Safety Data Sheet Revision Number: 001.2 Issue date: 12/17/2014 1. PRODUCT AND COMPANY IDENTIFICATION Product name: OSI WINTeQ TeQFlash Butyl Window Flashing Product type: Pressure sensitive adhesive tape Restriction of Use: identified Region: United States Company address: Contact information: Henkel Corporation One Henkel Way Rocky Hill, Connecticut 06067 Telephone: +1 (800) 624-7767 MEDICAL EMERGENCY Phone: Poison Control Center 1-877-671-4608 (toll free) or 1-303-592-1711 TRANSPORT EMERGENCY Phone: CHEMTREC 1-800-424-9300 (toll free) or 1-703-527-3887 2. HAZARDS IDENTIFICATION WARNING: EMERGENCY OVERVIEW ABRASION COULD RELEASE RESPIRABLE PARTICLES OF SILICA QUARTZ, A CANCER HAZARD BY INHALATION. NORMAL USE OF THIS PRODUCT CAUSES NO SUCH RELEASE. CAUSES SKIN IRRITATION. HAZARD CLASS HAZARD CATEGORY SKIN IRRITATION 2 PICTOGRAM(S) Precautionary Statements Prevention: Response: Storage: Disposal: Wash thoroughly after handling. Wear protective gloves. IF ON SKIN: Wash with plenty of soap and water. If skin irritation occurs: Get medical attention. Take off contaminated clothing. Not prescribed Not prescribed Classification complies with OSHA Hazard Communication Standard (29 CFR 1910.1200) and is consistent with the provisions of the United Nations Globally Harmonized System of Classification and Labeling of Chemicals (GHS). See Section 11 for additional toxicological information. 3. COMPOSITION / INFORMATION ON INGREDIENTS Hazardous Component(s) CAS Number Percentage* Distillates (petroleum), hydrotreated light 64742-53-6 5-10 Page 1 of 6
Distillates (petroleum), hydrotreated heavy 64742-52-5 10-30 Quartz (SiO2) 14808-60-7 0.1-1 Carbon black 1333-86-4 5-10 * Exact percentage is a trade secret. Concentration range is provided to assist users in providing appropriate protections. 4. FIRST AID MEASURES Inhalation: Skin contact: Eye contact: Ingestion: Move to fresh air, consult doctor if complaint persists. Wash with soap and water. Obtain medical attention if irritation persists. Flush eyes with plenty of water for at least 5 minutes. If irritation persists seek medical attention. Seek medical advice, symptomatic treatment. Symptoms: See Section 11. 5. FIRE FIGHTING MEASURES Extinguishing media: Special firefighting procedures: Unusual fire or explosion hazards: Hazardous combustion products: Wear self-contained breathing apparatus and full protective clothing, such as turn-out gear. In case of fire toxic gases can be released. 6. ACCIDENTAL RELEASE MEASURES Use personal protection recommended in Section 8, isolate the hazard area and deny entry to unnecessary and unprotected personnel. Environmental precautions: Clean-up methods: Do not allow product to enter sewer or waterways. 7. HANDLING AND STORAGE Handling: Storage: Do not handle or store near an open flame, heat or other sources of ignition. Keep in a cool, well ventilated area. For information on product shelf life, please review labels on container or check the Technical Data Sheet. Page 2 of 6
8. EXPOSURE CONTROLS / PERSONAL PROTECTION Employers should complete an assessment of all workplaces to determine the need for, and selection of, proper exposure controls and protective equipment for each task performed. Hazardous Component(s) ACGIH TLV OSHA PEL AIHA WEEL OTHER Distillates (petroleum), hydrotreated light Distillates (petroleum), hydrotreated heavy Quartz (SiO2) Carbon black Included in the regulation but with no data values. See regulation for further details Exposure by all routes should be carefully controlled to levels as low as possible. 5 mg/m3 TWA mist 10 mg/m3 STEL mist Exposure by all routes should be carefully controlled to levels as low as possible. Included in the regulation but with no data values. See regulation for further details 0.025 mg/m3 TWA Respirable fraction. 3 mg/m3 TWA Inhalable fraction. 5 mg/m3 TWA mist 10 mg/m3 TWA mist 500 ppm (2,000 mg/m3) PEL 5 mg/m3 PEL Mist. 5 mg/m3 TWA mist 500 ppm (2,000 mg/m3) PEL 5 mg/m3 PEL Mist. 2.4 MPPCF TWA Respirable. 0.1 mg/m3 TWA Respirable. 0.3 mg/m3 TWA Total dust. 3.5 mg/m3 PEL Engineering controls: Respiratory protection: Eye/face protection: Skin protection: No particular measures required. General room ventilation is usually adequate. Not normally required. Safety glasses. Use impermeable gloves and protective clothing as necessary to prevent skin contact. 9. PHYSICAL AND CHEMICAL PROPERTIES Physical state: Color: Odor: Odor threshold: ph: Vapor pressure: Boiling point/range: Melting point/ range: Vapor density: Flash point: Flammable/Explosive limits - lower: Flammable/Explosive limits - upper: Autoignition temperature: Evaporation rate: Solubility in water: Partition coefficient (n-octanol/water): foil black Slight Not applicable No data available. Page 3 of 6
