adequate ventilation. Do not flush with water or aqueous cleansing agents. Expiry date: 6 May 2019 Page 2 of 6
7 HANDLING AND STORAGE Precautions for safe handling Conditions for safe storage Ensure good ventilation/exhaustion at the workplace. Prevent formation of aerosols. Keep ignition sources away do not smoke. Protect against static discharges. No special requirements. 8 EXPOSURE CONTROLS & PERSONAL PROTECTION Control parameters Ingredient name Xylene Calcium carbonate Carbon black Appropriate engineering controls Personal protection measures Hygiene measures Eye and face protection Skin protection Respiratory protection Exposure limits TWA: 80 ppm / 350 mg/m 3 TWA: 10 mg/m 3 TWA: 3 mg/m 3 Keep away from foodstuffs, beverages and feed. Immediately remove all soiled and contaminated clothing. Wash hands before breaks and at the end of work. Avoid close or long-term contact with the skin. Avoid contact with the eyes. Tightly sealed goggles. Goggles recommended during refilling. Protective gloves. Protective suit. In case of brief exposure or low pollution use respiratory filter device. In case of intensive or longer exposure use respiratory protective device that is independent or circulating air. 9 PHYSICAL & CHEMICAL PROPERTIES Appearance Black liquid Odour Characteristic Odour threshold ph 7.0 @ 20 C Melting point / freezing point Boiling point / boiling range 135 C Flash point 30 C Evaporation rate Flammability Flammable liquid and vapour Category 3 Upper / lower flammability or explosive limits LEL: 1.0% vol. UEL: 7.0% vol. Expiry date: 6 May 2019 Page 3 of 6
Vapour pressure 6.0 hpa @ 20 C 20 hpa @ 50 C Vapour density Relative density 1.250 g/cm 3 @ 20 C Solubility Not miscible or difficult to mix. Partition coefficient: n- octanol/water Auto-ignition temperature 500 C Decomposition temperature Viscosity 1700 cp @ 20 C 10 STABILITY & REACTIVITY Reactivity Chemical stability Conditions to avoid Incompatible materials and possible hazardous reactions Hazardous decomposition products No decomposition if used according to specifications. None known. None known. 11 TOXICOLOGICAL INFORMATION Numerical measures of toxicity Ingredient name LD 50 (oral-rat) LC 50 (inhalation-rat) Xylene 8700 mg/kg 6350 mg/l/4hr Early-onset symptoms of Irritation. overexposure Interactive effects Delayed and chronic health effects Carcinogenicity Carbon black is considered possibly carcinogenic to humans and classified as a Group 2B carcinogen, because there is sufficient evidence in experimental animals with inadequate evidence in human epidemiologic studies. Data limitations Expiry date: 6 May 2019 Page 4 of 6
12 ECOLOGICAL INFORMATION Ecotoxicity Persistence and degradability Bioaccumulative potential Mobility in soil Other adverse effects Hazardous for water. Do not allow product to reach ground water, water course or sewage system. Danger to drinking water even if small quantities leak into the ground. 13 DISPOSAL CONSIDERATIONS Safe handling and disposal methods Disposal of any contaminated packaging Environmental regulations 14 TRANSPORT INFORMATION Regulation UN Number Proper shipping name ADG (road) 1263 PAINT-RELATED ADR (rail) 1263 PAINT-RELATED IMDG (sea) 1263 PAINT-RELATED IATA (air) 1263 PAINT-RELATED Environmental hazards Must not be disposed of together with household garbage. Disposal must be made according to official regulations. DG Class Packing Group HAZCHEM Additional information 15 REGULATORY INFORMATION Safety, health and AICS: all ingredients listed. environmental regulations specific for the product Poisons Schedule Number (SUSDP) Expiry date: 6 May 2019 Page 5 of 6
16 OTHER INFORMATION Date of SDS preparation 06/05/2014 Key / legend ADG ADR AICS CAS IARC IATA IMDG NOHSC STEL SUSMP TWA Notice to reader Australian Code for Transport of Dangerous Goods by Road and Rail European Agreement concerning the International Carriage of Dangerous Goods by Road Australian Inventory of Chemical Substances Chemical Abstracts Service International Agency for Research on Cancer International Air Transport Association International Maritime Dangerous Goods Code National Occupational Health and Safety Commission Short-term exposure limits Standard for the Uniform Scheduling of Medicines and Poisons Time-weighted average All reasonably practicable steps have been taken to ensure this data sheet and the health, safety and environmental information contained in it is accurate as of the date prepared (above). No warranty or representation, express or implied is made as to the accuracy or completeness of the data and information in this data sheet. The data and advice given apply when the product is sold for the stated application or applications. You should not use the product other than for the stated application or applications without seeking advice from us. It is the user s obligation to evaluate and use this product safely and to comply with all applicable laws and regulations. The GPI Group and GPI Automotive Products shall not be responsible for any damage or injury resulting from use, other than the stated product use of the material, from any failure to adhere to recommendations, or from any hazards inherent in the nature of the material. Purchasers of this product for supply to a third party for use at work, have a duty to take all necessary steps to ensure that any person handling or using the product is provided with the information in this sheet. Employers have a duty to tell employees and others who may be affected by the hazards described in this sheet and of any precautions that should be taken. Expiry date: 6 May 2019 Page 6 of 6