Page: 1 Compilation date: 04/08/2004 Revision date: 23/04/2015 Revision No: 11 Section 1: Identification of the substance/mixture and of the company/undertaking 1.1. Product identifier Product name: Product code: SRP/3/190510 1.2. Relevant identified uses of the substance or mixture and uses advised against Use of substance / mixture: Polish for use on motor vehicle bodies 1.3. Details of the supplier of the safety data sheet Company name: AUTOGLYM Works Road Letchworth Herts SG6 1LU UK Tel: +44 (0) 1462 677766 Fax: +44 (0) 1462 677712 Email: sds@autoglym.co.uk 1.4. Emergency telephone number Emergency tel: +44 (0) 1462 489498 (24Hrs) Section 2: Hazards identification 2.1. Classification of the substance or mixture Classification under CLP: Classification under CHIP: STOT SE 3: H336; -: EUH208 This product has no classification under CHIP. 2.2. Label elements Label elements under CLP: Hazard statements: Signal words: Hazard pictograms: * H336: May cause drowsiness or dizziness. EUH208: Contains 1,2-benzisothiazol-3(2H)-one and 2-methyl-2H-isothiazol-3-one. May produce an allergic reaction. * Warning * GHS07: Exclamation mark
Precautionary statements: 2.3. Other hazards SAFETY DATA SHEET * P102: Keep out of reach of children. P261: Avoid breathing vapours. P312: Call a POISON CENTER or doctor if you feel unwell. P403+233: Store in a well-ventilated place. Keep container tightly closed. P405: Store locked up. P271: Use only outdoors or in a well-ventilated area. Page: 2 PBT: This product is not identified as a PBT/vPvB substance. Section 3: Composition/information on ingredients 3.2. Mixtures Hazardous ingredients: NAPHTHA (PETROLEUM) HYDROTREATED HEAVY EINECS CAS CHIP Classification CLP Classification Percent 265-151-9 - Xn: R65; -: R10; -: R66 Substance with a Community workplace exposure limit. Asp. Tox. 1: H304; STOT SE 3: H336; Flam. Liq. 3: H226; -: EUH066 DISTILLATES (PETROLEUM) HYDROTREATED LIGHT - REACH registered number(s): 01-2119484819-18-0001 10-30% 265-149-8 64742-47-8 Xn: R65; -: R66 Substance with a Community workplace exposure limit. Asp. Tox. 1: H304 1-10% Section 4: First aid measures 4.1. Description of first aid measures Skin contact: Eye contact: Ingestion: Inhalation: Wash immediately with plenty of soap and water. Bathe the eye with running water for 15 minutes. Wash out mouth with water. Consult a doctor. 4.2. Most important symptoms and effects, both acute and delayed Skin contact: Eye contact: Ingestion: Inhalation: There may be mild irritation at the site of contact. There may be irritation and redness. There may be irritation of the throat. There may be irritation of the throat with a feeling of tightness in the chest. 4.3. Indication of any immediate medical attention and special treatment needed Immediate / special treatment: Not applicable.
