Material Safety Data Sheet SECTION I - Material Identity SECTION II - Manufacturer's Information SECTION III - Physical/Chemical Characteristics SECTION IV - Fire and Explosion Hazard Data SECTION V - Reactivity Data SECTION VI - Health Hazard Data SECTION VII - Precautions for Safe Handling and Use SECTION VIII - Control Measures SECTION IX - Label Data SECTION X - Transportation Data SECTION XI - Site Specific/Reporting Information SECTION XII - Ingredients/Identity Information SECTION I - Material Identity Item Name Part Number/Trade Name National Stock Number CAGE Code Part Number Indicator MSDS Number HAZ Code 99GY001 DEFTHANE ELT 36173 (FLUORO POLYURETHANE) GRAY 8010P99-GY-001 33461 A 194522 C SECTION II - Manufacturer's Information Manufacturer Name Street City State Country Zip Code Emergency Phone Information Phone DEFT, INC 17451 VON KARMAN AVE IRVINE CA US 92614 800-424-9300 CHEMTREC 949-474-0400 MSDS Preparer's Information Date MSDS Prepared/Revised - -Ac t-i v-e tn dtcat o^- 24FEB04 Alternate Vendors
99GY001 DEFTHANE ELT 36173 (FLUORO POLYURETHANE) GRAY Page 2 of 7 Specification Number Hazard Storage Compatibility Code C License Number Net Propellant Weight (Ammo) Appearance/Odor Boiling Point Melting Point Vapor Pressure Vapor Density Specific Gravity Decomposition Temperature Evaporation Rate Solubility in Water Volatiles by Volume Chemical ph Corrosion Rate Container Type Container Pressure Code Temperature Code Product State Code MIL-C-85285 GRAY LIQUID WITH SOLVENT ODOR 260-480 F > AIR 1.1129 0.37 INSOLUBLE 55.2 NA R 1 4 L SECTION IV - Fire and Explosion Hazard Data Flash Point Flash Point Method Lower Explosion Limit Upper Explosion Limit Extinguishing Media Special Fire Fighting Procedures Unusual Fire/Explosion Hazards 67 TCC 0.81 14 FOAM, ALCOHOL FOAM, C02, DRY CHEMICAL, WATER FOG, WATER SPRAY FULL FIRE FIGHTING EQUIPMENT WITH SCBA AND FULL PROTECTIVE GEAR SHOULD BE WORN BY FIRE FIGHTERS. WATER MAY BE USED TO COOL CLOSED CONTAINERS TO PREVENT PRESSURE BUILDUP, AUTO IGNITION OR EXPLOSION KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE FROM HEAT, SPARKS, ELECTRICAL EQUIPMENT AND OPEN FLAME. CLOSED CONTAINERS MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT. APPLICATION TO HOT SURFACES REQUIRES SPECIAL PRECAUTIONS. DURING EMERGENCY CONDITIONS OVEREXPOSURE TO DECOMPOSITION PRODUCTS MAY -CAUS -A-HEALTJi- -HAZARD _ SYMPTOMS MAY T BE IMMEDIATELY APPARENT
99GY001 DEFTHANE ELT 36173 (FLUORO POLYURETHANE) GRAY Page 3 of 7 Stability Stability Conditions to Avoid Materials to Avoid Hazardous Decomposition Hazardous Polymerization Products Polymerization Conditions to Avoid HIGH TEMPERATURES, SPARKS, OR OPEN FLAMES STRONG OXIDIZING AGENTS CARBON MOXIDE, CARBON DIOXIDE, AND OXIDES OF NITROGEN WILL T OCCUR SECTION VI - Health Hazard Data Route of Entry: Skin Route of Entry: Ingestion Route of Entry: Inhalation Health Hazards - Acute and Chronic Carcinogenity: NTP Carcinogenity: IARC Carcinogenity: OSHA Explanation of Carcinogenity Symptoms of Overexposure Medical Cond. Aggrevated by Exposure Emergency/First Aid Procedures [INHAL] IRRITATION OF THE RESPIRATORY TRACT AND ACUTE NERVOUS SYSTEM DEPRESSION CHARACTERIZED BY THE FOLLOWING PROGRESSIVE STEPS: HEADACHE, DIZZINESS, STAGGERING GAIT, CONFUSION, [SKIN] IRRITATION WITH SWELLING, REDNESS, AND RASH. PROLONGED/REPEATED IRRITATION, DRYING, AND DEFATTING (CRACKING OF THE SKIN) [E] LIQUID, AEROSOLS, OR VAPORS ARE IRRITATING AND MAY CAUSE TEARING, REDNESS, AND SWELLING ACCOMPANIED BY A STINGING SENSATION NE SEE ABOVE AND BELOW [INGEST] CAN RESULT IN IRRITATION AND POSSIBLE CORROSIVE ACTION IN THE MOUTH, STOMACH TISSUE AND DIGESTIVE TRACT. VOMITING MAY CAUSE ASPIRATION OF THE SOLVENT, RESULTING IN CHEMICAL PNEUMONITIS. [INHAL] VAPORS ARE IRRITATING TO E, SE, AND THROAT. INHALATION MAY CAUSE HEADACHES, DIFFICULT BREAHTING AND LOSS OF CONSCIOUSNE ASTHMA AND ANY OTHER RESPIRATORY DISORDERS. SKIN ALLERGIES, ECZEMA, AND CRMIIITIS [INHAL] MOVE TO AN AREA FREE FROM RISK OF FURTHER EXPOSURE. RESTORE BREATHING. OBTAIN MED
