Product's ID: KG-1 CARBON REMOVER Prepared 7/1/97 Printed: 11/23/2009 MATERIAL SAFETY DATA SHEET Section I Identification Product Identification KG-1 Carbon Remover Note: Blank fields are not permitted Manufacturer's Name Emergency Phone # KG Industries, LLC (800) 424-9300 Address: 204 Mustang Cove Information Phone # Taylor, TX 76574 (800) 348-9558 Section II Hazardous Ingredients DODECYBENZINE SULFONIC ACID Trade Secret 27176-87-0 PEL: TLV: LISTED 1. METHYL 2. PYRROLIDONE Trade Secret 872-50-4 N-METHYLPYRROLIDONE PEL: TLV: 100 PPM ESTIMATED LISTED MONOETHANOLAMINE Trade Secret 141-43-5 PEL: 3 PPM: TLV: 3 PPM 6 PPM BUTOXYETHANOL Trade Secret 111-76-2 GLYCOL ETHER, ETHYLENE GLYCOL, BUTYL CELLOSOLVE PEL: 50 PPM TLV: 25 PPM
Product's ID: KG-1 CARBON REMOVER Page 2. Section III Physical and Chemical Characteristics Boiling Point: 212 F : Specific Gravity: 1.015 Vapor Pressure: 06 @ 20C : Melting Point: N/A Vapor Density: 4.1 : Evaporation Rate: <1 SOLUBILITY IN WATER 100% SOLUABLE IN WATER APPEARANCE AND ODOR SLIGHT AMBER COLOR, MILD ODOR Section IV Fire and Explosion Hazard Data Flash Point: 195 F Limits: Lel: N/A Uel: N/A EXTINGUISHING MEDIA: USE WATER SPRAY, DRY CHEMICAL, CO2, OR ALCOHOL FOAM. SPECIAL FIRE FIGHTING PROCEDURES: FIRE FIGHTERS SHOULD WEAR SELF-CONTAINED BREATHING APPARATUS AND FULL PROTECTIVE CLOTHING. USE WATER SPRAY TO COOL NEARBY CONTAINERS AND STRUCTURES EXPOSED TO FIRES. UNUSUAL FIRE AND EXPLOSION HAZARDS: NO UNUSUAL FIRE OR EXPLOSION ARE EXPECTED STABILITY: STABLE Section V Reactivity Data CONDITIONS TO AVOID: STORE SEPARATE FROM ACIDS AND OXIDIZERS INCOMPATIBILITY (MATERIALS TO AVOID): OXIDIZING MATERIALS AND ACIDS HAZARDOUS DECOMPOSITION PRODUCTS: CARBON MONOXIDE, CARBON DIOXIDE AND UNIDENTIFIED ORGANIC COMPOUNDS IN THE FORM OF BLACK SMOKE HAZARDOUS POLYMERIZATION: WILL NOT OCCUR CONDITIONS TO AVOID: NO POLYMERIZING CONDITIONS ARE KNOWN
Product's ID: KG-1 CARBON REMOVER Page 3. Section VI Health Hazard Data CARCINOGENICITY NO NTP NO IARC NO OSHA REGULATED YES EFFECTS AND HAZARDS OF OVEREXPOSURE (ACUTE AND CHRONIC) EFFECTS AND HAZARDS OF EYE CONTACT VAPORS WILL IRRITATE EYES. LIQUID AND MISTS WILL IRRITATE AND MAY DAMAGE EYES, CAUSING CORNEAL INJURY. EFFECTS AND HAZARDS OF SKIN CONTACT PROLONGED OR REAPEATED WITH SKIN CAUSES IRRITATION, SWELLING AND POSSIBLE SKIN DAMAGE. EFFECTS AND HAZARDS OR INHALATION (BREATHING) VAPORS AND MIST CAN CAUSE NASAL IRRITATION OR DISTRESS. EFFECTS AND HAZARDS OF INGESTION (SWALLOWING) MODERATELY TOXIC, MAY CAUSE HEADACHE, DIZZINESS, NAUSEA, VOMITING AND DIARREA. SWALLOWING MAY ALSO CAUSE RED BLOOD CELL HEMOLYSIS, AND POSSIBLE LIVER, KIDNEY AMD LUNG INJURY. Emergency And First Aid Procedures TREATMENT FOR EYE CONTACT IMMEDIATELY FLUSH EYES WITH WATER FOR 15 MINUTES WHILE HOLDING EYELIDS OPEN. GET MEDICAL ATTENTION. TREATMENT FOR SKIN CONTACT FLUSH SKIN WITH WATER WHILE REMOVING CONTAMINATED CLOTHING. FOLLOW BY WASHING WITH SOAP AND WATER. DO NOT USE CLOTHS UNTIL WASHED. IF IRRITATION PERSISTS GET MEDICAL TREATMENT. TREATMENT FOR INHALATION (BREATHING) REMOVE VICTIM TO FRESH AIR AND PROVIDE OXYGEN IF BREATHING IS DIFFICULT. GIVE ARTIFICIAL RESPIRATION IF NOT BREATHING. GET MEDICAL ATTENTION. TREATMENT FOR INGESTION (SWALLOWING) IF SWALLOWED AND VICTIM IS CONSCIOUS, IMMEDIATELY INDUCE VOMITING BY GIVING TWO GLASSES OF WATER AND STICKING A FINGER DOWN THE THROAT. DO NOT GIVE ANYTHING TO AN UNCONSCIOUS OR CONVULSING PERSON. Product's ID: KG-1 CARBON REMOVER Page 4.
