SECTION 1: Identification of the substance/mixture and of the company/undertaking 1.1 Product identifier Commercial Product Name ALBODUR 965 VP 1.2 Relevant identified uses of the substance or mixture and uses advised against Relevant identified uses Recommended restrictions To produce polyurethanes for coatings, elastomers, sealants, resins, castings, adhesives and plastics No information available. 1.3 Details of the supplier of the safety data sheet Company designation Alberdingk Boley GmbH Düsseldorfer Str. 53 47829 Krefeld, Germany Telephone: +49 2151 528-0 FAX: +49 2151 573-643 Email: trm@alberdingk-boley.de Internet: www.alberdingk-boley.de 1.4 Emergency telephone number Emergency telephone number Tel.: +49 2151 528-0 at the office from 8-16 o'clock SECTION 2: Hazards identification 2.1 Classification of the substance or mixture Classification according to Regulation (EC) No. 1272/2008 Classification according to Directive 67/548/EEC / 1999/45/EEC 2.2 Label elements This product is classified as not hazardous according to regulation (EC) 1272/2008 [CLP]. This product is not classified as dangerous according to 67/548/EEC / 1999/45/EEC. Labelling according to Regulation (EC) No. 1272/2008 [CLP] The product does not have to be labelled according to Regulation (EC) No. 1272/2008 [CLP]. SECTION 3: Composition/information on ingredients 3.1 Substances Chemical characterization Polyol component based on castor oil SECTION 4: First aid measures 4.1 Description of first aid measures General advice If inhaled In case of skin contact In case of eye contact If swallowed In case of accident or unwellness, seek medical advice immediately (show directions for use or safety data sheet if possible). No special measures are necessary. In case of skin reactions, consult a physician. In case of eye irritation consult an ophthalmologist. 4.2 Most important symptoms and effects, both acute and delayed Symptoms In all cases of doubt, or when symptoms persist, seek medical advice. No known symptoms to date. 1 / 6
4.3 Indication of any immediate medical attention and special treatment needed Immediate medical attention Treat symptomatically. SECTION 5: Firefighting measures 5.1 Extinguishing media Suitable extinguishing media Extinguishing media which must not be used for safety reasons Dry extinguishing powder, Carbon dioxide (CO2), Sand Water Water can be used to cool containers filled with the product. Avoid contact with the caustic surface. A sprinkler system should only be used for cooling closed containers filled with the product. 5.2 Special hazards arising from the substance or mixture Special exposure hazards arising from the substance or preparation itself, its combustion products, or released gases In case of fire may be liberated: Acrolein, carbon monoxide, carbon dioxide 5.3 Advice for firefighters Special protective equipment for firefighting In case of fire: Wear self-contained breathing apparatus. SECTION 6: Accidental release measures 6.1 Personal precautions, protective equipment and emergency procedures Personal precautions Special danger of slipping by leaking/spilling product. 6.2 Environmental precautions Environmental precautions Do not allow to enter into surface water or drains. Do not allow to enter into soil/subsoil. 6.3 Methods and material for containment and cleaning up Methods for cleaning up 6.4 Reference to other sections Absorb with liquid-binding material (e.g. sand, diatomaceous earth, acid- or universal binding agents). Treat the recovered material as prescribed in the section on waste disposal. Reference to other sections Safe handling: see section 7 Personal protection equipment: see section 8 Disposal: see section 13 SECTION 7: Handling and storage 7.1 Precautions for safe handling Advice on safe handling Advice on protection against fire and explosion Do not bring in contact with strong oxidizing agents. Keep away from sources of heat (e.g. hot surfaces), sparks and open flames. 7.2 Conditions for safe storage, including any incompatibilities Storage space and container requirements Hints on storage assembly Storage specifications A sprinkler system should only be used for cooling closed containers filled with the product. Do not store together with: Oxidising agent, strong Store at a temperature of +10 C to +30 C and dark. 2 / 6