99GY001 DEFTHANE ELT 36173 (FLUORO POLYURETHANE) GRAY Page 4 of 7 LAUNDER BEFORE REUSE. WASH AFFECTED AREAS THOROUGHLY WITH SOAP AND WATER. [E] FLUSH WITH CLEAN LUKEWARM WATER (LOW PRESSURE) FOR AT LEAST 15 MIN ACCASIONALLY LIFT EYELIDS. OBTAIN MED ATTEN [INGEST] DO T INDUCE VOMITING. DO T GIVE ANYTHING TO AN UNCONSCIOUS PERSON. OBTAIN MED ATTENTION SECTION VII - Precautions for Safe Handling and Use Steps if Material Released/Spilled Waste Disposal Method Handling and Storage Precautions Other Precautions EVACUATE ALL N-ESSENTIAL PERSONNEL. REMOVE ALL SOURCES OF IGNITION (FLAME, SPARK SOURCES, HOT SURFACES). VENTILATE AREA. CONTAIN AND REMOVE WITH INERT ABSORBENT AND N- SPARKING TOOLS WASTE MUST BE DISPOSED OF IN ACCORDANCE WITH FEDERAL, STATE, AND LOCAL ENVIRONMENTAL CONTROL REGULATIONS. EMPTY CONTAINERS MUST BE HANDLED WITH CARE, DUE TO PRODUCT RESIDUE AND FLAMMABLE VAPOR DO T INCINERATE CLOSED CONTAINERS STORE IN BUILDINGS DESIGNED TO COMPLY WITH OSHA 1910.106. AVOID STORING NEAR HIGH TEMPERATURES, FIRE, OPEN FLAMES, AND SPARK SOURCES. STORE IN TIGHTLY CLOSED CONTAINERS. STORE IN WELL VENTILATED AREAS KEEP CONTAINERS TIGHT AND UPRIGHT TO PREVENT LEAKAGE, PREVENT PROLONGED BREATHING OF VAPORS OR SPRAY MISTS. PROLONGED OVEREXPOSURE MAY CAUSE AN ALLERGIC REACTION. AVOID CONTACT WITH SKIN AND E. DO T TAKE INTERNALLY. DO T HANDLE UNTIL THE MANUFACTURINERS SAFETY PRECAUTIONS HAVE BEEN READ AND UNDERSTOOD. WASH HANDS BEFORE EATING, SMOKING, OR USING WASHROOM. SMOKE IN SMOKING AREAS ONLY SECTION VIII - Control Measures ResDiratorv Protection IF TLV LIMITS CAN BE
99GY001 DEFTHANE ELT 36173 (FLUORO POLYURETHANE) GRAY Page 5 of 7 Ventilation Protective Gloves Eye Protection Other Protective Equipment Work Hygenic Practices LIMITS, AN AIR SUPPLIED RESPIRATOR MAY T BE REQUIRED. HOWEVER, OTHER OSHA/NIOSH APPROVED RESPIRATORS AMY BE USED EXHAUST VENTILATION SUFFICIENT TO KEEP THE AIRBORNE CONCENTRATIONS OF SOLVENT VAPORS OR MISTS BELOW THEIR RESPECTIVE TLV COTTON, NEOPRENE, RUBBER, POLYETHYLENE CHEM GOGGLES OR FACE SHIELDS LONG SLEEVE AND LONG LEG CLOTHING IS RECOMMENDED WASH THOROUGHLY AFTER HANDLING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE SECTION IX - Label Data Protect Eye Protect Skin Protect Respiratory Chronic Indicator Contact Code Fire Code Health Code React Code Specific Hazard and Precaution MODERATE UNKWN UNKWN UNKWN TARGET ORGANS: SKIN, RESPIRATORY SYSTEM SECTION X - Transportation Data Container Quantity Unit of Measure.75 GL SECTION XI - Site Specific/Reporting Information Volatile Organic Compounds (P/G) Volatile Organic Compounds (G/L) 3.9161 469.3 SECTION XII - Ingredients/Identity Information Ingredient I ^Proprietary 01 METHYL N-AMYL KETONE 110430 25 50 PPM
, 99GYOO 1 DEFTHANE ELT 36 1 73 (FLUORO POLYURETHANE) GRAY Page 6 of 7 Proprietary Recommended Limit Proprietary Recommended Limit Proprietary Recommended Limit Ingredient 1 DIPROPYLENE GLYCOL MOMETHYL ETHER 34590948 1 NE SPECIFED 03 XYLENE 1330207 5.85 NE SPECIFIED 04 ETHYL BENZENE 100414 1.22 NE SPECIFIED 05 TITANIUM DIOXIDE 13463677 5 06 COPPER, [29H,31H- PHTHALOCYANINATO(2-)- N29,N30,N31,N32]-, (SP-4- D- 147148 0. 02 07 DIETHYLBENZENE 25340174 0.1 08 2-PYRROLIDINE, 1-METHYL- 872504 0.29 09 ETHYL 3-ETHOXYPROPIONATE 763699 5 10 ( 2, 4-PENTANEDIONE «* PeJT CGI"1 1 5 11 STANNANE, DIBUTYLBIS [ ( 1-