Section VII Precautions for Save Handling and Use STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED LARGE SPILLS: SHUT OFF SOURCE OF SPILLAGE IF SAFE TO DO SO AND CONTAIN SPILL. WEAR PERSONAL PROTECTIVE EQUIPTMENT. REMOVE HEAT AND IGINITION SOURCES, VENTILATE THE AREA, CLEAN UP WITH INERT ABSORBANT. AVOID DISCHRGE TO SEWERS, SOIL AND WATERWAYS. SMALL SPILLS: SOAK UP WITH ABSORBANT MATERIAL AND PLACE IN NON-LEAKING CONTAINERS. SEAL TIGHTLY AND DISPOSE OF ACCORDING TO LOCAL, STATE AND FEDERAL GUIDLINES. WASTE DISPOSAL METHOD: USE NON-LEAKING CONTAINERS SEALED TIGHTLY AND LABLED PROPERLY. DISPOSE OF ACCORDING TO LOCAL, STATE AND FEDERAL REGULATIONS. PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING AVOID OVERHEATING AND FREEZING. SPILLED MATERIAL MAY BE SLIPPERY. WASH THOROUGHLY AFTER HANDLING. OTHER PRECAUTIONS CONTAINERS, EVEN THOSE THAT HAVE BEEN EMPTIED WILL RETAIN PRODUCT RESIDUE AND VAPORS. ALWAYS OBEY HAZARD WARNINGS AND HANDLE EMPTY CONTAINERS AS IF THEY WERE FULL. Section VIII Control Measures RESPIRATORY PROTECTION USE A NIOSH APPROVED RESPIRATOR AS REQUIRED TO PREVENT OVEREXPOSURE. IN ACCORD WITH 29 CFR 1910.143. USE EITHER A ATMOSPHERE SUPPLYING RESPIRATOR OR AN AIR-PURIFYING RESPIRATOR FOR ORGANIC VAPORS.. VENTILATION USE VENTILATION AS REQUIRED TO CONTROL VAPOR CONCENTRATIONS. * MECHANICAL (GENERAL) VENTILATION: USE IN A WELL VENTED AREA. OTHER VENTILATION: USE IN A WELL VENTED AREA Product's ID: KG-1 CARBON REMOVER Page 5. PROTECTIVE GLOVES WEAR CHEMICAL RESISTANT GLOVES AND CLOTHING AS NEEDED TO
PREVENT SKIN CONTACT. Section VIII Control Measures (Continued) EYE PROTECTION USE GOGGLES OR FACESHIELD WHEN USING THIS PRODUCT OTHER PROTECTIVE EQUIPMENT WEAR PROTECTIVE EQUIPMENT, CLOTHING AS REQUIRED TO PREVENT SKIN CONTACT. WORK AND HYGIENIC PRACTICES AVOID CONTACT WITH SKIN AND AVOID BREATHING VAPORS. DO NOT EAT, DRINK OR SMOKE IN THE WORK AREA. WASH HANDS. WASH EXPOSED AREAS OF SKIN WITH SOAP AND WATER. DISCLAIMER Judgment as to the suitability of the information contained herein or the purchaser s are the purchaser s responsibility. Reasonable care has been taken in the preparation of this information. KG Products, its agents employees or consultants extends no warranties, makes no representations and assumes no responsibility for this information or for any purchasers use or any consequences for the use of this product.