SAFETY DATA SHEET 1. Identification Product identifier Product name Product number 6195, 6045, 6044, 6190 Recommended use of the chemical and restrictions on use Application Hand Sanitiser Details of the supplier of the safety data sheet Supplier Deb Australia Pty Ltd Unit 1, 1 Secombe Place Moore Bank MSW 2170, Phone: (61 2) 8763 1800 Fax: (61 2) 8763 1899 Email:SALES@DEB.COM.AU Deb New Zealand Ltd PO Box 97740 Manukau Auckland 2241 NZ Phone: 0800 332 695 Fax: 0800 332 329 Manufacturer Emergency telephone number Emergency telephone DEB Worldwide Healthcare Inc 76 Adams Boulevard Brantford Ontario N3S 7V2 Telephone: 519-759-1051 Fax: 519-759-6384 CANUTEC 613-996-6666 (24 hours) NSW Poisons Information Centre Contact 131126 New Zealand Call 0800 764 766 2. Hazard(s) identification CLASSIFIED AS HAZARDOUS ACCORDING TO HAZARDOUS SUBSTANCES [CLASSIFICATION] REGULATIONS 2001 HSNO CLASSIFICATION 3.1B Flammable liquids: high hazard 6.4A Substances that are irritating to the eye 1/7
Environmental Physicochemical The product contains a substance which has a photochemical ozone creation potential. The product is highly flammable. Vapors may form explosive mixtures with air. Label elements Pictogram Signal word Hazard statements Precautionary statements Warning H225 Highly flammable liquid and vapor H320 Causes eye irritation. P103 Read label before use (applies only where the substance is available to the general public) P210 Keep away from heat/sparks/open flames/hot surfaces. No smoking. P233 Keep container tightly closed. P240 Ground/ bond container and receiving equipment. P241 Use explosion-proof electrical equipment. P242 Use only non-sparking tools. P243 Take precautionary measures against static discharge. P280 Wear protective gloves/ protective clothing/ eye protection/ face protection. P303+P361+P353 If on skin (or hair): Take off immediately all contaminated clothing. Rinse skin with water/ shower. P305 + P351 +P338 IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. P337 + P313 If eye irritation persists: Get medical advice/attention. P370+P378 In case of fire: Use foam, carbon dioxide, dry powder or water fog to extinguish. P403+P235 Store in a well-ventilated place. Keep cool. P501 Dispose of contents/ container in accordance with national regulations. 3. Composition/information on ingredients Substances INCI Mixtures Dehydrated Ethyl Alcohol 30-60% CAS number: 64-17-5 Classification Not Classified N-Propanol 10-30% CAS number: 71-23-8 Classification Not Classified 2/7
The full text for all hazard statements is displayed in Section 16. Composition comments Water, Propan-1-ol, Alcohol Denat., Glycerine, 1,3-Butylene Glycol, Glycol Ether, DEA-C8-18 Perfluroalkyethyl Phosphate, Coco Glucoside, Glyceryl Oleate 4. First-aid measures Description of first aid measures General information Get medical attention immediately. Inhalation Ingestion Skin Contact Eye contact Protection of first aiders General first aid, rest, warmth and fresh air. DO NOT induce vomiting. Get medical attention immediately. Wash off promptly and flush contaminated skin with water. Promptly remove clothing if soaked through and flush skin with water. Remove contact lenses, if present and easy to do. Continue rinsing. Promptly wash eyes with plenty of water while lifting the eye lids. Get medical attention if symptoms are severe or persist after washing. First aid personnel should wear appropriate protective equipment during any rescue. Most important symptoms and effects, both acute and delayed Inhalation No specific symptoms known. Ingestion Skin contact Eye contact May cause nausea, headache, dizziness and intoxication. None known. May cause irritation. Indication of immediate medical attention and special treatment needed Specific first aid measures No Specific first aid measures noted 5. Fire-fighting measures Extinguishing media Suitable extinguishing media Extinguish with alcohol-resistant foam, carbon dioxide, dry powder or water fog. Special hazards arising from the substance or mixture Flammability Class 7.1 Flammable Liquid IC. Specific hazards Advice for firefighters Protective actions during firefighting Special protective equipment for firefighters Emergency Action Code During fire, toxic gases (CO, CO2) are formed. If possible, fight fire from protected position. Containers close to fire should be removed or cooled with water. Wear positive-pressure self-contained breathing apparatus (SCBA) and appropriate protective clothing. 3YE 6. Accidental release measures Personal precautions, protective equipment and emergency procedures Personal precautions Take precautionary measures against static discharges. No smoking, sparks, flames or other sources of ignition near spillage. Wear suitable protective clothing as protection against splashing or contamination. Avoid inhalation of vapors and contact with eyes Environmental precautions 3/7
