Enerpac, A Division of Actuant N86 W12500 Westbrook Crossing Menomonee Falls, WI 53051 Phone: (262) 293-1500 Fax: (262) 293-7040
INHALATION: Remove exposed person to fresh air if adverse effects are observed. ORAL: DO NOT INDUCE VOMITING! If conscious, give 2 glasses of water. Get immediate medical attention. ADDITIONAL: Note to physician: treat symptomatically. SECTION 5 FIRE AND EXPLOSION HAZARDS FLASH POINT: UPPER FLAMMABLE LIMIT: LOWER FLAMMABLE LIMIT: 400 F 10% (Estimated value) 1% (Estimated value) EXTINGUISHING MEDIA: CO 2, dry chemical, foam, water spray, water fog SPECIAL FIRE FIGHTING PROCEDURES: Wear self contained breathing apparatus with full face piece. Cool exposed containers with water spray. Avoid breathing fumes. UNUSUAL FIRE & EXPLOSION HAZARDS: Toxic fumes may be evolved on burning or exposure to heat. Pressure may increase in overheated closed containers. Store below 120 F. SECTION 6 - SPILL OR LEAK PROCEDURES SPILL PROCEDURES: Prevent entry into sewers and waterways. Pick up free liquid for recycle or disposal. Absorb small amounts with an inert material. WASTE DISPOSAL: Dispose according to current local, state and federal regulations. Materials may become hazardous waste through use. If permitted, incineration may be practical. Consider recycling. SECTION 7 HANDLING AND STORAGE Keep containers closed when not in use. Do not handle or store near high heat or flames. Avoid breathing oil mists, wash skin thoroughly with soap and water after handling SECTION 8 EXPOSURE CONTROLS AND PERSONAL PROTECTION VENTILATION PROCEDURE: GLOVE PROTECTION: EYE PROTECTION: Use local exhaust ventilation to control dust. Neoprene or Nitrile Gloves Recommended. Safety glasses recommended. Page 2 of 6
RESPIRATORY PROTECTION: CLOTHING RECOMMENDATION: Normally not required, mask or respirator for mists. Launder as needed to prevent repeated or prolonged contact. «ACUTE EXPOSURE» ORAL TOXICITY: EYE IRRITATION: SKIN IRRITATION: DERMAL TOXICITY: Low order of acute oral toxicity. May cause irritation of the gastrointestinal tract, nausea and vomiting. Aspiration into the lungs during ingestion or vomiting may cause mild to severe pulmonary injury and possibly death. Eye irritant. Based on data from components or similar material. Skin irritant. Based on data from components or similar materials. Prolonged or repeated skin contact as from clothing wet with material may cause dermatitis. Symptoms may include redness, edema, drying, defatting and cracking of the skin. The LD50 in rabbits is > 2000 mg/kg. Based on data from components or similar materials. INHALATION TOXICITY: No data available to indicate product or components may be a toxic inhalation hazard. RESPIRATORY IRRITATION: If material is misted or if vapors are generated from heating, exposure may cause irritation of mucous membranes and the upper respiratory tract similar to that observed with mineral oil. Based on data from components or similar materials. Under good industrial hygiene practices where all exposure limits are observed respiratory irritation should not be a problem. DERMAL SENSITIZATION: No data available to indicate product or components may be a skin sensitizer. INHALATION SENSITIZATION: No data available to indicate product or components may be a respiratory sensitizer. CHRONIC EXPOSURE CHRONIC TOXICITY: No data available to indicate product or components present at greater than 1% are chronic health hazards. CARCINOGENICITY: MUTAGENICITY: No data available to indicate any components present at greater than 0.1% may present a carcinogenic hazard. No data available to indicate product or any components present at greater than 0.1% are mutagenic or genotoxic. REPRODUCTIVE TOXICITY: No data available to indicate either product or components present at greater than 0.1% that may cause reproductive toxicity. Page 3 of 6