VOC content: Viscosity: Decomposition temperature: < 1 g/l 10. STABILITY AND REACTIVITY Stability: Hazardous reactions: Hazardous decomposition products: Incompatible materials: Reactivity: Conditions to avoid: Stable under normal conditions of storage and use. Will not occur. Oxides of carbon. Oxides of nitrogen. Aldehydes. Acrolein. Hydrocarbons. Irritating and toxic gases or fumes may be released during a fire. Acids. Bases. Oxidizers. Excessive heat. 11. TOXICOLOGICAL INFORMATION Relevant routes of exposure: Skin Potential Health Effects/Symptoms Inhalation: Skin contact: Eye contact: Ingestion: Not a relevant route of exposure. Prolonged and/or repeated skin contact may result in mild irritation or redness. Not expected to cause injury. Eye contact may cause mild irritation. Not a relevant route of exposure. Hazardous Component(s) LD50s and LC50s Immediate and Delayed Health Effects Distillates (petroleum), hydrotreated light Distillates (petroleum), hydrotreated heavy Quartz (SiO2) Irritant Irritant Immune system, Lung, Some evidence of carcinogenicity Carbon black Oral LD50 (RAT) = > 8,000 mg/kg Respiratory, Some evidence of carcinogenicity Hazardous Component(s) NTP Carcinogen IARC Carcinogen OSHA Carcinogen (Specifically Regulated) Distillates (petroleum), hydrotreated light Known To Be Human Carcinogen. Group 1 No Distillates (petroleum), hydrotreated Known To Be Human heavy Carcinogen. Group 1 No Quartz (SiO2) Known To Be Human Carcinogen. Group 1 No Carbon black No Group 2B No 12. ECOLOGICAL INFORMATION Ecological information: Page 4 of 6
13. DISPOSAL CONSIDERATIONS Information provided is for unused product only. Recommended method of disposal: Hazardous waste number: Dispose of according to Federal, State and local governmental regulations. It is the responsibility of the user to determine if an item is hazardous as defined in the Resource Conservation and Recovery Act (RCRA) at the time of disposal. Product uses, transformations, mixtures, processes, etc., may render the resulting material hazardous, under the criteria of ignitability, corrosivity, reactivity and toxicity characteristics of the Toxicity Characteristics Leaching Procedure (TCLP) 40 CFR 261.20-24. 14. TRANSPORT INFORMATION The transport information provided in this section only applies to the material/formulation itself, and is not specific to any package/configuration. U.S. Department of Transportation Ground (49 CFR) Proper shipping name: Not regulated Hazard class or division: Identification number: Packing group: International Air Transportation (ICAO/IATA) Proper shipping name: Hazard class or division: Identification number: Packing group: Water Transportation (IMO/IMDG) Proper shipping name: Hazard class or division: Identification number: Packing group: Not regulated Not regulated 15. REGULATORY INFORMATION United States Regulatory Information TSCA 8 (b) Inventory Status: TSCA 12 (b) Export Notification: CERCLA/SARA Section 302 EHS: CERCLA/SARA Section 311/312: CERCLA/SARA Section 313: California Proposition 65: All components are listed or are exempt from listing on the Toxic Substances Control Act Inventory. above reporting de minimis above reporting de minimis Immediate Health, Delayed Health above reporting de minimis This product contains a chemical known in the State of California to cause cancer. Canada Regulatory Information CEPA DSL/NDSL Status: All components are listed on or are exempt from listing on the Canadian Domestic Substances List. 16. OTHER INFORMATION This safety data sheet contains changes from the previous version in sections: New Material Safety Data Sheet format. Prepared by: Mary Ellen Roddy, Sr. Regulatory Affairs Specialist Issue date: 12/17/2014 Page 5 of 6
DISCLAIMER: The data contained herein are furnished for information only and are believed to be reliable. However, Henkel Corporation and its affiliates ( Henkel ) does not assume responsibility for any results obtained by persons over whose methods Henkel has no control. It is the user s responsibility to determine the suitability of Henkel s products or any production methods mentioned herein for a particular purpose, and to adopt such precautions as may be advisable for the protection of property and persons against any hazards that may be involved in the handling and use of any Henkel s products. In light of the foregoing, Henkel specifically disclaims all warranties, express or implied, including warranties of merchantability and fitness for a particular purpose, arising from sale or use of Henkel s products. Henkel further disclaims any liability for consequential or incidental damages of any kind, including lost profits. Page 6 of 6