Environmental precautions Do not discharge onto the ground or into water courses. Contain spillage with sand, earth or other suitable non-combustible material. Methods and material for containment and cleaning up Methods for cleaning up Extinguish all ignition sources. Avoid sparks, flames, heat and smoking. Ventilate. Wash throughly after dealing with a spillage. Adsorb spillage with non-combustible, adsobent material. Collect in containers and seal securely. Reference to other sections For personal protection, see Section 8. 7. Handling and storage Precautions for safe handling Usage precautions Keep away from heat, sparks and open flame. Avoid contact with eyes. Conditions for safe storage, including any incompatibilities Storage precautions Storage class Store in tightly closed original container in a dry, cool and well-ventilated place. Keep away from heat, sparks and open flame. Flammable liquid storage. Specific end uses(s) Specific end use(s) The identified uses for this product are detailed in Section 1.2. 8. Exposure Controls/personal protection Control parameters Occupational exposure limits N-Propanol Long-term exposure limit (8-hour TWA): OSHA 200 ppm 500 mg/m³ OSHA = Occupational Safety and Health Administration. Ingredient comments WEL = Workplace Exposure Limits Exposure controls Protective equipment Immediate danger to life and health 800 ppm N-Propanol (CAS: 71-23-8) Appropriate engineering controls Eye/face protection Hand protection Hygiene measures Respiratory protection Not relevant. Not required normally but wear eye protection if you are conducting an operation where there is a risk of this product getting in the eyes. Hand protection not required. DO NOT SMOKE IN WORK AREA! Promptly remove any clothing that becomes contaminated. Not relevant. 4/7
9. Physical and Chemical Properties Information on basic physical and chemical properties Appearance Clear to slightly opalescent yellowish liquid Color Clear to slightly opalencent yellowish ph 6.5-8.5 Bulk density 0.880-0.895 g/ml 10. Stability and reactivity Reactivity Stability Possibility of hazardous reactions Conditions to avoid Materials to avoid Hazardous decomposition products There are no known reactivity hazards associated with this product. No particular stability concerns. Not known. Avoid heat, flames and other sources of ignition. No specific material or group of materials is likely to react with the product to produce a hazardous situation. Oxides of carbon. 11. Toxicological information Information on toxicological effects Respiratory Sensitisation Eye Irritation/Damage Skin Sensitisation General information Inhalation Ingestion Skin Contact Eye contact No specific health hazards known. No specific health hazards known. May cause nausea, headache, dizziness and intoxication. Skin irritation should not occur when used as recommended. Irritating to eyes. Symptoms following overexposure may include the following: Redness. Pain. 12. Ecological Information Toxicity Toxicity No data available. Persistence and degradability Persistence and degradability Data to support this assertion are held at the disposal of the competent authorities of the Member States and will be made available to them at their direct request, or at the request of a detergent manufacturer. Bioaccumulative potential 5/7
Bio-Accumulative Potential Mobility in soil Mobility No data available on bioaccumulation. The product is soluble in water. Results of PBT and vpvb assessment Results of PBT and vpvb This product does not contain any substances classified as PBT or vpvb. Assessment 6/7
Other adverse effects Other adverse effects None known. 13. Disposal considerations Waste treatment methods General information Disposal methods Waste should be treated as controlled waste. Dispose of waste to licensed waste disposal site in accordance with the requirements of the local Waste Disposal Authority. The empty Instantfoam cartridge is made of polythene (Polyethylene) so you can recover, reclaim or recycle it. Dispose of waste to licensed waste disposal site in accordance with the requirements of the local Waste Disposal Authority. Reuse or recycle products wherever possible. 14. Transport information CLASSED AS A DANGEROUS GOOD ACCORDING TO LAND TRANSPORT RULE: DANGEROUS GOODS 2005; NZS 5433:2007, UN, IMDG OR IATA Shipping Name ETHANOL (ETHYL ALCOHOL) or ETHANOL SOLUTION (ETHYL ALCOHOL SOLUTION) UN No. 1170 DG Class 3 Subsidiary Risk(s) None Allocated Packing Group III Hazchem Code 2YE EPG 3A1 IATA Shipping Name ETHANOL (ETHYL ALCOHOL) or ETHANOL SOLUTION (ETHYL ALCOHOL SOLUTION) UN No. 1170 DG Class 3 Subsidiary Risk(s) None Allocated Packing Group III IMDG Shipping Name ETHANOL (ETHYL ALCOHOL) or ETHANOL SOLUTION (ETHYL ALCOHOL SOLUTION) UN No. 1170 DG Class 3 Subsidiary Risk(s) None Allocated Packing Group III 15. Regulatory information Regulatory References National Code of Practice for the Labeling of Workplace Substances. National Code of Practice for the Preparation of Material Safety Data Sheets, Australian Inventory of Chemical Substances (AICS) and Standard for the Uniform Scheduling of Drugs and Poisons (SUSDP) This product is manufactured in compliance with the requirements of the Therapeutic Goods Administration. It is made according to GMP requirements. International Regulations NZ: Classified as hazardous according to Hazardous Substances (Classification) Regulations 2001 Approval Code HSR002528 Group Name Cleaning Products (Flammable) Group Standard 2006 HSNO Controls Refer to the ERMA website for more information: www.ermanz.govt.nz 7/7
16. Other information Revision comments. New SDS Software Revision of information Revision date 7/25/2016 Revision 5 Supersedes date 12/15/2015 SDS No. 20854 8/7