TERATOGENICITY: No data available to indicate either product or components contained at greater than 0.1% may cause birth defects. «ADDITIONAL INFORMATION» OTHER: EXPOSURE LIMITS: No other health hazards known. See Section 3 for any applicable exposure limits for components. SECTION 9 PHYSICAL DATA VAPOR PRESSURE: Less than 0.01 mm Hg @ 20 C PH: Essentially Neutral SPECIFIC GRAVITY: 0.85 LB/GAL: 7.11 WATER SOLUBILITY: Insoluble PERCENT VOLATILE: Negligible from open container in 4 hours @ 38 C (100 F) VAPOR DENSITY: Greater than 1 (Air = 1) EVAPORATION RATE: Less than 0.01 (@1 ATM and 25 C. n-butyl acetate = 1) ODOR: Mild Petroleum oil like APPEARANCE: Blue Viscous Liquid VISCOSITY: 30-34 cst @ 40 C SECTION 10 STABILITY STABILITY: INCOMPATIBILITY: POLYMERIZATION: THERMAL DECOMPOSITION: Stable Oxidizing agents and acids. Will not occur. Smoke, carbon monoxide, aldehydes and other products of incomplete combustion. Hydrogen sulfide and short chain alkyl mercaptans may also be released. Under combustion conditions, oxides of the following elements will be formed: Phosphorus, Sulfur, Zinc. SECTION 11 TOXICOLOGICAL INFORMATION EYES: Unlikely to cause more than transient stinging or redness if accidental eye contact occurs SKIN: Unlikely to cause harm to the skin on brief or occasional contact but prolonged or exposure may lead to dermatitis. Page 4 of 6
INGESTION: Unlikely to cause harm if accidentally swallowed in small doses, though larger quantities may cause nausea and diarrhea. INHALATION: At normal ambient temperatures this product will be unlikely to present an inhalation hazard because of its volatility. May cause irritation to eyes, nose, and throat due to exposure to vapor, mists, or fumes. SECTION 12 ECOLOGICAL INFORMATION MOBILITY: Spillage may penetrate the soil causing ground water contamination. PERSISTENCE AND DEGRADEABILITY: This product is inherently biodegradable. BIO-ACCUMULATIVE POTENTIAL: There is no evidence to suggest bio-accumulation will occur. AQUATIC TOXICITY: Spill may form a film on water surfaces causing physical damage to organisms. Oxygen transfer could also be impaired. SECTION 13 DISPOSAL CONSIDERATIONS Dispose according to current local, state and federal regulations. Materials may become hazardous waste through use. If permitted, incineration may be practical. Consider recycling. SECTION 14 TRANSPORTATION TRANSPORTATION INCIDENT INFORMATION: For further information relative to spills resulting from transportation incidents, refer to latest Department of Transportation Emergency Response Guidebook for Hazardous Materials Incidents. U.S. DOT HAZARDOUS MATERIALS SHIPPING DESCRIPTION: Not Regulated. SECTION 15 REGULATORY INFORMATION Not classified as hazardous for supply. Refer to your national legislation implementing the EC Directive 91/155/EG SARA Ext. Haz. Subst. SARA Section 313 This product does not contain greater than 1.0% of any chemical substances on the SARA Extremely Hazardous Substances list. Contains 0.3%-0.5% zinc compounds. Contains 0.002% Ethylbenzenes Contains 0.008% Dimethylbenzenes Chronic Hazard Acute Hazard Fire Hazard YES YES NO Page 5 of 6
SARA 311 Classifications Reactivity Hazard NO Toxic Substance Control Act (TSCA) Status: The materials in this product are listed on the EPA/TSCA Inventory of Chemical Substances. SECTION 16 OTHER INFORMATION OSHA REQUIRED LABEL INFORMATION: In compliance with hazard and right-to-know requirements, where applicable OSHA Hazard Warnings may be found on the label, bill of lading or invoice accompanying this shipment. The information presented herein has been compiled from sources considered to be dependable and is accurate to the best of seller's knowledge, however, seller makes no warranty whatsoever, expressed, implied or of merchantability regarding the accuracy of such data or the results to be obtained from the use thereof, seller assumes no responsibility for injury to buyer or to third persons or for any damage to any property and buyer assumes all such risks. N.A. = Not Applicable N.D. = Not Determined N.E. = Not Established Page 6 of 6