TRGS 510 10 - Combustible liquids, unless storage class 3 7.3 Specific end use(s) Specific use(s) No information available. SECTION 8: Exposure controls/personal protection 8.1 Control parameters The product does not contain any relevant quantities of materials with critical values that have to be monitored at the workplace. 8.2 Exposure controls Respiratory protection Hand protection Eye protection Skin and body protection Respiratory protection not required Hand protection is not required Wear protective eye glasses for protection against liquid splashes. Wear suitable protective clothing. SECTION 9: Physical and chemical properties 9.1 Information on basic physical and chemical properties Physical state Colour Odour Odour threshold ph Melting point [ C] / Freezing point [ C] liquid Boiling point [ C] >250 Flash point [ C] >100 Evaporation rate [kg/(s*m²)] Flammability (solid, gas) Explosion limits [Vol-% ] Lower limit: Upper limit: Vapour pressure [kpa] < 0,1 Temperature: 20 C Vapour density Relative density Solubility [g/l] Partition coefficient n-octanol /water (log P O/W) Autoignition temperature [ C] light yellow characteristic Not applicable This material is combustible and can be ignited by heat, sparks, flames, or other sources of ignition (e.g. static electricity, pilot lights, or mechanical/electrical equipment). Miscible with: Ethanol Decomposition temperature [ C] > 250 C 3 / 6
Viscosity, dynamic ca. 1100 unit: mpas Temperature: 25 C Measuring method: DIN 53015 Risk of explosion. not explosive. Oxidising properties Not oxidising. 9.2 Other information Ignition temperature [ C] Solid content [%] ca. 100 Measuring method: DIN EN ISO 3251 SECTION 10: Stability and reactivity 10.1 Reactivity Thermal decomposition 10.2 Chemical stability Chemical stability Decompostion takes place from temperatures above: >250 C The product is stable under storage at normal ambient temperatures. 10.3 Possibility of hazardous reactions Hazardous reactions No known hazardous reactions. 10.4 Conditions to avoid Conditions to avoid 10.5 Incompatible materials Materials to avoid Keep away from heat sources, sparks and open flames. Oxidising agent, strong Alkali (lye), concentrated Strong acid 10.6 Hazardous decomposition products Hazardous decomposition products Acrolein, carbon monoxide, carbon dioxide SECTION 11: Toxicological information 11.1 Information on toxicological effects Oral toxicity [mg/kg] Dermal toxicity [mg/kg] Inhalative toxicity [mg/l] Irritant effect on skin Not an irritant. Irritant effect on eyes Not an irritant. Sensitization not sensitising. Carcinogenic effects Mutagenicity Reproduction toxicity Caustic effect not corrosive 4 / 6
SECTION 12: Ecological information 12.1 Toxicity Toxicity to fish [mg/l] Toxicity to daphnia [mg/l] Toxicity to algae [mg/l] 12.2 Persistence and degradability Biodegradability 12.3 Bioaccumulative potential Bioaccumulation 12.4 Mobility in soil Mobility There are no data available on the mixture itself. There are no data available on the mixture itself. There are no data available on the mixture itself. 12.5 Results of PBT and vpvb assessment Results of PBT characteristics determination The substances in the mixture do not meet the PBT/vPvB criteria according to REACH, annex XIII. 12.6 Other adverse effects Further information on ecology SECTION 13: Disposal considerations 13.1 Waste treatment methods Disposal considerations Uncleaned empty packaging Suitable cleaning agents Do not dispose of with household waste. Do not allow to enter drains. Dispose of waste according to applicable legislation. Handle contaminated packages in the same way as the substance itself. Water and soap Retain contaminated washing water and dispose it. SECTION 14: Transport information Land transport ADR/RID Marine transport IMDG Air transport ICAO/IATA 14.1 UN-No not applicable not applicable not applicable 14.2 UN proper shipping Non dangerous good Non dangerous good Non dangerous good name 14.3 Transport hazard not applicable not applicable not applicable class(es) 14.4 Packaging group not applicable not applicable not applicable 14.5 Environmental hazards not applicable not applicable not applicable Leerzeile 14.6 Special precautions for user Precautions not applicable 14.7 Transport in bulk according to Annex II of MARPOL73/78 and the IBC Code Transport in bulk according to Annex II of MARPOL73/78 and the IBC Code not applicable 5 / 6
SECTION 15: Regulatory information 15.2 Chemical safety assessment Safety assessment Not applicable SECTION 16: Other information Department issuing safety data sheet TRM Recommended restrictions No information available. This information is provided in accordance with the current status of our knowledge and experience. The Safety Data Sheet describes products with a view to relevant safety requirements. This information does not constitute a warranty of properties, features or qualities. 6 / 6