Page: 3 Section 5: Fire-fighting measures 5.1. Extinguishing media Extinguishing media: Suitable extinguishing media for the surrounding fire should be used. 5.2. Special hazards arising from the substance or mixture Exposure hazards: In combustion emits toxic fumes. 5.3. Advice for fire-fighters Advice for fire-fighters: Wear self-contained breathing apparatus. Wear protective clothing to prevent contact with skin and eyes. Section 6: Accidental release measures 6.1. Personal precautions, protective equipment and emergency procedures Personal precautions: Refer to section 8 of SDS for personal protection details. 6.2. Environmental precautions Environmental precautions: Do not discharge into drains or rivers. 6.3. Methods and material for containment and cleaning up Clean-up procedures: Wash the spillage site with large amounts of water. 6.4. Reference to other sections Reference to other sections: Refer to section 8 of SDS. Section 7: Handling and storage 7.1. Precautions for safe handling Handling requirements: Avoid the formation or spread of dust in the air. 7.2. Conditions for safe storage, including any incompatibilities Storage conditions: Store in cool, well ventilated area. 7.3. Specific end use(s) Specific end use(s): Section 8: Exposure controls/personal protection 8.1. Control parameters Workplace exposure limits: DNEL/PNEC Values DNEL / PNEC
Page: 4 8.2. Exposure controls Engineering measures: Respiratory protection: Hand protection: Eye protection: Skin protection: Ensure there is sufficient ventilation of the area. Respiratory protective device with particle filter. Protective gloves. Safety glasses. Ensure eye bath is to hand. Protective clothing. Section 9: Physical and chemical properties 9.1. Information on basic physical and chemical properties State: Liquid Colour: White Odour: Characteristic odour Evaporation rate: Oxidising: Solubility in water: Not miscible Viscosity: Viscous Boiling point/range C: 100 Melting point/range C: Flammability limits %: lower: upper: Flash point C: 61 Part.coeff. n-octanol/water: Autoflammability C: Vapour pressure: Relative density: 0.98 ph: 5.5 VOC g/l: 9.2. Other information Other information: Section 10: Stability and reactivity 10.1. Reactivity Reactivity: Stable under recommended transport or storage conditions. 10.2. Chemical stability Chemical stability: Stable under normal conditions. 10.3. Possibility of hazardous reactions Hazardous reactions: Hazardous reactions will not occur under normal transport or storage conditions. Decomposition may occur on exposure to conditions or materials listed below. 10.4. Conditions to avoid Conditions to avoid: Heat.
Page: 5 10.5. Incompatible materials Materials to avoid: Strong oxidising agents. Strong acids. 10.6. Hazardous decomposition products Haz. decomp. products: In combustion emits toxic fumes. Section 11: Toxicological information 11.1. Information on toxicological effects Toxicity values: Symptoms / routes of exposure Skin contact: Eye contact: Ingestion: Inhalation: There may be mild irritation at the site of contact. There may be irritation and redness. There may be irritation of the throat. There may be irritation of the throat with a feeling of tightness in the chest. Section 12: Ecological information 12.1. Toxicity Hazardous ingredients: DISTILLATES (PETROLEUM) HYDROTREATED LIGHT - 72H IC50 20 ppm 12.2. Persistence and degradability Persistence and degradability: Biodegradable. 12.3. Bioaccumulative potential Bioaccumulative potential: No bioaccumulation potential. 12.4. Mobility in soil 12.5. Results of PBT and vpvb assessment PBT identification: This product is not identified as a PBT/vPvB substance. 12.6. Other adverse effects Other adverse effects: Negligible ecotoxicity. Section 13: Disposal considerations 13.1. Waste treatment methods Waste code number: 140603 NB: The user's attention is drawn to the possible existence of regional or national regulations regarding disposal.
Page: 6 Section 14: Transport information Transport class: This product does not require a classification for transport. Section 15: Regulatory information 15.1. Safety, health and environmental regulations/legislation specific for the substance or mixture 15.2. Chemical Safety Assessment Section 16: Other information Other information Other information: This safety data sheet is prepared in accordance with Commission Regulation (EU) No 453/2010. Phrases used in s.2 and s.3: Legend to abbreviations: * indicates text in the SDS which has changed since the last revision. EUH066: Repeated exposure may cause skin dryness or cracking. EUH208: Contains <name of sensitising substance>. May produce an allergic reaction. H226: Flammable liquid and vapour. H304: May be fatal if swallowed and enters airways. H336: May cause drowsiness or dizziness. R10: Flammable. R65: Harmful: may cause lung damage if swallowed. R66: Repeated exposure may cause skin dryness or cracking. PNEC = predicted no effect level DNEL = derived no effect level LD50 = median lethal dose LC50 = median lethal concentration EC50 = median effective concentration IC50 = median inhibitory concentration dw = dry weight bw = body weight cc = closed cup oc = open cup MUS = mouse GPG = guinea pig RBT = rabbit HAM = hamster HMN = human MAM = mammal PGN = pigeon IVN = intravenous SCU = subcutaneous
Legal disclaimer: SAFETY DATA SHEET Page: 7 SKN = skin DRM = dermal OCC = ocular/corneal PCP = phycico-chemical properties The above information is believed to be correct but does not purport to be all inclusive and shall be used only as a guide. This company shall not be held liable for any damage resulting from handling or from contact with the above product. [final page]